There are 6 stored owner reports matching the brakes leading-label group for the 2003 Saturn Ion in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 6 of 6 matching reports.
Open the full vehicle complaint log (all categories)2003 SATURN ION COUPE WILL NOT START IN COLD HUMID WEATHER. *TR
BRAKES INSTALLED ON MY 2003 SATURN ION BY FIRESTONE SERVICE CENTER FAILED A WEEK AFTER INSTALLATION RESULTING IN A AUTO ACCIDENT. I HAD TO TAKE MY CAR TO 4 FIRESTONE COULD FIX THE PROBLEM. *TR
WHEN IT RAINS OR SNOWS, MY DRIVER SEAT AND FLOOR GETS WET. THERE ARE NO WATER STAINS AROUND THE SUN ROOF NOR IS THERE ANY WATER DAMAGE ON THE DRIVERS' DOOR. IN NEW ENGLAND, THE CAR IS NON-FUNCTIONAL IN THE WINTER AND SPRING BECAUSE OF THIS PROBLEM. I HAVE TAKEN IT TO THE LOCAL SATURN DEALERSHIP AND THEY HAVE REFUSED TO FIX IT. 2) I HAVE HAD TO REPLACE MY FRONT TURN SIGNALS 3 TIMES IN 1.5 YEARS. I AM ALMOST CONVINCED IT IS A SOCKET PROBLEM AND NOT A LIGHTBULB PROBLEM. 3) I HAVE HAD TO REPLACE THE BRAKES AND ROTORS TWICE WITHIN A 12 MONTH PERIOD. IN THAT TIME. I HAVE ONLY DRIVEN 17,000 MILES. ONCE IS UNDERSTANDABLE. TWICE IS EXPENSIVE AND RIDICULOUS. *TR
I OWN A SATURN ION 3. ON 1/8/06, I HEARD A SCREACHING, RUBBING SOUND FROM FRONT BRAKES. TOOK THE VEHICLE TO DEALER ON 1/9/06. BRAKE PADS AND ROTORS WERE DAMAGED. THE CAR ONLY HAD 35,925 MILES ON IT AND THE BRAKES HAD BEEN CHECKED BY THE DEALER AT 28,900 MILES. AT THAT TIME, IT WAS DOCUMENTED THAT THE PADS HAD 40% LEFT. THE SERVICES REP. STATED THAT THERE WAS NOTHING I COULD HAVE DONE TO PREVENT THIS FROM HAPPENING, THAT THE ION WAS TOO HEAVY FOR THE STYLE OF BRAKES USED. SINCE BRAKES ARE NOT COVERED UNDER MY EXTENDED WARRANTY, THIS COST ME $484. I DID NOT TAKE THE VEHICLE SOMEWHERE ELSE FOR THE REPAIR AS I WAS AFRAID TO DRIVE IT WITH THE FAULTY BRAKES. I AM NOT HARD ON BRAKES, THIS IS MY 3RD SATURN VEHICLE, AMONG OTHER VEHICLES THAT I HAVE OWNED AND I HAVE NOT HAD THIS HAPPEN AT ALL, MUCH LESS AT SUCH A LOW MILEAGE. SATURN DEALER REPLACED PADS AND ROTORS WITH GENUINE SATURN PARTS AT MY EXPENSE, WHICH I ASSUME WILL NOT HOLD UP ANY LONGER THAN THE LAST ONES. *NM
THERE IS A LEAK IN THE C-LINE (THE HOSE BETWEEN THE MASTER CYLINDER AND THE SLAVE CYLINDER. I TALKED TO ANOTHER SATURN OWNER AND THEY HAVE THE SAME PROBLEM OF THE LEAKING HOSE. SINCE THIS FLUID CONTROLS BOTH MY CLUTCH AND MY BRAKES, THIS IS A MAJOR PROBLEM. *JB
2003 ION HAS HAD BLOWER FAN, CLUTCH SWITCH, CYLINDER CABLE HOOD LATCH, BRAKE LIGHT BULB, WIPER MODULE ALL REPLACED WITH IN MONTHS APART FROM EACH OTHER. *TS THE ROTORS WERE WARPED AND THE TAIL LAMP FAILED. *JB
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.