2010 MINI Cooper

The dealer refused to perform the required FRM recall inspection and denied the recall without providing any of the federally required documentation. I was forced to pay out‑of‑pocket for the FRM module replacement even though my VIN is listed under the safety recall. MINI of Murray stated my FRM “failed,” but admitted they never opened the module, which is required to determine internal moisture intrusion. • The Service Manager stated they based their denial on “carpet and headliner moisture,” which is not part of the FRM recall inspection procedure. • I requested the FRM inspection report, photos, and the MINI Corporate denial code. I received none of these. • MINI Corporate Recall Team confirmed they had no documentation from the dealer and incorrectly stated that the module does not need to be opened. • Without a completed inspection uploaded to MINI Corporate, a denial code cannot be generated. • I was charged for the FRM replacement part, even though the recall should cover the repair if the module is affected. • The dealer only offered to waive a $149 programming fee. Safety Concern: The dealer failed to follow required recall procedures, failed to document the inspection, and denied federally mandated recall coverage without evidence. This violates recall protocol and leaves the safety defect unresolved. The module was replaced at my expense.

The vehicle is experiencing repeated failure of the Footwell module (FRM), a known defect acknowledged by MINI/BMW. During the two years I have owned the vehicle, the FRM has required four separate reflashes due to recurring malfunctions. The failure causes loss of proper power window operation, including the passenger window reversing or rolling down unexpectedly, and loss or malfunction of other body electrical functions controlled by the FRM. Headlamps will not turn off, resulting in a dead battery and electrical/intermittent dash light surges. The FRM failed again after a software reflash, which is a documented trigger for FRM internal memory corruption. MINI/BMW issued and Extended Limited Warranty for FRM failure, acknowledging this defect; however, I received the official notice after the warranty period had already expired, leaving no opportunity to repair the defect while covered. This failure affects safe operation of the vehicle, including the inability to properly secure windows and maintain normal electrical functionality. The issue is not due to wear or misuse, but an internal electronic defect recognized by the manufacturer. The repeated nature of the failure and reliance on reflashing demonstrate the defect was never fully resolved. I am reporting this issue to document the repeated failures, late manufacturer notification, and ongoing safety-related electrical system issues. I purchased the vehicle with 86,000 miles. It now has 100,000, well below the criteria for the LW. In the 14,000 miles and two years I have owned and driven it, it has required four FRM reflashings. Had I known about the Extended Limited Warranty, I would have had BMW repair it under said warranty. That wasn't possible because I received notice of the known failure after the ELW expired.

On Thursday I was driving my 2010 Mini Cooper S with 75,000 miles on it and there was a total and sudden power outage on the high way. I was able to get to the breakdown lane and had it towed. My mini certified garage ran the computer on it and the car started right up. It was due for an inspection so we did an oil and filter and put on some new tires. No issues were found and car was running well. We picked it up on Friday and Saturday morning after a short drive I was parking and smoke started pouring out from behind the steering wheel. I ran inside a coffee shop for help and they asked if there were flames. I went back out and opened the car door and there was loud noise and the hood was in flames. The entire dash was melted, the hood had a hole burned in it and with the fire rescue interventions the car was a total loss. No one was injured.

The passenger airbag with seat belt icon is always indicating no one is in the seat or not buckled. The alert icon for the lighting is also on and we have replaced bulbs and still won’t work and the windows at times just randomly stops would have to unplug battery for it to reset for the windows only. I just bought this car and have registered since. Was told there was several recalls with the same issue I am experiencing. Please include my car for the proper recalls so I can have a safe reliable vehicle for my family.

Passenger Airbag sensor is off even when passenger is in the seat and airbag should be on.

In an attempt to resolve persistent rough running engine issue, mechanic discovered that the timing chain guides failed (broke apart) and that plastic pieces of the guides migrated into the engine oil system.

