NHTSA Owner Complaint Log
This page lists owner-reported complaints filed with NHTSA for the 2022 Tesla Model 3. Complaints are unverified consumer reports submitted to NHTSA and do not by themselves prove a defect or defect rate.
2022 Tesla Model 3 with approximately 19,373 miles. Third-party tire shop inspection on April 25, 2026 identified visible tearing of front lower control arm bushings on BOTH sides (bilateral failure). Rubber bushing material has separated from inner metal sleeve on both left and right front lower control arms in identical pattern. No impact event or curb strike. Symmetric bilateral failure indicates manufacturing/material defect, not impact damage. Failure occurred at mileage well below the 40,000-70,000 mile range commonly cited for this known Tesla Model 3 lower control arm bushing wear pattern. Suggests accelerated failure mode that warrants investigation. Photos from third-party inspection attached. Vehicle scheduled for Tesla service center evaluation under remaining factory warranty.
I went to open the trunk on my 2022 Tesla Model 3 using the normal electric trunk button above the license plate. When I clicked the button, the trunk opened a few inches, made an abnormal noise, and then came crashing shut. At this point, I opened trunk manually to see what occurred and immediately saw the electrically-operated trunk strut separated from the trunk and also a crack in my rear glass as a result of the strut breaking off and getting sandwiched between the glass and the trunk lid when it came crashing shut. This is not only a major design flaw, but a huge safety concern. Other Model 3 owners on Reddit have experienced this exact same event happen, clearly indicating the flaw in the part and design of it. In the newer generation Model 3 from 2024 until present, Tesla has changed the design of the trunk strut because they knew it was flawed on the last one. My 2022 Model 3 has the older, more dangerous design. Had my hand and fingers been under the trunk when this occurred, I could’ve sustained a serious injury from the weight of the trunk collapsing on me, but it thankfully didn’t. There is no failsafe in place like a backup gas strut in the event that something like this happens and Tesla put the entire weight of the trunk lid on one electrically-actuated strut on the left side that is prone to misalignment and failure. Tesla needs to be held accountable for this design flaw in the older Model 3s as this trunk part is beginning to wear out or become misaligned in many people’s vehicles by this point. My car has only 62,500 miles on it and this managed to occur. It’s only a matter of time before this part fails on many other Tesla owners, causing massive financial losses and potential injury.
What component or system failed or malfunctioned, and is it available for inspection upon request? The front windshield (Acoustic Glass) failed due to a spontaneous stress fracture. The crack originated from the edge of the glass without any external impact. The vehicle has been repaired, but the service records and high-resolution photos of the crack are available for inspection upon request. How was your safety or the safety of others put at risk? The spontaneous crack occurred suddenly during a heatwave, significantly obstructing the driver’s forward visibility. Furthermore, the crack expanded rapidly during a subsequent rainstorm and temperature change, compromising the structural integrity of the windshield and potentially interfering with the front-facing ADAS cameras (Autopilot/Safety features) located behind the rearview mirror. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The problem was formally inspected and confirmed by the Tesla Burlingame Service Center. They issued a written evaluation report stating the damage was a "Stress Impact" (a manufacturing/structural defect) rather than a rock chip. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, the component was inspected by the manufacturer (Tesla Service Centers in both Burlingame and San Francisco). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps or messages appeared. However, this vehicle was previously subject to a Heat Pump recall (22V045) related to defrosting issues, which may have contributed to long-term thermal stress on the windshield structure prior to this failure.
My 2022 Tesla Model 3 experienced a heat pump compressor failure at approximately 89,457 miles. Tesla Service Center diagnosed an internal failure in the heat pump system. The heat pump system controls cabin heating, windshield defrosting, and thermal management for the vehicle. When the system failed, the vehicle lost heating and proper defrost capability. This can impair windshield visibility during cold or foggy conditions, creating a potential safety hazard while driving. Tesla quoted approximately $3,000 to repair the compressor and declined warranty assistance despite the system being critical to safe vehicle operation.
