2020 Subaru Outback Air Bags & Restraints Problems

I am reporting a safety-related defect involving the Supplemental Restraint System (SRS) on my 2020 Subaru Outback with approximately 20,480 miles. Multiple SRS and occupant detection system warning lights illuminated. Dealer diagnostics showed multiple SRS-related faults including airbag ECU malfunction, occupant detection sensor communication failures (lost communication/mismatch), and SRS power/voltage-related faults. These systems directly control airbag deployment and passenger safety. The vehicle has not been involved in any accidents and has not been misused. The dealer advised the vehicle is not safe until repaired. Subaru of America declined assistance and closed my case, stating it is outside goodwill parameters, and is requiring me to pay approximately $1,200 to repair the airbag-related system. In November of the prior year, the vehicle had a battery failure and was serviced by a Subaru-certified dealer. During that repair, wiring work was also performed. Given the current SRS faults and the prior wiring/battery service, I am concerned this may be a systemic or related defect rather than normal wear. I am requesting NHTSA review this issue as a potential safety defect involving the SRS/occupant detection system.

I received letter from Subaru of America saying parts available for recall repair but when I went to the dealer they did not have the parts.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Air bag sensor light came on. Took to dealership - Suburban Subaru, Troy, MI. $189 to diagnose....then received this note: Air Bag - Control Module: scanned vehicle using ssm4 and found codes B1185, B1195 and B1196. per subaru diagnostics, replacement of the SRS module is recommended to complete repair. repairs will include removal and replacement of current module as well as passenger seal Occupant Detection System relearn. $1415.16 in additional cost. This is a defect...and Subaru should cover the cost.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (AIR BAGS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while reversing, the rearview camera displayed a distorted image, compromising the back-over prevention system. No warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The contact related the failure to NHTSA: 20V766000 (BACK OVER PREVENTION) however, the VIN was not included. The failure mileage was 61,000. Parts distribution disconnect.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while operating the vehicle with a front seat passenger seated inside the vehicle, the warning message "Air Bag Off" flashed off and on. The cause of the failure was not determined. The failure mileage was 44,300. VIN tool confirms parts not available.

I have a occupancy sensor error which has turned off the airbags on the passenger seat. I looked up the issue and found an open recall with Subaru regarding this issue. I spoke with multiple case managers to resolve the issue. They said they have reported the issue to NHTSA but it is not an active recall because they have yet to find a solution. So they have no responsibility to fix the issue at this time. They are unwilling to provide me with an alternate option than driving my car with the exact issue they issued the recall for.

See attached document for complaint

I received a safety recall notice (Campaign Number: 24V227000 / Subaru Code: WRA24) for my Subaru Outback. I contacted multiple Subaru dealerships in my area, and they all told me that the repair parts are not available and there is no clear ETA for when they will arrive. This recall relates to a safety issue, and I am concerned that my vehicle may not be safe to drive, especially at highway speeds. Every time I follow up, I receive the same response: “No parts available, but we can order for you." I am wait for this for 1 year. I believe this delay is unreasonable given the nature of the recall, and I’m worried that a serious accident could occur if the issue is not resolved in a timely manner. I would appreciate it if NHTSA could follow up with Subaru to ensure they are providing timely remedies or alternative solutions for affected owners. Thank you.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owned a 2020 Subaru Outback. The contact stated while driving 50 mph, a truck pulled into the roadway and struck the contact's vehicle however none of the airbags deploying. In addition, the lane keep assist system did not chime. No one was injured and a police report was filed. The vehicle was towed to a local mechanic where it was diagnosed as destroyed. The contact stated no warning lights were illuminated. The manufacturer was not informed of the failure. The failure mileage was approximately 12,000.

The airbag light came on in my 2020 Subaru Outback in May 2021. I’ve had the vehicle to Reliable Subaru service department four times for repair and each time they were unable to repair the airbag system. The front passenger seat reacts like someone is in the seat even when it is empty. The problem is if a child is in the seat, the airbag will deploy most likely in an impact. The car is available for inspection at anytime.

ON DECEMBER 18,2020 I WAS CROSSING AN INTERSECTION. I WAS TRAVELING MAYBE 5-10 MILES AN HOUR THROUGH A GREEN LIGHT. AN AUTOMOBILE STRUCK ME PERPENDICULAR AT 30-40 MPH. THE IMPACT WAS ALMOST ENTIRELY TAKEN BY THE DRIVERS DOOR. THE SPEED WAS ACCORDING TO THE DRIVER OF THE VEHICLE AND WITNESSES. THE CAR WAS STRUCK SO VIOLENTLY THAT THE TIRES ON THE PASSENGER SIDE WERE SCUFFED ON THE SIDEWALL FROM THEM ROLLING UNDER THE CAR. I HIT MY HEAD ON THE DRIVERS WINDOW FROM THE IMPACT. I WAS WEARING MY SEATBELT. NO AIRBAGS DEPLOYED, NO SIDECURTAINS DEPLOYED. IT SHOULD BE NOTED THE AIRBAGS DEPLOYED ON THE KIA THAT IMPACTED ME. SUBARU TIED MY CAR UP FOR 4 MONTHS AFTER I REQUESTED THEY COME LOOK AT THE CAR TO DETERMINE IF IT ACTED CORRECTLY AT THE TIME OF THE ACCIDENT. THEY DOWNLOADED DATA FROM MY CAR AND HAVE REFUSED TO SHARE IT WITH ME. THEY CLAIM THAT THE IMPACT WAS OBLIQUE. THAT THE AIRBAGS WERE DESIGNED NOT TO GO OFF IF IN FACT THIS HAPPENS. THEY ALSO SAY THAT THE OWNERS MANUAL STATES THAT. I READ THE OWNERS MANUAL. IT SAYS THAT IF THE IMPACT IS PERPENDICULAR THE AIRBAGS/SIDE CURTAINS SHOULD DEPLOY. THE CAR WAS 3 MONTHS OLD TO THE DAY. INCLUDED ARE PICTURES OF MY CAR SHOWING THE DAMAGE. I ALSO SENT PICTURES OF HOW THE FRONT TIRE WAS BENT FROM THE IMPACT.. I HAVE ALSO INCLUDED THE PICTURES OF THE KIA THAT IMPACTED MY SUBARU.

THIS IS NOT AGAINST SUBARU IT IS AGAINST DOHCLO COMPANY. I PURCHASED AN AFTER MARKET SEATBELT EXTENDER. IT IS DEFECTIVE AND WILL NOT SECURE THE SEATBELT TO RESTRAINT YOU IN AN ACCIDENT THAT COULD RESULT IN EJECTION FROM THE VEHICLE DURING AN ACCIDENT. I CONTACTED THE COMPANY AND THEY ARE REFUSING TO ASSIST. I WORRY ABOUT THE SAFETY OF OTHER PEOPLE THAT MAY USE THE ITEM WITHOUT CHECKING THAT IT IS SECURED PROPERLY. I FEEL THAT A RECALL SHOULD BE STARTED. I HAVE PHOTOS, THE PRODUCT AND COPIES OF ALL MY EMAILS REGARDING THIS.*DT*DT*AS*DT *TR*DT