Engine issues Engine leaks over heating seal gasket Timing bell Engine missed firing

Engine stalling Oil pan leaks Caused the engine to shut down when slowing down or sitting in traffic on highway. No warning lights prior to incidents Only right after

Airbag light is deployed when passenger is sitting in seat. Module under seat is not recognizing the passenger and airbags are turned off. This is a safety concern in likeliness of an accident the passenger could be injured.

The car showed a check vehicle light. Looks like a car being lifted up (red light). The windows do not move up or down, light switches do not work and the blinkers do not work. I was told by my mechanic it was the footwell module. I read there was a recall for this but my VIN wasn't on the list. Is it possible to check to see if it should have been on the list for the recall?

Trailer brakes disconnected in 18k lb trailer while driving down mountain. This bulletin is the issue, should be a recall. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On [XXX], mileage was 47,744 I took Mini for service, and told them that the front right headlight didn't work, they replaced the light bulb and they found out that the headlight was still inoperable, and internally shorted. They didn't want to include it in the extended warranty. The mini has electrical issues (FRM). The headlight wires are damaged inside the light housing and are bare-striped even if you change the light bulb when you hit a bump the wires touch the bulb short out. So my car was under the extended warranty when I took it to Braman Motors Miami for service but they failed to correct the problem. BMW of North America extended the warranty for 10 years /156,000 miles whichever occurs first, as determined by your vehicle's service date (original service date is 3/16/2010) extending the limited warranty for the Footwell Module (FRM) This problem is a known problem by BMW / Mini they currently have open recalls on the model, series, production date, and year. but since hardly anyone files complaints to NHTSA in Fla, this problem is ongoing. [XXX], under violation of federal law (The Safety Act) dealers can't sell, lease, or deliver any vehicle until recall repairs have been performed. But they overlook the problem at the dealership when the car is in the shop for service. I was given a multi-point inspection it passed 28 of them LOL, but the first one (Operation of all light and signals, (passed)...lol So how can this test pass? When I picked up the Mini nothing was working turn signals, the front right headlight, windows, hazard lights, fog lights. However, the dealer overlooks the safety recall and wants to charge the client an additional charge to diagnose the FRM. They gave me an estimate for $1,985.38 if I had approved the work that they said the Mini needed, but nothing to do with the recall (FRM) is this how BMW handles this safety recall? They don't care to solve the problem at any level dealer or manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2010 Mini Cooper S Hartop. The contact stated that while driving at 25 MPH with the two sunroofs open, the vehicle caught fire. There were flames underneath the rear of the vehicle. There were no warning lights illuminated. The contact opened the hood and threw baking soda on the flames but sustained burns to her hands and face, and medical attention was provided. The neighbors had used a fire extinguisher to put out the fire. The fire department was able to extinguish the fire. The airbags did not deploy. A police report was filed. There was no crash. The vehicle was previously taken to an independent mechanic who replaced the footwell control module. The vehicle was towed to a tow lot. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. Parts distribution disconnect. The failure mileage was approximately 130,000. The insurance deemed the vehicle a total loss.

My 2010 Mini Cooper convertible recently had an electrical failure. I lost power while driving and the power steering wouldn’t work. Once it started again the blinkers wouldn’t work and brake lights and radio worked intermittently. I took it to the mechanic and the diagnostic determined that the footwell module is bad. Unfortunately this part is apparently on back order so the part cannot be ordered. The car is not safe to drive nor is a solution available. I looked up recalls on Mini coopers. This current recall shows that the footwell module has been recalled on 2010 hardtop Mini Coopers: MINI Recall 23V-xxx: Footwell Module Attachments: BMW AG is conducting a Voluntary Safety Recall (effective May 11, 2023) on certain Model Year 2007 - 2014 MINI vehicles that were produced between November 16, 2006, and June 27, 2014. (Due to several contributing factors (environmental, certain US States’ wintertime road treatment, vehicle design configuration and age), over time, the Footwell module (FRM) could become susceptible to corrosion) It doesn’t make sense that the exact year Mini in hardtop has the recall. Clearly the footwell modules are a problem in convertibles as well. The wording of the recall says that winter conditions can contribute to the problem. My convertible resided in a winter area for 10 years. I believe that the Mini Cooper convertibles should be included in the recall.

