2015 Ram 2500 Electrical System Problems

Airbag light triggered and message center says service airbags system. Horn does not work and all steering wheel controls do not work. Traced to bad clock spring in steering wheel. Will not pass inspection. Self diagnosed. Warning light always on and message center says service airbags on every start up. Possible severe injury during a front end collision..

MANUFACTURER VIOLATION OF FEDERAL TREAD ACT REIMBURSEMENT REQUIREMENTS Vehicle experienced ABS hydraulic control unit failure in September 2022 with warning lights and transmission shifting problems. Repairs cost $5651 addressing brake system hydraulic control unit defects. In November 2024, manufacturer issued Recall C7B/NHTSA 24E-100 for identical hydraulic control unit ABS defects affecting 2012-2018 Ram vehicles. Federal regulation 49 CFR 573.13 requires manufacturers reimburse pre-notification repairs reasonably necessary to correct recalled defects. Manufacturer FCA US LLC improperly denied reimbursement under case 92237530, claiming parts not covered under recall repair. This violates federal TREAD Act mandatory reimbursement requirements. Manufacturer referenced wrong recall campaigns in denial letters, demonstrating failure to properly evaluate claim under applicable federal regulations. Request NHTSA enforcement action to compel manufacturer compliance with federal reimbursement obligations. Manufacturer operates established reimbursement system but improperly applies federal requirements. Safety defect was present in 2022 and subsequently recalled, establishing federal obligation for pre-recall repair reimbursement. Wilson v FCA class action settlement demonstrates manufacturer previously paid identical hydraulic control unit replacement costs for same defect type.

The contact owns a 2015 Ram 2500. The contact stated while the vehicle was parked, driving, or attempting to depress the brake pedal, the integrated trailer brake control failed to respond as intended while the trailer was hitched to the vehicle. The contact stated that an independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the integrated trailer brake control was not receiving adequate power, due to a faulty brake control not functioning as intended. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 207,000.

After parking right after a paid car wash, the truck wouldn’t start and had no power to any component. Couldn’t get vehicle out of park. Batteries fully charged and no issue with terminals. There would be random moments when power came back but when starter was pressed, a clicking sound would occur and all power shut down again. Truck had to be towed to dealership where they were unable to duplicate or determine what caused the problem. Our concern is not being able to move the vehicle out of danger when this occurs or the danger of it occurring while in motion, which we experienced years ago with a Jeep Grand Cherokee.

10 months ago engine would die 1x/months Then 2x/months Then Weekly Titusville FL dealer changed ignition and wire harness, $865 & no change. 1x/months is now every mile. In Texas. This is dealer ripped me off.

While my truck was parked and running (auto-started: FACTORY auto start), truck spontaneously burst into flames and burnt down before fire dept could get to it and put it out. TOTAL LOSS. Of note: fire dept was about 100yds away and responded as soon as we saw flames.

The blower motor for my air conditioner and heater is not working properly. The service company told me this is an ongoing issue with this model truck and I should file a complaint due to the number of incidents They are having with this vehicle with this problem. The service technician stated the computer box was full of corrosion from not being sealed properly from the factory. The service technician also stated that if the corrosion continues and the issue is not corrected, it could affect the entire ECM of my truck and my truck will not start.

RADIO FAILS TO STAY OPERATIONAL AFTER VEHICLE IS STARTED. IT WORKS WHILE THE KEY IS IN ACCESSORY POSITION, BUT DOES NOT WORK ONCE THE CAR IS STARTED. I AM ALSO UNABLE TO USE THE BACKUP CAMERA BECAUSE THE RADIO DOES NOT WORK. THAT IS A SAFETY ISSUE

TL* THE CONTACT OWNS A 2015 RAM 2500. THE CONTACT STATED WHILE DRIVING THE VEHICLE, THE ELECTRONIC VEHICLE INFORMATION CENTER MALFUNCTIONED AND THE DISPLAY SCREEN FROZE AND ONLY DISPLAYED THE VEHICLE'S SPEED. DUE TO THE FAILURE, THE DRIVER WAS UNABLE TO ACCESS OTHER SAFETY INFORMATION SUCH AS TIRE PRESSURE AND TOWING. ADDITIONALLY, THE HORN NO LONGER OPERATED AS DESIGNED. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE MANUFACTURER WAS CONTACTED. THE LOCAL DEALER WAS NOT YET NOTIFIED. THE FAILURE MILEAGE WAS 42,080.*DT*DT

BLOWER MOTOR WORK INTERMITTENTLY, STARTS AFTER DRIVING FOR 30 MINUTES OR MORE. *TR

DRIVERS AND PASSENGER WINDOWS DO NOT RAISE OR LOWER BUT THE BACK SEAT WINDOWS ON BOTH SIDES RAISE AND LOWER FINE. THE OUTSIDE MIRRORS WILL NOT RETRACK AND THE RADIO DOES NOT TURN OFF WHEN THE KEY IS TURNED OFF AND REMOVED, EVEN IF TO GET OUT OF THE TRUCK AND USE THE REMOTE AND LOCK THE DOORS THE RADIO REMAINS ON, THE ONLY WAY TO TURN IT OFF IS USING RADIO KNOB TO TURN IT OFF. THE REMOTE START ONLY ALLOWS THE TRUCK TO RUN FOR 5 SECONDS THEN SHUTS THE ENGINE OFF. THIS TRUCK HAS A MIND OF IT SELF WITH THE DRIVER NOT BEING ABLE TO CONTROL THE FUNCTIONS. IT HAS BEEN SEEN BY DODGE MANY TIMES IN TEXAS AND NOW ARIZONA OVER A SPAN OF TWO YEARS.