I am filing a safety complaint regarding water intrusion into the rear tail lamp assembly of my 3-year-old Tesla Model 3. The rear tail light has progressed from minor condensation to active water accumulation and visible pooling inside the sealed housing. This is not light fogging — there is standing moisture inside the assembly. The vehicle has not been involved in any collision and there is no visible external damage to the lamp. I have already been pulled over, and drivers behind me have indicated that the affected tail light is not clearly visible. Reduced rear illumination creates a serious safety risk, particularly at night or in poor weather conditions. A malfunctioning tail lamp increases the likelihood of a rear-end collision. Rear lighting is a federally regulated safety component. Water intrusion into a sealed LED lighting assembly creates risk of electrical malfunction, corrosion, and sudden loss of rear illumination. The vehicle is currently out of warranty due to mileage; however, it is only three years old. A sealed LED tail lamp is not a wear-and-tear item and should not fail due to normal mileage accumulation. This appears to be premature sealing failure. I contacted Tesla Service regarding this issue. Their written response stated that because the vehicle is out of warranty due to mileage, any repairs would be at my expense. They did not address the safety concern or the presence of internal water accumulation. There are numerous reports from other Model 3 owners describing similar tail lamp water intrusion issues. I am requesting that NHTSA review whether water intrusion into sealed rear lighting assemblies constitutes a safety defect and whether further investigation is warranted.
While using Tesla's Full Self-Driving (Supervised) software on the Pacific Coast Highway (PCH) and other highways, the vehicle’s automated steering system repeatedly malfunctions by failing to maintain lane centering. Specifically, the car drifts or actively steers across double yellow lines into the lane of oncoming traffic. This issue is a persistent failure of the Advanced Driver Assistance System (ADAS) and Lane Keeping Assistance. The vehicle has attempted this maneuver multiple times at [Approximate Speed, e.g., 40-60 mph], requiring immediate and forceful manual steering intervention to avoid head-on collisions with oncoming vehicles. The system provides no warning chimes, error messages, or "Take Over Immediately" alerts prior to crossing the lines; it appears to perceive the oncoming lane as a valid path or fails to recognize the double yellow boundary entirely. This has occurred during [mention conditions: e.g., bright daylight with high glare / night time]. The vehicle is equipped with Hardware 3.0 (HW3). I believe the 1.2-megapixel camera suite or the processing power of the HW3 computer is insufficient to safely navigate the geometry of the PCH or any roads within mountains/hills. I have attempted to "Clear Calibration" and performed system resets, but the life-threatening behavior persists. The vehicle and its internal data logs are available for inspection. I have also sent "Bug Reports" via voice command to the manufacturer immediately following these near-miss events.
While I was making a left turn my steering wheel suddenly got stuck. A vehicle almost hit me.
Tesla Full Self-Driving (FSD) drove the vehicle onto a curb inadvertently, a few days after a software update. The incident caused a scratch to the wheel and a cut in the tire. Tesla has refused to cover the repair, stating that FSD requires driver attention. The issue is that the vehicle had never driven into a curb on a 90-degree turn before. I had my hands on the wheel and did not anticipate the software making an incorrect decision and striking the curb. Full Self-Driving was engaged at the time, and the software made an incorrect calculation that resulted in the impact. Tesla should replace the damaged tire and repair the wheel. I have the 1 min recording of the incident but could not upload the video due ot its size being more than 10 MB.
When cabin heat is enabled, visible vapor/smoke emits from the front trunk area under the windshield cowl and is pulled directly into the cabin through the HVAC intake. The vapor has a chemical/sweet odor consistent with coolant or refrigerant. Smoke enters the passenger compartment, especially when stopped or idling. This occurs repeatedly in cold temperatures and stops immediately when HVAC heat is turned off. No warning lights appear. This appears to be a heat pump or coolant system leak upstream of the cabin intake, allowing chemical fumes to enter the cabin air stream. Occupants are exposed to fumes while driving. This is a safety concern due to inhalation risk and lack of driver warning.
