2003 MINI Cooper Complaint Log

The contact owns a 2003 Mini Cooper. The contact stated that while operating the vehicle, the steering wheel was difficult to turn in either direction. The contact stated that the steering wheel malfunctioned, making the steering wheel easy to turn, causing severe oversteer while making a turn in either direction. The contact stated that the failure was due to a faulty power steering pump, and installed as part of the NHTSA Campaign Number: 15V660000 (STEERING). The vehicle was not repaired. The contact stated that after turning off the vehicle, the power steering pump remained running, causing the battery to drain. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 230,000.

68k miles on a 2003 mini cooper s and the power steering pump is whining. I feel as if this may be really early for it to be needing to be replaced.

No air or blower or heat to defog windshield. Water in driver-side foot well. Power steering intermittent fault. Engine continues running and panel gauge lights remain on with ignition off and key removed.

The contact owns a 2003 Mini Cooper S equipped with Falken Tires, Tire Line: Sincera SN250 A/S, Tire Size: 235/45R17, DOT Number: FMHR3120. The contact stated that while washing the vehicle, he noticed that a bubble had developed on the front driver’s side tire. The contact was concerned for his safety while driving the vehicle. The contact stated that he rotated the tire to the rear driver’s side but was concerned and uncertain if the bubble might cause a risk to his safety while driving. The vehicle had not yet been diagnosed. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 101,000.

i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put down passenger window pull handel to get out . car is possessed light work whren they want does all kinda crazt stuff . batter has problems . charge and still cant start it . and hatch locks so i cant get to battery. power steering leaking going bad . timing belt making noise . no power on hills .cracking noise in right front pulls to right had . hazard to me ive been locked inside three times could get out of car i coulda sat in heat and died or cold and froze . cant get out of car when it ts electric doors dont work . car sucks . this has been gradual thing these events from feb to may . now i just hate the car

The contact owns a 2003 Mini Cooper. The contact received notification of NHTSA Campaign Number: 15V660000 (Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the steering wheel was firm, and the vehicle was difficult to maneuver. No warning lights were illuminated. The dealer was made aware of the failure but failed to confirm if the parts were available for the repair. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to call the service center directly. The failure mileage was unavailable. Parts distribution disconnect.

My 2003 Mini Cooper was affected by the 2015 electrohydraulic steering assistance recall. Mini did the repair at 79, 322 miles in 2016. In November 2021, at 98, 000 miles, the car began having intermittent power steering loss. The power steering might disappear for under a minute, or it might return for mere seconds. There is no warning when the power steering goes out, so you have to assume that it is not going to respond with the electrohydraulic steering assistance feature operating. As of today, it has been completely offline for 3 days (although it did come back on for about 5 seconds yesterday). Without this feature operating properly, the car can be extremely difficult to steer.

While driving on I-81 to NY state, I experienced serious tire vibration followed by tire loss of air. All tires were checked for proper tire inflation before trip. After pulling off to the side of the road, I witnessed a large hole with metal fiber sticking through the tire tread. I believe the tread separation was the cause.

While driving on I-81 to NY state, I experienced serious tire vibration followed by tire loss of air. All tires were checked for proper tire inflation before trip. The service center in which I ended up in said that the tire belts had separated and caused the rapid tire deflation.

The contact owns a 2003 Mini Cooper. The contact stated that while driving approximately 35 mph and making a right turn, the power steering malfunctioned and the steering wheel suddenly became difficult to turn in either direction. The vehicle was taken to the local dealer who diagnosed that the power steering pump and fan needed to be replaced and the intake and return power steering lines also were faulty and needed to be replaced. The manufacturer was notified of the failure. The contact was informed that the vehicle was not included in the NHTSA campaign number: 15V660000 (Steering). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was approximately 134,000.