WHEN I BUMPED THE IGNITION KEY WITH MY KNEE WHILE DRIVING 75 MPH ; THE ENGINE DIED. I HAD TO COME TO A COMPLETE STOP, PUT THE VEHICLE IN PARK, AND PRESS ON THE BRAKE TO RESTART THE ENGINE. I LOST POWER STEERING WHILE PULLING A LOAD IN HEAVY TRAFFIC.

I WENT OUT TO THE GARAGE AND STARTED THE TRUCK ON 2/19/2019 TO LEAVE ON VACATION. I DROVE APPROXIMATELY ONE MILE AND TURNED THE ENGINE OFF. UPON RETURNING TO THE TRUCK, THE ENGINE WOULD NOT START AND THE DASH SAID WRONG KEY FOB. WAITED 15 MINUTES NO START AND ONE HOUR LATER STILL WOULD NOT START HAD IT TOWED IN FOR SERVICE. THE DIAGNOSTIC TESTING SHOWED THE KEY FOB LOST CODE FOR THE IGNITION. CODE B1A7B-01 IGNM GENERAL ELECTRICAL FAILURE. THIS IS THE SECOND TIME THAT HAS HAPPENED TO THIS TRUCK. THE OTHER TIME WAS IN JULY, 2016. AT THAT TIME I WAS IN MY DRIVEWAY TRYING TO MOVE THE TRUCK WHEN THE DASH KEPT TELLING ME WRONG KEY FOB. SOMETIMES ONE KEY WOULD WORK AND THE OTHER KEY WOULDN'T AND VICE VERSA. I FINALLY GOT IT STARTED AND DROVE TO THE DEALER. THE KEY FOB LOST CODE FOR THE IGNITION WAS ALSO THE PROBLEM AT THAT TIME.

The first time I started to have issue was rear ABS sensor started going in and out got repaired and they said the wires going down the frame rail are getting pinched by the fuel tank in the frame rail then my backup camera went and same issue I was told by dealer and now my drivers side rear blinker is doing the same where starting to not work and from what I found the wires are being broke between fuel tank and frame rail from the factory they way the run the harness

WHILE YOUR DRIVING THE VEL SHUTS OFF AND YOU LOSE POWER THE BRAKES DONT WORK AND YOU CANT DRIVE THE VEL ITS HAPPEN 3 TIME IN THE LAST WEEK THE DEALER SAID IT IS NOTHING PLUS THEY SAID THERES NO RECALL ON ANYTHING

WIRE HARNESS CHAFED CAUSING THE BCM TO SHORT OUT AND LOST USE OF FUEL GAUG.

THE NAVIGATION DOES NOT TRACK MY VEHICLE PROPERLY. THE KEY FOBS FAIL OVER 50% OF THE TIME. THE UCONNECT APPLICATION ON MY PHONE FAILS TO WORK OVER 50% OF THE TIME AND TRUCK WILL NOT START, LOCK OR UNLOCK. THE TRUCK SAYS THE KEY FOB LEFT THE VEHICLE WHEN IT IS STILL IN THE VEHICLE CAUSING A SAFETY CONCERN WHEN DRIVING. EVEN WITH NEW BATTERIES IN THE FOBS. THE UPDATES HAVE FAILED DIFFERENT TIMES DUE TO SOMETHING CALLED THE SIERRA BOLO WIRELESS CARD. THE MORE AND MORE I HAVE EXPLORED WHAT COULD BE THE ISSUE, THE MORE CASES LIKE THIS I SEE AND WONDERING WHY THERE IS NO RECALL ON IT. THIS STARTED TAKING PLACE AS SOON AS I PURCHASED IT IN THE FALL OF 2017.

I [XXX] WENT TO [XXX] AND TALKED TO [XXX] TO HAVE FIXED BECAUSE OF THESE RECALLS THAT I HAVE GOTTEN ON MY WORK VAN AND HE SAID THAT I WOULD HAVE TO LEAVE MY WORK VAN FOR 2-3 DAYS TO GET IT FIXED WHICH I THINK IS ABSOLUTELY NOT OK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

EITHER FROM A COLD START OR WHILE STARTED AND IN PARK, BUT ALWAYS STATIONARY, THE GEAR SHIFT INDICATOR WILL INDICATE IN REVERSE, BUT THE TRUCK IS IN PARK. SO, NOW THE KEY CAN NOT BE TURNED OFF AND REMOVED NOR CAN THE KEY BE TURNED TO START THE ENGINE, AND THE GEAR SHIFT CAN NOT BE MOVED UNLESS THE OVER RIDE BUTTON IS PRESSED, BUT THE ENGINE CAN NOT STILL BE STARTED. IT WILL RESET AND BE ABLE TO BE STARTED AFTER A PERIOD OF TIME RANGING FROM AVERAGE OF 15 MINUTES TO ONE HOUR, I ONCE HAD TO HAVE THE TRUCK TOWED BECAUSE IT WOULD NOT RESET AFTER ABOUT 5 HOURS. THE TRUCK HAS BEEN TO THE DEALER 4 TIMES FOR THIS PROBLEM AND THE DEALER AS WELL AS CHRYSLER CAN NOT DUPLICATE THE PROBLEM AND STILL DENY THAT A PROBLEM LIKE THIS EXIST IN ANOTHER VEHICLE. I HAVE FILED THE LEMON LAW PAPER WORK AND WILL BEGIN THE PROCESS WITH IT.

TL* THE CONTACT OWNS A 2015 RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16E039000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.