RECURRING 12V LOW-VOLTAGE SYSTEM FAILURE AND DEFECTIVE REAR DEFROSTER HEATER GRID VEHICLE: 2022 Tesla Model 3 (VIN: [XXX] ). ODOMETER: 114,093 miles at time of third service visit. SUMMARY OF DEFECT: Vehicle has experienced recurring low-voltage (12V) system alerts since late December 2025. The 12V battery has been replaced three times by Tesla service. After each replacement, the low-voltage alerts return within days. Tesla's diagnostic system detected a DCR (DC resistance) reading of 16.8 milliohms against a threshold of 16 milliohms, indicating the battery's internal resistance is too high for the vehicle's electrical system to function properly. A brand-new 12V battery showed "Degraded - Replace" status within one week of installation. These low-voltage errors did not exist before Tesla replaced the 12V battery during the first service visit. DIAGNOSTIC FINDINGS: During the third service visit (February 2026), Tesla technician performed a resistance check on the rear defroster heater grid and described it as "out of spec but not significantly." Ground straps were also described as "out of spec but again not significantly." The technician stated there was "no smoking gun yet" and it was "maybe a combination of all leading to the 12V warning." Tesla proposed replacing the rear backlight glass at a cost of 1,265 to the customer. Additionally, severe rodent damage was discovered in the front wiring harness with chewed wires and nesting material. Despite this confirmed damage to the electrical system, the service manager stated the rodent damage was "not associated with the error" while the technician simultaneously stated there was no confirmed root cause. SAFETY CONCERN: The recurring 12V low-voltage condition presents a safety risk. The 12V system powers critical vehicle functions including exterior lighting, hazard lights, door locks, windows, the vehicle's computer systems, and safety features. Repeated system alerts include DIF_a018_hwLVSupplyUV (ha INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving, the center display intermittently goes completely black. When this occurs, I lose access to the speedometer and all driver information. The issue has been ongoing and progressively worsening. The vehicle was purchased new. The issue was reported during the warranty period and initially attributed to software updates. A recent service visit confirmed the vehicle computer is failing, and the issue immediately recurred after pickup. Loss of speed and driver information while driving creates a safety concern.
This car uses auto-dimming rear view and side mirrors. However, the rear view mirror is only able to be dimmed automatically, or be disabled in the settings. The issue is that the dimming is not based on a light sensor at all, it is merely timed to dim around 30 minutes after sunset and return to normal 30 minutes before sunrise. I have confirmed this timing on many drives and it is repeatable. The safety concern is that there is no way to manually dim the rear view mirror, which is a big issue around sunrise and sunset when cars headlights turn on before the mirrors dim. This is especially an issue with larger trucks behind a sedan like my Model 3. The only option I have to fight the blinding glare from headlights is to manually move my mirror so that I can no longer see out of the rear window, which makes lane changes much more dangerous.
The vehicle has a manufacturing defect in the charge port body seal allowing water intrusion into the vehicle cabin and near high-voltage charging components. This has resulted in dampness and potential mold growth, posing a respiratory health hazard to occupants.
All safety and driver-assistance systems on my 2022 Tesla Model 3 failed due to an internal short in the vehicle’s computer, as confirmed in writing by Tesla’s technician. All cameras (rear, side, front) are non-functional, navigation does not work, and all ADAS features (Autopilot, lane-keeping, collision warning, blind-spot monitoring, emergency braking, etc.) are disabled. The vehicle has no visibility when reversing and no active safety protections while driving. Tesla documented the cause as an internal computer failure, not related to damage or misuse. This creates a dangerous condition on public roads since the car loses all safety systems. Tesla quoted ~$2,900 for a new computer even though the failure involves critical safety components. This may indicate a broader safety defect.