I WAS STARTING MY VEHICLE AND IT MADE A BAD KNOCKING NOISE THEN IT WAS LIKE CRUNCHING NOISE SO I STOPPED TURN IT OFF AND WAITED FOR A WHILE WENT BACK TO THE CAR STILL MAKING A STRANGE NOISE BUT ONCE I PUT IT IN THE DRIVE IT STOPPED MAKING NOISE DROVE DOWN THE ROAD A BIT AND TALKING ABOUT APPARENTLY SLIPS OFF OF THE CAR SO IT JUST PULLS OVER INSIDE ALL THE ALL THE WEARING LIGHTS CAME ON SO PULLED OVER APPARENTLY THIS HAPPENS QUITE OFTEN BUT THE HARMONIC BALANCER SEPARATED AND WITH SPINNING AGAINST ITSELF AND KNOCKED THE PIECES OFF OF IT AND THROUGH THE SERPENTINE BELT SO THAT NEEDS TO REPLACE NOW THAT SHOULD NOT HAPPEN IT'S ONE PIECE IS THIS ONE PIECE THIS NEEDS TO BE RECALLED FOR THESE WHATEVER CARS HAD THESE HARMONIC BALANCERS IS DANGEROUS AND IT COULD BLOW YOUR CAR UP THANK YOU

IN MOTION.. THE POWER STEERING WHEEL FEELS TO HARD TO TURN OPERATE;I CHECK THE VIN# NUMBER AND APPEAR (1) RECALL FOR POWER STEERING INCOMPLETE;WE CALL AT BMW OF DALLAS AND THEY SETUP AN APOINMENT ON JANUARY,15,2020...WHEN I SHOW UP...THEY SAY MY CAR DON'T HAVE ANY RECALL;AND I SHOW IM THE OFFICIAL RECALL WITH MY VIN#...BMW RECALL & NHTSA RECALL AND THEY SAY THE CAR WARRANTY IS EXPIRED,I SAID I JUST NEED FIX THE RECALL ON MY CAR AND THEY WANNA CHARGE ME $180 DLLS JUST TO GET THE VEHICLE INSPECTED,IF THE CAR GOT SOMETHING WRONG THEY CHARGE ME THE COST...I DONT ACCEPT...MY CAR GOT THE RECALL AND THEY MAKE ME DRIVE 120 MILES WHIT THE CAR FOR NOTHING

TL* THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING 30 MPH, THE POWER STEERING COMPLETELY FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE; HOWEVER, THE STEERING WAS ROUGH AND STIFF. THE CONTACT PERFORMED HIS OWN INSPECTION ON THE VEHICLE AND NOTICED THAT THE POWER STEERING PUMP WAS LEAKING. THE CONTACT SPOKE WITH AN INDEPENDENT MECHANIC AND WAS INFORMED THAT THE VEHICLE MAY BE INCLUDED IN AN UNKNOWN RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE CONTACT TOOK THE VEHICLE TO MINI OF THE WOODLANDS (16675 I-45, CONROE, TX 77385, 936-344-1258) AND WAS INFORMED THAT THE VEHICLE COULD NOT BE REPAIRED BECAUSE THE STEERING PUMP WAS NOT THE ORIGINAL MINI COOPER STEERING PUMP. THE DEALER OFFERED NO FURTHER ASSISTANCE. THE PUMP HAD NOT BEEN REPLACED. THE FAILURE MILEAGE WAS 83,000.

BOUGHT THIS CAR FOR 16 YR OLD DAUGHTER. STEERING WAS CUTTING OUT WHILE DRIVING TOOK CAR TO MINI OF DALLAS RECALL WAS DONE ON HARNESS, PUMP, COOLING FAN. NEXT WEEK NO STEERING AGAIN WHILE DRIVING TOOK CAR BACK. MINI STATED DRIVE BELT BROKE AND WAS REPAIRED FOR 260.00. 3 DAYS LATER WAS CALLED AT A 11:30 AT NIGHT MY DAUGHTER STATING THE STEERING HAD CUT OUT AGAIN. I DON'T WANT MY DAUGHTER IN THIS CAR OR ANYONE ELSE FOR THAT MATTER WHAT SHOULD I DO WITH THIS CAR.

POWER STEERING FAILURE - INTERMITTENT AND DURING MOTION, MINI DEALERSHIP PROVIDED RECORDS THAT THE CLAIM WAS CLEARED WITH # AND MILEAGE, BUT THIS IS FALSE INFORMATION IF STILL COVERED BY NHTSA # 15V660000. ORIGINAL RECALL # THAT WAS ENTERED IN THE "REPAIR HISTORY" FROM MINI THAT NEVER OCCURRED IS M320215. THANK YOU

OCCASIONALLY THE STEERING OVER MY MINI COOPER S IS BECOMING VERY HARD. IT SEEMS LIKE THE POWER STEERING IS FAILING. THE CAR THEN CAN ONLY BE STEERED WITH A LOT OF DIFFICULTY. I CAN NO LONGER RISK TO HAVE MY DAUGHTER OR WIFE DRIVE THIS CAR. I CHECKED THE STEERING FLUID AND IT IS AT OPTIMAL LEVELS. IT USUALLY HAPPENS AT LOWER SPEED, BUT I HAVE NOT DRIVEN IT ON THE FREEWAY SINCE THIS ISSUE STARTED TO APPEAR.

