2003 MINI Cooper Electrical System Problems

i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put down passenger window pull handel to get out . car is possessed light work whren they want does all kinda crazt stuff . batter has problems . charge and still cant start it . and hatch locks so i cant get to battery. power steering leaking going bad . timing belt making noise . no power on hills .cracking noise in right front pulls to right had . hazard to me ive been locked inside three times could get out of car i coulda sat in heat and died or cold and froze . cant get out of car when it ts electric doors dont work . car sucks . this has been gradual thing these events from feb to may . now i just hate the car

OUR 2003 MINI COOPER WAS DRIVEN IN OCTOBER 2015 IN FIRST AND SECOND GEAR, IN BUMPER TO BUMPER SLOW TRAFFIC, UPHILL FOR ABOUT A MILE. WHEN WE SHUT THE CAR OFF AND GOT OUT OF IT, A FAN IN THE ENGINE COMPARTMENT CONTINUED TO RUN. WE WENT BACK INTO THE CAR, STARTED IT AGAIN, THEN SHUT IF OFF FOR A SECOND TIME, AND THE FAN CONTINUED TO RUN. THE FAN RAN ABOUT 5 TO 10 MINUTES WHILE THE CAR WAS PARKED. WE HAVE BEEN TOLD THAT THE STAGE 1 COOLING FAN HAS FAILED AND THAT THE STAGE 2 COOLING FAN WAS RUNNING TO COOL DOWN THE ENGINE.

AFTER BATTERY WENT DEAD, REPLACED WITH NEW BATTERY AND SHORTLY AFTER AIR BAG LIGHT ILLUMINATED. HAD INDEPENDENT SHOP CLEAR CODE IN 2015 INSPECTED HARNESS FOUND NOTHING OUT OF ORDINARY. 3 DAYS LATER AIR BAG LIGHT RETURNED. NOW IN FEBRUARY 2018 HAD MINI OF TOWSON DIAGNOSE AIR BAG LIGHT THINKING THE DEALERSHIP CAN RESET AIR BAG LIGHT PROPERLY. DEALERSHIP RECOMMENDED UPGRADING WIRING HARNESS UNDER SEAT FOR 525 DOLLARS. I HAVE BEEN ON MULTIPLE FORUMS AND THIS AIR BAG LIGHT IS A COMMON PROBLEM FOR 02-03 MINIS, INCLUDING 05-06, AND 12-15 YEAR MINIS. MY CONCERN IS THAT MINI KNOWS THIS IS A DEFECTIVE PART FROM THE MANUFACTURER BUT REFUSES TO STAND BY THEIR PRODUCT EVEN WHEN IT COULD AFFECT THE SAFETY OF THE PURCHASER OF ITS VEHICLES. IN THE EVENT NHTSA RECEIVES ENOUGH COMPLAINTS TO FORCE MINI TO ISSUE A RECALL FOR THIS ISSUE, I WOULD LIKE TO BE INCLUDED AS ANOTHER DISSATISFIED CONSUMER. THANK YOU FOR YOUR TIME, GARRETT

THE MANUAL TAILGATE RELEASE CABLE WAS NOT FITTED IN THIS AND OTHER EARLY PRODUCTION MINI COOPER S CARS, THOUGH THE OWNER'S MANUAL INDICATES THAT THIS SAFETY FEATURE IS PART OF THE DESIGN. THE MANUAL TAILGATE RELEASE CABLE ALLOWS ACCESS TO THE BATTERY COMPARTMENT, WHICH IS IN THE TRUNK OF THE VEHICLE, WHEN THERE IS AN ELECTRICAL MALFUNCTION SUCH AS A BATTERY FAILURE. WITHOUT THE MANUAL RELEASE CABLE, THE BATTERY IS INACCESSIBLE IN THE EVENT OF A FAILED BATTERY OR OTHER ELECTRICAL MALFUNCTION. THE BATTERY IN MY CAR FAILED AND LEFT ME STRANDED ON THE SIDE OF THE HIGHWAY WITH NO CONVENIENT ACCESS TO REMOVE THE BATTERY. FURTHER, THE ABSENCE OF THIS MANUAL RELEASE CABLE MEANS THAT THE TAILGATE COULD NOT BE USED AS AN EGRESS FOR VEHICLE OCCUPANTS IN THE EVENT OF AN EMERGENCY.