teslas have blind spot monitor cameras that activate when the turn signal is activated as a turn left or right. there seems to be a noticeable delay on older cars with intel processors where the cameras take longer to display on the screen in split second manuvers and lane changes that can lead to accidents
The 2022 Model 3 Tesla does not have readily available emergency rear door release. Tesla's automated response to me was to locate the bolts and screws on the underside of the door armrest, then I need to remove the bolts and screw. Once that is done I can then remove the panel under the armrest so I can then reach inside and pull on the manual release cable. This could not be done during an emergency, you would need to have tools and in an emergency people panic and they would have to do everything by feel if they are trapped in the backseat of the Model 3 Tesla. This is a life safety hazard and needs to be addressed by Tesla to provide a fix that will allow easy access and not require tools to open the door if there is no power to the door release. This needs to investigated and corrective actions taken to make Tesla comply with changes for safety.
My family and I were in my Tesla Model 3 2022 and heading from Charlotte to Orlando on [XXX]. The car was in Full Self-Drive (FSD) mode while commuting through Daytona Beach. The rain was heavy in the area. While driving in Daytona Beach, FSD caused the car to change lanes and go to a lane that had standing rain puddles on [XXX]. After FSD caused the lane change, the car immediately hydroplaned out of control. The car's short clearance from it's bottom and the ground which traps water that exacerbates hydroplaning, along with its generative breaking feature made matters worse and uncontrollable. The car spun into the median three times and settled in the middle of danger interstate. The car is totalled. My family and I require medical attention and counseling due to the trauma. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving home, my Tesla was operating in Full Self-Driving (FSD) mode and initially performed normally, stopping at a red light and proceeding smoothly when it turned green. Moments later, the vehicle suddenly accelerated on its own, lost control, and began spinning uncontrollably before sideswiping a parked car and coming to a stop on the wrong side of the street in oncoming traffic. I was fully awake, alert, and did not manually steer or accelerate at any point. The incident appears to have resulted from a malfunction in the vehicle’s FSD system and/or its steering and acceleration control mechanisms. There were no warning lights, error messages, or alerts before or during the event—it occurred without warning. This malfunction created an immediate safety hazard that endangered my life and posed a serious risk to other drivers, pedestrians, and surrounding property. The situation could have easily resulted in a fatal collision or injury. I promptly notified the police, and the incident was reported to Tesla Insurance, which serves as my coverage provider. Despite my repeated efforts to have the issue inspected and addressed, Tesla Insurance has refused to acknowledge fault, open a claim, or cover related damages. As a result, the malfunction has not been reproduced or confirmed by Tesla or any authorized service center. The vehicle has since been inspected by Collision Works, a Certified Tesla Collision Center in Long Beach, California (500 E. Anaheim St, Long Beach, CA 90813), which provided a preliminary repair estimate. I am currently responsible for repair costs out of pocket pending resolution with Tesla Insurance. The vehicle remains in my possession and is available for inspection by Tesla, investigators, or safety authorities upon request. The complete and unexpected failure of the FSD system to regulate acceleration and steering represents a serious safety defect that warrants immediate investigation to prevent future harm.
While at a red light, my car was stopped with Tesla Full Self-Driving (FSD) on. When the car in front of me nudged forward, my car, still in FSD , accelerated and drove into the car in front. Looking at the event report of my car, the automatic emergency break did engage but too late. This means the sensors in front failed to recognize the vehicle ahead.
There is NO way to find the emergency manual release in the rear doors. WHERE ARE THEY!!!!??? There is no panel or cover to remove to find a release for the doors in case there is no power!!! This my friends car. I don't have his VIN so I grabbed on off the internet.
The contact owns a 2022 Tesla Model 3. The contact stated that while approaching the vehicle, the tire was abnormally low. The TPMS warning light was illuminated. The vehicle was taken to the dealer, who discovered a crack in the wheel, resulting in damages to the tire. The contact was informed that the wheel needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance because the wheels were not covered under warranty. The failure mileage was 20,000.