POWER STEERING PUMP FAILED WHILE DRIVING

DRIVING NORMALLY ON CITY PAVED ROAD STARTED TO MAKE TURN ON SIDE STREET AND LOST TOTAL STEERING CONTROL AND WENT UP ON CURB JUST MISSING A PEDESTRIAN ON SIDEWALK.THIS VEHICLE HAS 79300 MILES.THE ELECTRIC HYDRAULIC PUMP COMPLETELY FAILED.MINI USA SAID THIS VIN IS NOT PART OF THE RECALL YET JUST ABOUT EVERY MINI INPORTED TO USA HAS COMPLETE STEERING LOSE 2002-2003-2004-2005 AND I BELIEVE THEY ARE HIDING THIS FROM YOU AND THE PUBLIC WHO ARE STILL BUYING THESE USED CARS AND NOT KNOWING THE DANGEROUS PROBLEM THE MINI HAS AND FLAWED POWER STEERING PUMP DESIGN.THANK YOU.

THE WARNING FOR TH EPASSENGER AIRBAG COMES ON, THOUGH APPARENTLY NOTHING IS WROMG WITH IT. IT SEEMS TO BE A COMMMON PROBLEM THAT MINI IS AWARE OFF, PUTS PEOPLE IN DANGER, BUT DOESNT DO ANYTHING TO FIX THE HARNESS UNDERNEATH THE PASSENGER SEAT, WHICH THEY QUOTE AT 1200 TO 1400 TO REPAIR THEIR ILL DESIGN AND FINAL PRODUCT

TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED AND AN ABNORMAL NOISE WAS HEARD WHILE DRIVING APPROXIMATELY 65 MPH. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO MINI OF SAN DIEGO (5202 KEARNY MESA RD, SAN DIEGO, CA) WHERE IT WAS DIAGNOSED THAT THE VEHICLE WAS OPERATING AS INTENDED. THE DEALER ALSO STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DETERMINED THAT THE POWER STEERING PUMP WAS THE ORIGINAL MANUFACTURED PART, WHICH MEANT THAT NO PARTS WERE REPLACED AS THE DEALER ORIGINALLY STATED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THEY HAD NO RECORDS OF THE VEHICLE BEING SERVICED PER THE RECALL. THE DEALER WAS CONTACTED AGAIN AND STATED THAT THE RECALL WAS SERVICED IN MARCH OF 2017. THE FAILURE MILEAGE WAS APPROXIMATELY 164,000.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT NOTICED FUEL LEAKING UNDERNEATH THE VEHICLE. THE CONTACT CHECKED UNDER THE HOOD AND DISCOVERED THAT THE FUEL FILTER HAD A LEAK. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

