2014 Ram 1500 Engine Problems

The contact owns a 2014 Ram 1500. The contact stated that while his wife was driving approximately 45 MPH and entering the freeway, the driver heard an abnormal popping sound, and it felt as if the vehicle had been rear-ended. The message "Throttle Alert" was displayed, and the vehicle failed to exceed 50 MPH while depressing the accelerator pedal. The driver was unable to pull over to the side of the road due to oncoming traffic. The driver was able to drive the vehicle to the dealer, where it was diagnosed that the crankshaft position sensor tone wheel had fractured and was missing. The dealer determined that the part needed to be replaced. The contact related the failure to NHTSA Campaign Number: 20V475000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 199,000.

TICKING NOISE FROM 3.6l PENTASTAR ENGINE. SAFTEY CONCERN COULD RUIN MY ENGINE CAUSING STALLS AND MISFIREING AND SEZEING.

This complaint concerns failure of the remedy for Safety Recall Z46 / NHTSA Campaign 22V406 involving the high pressure fuel pump (HPFP) on a 3.0L diesel pickup. The HPFP had previously been replaced under the recall by an authorized dealer. About 19 months later, while the vehicle was at a dealership for service, the replacement HPFP failed again during dealer testing. The dealer documented metal contamination throughout the fuel system caused by the HPFP failure. The dealer then replaced the contaminated fuel system components. After those repairs and during post-repair test driving, the vehicle developed new bottom-end engine noise. The dealer later documented connecting rod bearing damage / rod knock and recommended complete engine replacement. The vehicle had been brought in with no bottom-end engine noise, and the dealer’s intake inspection documented oil condition as OK. An independent oil analysis later showed the engine oil was normal and did not indicate long-term lubrication failure. This suggests the engine damage occurred acutely after the HPFP failure and resulting contamination event, not from routine wear. This condition creates a serious safety risk because HPFP failure can cause loss of fuel pressure, engine stall, or loss of motive power, and the subsequent engine damage raises the risk of sudden engine failure or seizure while driving. That could increase the risk of a crash, especially in traffic or at highway speeds. The failure was confirmed by the dealer and is documented in the repair order. The vehicle remains inoperable and is available for inspection upon request. I am requesting investigation into whether the recall remedy was adequate, since the recall replacement HPFP failed again and the resulting contamination appears to have led to catastrophic secondary engine damage.

Flexplate (flywheel) had tone wheel dislodge and destroy crank position sensor. After a $2200 repair quote from dealer and while at the dealer the repair shop claims the engine is failed completely and new ecodiesel engine is needed. Crankshaft is suspected failure. Vehicle had total loss of power when crank tone wheel failed. Very dangerous to find a shoulder without power while towing travel trailer. Vehicle was purchased due to longevity expected from diesel engine.

The contact owns a 2014 Ram 1500. The contact stated that the vehicle experienced rough idling with the check engine warning light illuminated. The vehicle was taken to the local dealer who diagnosed that the piston rod was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not yet contacted. The failure mileage was 140,000. The VIN was not available.

this vehicle is equipped with 3.0 litre ecodiesel. truck has been in for numerous recalls--no problem. i have spoken to numerous buyers of these trucks with this engine and virtually everyone has replaced engine once or sometimes twice. i needed to replace toner wheel behind flywheel a couple weeks ago. this was a 1200.00 fix. stellantis's fix was to reprogram ecu so engine would not fail on highway but did not address the root cause of the problem. i find it appalling that stellantis has not been forced to extend the warranty on these engines since every customer paid extra for the longevity of diesel power. i am afraid to drive this truck since there are probably 2-3 rams every week on facebook marketplace locally with seized engines. this truck has 135000 miles and i am afraid the end is near.

The contact owns a 2014 Ram 1500. The contact stated while accelerating to overtake another vehicle at 55 MPH, the vehicle lost motive power. The contact was able to pull over safely; however, the vehicle was difficult to restart. The electronic throttle control warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed. The dealer informed the contact that the failure was related to NHTSA Campaign Number: 23V411000 (Engine and Engine Cooling). The diagnostic test determined that the tone wheel needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 235,000.

The crankshaft position sensor and tone wheel failed which is the recall for 66A, was driving truck 45mph down heavily traffic roadway, truck died and stopped in the middle of road. took truck to dealership and dealer charged diagnostic fee explained to them that issue sounded like a crankshaft issue and was showing crankshaft codes. They refused to look into this and do the recall. Went and picked the truck up took it to a local mechanic, mechanic diagnosed issue come to found out it was indeed the crankshaft sensor and tone wheel that was the issue, purchased mopar oem parts and installed in vehicle, once repaired vehicle started and ran perfectly.

The contact owns a 2014 Ram 1500. The contact stated while driving at an undisclosed speed, the vehicle stalled, and the engine seized. In addition, the shift to park warning light was illuminated. The contact stated that the vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed with a failed tone wheel. The contact was informed that the tone wheel needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the complete fuel system and high-pressure fuel pump were replaced. The manufacturer was made aware of the failure and a case was filed. The contact referenced NHTSA Campaign Number: 20V475000 (Engine and Engine Cooling); however, the VIN was not included. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 150,000.