SAFETY CONCERN: for kids getting trapped in rear doors with no manual release in the rear of my 2022 Tesla model 3. Only the front has a manual release which is not practical for two kids in the back.
Tesla’s full self driving did not react to emergency vehicles approaching from behind.. vehicle was a police cruiser emergency lights, and sirens were active on freeway.
Then forward collision warning system inaccurately reported and reacted to a park car that was not in my lane. This caused my car to slam the brakes and subsequently almost cause an accident behind me. This also raised my car insurance premium so they can charge me more money
The central computer in my 2022 Tesla Model 3 failed unexpectedly. This is a critical component that controls essential vehicle functions, including safety alerts, battery management, regenerative braking, Autopilot features, navigation, and over-the-air updates. The failure makes the vehicle unsafe to operate. The car is only 2–3 years old, and such a major systems failure in such a short time frame suggests a defect or premature failure in a component that is expected to last the life of the vehicle. Tesla has not offered a remedy despite this being a safety-critical system. I believe this failure presents a serious safety risk to myself and others on the road and should be investigated.
Tesla odometer discrepancy) combines the energy to run the car to count against the mileage. The car is often sitting parked and all of a sudden the mileage is shorter… Basically the odometer reading is wrong because weekly added miles are attached to odometer because the air is on or screen is used and that’s not fair for us because it’s incorrect.
Tesla M3 RWD 2022 - 79750k miles. Touchscreen keep restarting throughout the day , in the morning when I am backing out of the garage, while I am driving, while I parked. It is dangerous specially while I am backing out of garage, car will stop sometime, because whole system reboots. I have no visibility I have to wait till its finish restarting. Tesla's main computer handles everything in the car, A/C, Turn signals, speedometer, backup cameras, forward collision warning and many more necessary function of the car. Tesla service center diagnose stats "The cause was identified as kernel panics detected in the system. The internal memory of the car computer is corrupt and will not allow enough data transfer and causing the computer to reboot to clear space" They suggested to replace the computer and its a out of warranty fix, since I drove 79k miles. This is a crucial of the car and it should not fail in 3 years, driving 79k in California is not unusual, Tesla service also blamed that we didn't extended our warranty after 50k. We couldn't find any correspondence from Tesla on service app or email regrading warranty extension. $3000 to replace a computer is a very high price.
The contact owns a 2022 Tesla Model 3. The contact stated that while operating the vehicle, the front driver's side seat belt warning chime was inoperable, failing to alert the driver that the front driver’s side seat belt was not secured while driving. The cause of the failure was not yet determined. The local dealer was notified of the failure, and a service appointment was scheduled. The manufacturer was not contacted. The failure mileage was 35,400.
pedestrian warning system has failed for a second time. speaker was replaced once already. presents safety issue to pedestrians (this displays an error that it is not working, the error also states that the horn may not work, however this is for newer cars that do not have separate horns and PWS speaker) Horns are intermittent in functionality, sometimes high or low tone only works, other times no horn sounds, this is a separate device from the PWS speaker, there is no error message shown for this when the PWS is functioning as intended
I have experienced multiple tire failures on my 2022 Tesla Model 3, with at least 7 tires needing replacement due to air bubbles. These issues have occurred on both front and rear tires, and currently I have 3 more tires with visible bubbles and one tire is actually leaking air. Most of these tires failed within 2,000-6,000 miles of use, which is far below normal tire lifespan of 25,000-40,000 miles. Despite repeated service visits, no alignment or suspension inspection has ever been performed by Tesla to determine why this keeps happening. The tires are just replaced at my cost, with the problem recurring again and again. Despite the pattern, Tesla service advisors continue to blame road conditions or driving habits. I want to be clear: I actively avoid potholes, drive cautiously, and have never experienced anything like this with any previous vehicle. Something is clearly abnormal here. In addition, I have noticed strange clicking and popping noises while driving, which seem to come from the chassis or steering area. It worries me that there may be a deeper mechanical or build quality issue. The vehicle often feels unstable, and I am genuinely concerned that a failure of a suspension component, battery mounting, or other structure could lead to a fire or loss of control. No warning lights have appeared, but the pattern of repeated air bubbles showing in my tire after just driving not even 1,000 miles and abnormal noises makes the vehicle feel unsafe to operate.