WE KNOW OF TWICE THAT OUR CAR'S POWER STEERING PUMP FAILED WHILE IN MOTION. AFTER BMW WAS FINALLY FORCED INTO A RECALL FOR THE POWER STEERING PUMP FAILURE AND WE RECEIVED A NOTIFICATION, WE TOOK OUR CAR TO CENTURY BMW IN GREENVILLE, SC. THE SERVICE DEPARTMENT CHECKED OUR WORK REGARDING REPLACEMENT PUMP, FAN, ETC. AND DEEMED IT 100% SATISFACTORY. WE SUBMITTED THE PAPERWORK AND INVOICE FOR THE REPAIR AND WAITED (REQUESTED . AFTER 16 WEEKS AND NO REIMBURSEMENT OR NOTIFICATION, WE CALLED AND WAS INFORMED BY THE SERVICE DEPARTMENT MANAGER THAT BMW WOULDN'T PAY US ANYTHING BECAUSE WE DIDN'T USE OEM PARTS. WHY WOULD WE KEEP REPLACING THE PUMP (THIS WAS THE 3RD PUMP THAT WE KNOW OF) WITH A DEFECTIVE ONE (BY ZF) THAT KEPT QUITTING? WE REPLACED IT WITH DORMAN (WELL-KNOWN MANUFACTURER OF QUALITY PARTS) WHICH HAD A LIFE-TIME WARRANTY (LIFE-TIME!) AND WAS MUCH CHEAPER. THE SD MANAGER EVEN SAID THAT SINCE HE'D SEEN SO MANY REPAIRS USING THAT BRAND OF POWER STEERING PUMP HE HAD RESEARCHED THEM AND FOUND NOTHING WRONG WITH THEM. BUT BMW DECIDED THEY WOULDN'T PAY FOR THIS. THERE WAS NOTHING IN THE RECALL LETTER THAT SAID OEM HAD TO BE USED OR THEY WOULDN'T REIMBURSE FOR REPAIRS. I BELIEVE BMW SAW SO MANY DORMAN PUMPS USED THEY KNEW THEY COULD SAVE A LOT OF MONEY BY REFUSING TO PAY. WE FILED A COMPLAINT WITH THE SC DEPT. OF CONSUMER AFFAIRS BUT BMW WOULDN'T ANSWER THEM SO THEY JUST DROPPED IT, LETTING BMW GET BY WITH THIS. WE WERE ONLY REQUESTING $721.04 WHICH IS LESS THAN HALF OF WHAT A REPAIR SHOP WOULD HAVE CHARGED. CAN YOU DO ANYTHING ABOUT THIS? WE FILED THE COMPLAINT WITH SC CONSUMER AFFAIRS IN DECEMBER OF 2017, TOOK THE CAR TO BMW IN MAY OF 2017 SO THIS HAS BEEN GOING ON FOR A WHILE. HAVE OTHER OWNERS HAD THIS PROBLEM? HAS A LAWSUIT BEEN STARTED AGAINST BMW?

WHILE IN MOTION, CAR BEGAN TO BECOME JERKY WHILE EXCELERATING, THAN THE TRANSMISSION DISINGAGED. NO GEAR WOULD WORK THEREAFTER.

POWER STEERING WENT OUT WITHOUT WARNING, CAUSING LOSS OF CONTROL WHILE VEHICLE WAS IN MOTION; MINI USA ADVISED IT WAS STILL DRIVEABLE, BUT TO BE CAUTIOUS DUE TO LACK OF CONTROL/POWER STEERING; WHEN PARKED, SMOKE BEGAN TO PLUME FROM UNDER HOOD WHERE A FIRE WAS NOTICED IN BACK OF ENGINE. CALLED MINI USA BACK AND THEY ADVISED US TO NOT DRIVE VEHICLE, AS IT WAS A SAFETY HAZARD. CONTACTED MINI TO SET UP RECALLED PART (HYDRAULIC POWER STEERING), BUT THEY WERE NOT WILLING TO HAVE CAR TOWED TO DEALER (120 MILES FROM MY RESIDENCE).

TL* THE CONTACT OWNED A 2003 MINI COOPER. WHILE THE VEHICLE WAS PARKED IN THE PARKING LOT, THE NEIGHBORS NOTICED THAT IT CAUGHT FIRE AND CALLED THE FIRE DEPARTMENT. THE POLICE ARRIVED AND FILED A REPORT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE POLICE INFORMED THE CONTACT THAT THE FIRE ORIGINATED FROM THE ENGINE. THE VEHICLE WAS DESTROYED AND TOWED TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

THE ELECTRO-HYDRAULIC POWER STEERING SYSTEM EXPERIENCES TEMPORARY LOSS OF ASSISTANCE WHEN VEHICLE IS STARTING UP AND IT IS NEARLY IMPOSSIBLE TO MANEUVER THE CAR TO PULL OUT OF A PARKING SPACE. HOWEVER, THE POWER STEERING RETURNS TO NORMAL AS SOON AS YOU BEGIN STREET OR HIGHWAY DRIVING. I TOOK MY CAR TO A MINI DEALERSHIP AND THEY STATED THAT MY PARTICULAR STEERING PUMP ISN'T COVERED IN THE WARRANTY ALTHOUGH I DID RECEIVE A LETTER INDICATING THAT IT SHOULD BE. I HAVE THE EXACT SAME ISSUES HAPPENING WITH MY VEHICLE THAT THE RECALL IS TALKING ABOUT.