We have a 2014 dodge ram 1500 SLT with a 5.7 hemi. I was driving down the road and stopped at a red light and the truck shut off and wouldn't start again we had to tow it home. We had a mechanic look at the vehicle and run the codes for the truck to find out what was wrong it was a misfire in cylinder 3. We called a few mechanic shops in town to get other opinions and they all said the same thing its more than likely the lifters or the camshaft is bad and its a very common problem with this model truck with the engine and it would cost over $5,000 to fix it. I spoke to the dodge dealership in our town they said the same thing its more than likely the lifters they see it all the time and its around $5,000 plus to fix. Why is this allowed to happen if so many people are having this specific issue with this specific truck and this specific problem with the engine and cost us thousands to fix. This is a major safety issue what if the engine stopped while I was driving this could cause an accident. If you look it up online as well everyone is saying the same thing their problem was with the lifters. We haven't been able to get it fixed because of the cost and the cost to tow it to a mechanic. We just have it sitting in our driveway and when I found out so many others have this same issue something needs to be done.

This truck has many issues including emmissions problems thst cussed the truck to go into limp mode related to the boost sensors. This happened to me 3 times on the freeway when the truck flashes service electronic throttle control and power is reduced. On October 28th I was driving the truck on 55 mph roads. As I came to a 45 mph road, the engine started knocking. As I got into stop and go traffic the oil pressure started dropping to 0 and back to normal and the knock got louder. I had the truck towed into the dealership where they verbally quoted me over $24,000 for a new motor. The truck had just over 118,000 miles on it. They stated none of the repairs would be covered by the extended emissions warranty. The dealership then allowed me trade the truck in for less than the value ($16,000) causing extra thousands of dollars to be spent instead of repair. The dealership stated it would be an auction truck. On 11/6 I found that the truck had been listed on the dealerships website for $21,325. There is no mention of the repair or defects on the truck and that price is less than what I was quoted for a motor replacement.

The contact owned a 2014 Ram 1500. The contact stated that while driving 60 MPH in the mountains, the check engine light illuminated. There was an abnormally strong odor of anti-freeze inside the cab. There was antifreeze coming from the tailpipe. The contact and her son noticed smoke on the side of the vehicle. The contact decreased her speed to approximately 45 MPH and was able to pull over. After stopping, the vehicle caught fire and was engulfed in flames. The contact stated that the failure was related to NHTSA Campaign Number: 19V757000 (Engine and Engine Cooling). The contact, her son, and her dog were able to exit the vehicle safely. The contact and her son sustained a traumatic injury, but medical attention was not provided. The dog sustained unknown injuries and was taken to the veterinarian for medical attention. A police report was not filed. The fire department was able to extinguish the fire. The local dealer was contacted. The vehicle was not diagnosed or repaired. Before the failure, the vehicle had been taken to the same dealer for NHTSA Campaign Number 19V757000 (Engine and Engine Cooling). The manufacturer was not made aware of the failure. The vehicle was towed to a tow lot. The insurance company deemed the vehicle a total loss. The failure mileage was approximately 100,000.

The contact owns a 2014 Ram 1500. The contact received notification of NHTSA Campaign Number: 22V406000 (FUEL SYSTEM, DIESEL) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2014 Ram 1500. The contact stated that while driving approximately 70 MPH, there was a chemical burning odor inside the cabin of the vehicle. Later, while driving the check engine warning light illuminated, and the "throttle body" message was displayed before the vehicle decelerated and stalled. The vehicle was taken to the local dealer who diagnosed that the crankshaft position sensor was faulty and needed to be replaced. The vehicle was not yet repaired. The contact stated that the vehicle was previously serviced under NHTSA Campaign Number: 20V475000 (Engine, Engine Cooling); but later experienced the failure listed in the recall. The manufacturer was not yet contacted. The failure mileage was 138,000.

This vehicle lost power while driving and would not re-start. A message came on dash saying “service electronic throttle” and then the vehicle burst into flames. There is a recall for other models with the same engine but not this vehicle. It is a safety hazard that almost killed me.

I was driving back home after a long day of work, but I stopped at the gas station first. After putting gas.I started to pull out of the gas station, when the truck suddenly turned off. I turned it on again and a couple miles ahead it started to loss speed. I was going 65 suddenly went down to 40 20 started to stall had to exit the fwy before it stopped. Auto shop say it's the engine. Cost to repair $8,000.00.

Exhaust manifolds on 5.7 Litre Hemi’s, bolts that hold exhaust manifold to head break often resulting in exhaust manifold to warp, common issue on various years of 5.7 hemi, the exhaust gases leaking from around the manifold therefore can pass through the firewall, and cabin vent system causing the occupants inside cab to breath dangerous exhaust gases, also resulting in uncontrolled exhaust levels that are not being passed through exhaust system properly equaling higher exhaust emissions. Department of Transportation (DOT) put Tractor Trailers out of service for similar issues due to the health safety risks. This is a common issue with Dodge Hemi 5.7 litre engines of various years and should be a serious issue as breathing carbon monoxide and traces of carbon dioxide are very harmful. Please look into this, the dealership has repaired mine twice with the same faulty parts and now it is bad again and said vehicle only has 70,000 miles on it. Thank you. This is third time first one occurred in 2018 was covered under warranty and only had around 25,000 miles on it.

rear Exhaust manifold bolts broken off in engine allowing gas into the cabin. Ram dealer wants $1900 to repair.

The contact owns a 2014 Ram 1500. The contact received notifications of NHTSA Campaign Numbers: 22V406000 (Fuel System, Diesel) and 23V411000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated while her husband was driving approximately 45 MPH, the vehicle jerked, and the instrument panel gauges were fluctuating. The vehicle then lost motive power. There was no warning light illuminated. The contact's husband was unable to pull to the side of the road. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed and determined that the failure was related to NHTSA Campaign Number: 23V411000 (Engine and Engine Cooling). The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact that parts were not yet available. The failure mileage was unknown. VIN tool confirms parts not available.

My 2014 ram 1500 has a ticking noise which in turn is creating an exhaust smell inside my vehicle which is making me dizzy / sleepy when I drive.