While driving on AutoPilot the I-10W on Wednesday July 16, 2025, the car suddenly and very harshly braked for no reason at all. The vehicle in front of me was visible on the vehicle's display, meaning it was keeping it distance and was actively adapting to its speed and distance, and at no time did I press the brake or move the steering wheel for the vehicle to use its emergency braking. It was so harsh, I felt the blood throughout my head and body lunge forward, and AutoPilot immediately turned off. If I wasn't aware of this sudden braking, I would have assumed AutoPilot would still be active, but knowing of Tesla's "phantom braking", I immediately took control once I noticed AutoPilot turned off on its own. I have a video of the dash cam available (over 10MB) if needed.
I took my car to Tesla service to have 3 tires changed. On the drive home for the service, the car automatically pulled the to right several times with the final time pulling so hard, the car jumped the curb and damaged the car. Speaking with the Tesla service associate after the accident, they admitted that they did not complete alignment of the tires and that the automatic lane correction mechanism uses the alignment to gauge if it should correct or not. Tesla service will not take responsibility for causing the issue.
I pulled up to a red light in a protected left turn lane. My car is set to use regenerative braking and hold/not roll once stopped. I felt my car roll forward a bit, which shouldn't happen when these settings are on. I quickly checked my rearview mirror, assuming someone had hit me from behind to cause me to roll forward. No one was behind me. I hit my brake and the car suddenly accelerated at full throttle speed, I would guess, into the intersection, despite the light being red for me. I quickly glanced down at my foot to confirm that it was on the brake pedal and it definitely was. I continued to repeatedly push the brake pedal down to no avail. I was steering and tried to navigate my way through 4 lanes of moving traffic because they had a green light. I hit the front end of a car, which didn't slow my car at all. I went on to hit another car's front end, which didn't slow my car at all either. My car then charged out of control to hit the curb on the opposite side of the street facing traffic. Hitting the curb stopped my car finally. I noticed that the airbags on the right side of my car were deployed. Components that failed/malfunctioned: brakes, fuel/propulsion system, speed control, automatic emergency braking, collision warning/avoidance, traffic signal detection Tesla Insurance has deemed the car a total loss. I also reported the malfunction to their Vehicle Support but haven't gotten the report or the data report from the car that I requested yet. I was told that the report would be complete by 8/7/25. The car was placed on a hold for the investigation, so it should be available for inspection. I do have the dashcam videos and photos of my car, if needed. This incident was terrifying because I had zero control of my vehicle due to the sudden unintended acceleration (SUA). I see on the internet that SUA is a problem with Tesla that has been reported repeatedly. It is a miracle that no one was hurt or killed. Tesla needs to address this immediately!
While traveling at approximately 70 miles per hour on an interstate, the vehicle's automatic emergency braking system engaged multiple times in rapid succession—approximately five separate braking events. Each time, the system falsely detected an obstacle, which it appeared to interpret as a person in front of the vehicle. In reality, there was nothing on the road; the system was reacting to a roof-mounted strap that was fluttering slightly in view of the forward sensors. These false positives caused the vehicle to brake suddenly and forcefully, creating a highly dangerous situation for vehicles behind me. Multiple drivers were forced to swerve to avoid a collision. Thankfully, no crash occurred, but the repeated unexpected braking posed a serious risk to my safety and the safety of others on the highway. Additionally, I had previously disabled the automatic emergency braking feature in the vehicle's settings. However, I later discovered that this system reactivates by default every time the vehicle is restarted. There is currently no option to permanently disable this feature, meaning drivers must manually turn it off for each individual trip, which is not clearly communicated by the system. This issue has not yet been inspected by the manufacturer or a dealer. No warning lights or error messages appeared before or during the braking events.