WHILE TRAVELING NORTH ON US 221 FROM BENT MOUNTAIN, VA TO ROANOKE VA MY HYDRALIC STEERING TOTALLY FAILED. AS I TRAVELLED A SHORT DISTANCE MY BRAKE LIGHT WARNING LIGHTS, ABS LIGHT, OTHER BRAKE SYSTEM LIGHT, BATTERY LIGHT AND AIR BAG WARNING LIGHT CAME ON. I LOOKED AT THE ENGINE TEMPERATURE GUAGE AND THE TEMP WAS NORMAL. I PULLED INTO A PARKING LOT, RAISED THE HOOD, CHECKED THE FLUIDS IN THE ENGINE COMPARTMENT AND REENTERED THE CAR. WHILE SITTING IN THE DRIVERS SEAT I HEARD A LOUD EXPLOSION, LOOKED FORWARD AND NOTED THICK STEAM COMING FROM THE ENGINE COMPARTMENT. I TURNED THE ENGINE OFF, EXITED THE CAR AND WHEN THE STEAM DISSIPATED I NOTED THAT THE COOLING SYSTEM FILLING/OVERFLOW TANK WAS SPLIT IN HALF DAMAGING A PROTECTING COVER ON THE FIREWALL AND SPRAYED A BUILDING WALL AND WINDOW WITH ENGINE COOLANT 10 FEET AWAY IN FRONT OF THE VEHICLE. I HAD THE CAR TOWED TO MARTIN'S GERMAN SERVICE IN CAVE SPRING, VA. BECAUSE THE CLOSEST DEALERSHIP IN LOCATED IN NORTH CAROLINA 150 MILES AWAY. DUE TO SERVICE VOLUME THEY WILL NOT BE ABLE TO EVALUATE THE PROBLEM UNTIL 24 MAY 2016.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) ; HOWEVER, THE PART FOR THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT THE POWER STEERING FAILED WITHOUT WARNING AT VARIOUS SPEEDS, ESPECIALLY WHEN TURNING THE STEERING WHEEL. THE APPROXIMATE FAILURE MILEAGE WAS 171,000. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING BECAME VERY DIFFICULT TO MANEUVER. AFTER TURNING OFF AND RESTARTING THE VEHICLE 30 MINUTES LATER, THE POWER STEERING RETURNED TO NORMAL, BUT THEN FAILED AGAIN. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRO-HYDRAULIC POWER STEERING FAILED AND NEEDED TO BE REPLACED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE DEALER WANTED TO CHARGE FOR THE REPAIR BECAUSE OF THE MILEAGE ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 181,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

I WAS APPROACHING A CORNER ON A BACK ROAD AND HALF WAY THROUGH THE POWER STEERING FAILED WHICH CAUSED THE CAR TO GO OFF THE ROAD ROLLING TWO AND A HALF TIMES LANDING ON THE ROOF.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 05/18/16*LJ UPDATED 06/14/16.*JB

TL* THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING APPROXIMATELY 30 MPH, THERE WAS A LOSS OF POWER STEERING WITHOUT WARNING. THE VEHICLE WAS MANUVERED TO THE SIDE OF THE ROAD. THE CONTACT RESUMED DRIVING; HOWEVER, THE STEERING WHEEL WAS EXTREMELY DIFFICULT TO TURN. THE CONTACT MENTIONED THAT THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, THE DEALER FAILED TO SERVICE THE VEHICLE BECAUSE THE RECALL NOTIFICATION WAS NOT RECEIVED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,113.

TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V6600000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. WHILE DRIVING 5 MPH WHEN ATTEMPTING TO TURN THE VEHICLE, THE STEERING WHEEL MALFUNCTIONED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THE VEHICLE, BUT THE RESULTS WERE UNKNOWN. THE VEHICLE WAS REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING APPROXIMATELY 15 MPH, THE POWER STEERING SEIZED. THE BATTERY AND TEMPERATURE GAUGE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 168,000.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHILE OPERATING THE VEHICLE AT LOW SPEEDS, THE STEERING WHEEL REQUIRED EXCESSIVE FORCE IN ORDER TO TURN. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE POWER STEERING FLUID LEAKED FROM THE POWER STEERING FLUID RESERVOIR. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 136,000.

SUDDENLY OUT OF NOWHERE AS SOON AS I STARTED THE CAR TO BACK OUT OF MY DRIVEWAY & GO TO WORK THE STEERING WAS COMPLETELY LOCKED UP, ONLY HAVING APPROXIMATELY AN INCH TO INCH AND A HALF OF MOBILITY IN EITHER DIRECTION. I THEN TURNED THE CAR OFF, LET IT SIT OFF FOR ABOUT 5 MINS THEN RE-STARTED IT AND THE STEERING WAS STILL THE SAME WAY.