DRAIN HOSE FROM SUNROOF DRAIN RUNNING DOWN A-PILLAR CAME DISLODGED THROUGH "NORMAL WEAR AND TEAR" CAUSING MASSIVE FLOODING TO THE INTERIOR OF MY CAR. IT WAS RENDERED UNSERVICEABLE AND TOTALED, ON JUNE 16, 2014, BUT UNCOVERED BY INSURANCE. THIS WAS NOTHING THAT I WAS AWARE OF THAT WAS AN ISSUE, NOR WERE ANY RECALLS EVER ISSUED ON THIS ISSUE. I HAD IT IN TO THE DEALERSHIP IN 2012, 2 YEARS AGO, FOR ELECTRICAL FAILURE, AND THEY THOUGHT IT WAS MERELY THE BATTERY, SO THEY REPLACED IT AND IT SEEMED TO BE FINE, BUT THEY SAID TO KEEP THE BATTERY AS A BACK UP "JUST IN CASE" BECAUSE IT STILL APPEARED TO BE A GOOD BATTERY. THEN LATER IN 2013, I TOOK IT BACK TO THE MINI DEALER FOR GENERAL SERVICE AND I SAID I NOTICED WATER IN THE BOOT (TRUNK) AND FOR THEM TO CHECK THE HATCHBACK SEAL TO SEE IF THERE WAS ANY LEAKS, THEY SAID NO, AND NO FURTHER INVESTIGATION WAS DONE FOR EITHER EVENT. I BELIEVE THAT BOTH THESE EVENTS WERE RESULTS OF THE FAULTY DRAIN HOSE FROM THE A-PILLAR BEING DISLODGED FOR SO LONG. TODAY, THE AUTOMOBILE LEFT MY POSSESSION, TO AN AUCTION HOUSE. I WANTED TO FILE THIS COMPLAINT SO THAT YOU, THE NHTSA CAN PERHAPS HAVE MINI ISSUE A RECALL TO FIX THIS ISSUE AND HAVE THEM CHANGE THEIR VEHICLE'S SUNROOF DRAINAGE SYSTEM SO THAT SOMEONE ELSE DOESN'T HAVE A CAR TOTALLY RUINED BY FLOODING DUE TO THIS DEFECT IN ENGINEERING AND DESIGN. AFTER VIEWING SOME MINI FORUMS, I AM NOT THE ONLY PERSON WHO HAS HAD THIS ISSUE HAS HAPPENED TO THEIR MINI COOPER. I'M VERY SAD, BECAUSE I HAPPENED TO REALLY ENJOY THIS CAR, AND IT WAS TOTALLY FUN TO DRIVE. I WAS ADVISED BY A FRIEND WHO IS A MOTORCYCLE MECHANIC AND MY INSURANCE AGENT TO FILE THIS REPORT WITH YOUR ORGANIZATION, IN HOPES THAT SOMETHING WILL BE DONE ABOUT THIS. TOO MANY PEOPLE DON'T SPEAK UP, AND I AM NOT ONE TO LET SOMETHING DONE WRONG TO ME GO WITHOUT A FIGHT! DO ALL YOU CAN TO RECTIFY THIS ISSUE WITH MINI! *TR

CAR IMPACTED THE REAR END OF A JEEP AT LOW RATE OF SPEED (WAS BRAKING TO AVOID CRASH IN THE FRONT). UPON IMPACT THE CAR BURST INTO FLAMES. THE AIR BAG DEPLOYED. LUCKILY THE OCCUPANT OF THE VEHICLE WAS ABLE TO GET OUT OF CAR. WITHIN MINUTES THE CAR WAS TOTALLY IN FLAMES. NO ONE WAS KILLED OR SERIOUSLY INJURED BUT IF THE OCCUPANT DID NOT GET OUT WHEN THEY DID THE OCCUPANT WOULD HAVE DIED DUE TO SMOKE OR FLAME INJURY.MY COMPLAINT IS THAT THIS LOW FRONT END IMPACT SHOULD NOT HAVE RESULTED IN IMMEDIATE FIRE AND LARGE FLAMES. I HAVE PHOTOS OF THE CAR JUST AFTER THE OCCUPANT GOT OUT OF THE VEHICLE AND ALSO PHOTOS OF THE CAR AFTER IT WAS TOWED BACK TO WRECKER YARD. *TR