I was traveling northbound on [XXX} in Sugar Grove, IL with the traffic aware cruise control on. As I passed under [XXX] the car braked heavily for no reason. No cars in the area...thankfully. I could have easily been rear-ended. It has done this on more than one occasion at this location. I filed a "bug-report" via the right hand button on the steering wheel. I was also traveling [XXX] near Lasalle-Peru with the cruise control on at about 80 mph when the vehicle suddenly braked heavily. No cars around at all. The moment was extremely frightening. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
During operation steering wheel becomes heavy and difficult to turn and becomes notchy. Very difficult to stay in ones own lane.
The contact owns a 2022 Tesla Model 3. The contact stated that while attempting to reverse into a parking spot, the cameras failed to activate, along with the sensors, which included the backup sensors failed to alert that there was an object. As a result, the contact crashed in reverse into a cement pole on the front driver's side door and mirror. No property damage was reported, and the vehicle came to a stop upon the contact depressing the brake pedal. The air bags were not deployed. The vehicle was going 5 MPH at the time of the crash. The contact attempted to retrieve the recording of the crash, and there was no record. No warning lights were illuminated. A police report was not filed. The vehicle was not destroyed. No injuries were reported. The local dealer was contacted, however the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 17,290.
The power lift‑gate strut PN 1551489‑00‑B failed, bent inward, and shattered the rear glass on 16 May 2025. A known defect: Tesla superseded the part to PN 1551488‑00‑C in Oct 2023. Local Tesla Service center declined goodwill coverage to resolve the issue.
The contact owns a 2022 Tesla Model 3. The contact stated that while the vehicle was in self-driving mode, the vehicle was supposed to merge into the right lane, however the vehicle accelerated into the left lane, and another vehicle collided into the front driver side of the vehicle. The contact stated that he did not sustain any injuries, however the passenger stated he sustained injuries, but the injuries were unknown. No medical attention was required. The contact stated that a police report was filed. The vehicle was taken to dealer where it was diagnosed that the software needs to be updated. The vehicle was not repaired. The vehicle was still drivable after the incident. The manufacturer was not notified of the failure. The approximate failure mileage was 104,547.
When the vehicle is set to regenerative braking mode, lifting off the accelerator pedal causes the car to decelerate significantly. However, in many cases, the brake lights do not illuminate during this process. This could potentially create a safety risk, as drivers behind may not realize the car is slowing down and may not respond in time. tesla
Passenger safety restraint failure message came on so I made an appointment and took it to Pleasanton Tesla for repair 3/19/25; was under the 60,000 safety warranty. Then on 5/6/25, 6 weeks later, the passenger safety restraint failure message appeared again. I contacted Pleasanton Tesla and they told me I was now responsible for a different piece to be replaced, which was quoted over $1,000 to repair, as the 60,000 mile safety warranty was up and it is a different piece that needed to be replaced. I said it’s the same message, passenger safety restraint failure!
Passenger safety restraint system fault error appears on and off without any correlation to driving conditions or passenger presence. This error is potentially deadly since it will cause the passenger airbag not to deploy in an accident.
Rodents Chew on Car Wires Consequences of Rodent Damage: Malfunctioning Components: Chewed wires can lead to a variety of problems, including issues with the engine, lights, sensors, and other electrical components. Expensive Repairs: Repairing or replacing damaged wiring harnesses can be costly, potentially running into the thousands of dollars. Safety Hazards: Damaged wiring can pose safety risks, potentially causing electrical shorts, fires, or malfunctions while driving.