Unknown. I’d just like to know how long Mini is allowed to work on a solution for the safety recall for the footwell control module that was issued last May. Given that they have known about problems with this module for years, it seems to me that they should have a solution ready to deploy by now. Thanks for your assistance.

The contact owns a 2010 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

My vehicle started smelling intensely like burning plastic which filled the compartment. I brought it immediately to the repair shop. I had it towed in. It was apparent something was on fire. When I got to the repair shop (not mini) the electrical components for the interior, turn signals and windows) had failed and smoldered. There were no warning lights. I was told that there was a recall for the Footwell Module and that this had caused the problem. I never received a letter for the recall. The car is registered in California but was first sold in New York and so it qualifies for the recall but when I look up my VIN it says no recalls. The part has failed, and they have told me they have no replacement part yet so my car is now sitting with a car cover with the windows rolled own because they cannot roll up without the Footwell Module. Mini says they have no solution. I had to buy a new car. This was not an easy expense for me as I have limited income due to a disability.

02/16/2023 i purchase mini cooper s from a private owner i paid cash 6,0000 for the car 2 months later my car broke down i had my car towed to a shop i was told that my motor mounts had no bolts or screws and that what cause my car to break down it also broke my intake and wheel bearings had to be replaced total cost 1,600.00 On 08/04/2023 my car breaks down i was told that my valve broke and two cylinders needed to be replace the mechanic also told me that my card did not have the miles that it showing on the odometer when i purchase my car odometer read 156,000 miles i was told my mechanic that my car has almost 300,000 miles and the memory brain on my car is ready it a 2006 but my vin number said 2010 im having to replace my engine on my car still in th shop at i already paid up front 4200

COPY OF COMPLAINT sent to MINI USA today 9/2/24. (Removed my personal data -name, address, email, phone number): I have been waiting since JULY 2023 for notice of a fix for this DANGEROUS ISSUE of failed FOOTWELL MODULES that can CATCH ON FIRE! How is this either legal or humane? When I call, and I call regularly, to ask about any progress made in CORRECTING THE POTENTIALLY FATAL to the driver, problem, I'm asked to BE PATIENT...that a fix is being studied but none has become available. And, oh yes, always the "FOOTWELL FIRES are very very rare"...so I suppose if I have one and I DIE my heirs should take comfort in knowing that it was very very rare? Here's the bottom line. I spoke with a service manager at MINI OF LOVELAND and I will not divulge his name because he doesn't deserve to be reprimanded or hassled. I asked him if they were replacing ANY FOOTWELL MODULES BECAUSE OF THE RECALL. I was given the same BS about "working on creating a part that will fix it". Yeah, right. But here's the jewel in this conversation: When I asked what they'd do if my Footwell module failed for MECHANICAL REASONS he told me and I BELIEVE it's a fix that should be offered to all affected owners: "He told me that when FWMODULES in my make/model/year mini, fail (not catch fire but fail as they normally do - i.e. windows won't go up or down, OR turn signals and or/headlights won't work, etc. the fix for that also address the recall issue: REPLACE THE FOOTWELL WITH THE SAME PART with these modifications to address the corrosion/fire recall: They remove the old broken module. They clean out the entire footwell removing any signs of corrosion from the leaked in water. THEY PACK the module with material that will prevent moisture from seeping in. AND then they close it back up! AT NO CHARGE TO THE OWNER> I WANT THIS FIX! I deserve this fix as do other mini owners who are affected by this recall to prevent death or severe burns or both from failed footwell modules. THANKS

The contact owns a 2010 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact recently stated that the vehicle failed to start without warning. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.