UPON TURNING ON MY DRIVER'S SIDE HEATED SEAT, ONE PART OF MY BACK SEEMED TO BE GETTING EXTREMELY HOT. UPON TURNING AROUND, I SAW A SMALL HOLE HAD BEEN BURNED IN THE SEAT COVER AND WAS SMOLDERING AND SMOKING. I IMMEDIATELY TURNED OFF THE SEAT WARMER. IT TOOK MANY MINUTES TO COOL DOWN AND STOP SMOKING. THANKFULLY THE VEHICLE WAS STATIONARY WHEN THIS HAPPENED. IF IT HAD BEEN IN MOTION, MY SAFETY WOULD CERTAINLY HAVE BEEN COMPRISED, AS I COULD HAVE SUSTAINED BURNS BEFORE PULLING THE CAR TO THE SIDE OF THE ROAD. THE DISTRACTION OF A BURNING SEAT IS ALSO NOT AN INSIGNIFICANT SAFETY HAZARD AS WELL. *TR

TL* THE CONTACT OWNS A 2003 BMW MINI COOPER S. WHILE DRIVING, THE VEHICLE SHUT OFF. THE CONTACT NOTICED SMOKE COMING FROM UNDERNEATH THE HOOD. WHEN THE BATTERY WAS DISCONNECTED SHE NOTICED THAT THE WIRES WERE MELTING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS INSPECTED. THE DEALER INFORMED THE CONTACT THAT THE RELAY AND POWER STEERING PUMP BOTH FAILED AND WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 41,000. .UPDATED 09/19/11 *BF THE CONTROL HARNESS AND POWER SUPPLY HARNESS CONNECTOR MELTED ON THE POWER STEERING MOTOR. THE VEHICLE HAS SINCE BEEN REPAIRED.

BEGINNING IN APPROXIMATELY APRIL OF 2009, THE AIRBAG WARNING LIGHT HAS BEEN ON CONSTANTLY. ANYONE WHO IS INTELLIGENT ENOUGH TO USE ANY INTERNET SEARCH ENGINE CAN FIND HUNDREDS OF ACCOUNTS OF THE SAME ISSUE. DUE TO WHAT HAS BEEN INDEPENDENTLY VERIFIED AS A WIRING PROBLEM IN THE SEAT SENSORS, THE AIRBAG WARNING LIGHT IS ALWAYS ON AND CAN CAUSE THE CAR TO DEPLOY WITH IMPROPER FORCE. THIS IS A WIDELY KNOWN ISSUE WITH MINI OWNERS, AND SEVERAL INDEPENDENT MECHANICS HAVE ALL ATTRIBUTED THE PROBLEM TO A WIRING HARNESS UNDERNEATH THE SEAT THAT BREAKS DUE TO MOVING THE SEAT BACK AND FORTH. UNLESS I'M MISSING PAGES FROM THE MANUAL, MOVING THE SEAT BACK AND FORTH IS A NORMAL FUNCTION, AND IT SHOULD NOT BE CONSIDERED NORMAL WEAR AND TEAR IF SIMPLY MOVING THE SEAT BACK AND FORTH CAN RENDER THE AIRBAG SENSOR USELESS. MINI ACKNOWLEDGED THIS ISSUE IN 2006, AND STATED 'IN THE INTEREST OF CUSTOMER SATISFACTION, WE ARE EXTENDING THE WARRANTY COVERAGE OF THE VEHICLE FOR DEFECTS THAT MAY OCCUR, FOR THIS SPECIFIC AIR BAG WARNING LAMP ISSUE, ON YOUR VEHICLE FOR 10 YEARS / 150,000 MILES, WHICHEVER OCCURS FIRST. UNDER TERMS OF THIS WARRANTY COVERAGE, MINI WILL COVER ALL NECESSARY REPAIR COSTS RELATED TO THIS ACTION.' I HAVE BEEN TOLD THREE TIMES BY MINI THAT THIS DOES NOT APPLY TO MY CAR. THEY CANNOT PROVIDE ANY INFORMATION AS TO WHY IT DOES NOT APPLY. THEY JUST TELL ME THAT MY CAR IS NOT ELIGIBLE FOR THIS REPAIR DESPITE THE FACT THAT IT CLEARLY FITS THE BILL. THIS IS A MAJOR SAFETY ISSUE. THE WIRING IS CLEARLY DEFECTIVE, AND NOBODY SHOULD HAVE TO PAY OUT OF POCKET TO HAVE A DEFECT CORRECTED. MINI WON'T EVEN PAY TO HAVE A TECHNICIAN DIAGNOSE THE ISSUE. *TR

