2024 Toyota Corolla Steering Problems

DEFECT: Steering wheel fails to fully return to center after turns, consistently stopping 1/2-1 inch off-center. Minor steering adjustments stick and don't self-correct. Pronounced binding zone near center prevents smooth return. SYMPTOMS: After curves, wheel returns 80% but stops visibly off-center requiring manual correction. Minor lane adjustments stick and require counter-correction. Constant manual steering correction causes driver fatigue. Progressive worsening since purchase. SAFETY: Incomplete return at highway speeds causes drift. Sticking divides attention from hazards. Emergency maneuvers require manual straightening during critical response time. SERVICE: February 2026 - McGovern Toyota technician documented "VEHICLE DID NOT RETURN OR SELF CENTER" but Toyota corporate refused repair claiming "normal characteristic." Had 6+ alignments with no improvement. Recent alignment caused binding to flip sides, proving internal mechanical binding not alignment issue. RELATED: Toyota issued CSP 22TE02/TSB T-SB-0028-22 (2022) for 2018 Camry with identical "reduced return to center" caused by intermediate shaft binding. My 2024 Corolla has same defect Toyota acknowledged in 2018 models but refuses to repair. INDUSTRY PATTERN: Honda HR-V TSB 24-094 (2024), Mazda CX-90 Recall 24V-022 (26+ failed fix complaints, 2 crashes), GM Bolt TSB 17-NA-148, Ford Explorer ST owner reports - all for steering not returning to center. REQUEST: Investigate if Toyota intermediate shaft defect extends to 2024 Corolla and whether industry-wide EPS binding represents systemic safety issue. Toyota confirmed defect in writing but denies repair.

while I am driving on a highway the steering tries to turn right while i am driving. there a ditches on the right on the highway my car is not safe to drive it is putting me and my family in danger. I took my car to the dealership twice they said my car is fine.

I purchased a used 2024 Toyota Corolla from Chapman Chrysler Jeep on 8/9/25 at 31,890 miles. When exiting the freeway 3 miles later, the vehicle suddenly swerved uncontrollably without any steering input from me. This was an extremely dangerous incident that could have caused a serious accident injuring myself and others.

My [XXX] daughter's 2024 Toyota Corolla stopped in the middle of the road and would not move. She received a message that said, "engine stopped steering power low". She called me in a panic and could not move the car out of traffic. I asked her to turn the car off and back on and it resolved the issue. This could cause a traffic fatality with loss of control of a car in traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle Information: * Make: Toyota * Model: Corolla Hybrid AWD * Model Year: 2024 * Current Mileage: [14,000] * Mileage When Problem Noticed: ~8,000-9,000 miles Incident Description: My 2024 Toyota Corolla Hybrid AWD has a severe steering defect. After a right turn, the steering wheel consistently fails to return to center, remaining 5-15 degrees (up to 20 for sharp turns) off-center to the right. It does not self-correct. Occasionally, this also occurs after left turns, but less frequently. The vehicle requires constant, active manual correction to stay straight. If I release the wheel, the car can drift right, posing a significant collision risk. The steering feels "floaty" and lacks the expected resistance to return to center. This issue began abruptly around 8,000-9,000 miles. Multiple dealership visits and alignment checks have not resolved it. No prior accidents or modifications. The Lane Tracing Assist (LTA) system functions smoothly, keeping the car centered. However, immediately after disengaging LTA, the manual steering defect reappears, indicating an underlying mechanical problem, not an electronic one. Safety Concern: This defect creates a serious safety hazard. It demands constant driver attention and effort, leading to distraction and fatigue. This compromises directional stability and significantly increases accident risk, as the car will veer off course if not continuously corrected. I urge NHTSA to investigate this defect. Similar "sticky steering" or "poor return to center" issues are reported in other modern vehicles, and Toyota itself issued CSP 22TE02 for a related "slower to return to center" issue in 2018 Camry models, proving this is a known type of defect, not normal operation.

I was able to distinguish today the car noises my vehicle is making happens when I break. Like a “eeeeek” sound. My mileage is under 8,000, had the car almost a year. Also I notice my wheel stiffens. I’m able to verify it happens when I merge - specifically when the lane dashes end. The wheel somehow gets tight even when driving with both hands. As if the vehicle gets confused. This has happened about 5 times this year but every time it happens- I brace myself for the vehicle to crash since I can’t control the wheel, no matter how strong I try to gain control. The wheel gets too tight to steer. These episodes lasts about 3-4 seconds. I am going to take it to the dealership on April 1, 2025. Also there were no messages on my dashboard when these episodes occurred.

My son reported driving home from school. He was stopped an intersection ready to make a turn. When he stepped on the gas pedal to go, the engine stopped and a message "Engine Stopped, Steering Power Low" message appeared in the dashboard. Engine light and steering light also came "on" the dash. This may occur while driving and put the driver at risk. His 2024 Toyota Corolla was brought in to the Wesley Chapel Toyota Dealership yesterday 10/29/2024. The technician did not find any error codes and found the battery and alternator to be in good working condition. Issue unresolved by the dealership.

My vehicle stalled when pulling out into traffic. I lost power steering and electrical and the engine died. The vehicle had to be restarted to continue driving. I was going about 1 to 2 mph when the issue happened. The vehicle was in motion and stalled while other vehicles were in motion putting my safety at risk, had I been going any faster or if there was an increased amount of traffic. I reported the problem to the dealer service center, but they were unable to reproduce it. The vehicle was inspected by Toyota only, no police or insurance. When the issue happened, a warning light appeared on the dash similar to a circle with an exclamation mark inside. There were no messages and no other symptoms prior to the failure.

Steering—car seems to slip when driving at 30mph and taking a curve. Very brief. Traveling at 70mph car shakes.

Car has broke down a total of 4 times since I have gotten it from Toyota back in December of 2023. I have a dash-cam now that has footage of the car breaking down. Toyota fails to acknowledge my concerns and comes up with excuses and tells me to wait until it happens more frequently. I would love to have this car inspected, but as Toyota has stated they cannot get the issue to repeat. My safety for others and myself feel uneasy with the whole ordeal as it happens at the most random times. The first few times my car has broke down, the steering wheel locked up and forced itself all the way to the left on its own causing me to hit a curb and median. Manual control over the steering wheel was not possible. Luckily with this occurring both times I was going a slow speed. The other two times I had full control of the wheel but my engine would stop and the engine stopped message would appear on my dash screen. Vehicle has been inspected by the dealership 4 times with no luck on repeating the issue. Breaking down presented a dash message of engine stopped, abs system stopped, power steering stopped and would quickly cycle through warnings and shutdown.

On 11/29/23 after 11:30pm, I was in the process of clearing an exit and at the tail end of the exit it felt like the car was "correcting" itself and I was unable to stay turning right. The steering wheel felt locked and I was unable to control the car. The car impacted the guardrail and I was able to regain control after the initial impact. -This is a BRAND NEW car with less than 100 miles at the time of the accident. - Prior to the collision, there were no warning signals from the dashboard. - I was not injured from the accident as I was only able to go around 27-33mph due to a tractor trailor clearing the exit in front of me. No others were involved. - The manufacturer sent an inspector to look at the vehicle and test drive it. However, they did not test drive in the same conditions I was in or at. - The issue was not reproduced by another party. (Photos were taken the next day)