OUR 2003 MINI COOPER WAS DRIVEN IN OCTOBER 2015 IN FIRST AND SECOND GEAR, IN BUMPER TO BUMPER SLOW TRAFFIC, UPHILL FOR ABOUT A MILE. WHEN WE SHUT THE CAR OFF AND GOT OUT OF IT, A FAN IN THE ENGINE COMPARTMENT CONTINUED TO RUN. WE WENT BACK INTO THE CAR, STARTED IT AGAIN, THEN SHUT IF OFF FOR A SECOND TIME, AND THE FAN CONTINUED TO RUN. THE FAN RAN ABOUT 5 TO 10 MINUTES WHILE THE CAR WAS PARKED. WE HAVE BEEN TOLD THAT THE STAGE 1 COOLING FAN HAS FAILED AND THAT THE STAGE 2 COOLING FAN WAS RUNNING TO COOL DOWN THE ENGINE.

POWER STEERING PUMP FAILED AT 69,000 MILES. PUMP AND FAN WERE REPLACED UNDER WARRANTY, BUT DEALER REQUIRED ADDITIONAL WORK TO BE PERFORMED TO KEEP EXTENDED WARRANTY IN FORCE. THE WORK INCLUDED REPLACEMENT OF ALL POWER STEERING HOSES AT A COST OF OVER $600.00

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

POWER STEERING FAILED AND DIFFICULT TO STEER. POWER STEERING WOULD THEN CUT IN AND OUT. WARRANTY REPAIR BY MINI DEALER ON SEPTEMBER 16, 2015 REPLACED STEERING PUMP BUT POWER STEERING HOSE LEAK WAS NOT COVERED BY WARRANTY AND CHARGED $607.59 TO DO ALL NECESSARY REPAIRS FOR THE POWER STEERING TO WORK. THE LACK OF CONSISTENCY OF HAVING POWER ASSIST STEERING OR NOT COULD CONTRIBUTE TO AN ACCIDENT SINCE THERE IS NO WAY TO PREDICT THE AMOUNT OF EFFORT TO STEER THE CAR. THE NEEDED POWER STEERING REPAIRS WERE NOT FREE BUT COST $607.59.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHILE DRIVING 40 MPH AND ATTEMPTING TO MAKE A TURN, THE POWER STEERING FAILED. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED CONTUSIONS TO THE FACE AND LOST A TOOTH. THE OCCUPANTS OF THE OTHER VEHICLE SUSTAINED UNKNOWN INJURIES. MEDICAL ATTENTION WAS NOT REQUIRED. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 213,000.

WE WERE CHARGED $1300.00 TO REPLACE THE POWER STEERING PUMP AND FAN.

AFTER BATTERY WENT DEAD, REPLACED WITH NEW BATTERY AND SHORTLY AFTER AIR BAG LIGHT ILLUMINATED. HAD INDEPENDENT SHOP CLEAR CODE IN 2015 INSPECTED HARNESS FOUND NOTHING OUT OF ORDINARY. 3 DAYS LATER AIR BAG LIGHT RETURNED. NOW IN FEBRUARY 2018 HAD MINI OF TOWSON DIAGNOSE AIR BAG LIGHT THINKING THE DEALERSHIP CAN RESET AIR BAG LIGHT PROPERLY. DEALERSHIP RECOMMENDED UPGRADING WIRING HARNESS UNDER SEAT FOR 525 DOLLARS. I HAVE BEEN ON MULTIPLE FORUMS AND THIS AIR BAG LIGHT IS A COMMON PROBLEM FOR 02-03 MINIS, INCLUDING 05-06, AND 12-15 YEAR MINIS. MY CONCERN IS THAT MINI KNOWS THIS IS A DEFECTIVE PART FROM THE MANUFACTURER BUT REFUSES TO STAND BY THEIR PRODUCT EVEN WHEN IT COULD AFFECT THE SAFETY OF THE PURCHASER OF ITS VEHICLES. IN THE EVENT NHTSA RECEIVES ENOUGH COMPLAINTS TO FORCE MINI TO ISSUE A RECALL FOR THIS ISSUE, I WOULD LIKE TO BE INCLUDED AS ANOTHER DISSATISFIED CONSUMER. THANK YOU FOR YOUR TIME, GARRETT

TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT STATED THAT THE GEAR SHIFTER FAILED TO MOVE WHEN ATTEMPTING TO OPERATE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000.