BATTERY FAILURE. BATTERY HAS FAILED FOR THE THIRD TIME SINCE CAR BRAND NEW IN FEB, 2003. ON EACH OCCASION THE VEHICLE WOULD NOT START AFTER HAVING GIVEN NO WARNING. THE FIRST FAILURE WAS IN 2005 AT 26,000 MI., THE SECOND IN 2007 AT 51,000 MI., THE THIRD IN 2008 AT 68,000 MI. EACH FAILED BATTERY WAS A MANUFACTURER'S BRAND (MINI). *TR

I WAS DRIVING HOME ONE DAY WHEN SEVERAL LIGHTS LIT UP IN MY CAR. I WAS SCARED BECAUSE THESE LIGHTS WERE: LOW TIRE PRESSURE, LOW BRAKE PADS, TRACTION CONTROL LIGHT, & ABS BREAK LIGHT. I PULLED OVER AND SHUT OFF THE CAR, AND WHEN I TURNED IT BACK ON, THEY STILL WERE LIT UP. I AM NOT SURE WHAT CAUSED THIS AS I WASN'T DRIVING ERRATICALLY, JUST NORMAL. I STILL DO NOT KNOW WHY EXACTLY THEY ARE ON, HOWEVER I FIGURE IT IS SOMETHING TO DO WITH THE COMPUTER. *TR

WHILE DRIVING AT A THREE WAY INTERSECTION MY MINI SUDDENLY CUT OUT AND BLOCKED TRAFFIC IN ALL DIRECTIONS; SO MUCH SO THAT PEOPLE HAD TO STOP TRAFFIC AND CARS NEEDED TO BE BACKED UP TO GET MY CAR IN A SECURE PLACE. THIS WAS DUE TO A DEFECTIVE WIRING HARNESS. INITIAL ESTIMATE FOR REPAIR WAS $1200 PARTS AND LABOR, BUT UPON MY COMPLAINT JUST LABOR WAS CHARGED ME - I FEEL NEITHER IS APPROPRIATE AS THIS IS A PRODUCT ISSUE, IN MY CASE A SAFETY ISSUE, AND I SHOULD BE REINSTATED TO MY PRE-HARNESS INCIDENCE AT THE PRODUCT OWNER'S EXPENSE. I FURTHER NOTICE THAT THERE IS A T.O. FOR THIS ITEM AND PART OF IT STATES ONLY REPLACE AT OWNER'S COMPLAINT - IN MY CASE THIS WAS ALMOST TOO LATE AS I WAS IN A VERY BUSY AREA WHEN MY CAR DIED AND SHUT DOWN THREE LANES OF TRAFFIC. *JB