If you are on a hill and you accidently press both the brake an accelerator, the car will fall to neutral and free roll. In whatever direction is downhill. I have big feet. Happened again to me, I bumped the brake pedal (but not enough to apply the brakes to stop) when attempting to pull forwards slowly and my car beeped with the "both pedals detected pressed" alert. and then it free rolled backwards (because I was on an uphill). THIS WILL CAUSE AN ACCIDENT BECAUSE THE CAR IS NOT SUPPOSED TO FREE ROLL BACKWARDS WHEN IN DRIVE, THIS IS A SAFETY PROBLEM. It has been 4 years now, and no action has been taken to adress this software defect. a NORMAL gas car does NOT do this. If you bump the brake in a normal gas car, IT DOES NOT FREE ROLL IN ANY DIRECTION. This is a tesla software problem that tesla needs to promptly fix ASAP!!!!!
We received a Front passenger safety restraint system fault on our car. When a passenger sits in the seat the fault is not displayed. This was not a software update and the sensor was faulty and could cause the airbags not to go off. The sensor was faulty in the seat but because we were out of warranty we had to pay for the repair. Clearly they have seen this issue and said it was not a recall but a bulletins and bulletins were a caution, they made us pay for the repair.
Wy wife and I drove our Tesla Model 3 from Palo Alto, CA to San Francisco downtown, to meet friends. I was the driver, and my wife sat on the passenger seat. The weather was clear, and the pavement was dry. I did not engage auto-pilot features during the entire trip. The car condition was normal with no signs of error or warning. I made a right turn onto [XXX] from [XXX] Shortly after I completed the turn, the car unexpectedly lost control. Without any prior warnings, it suddenly veered into the center divider, snapped a tree, dashed towards oncoming traffic on the other side of [XXX] , and finally stopped on [XXX] , labelled as location A on the attached drawing. Everything happened so quickly: I could not control the steering wheel, and I applied the brakes in vain. The vehicle seized control, no matter how hard I tried to stop it. I regained control of the vehicle at the intersection of [XXX] and [XXX] , and was able to park the car at location A. We were very fortunate and blessed that we did not hit people at the bus stop, that there were no cars in front of us, that the opposite traffic on [XXX] was stopped by a red light, and that the traffic was light on [XXX] Without such luck, my wife and I, and probably others, would have been seriously injured, if not worse. Because [XXX] is one-way, we decided to move the vehicle to [XXX] , and parked at location B in the drawing. I called 911 and spoke to a female dispatcher. She asked us to remain at location B and wait for police officers to arrive. We waited there for almost 3 hours, but no police arrived. The dashboard display indicated that we had a flat tire(s). We called mobile tire services. After their inspection, most of our tires were alright, except the rim of the front-left wheel was badly bent, as you can see in the attached photo. The mobile tire service staff was skilled enough to carefully patch the damage and said it should be OK to drive back to Palo Alto. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
* Front passenger safety restraint system issue - sensors under passenger seat intermittently failing for months even after taking it in for service. * Safety of passenger is at risk as airbags might not fire due to occupant classification system failing. * Service center said nothing looks wrong even though car alerts multiple times per drive. Many reports online of Alert RCM2_a636 . * has been inspected by service center * alert from car beeps every 30 seconds to 1 minute intermittently, has been occurring for months
Forward collision warning was falsely triggered causing the car to inappropriately apply the brakes twice in one drive. This causes the car to brake harshly and causes cars behind me to either swerve or slam their brakes. This causes a chain reaction of extremely dangerous behavior. The forward collision warning system is far too sensitive when there’s literally no obstacles to cause a collision or avoid.
The cars forward collision warning system is far too sensitive and braked extremely hard when there was nothing to collide with. This caused the car behind me to slam their brakes and they got rear ended. This needs to be forced on Tesla to be addressed
Two false collision warnings were triggered when in fact, there was nothing to collide with. This caused the car to brake extremely forcefully nearly causing another can to rear end me in midday traffic. If they would have hit me, it easily would have caused a 10+ car accident.
Data synced from NHTSA on May 4, 2026