OUR 2003 MINI COOPER HAS ABOUT 120K MILES ON IT. IT WAS COMPLETELY FINE UNTIL RECENTLY WHEN THE POWER STEERING PUMP STARTED WHINING. SOMETIMES IT COMPLETELY STOPPED WORKING AND WE HAD NO POWER STEERING, THANKFULLY THIS WAS WHILE THE CAR WAS PARKED AND NOT WHILE DRIVING. TURNING THE WHEEL IS A LITTLE HARDER THAN USUAL, AND IF YOU TURN IT TOO MUCH, THE CAR BOGS DOWN AND THE REVS GO WAY DOWN. WE'VE TRIED FLUSHING AND REPLACING THE POWER STEERING FLUID, BUT IT DIDN'T SEEM TO HELP. WE'VE EVEN PUT IN SOME EXPENSIVE ADDITIVES THAT PROMISE TO REPAIR THE PROBLEM AND STOP THE NOISE, BUT IT DOESN'T WORK. WE DON'T FEEL SAFE KNOWING THAT OUR POWER STEERING MAY GO OUT AT ANY MOMENT. AND WE CERTAINLY DON'T APPRECIATE THE LOOKS WE GET WHEN WE DRIVE PAST PEOPLE. *TR

STEERING FLUID CONTINUOUSLY LEAKS - REPLACE HYDRAULIC HOSE TWICE - KNOWN DEFECT - MINI REFUSED TO FIX FOR FREE ENGINE COOLING - FAN RUNS AFTER SHUTOFF CONTINUOUSLY - KNOWN DEFECT - MINI REFUSED TO FIX FOR FREE ELECTRICAL - DOORS, WINDOWS, SUNROOF FIRE OFF ON THEIR OWN WHILE CAR IS MOVING AND WHEN IS PARKED. WILL DO THIS AT HIGHWAY SPEED OR WHEN SITTING OUTSIDE (RAIN OR SHINE) - CAR UNLOCKS ITSELF AND WINDOWS ALL OPEN UP -KNOWN DEFECT - KIND OF DISTRACTING AT HIGHWAY SPEED -MINI REFUSED TO FIX FOR FREE. DEALERS WILL NOT FIX THESE ISSUES UNLESS YOU MAKE THEM RECALL VEHICLES WITH MULTIPLE SMALL PROBLEMS ( NOT JUST ONE BIG PROBLEM) - THIS MODEL HAS 73 TSBS THAT DEALERS CHARGE YOU TO FIX EVEN THOUGH THE PROBLEMS ARE KNOWN AND DANGEROUS ISSUES. IN MY MIND, MANY SMALL PROBLEMS CAN BE MORE DANGEROUS THAN A FEW BIG ONES - STEERING, DOOR LOCKS, COOLING - NOT GOOD. THIS IS AN OLD CAR BUT THESE PROBLEMS ARE OLD TOO - KNOWN TSBS SHOULD NOT BE SUBJECT TO WARRANTY TIME FRAMES, THEY ARE STILL DANGEROUS AFTER THE WARRANTY EXPIRES. WHEN THESE CARS ARE ROUTINELY SERVICED, THESE KNOWN/DANGEROUS ISSUES NEED TO BE CORRECTED OR THE CARS SHOULD BE TAKEN OFF THE ROAD. I USED THE DATE OF THE LAST INCIDENT, NOT THE FIRST ONE. THANK YOU. *TR

THE LEFT REAR CONTROL ARM BROKE IN HALF. I NOTICED MY CAR WAS NOT REVERSING CORRECTLY AS IF THE REAR WHEEL WAS DRAGGING. I EXITED THE CAR AND ELEVATED IT WITH A FLOOR JACK TO FIND THE REAR CONTROL ARM ON THE DRIVER'S SIDE BROKEN IN HALF. *TR

TRANSMISSION. *TR

WHILE ADJUSTING THE TILT CONTROL ON MY MINI COOPER, I DISCOVERED THAT THE ENTIRE STEERING COLUMN HAD BECOME LOOSE. UPON INSPECTION, I DISCOVERED THAT TWO METAL BRACKETS USED TO SUPPORT THE STEERING COLUMN AND ATTENDANT ASSEMBLY HAD SHEERED OFF, APPARENTLY UNDER NORMAL USE. *TR