2003 MINI COOPER S I DROVE TO WORK AS ON ANY OTHER DAY AND PULLED INTO MY USUAL PARKING SPOT. ABOUT 10 MINUTES LATER MY CAR ALARM WENT OFF. WHEN I WENT OUTSIDE TO CHECK, ALL THE ELECTRICAL SYSTEMS WERE GOING NUTS - DOOR LOCKS, LIGHTS, THE ALARM, ETC. I SAW A LITTLE BIT OF SMOKE COMING FROM UNDER THE HOOD. I POPPED THE HOOD AND BOOT, PULLED OUT MY FIRE EXTINGUISHER, BUT DIDN'T SEE FLAMES. I SMELLED ELECTRICAL FIRE, AND SAW A WHISP OF SMOKE BUT THAT WAS IT. I EMPTIED THE BOOT AND TRIED TO DISCONNECT THE BATTERY (I HEARD SOMETHING 'WHIRRING' AND REALIZED THAT THE ELECTRICAL SYSTEM WAS OBVIOUSLY MALFUNCTIONING.) I COULDN'T DISCONNECT IT MANUALLY SO I LEFT IT AND CHECKED THE ENGINE BAY AGAIN. STILL NO FLAME, BUT MORE SMOKE. I RAN INSIDE AND ASKED A CO-WORKER TO CALL THE FIRE DEPARTMENT. THEN GRABBED MY PHONE AND RAN BACK OUT. ANOTHER CO-WORKER CAME OUT WITH ME AND HELPED ME GET THE FIRE EXTINGUISHER WORKING; NOW WE COULD SEE SOME SMALL FLAMES COMING FROM BELOW THE AIRBOX. I USED UP THE EXTINGUISHER BUT THERE WAS STILL A LITTLE FIRE. FORTUNATELY IT WORKED ITSELF OUT... THEN THE FIRE DEPARTMENT SHOWED UP. THEY DISCONNECTED MY BATTERY AND HAD A LOOK. THEY SAID THAT USING THE EXTINGUISHER DEFINITELY KEPT IT FROM SPREADING. THEY FILED A REPORT BUT TO MY KNOWLEDGE THERE WAS NO POLICE REPORT. THE DAMAGE STARTED WITH THE POWER STEERING PUMP IGNITING. THE PUMP WAS REPLACED ALONG WITH SOME WIRING HARNESSES AND A FEW OTHER ASSORTED PARTS. THE ENGINE BAY WAS DETAILED TO GET ALL THE FIRE EXTINGUISHER 'GOO' OUT OF IT. THE CAR HAS BEEN FUNCTIONING NORMALLY FOR ALMOST A YEAR NOW WITH THE NEW PARTS. MORE INFO HERE: HTTP://WWW.NORTHAMERICANMOTORING.COM/FORUMS/SHOWTHREAD.PHP?T=73527. *TR

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT STATED THAT ON THREE OCCASIONS, THE MAT OCCUPANCY SENSOR ON THE FRONT PASSENGER'S SEAT WAS REPLACED DUE TO THE WARNING LIGHT BEING ILLUMINATED. THE VEHICLE WAS TAKEN TO MINI OF BIRMINGHAM LOCATED AT 2001 TOM WILLIAMS WAY, BIRMINGHAM, AL 35210, 205-267-4505. THE CONTACT WAS INFORMED THAT THE MAT SENSOR NEEDED TO BE REPLACED AT A COST OF $1,200. THE CONTACT WAS ALSO INFORMED THAT THE PART MAY ALSO BE AVAILABLE AT THE LOCAL JUNKYARD. THE MAT SENSOR WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE CONTACT WAS INFORMED THAT THE SEAT SHOULD BE REPLACED WHICH WAS STILL PENDING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.

WHILE DRIVING 10 MPH A FIRE STARTED IN THE DASHBOARD. CONSUMER MANAGED TO PULL OVER, AND PUT OUT THE FIRE OUT. THEN HAD THE VEHICLE TOWED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

COMPUTER(S) FAILURE RESULTING IN A LOST OF ABILITY TO MOVE FORWARD OR REARWARD. THE ENGINE COMPUTER(S) HAVE BEEN REPLACED AS WELL AS THE TRANSMISSION.

MINI COOPER 2003 STOP DEAD AT THE THE INTERSECTION FOR THE THIRD TIME.THE CAR WAS TOWED TO THE DEALER. *AK

THE COMPUTER SYSTEM DOESN'T SEEM TO BE WORKING PROPERLY. MY CAR JUST STOPPED RUNNING WHILE DRIVING IN RUSH HOUR TRAFFIC (THIS HAPPENED TWICE.) MY KEY-LESS ENTRY DOESN'T WORK. FINALLY, THE TIRE FAILURE LIGHT COMES ON WHEN THE TIRE PRESSURE CHANGES BUT IT DOESN'T LIGHT UP WHEN I HAD A FLAT.*AK

DRIVER'S SIDE ELECTRIC WINDOW WOULD NOT OPEN FOR 18 HOURS. THIS OCCURRED AFTER A HEAVY RAIN STORM AND DID NOT CLEAR UNTIL AFTER A 20 MINUTE DRIVE THE FOLLOWING DAY. ATTEMPTS TO OPEN THE WINDOW THE DAY AND EVENING OF THE FAILURE WHILE PARKED AND DRIVING ALL FAILED. *CB