2010 Toyota Prius Complaint Log

hope this message finds you well. I am reaching out regarding a potential recall issue with my 2010 Toyota Prius. The vehicle's VIN is [XXX] , and I am currently located in the Austin area. Recently, my vehicle has been experiencing problems related to the brake system, specifically the brake booster pump assembly. The diagnostic results returned codes C1241, C1391, and C2300, which point to issues such as abnormal leaks in the accumulator pressure and actuator system malfunctions. Given that this issue may fall under a recall or extended warranty for the brake booster pump assembly, I would appreciate it if you could confirm whether my vehicle qualifies for this service. If it does, I would like to schedule an appointment to bring my car into the nearest authorized service center to have the necessary parts replaced. Please let me know if any additional information is needed. I look forward to your response and would greatly appreciate your assistance in resolving this matter as soon as possible. Thank you for your time and support. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Brakes started making a hissing sound a couple of weeks ago. Yesterday evening when I was driving on freeway , I got an assortment of lights on my dash while driving . ABS was instantly disabled and it was significantly harder to brake the car. BRAKE light on dashboard came on. Traction control light came on . It was very dangerous and it was mere luck that there was no car in the front - otherwise I could have crashed. Pulled over to the side on the freeway and then came in internal roads to my destination , keeping a lot of braking distance and at slow speed. Turns out this is the infamous brake booster leak that was so bad Toyota was forced to create an extended warranty program on Gen 3 to fix it. Brought it to dealer next day. Got an estimate for $4000 for "REPLACE BRAKE BOOSTER AND MASTER CYLINDER(DUE TO INTERNAL LEAK)"

ABS and brake lights lit at around 141000 miles code C1391 came up during diagnosis.

Heading westbound on I-70, taking Exit 29 off ramp from highway, I drove over uneven pavement. My traction control, ABS and brake lights illuminated, the brakes suddenly felt mushy. As I approached the stoplight at the end of the exit ramp, I questioned whether I would be able to stop. Scared me immensely. Luckily no cars were near me. I now do not have ABS, Traction Control, stability control OR regenerative braking.

odometer error

Toyota refuses to cover a recall that I was never made aware of. My Prius need to have ABS Brake Accumulator and other components replaced. My VIN I was told had a recall but I was never made aware. I was told it may not be safe to drive my car. Toyota told me I would have to cover all cost for the repair and for my family that is just not possible. For the safety of my family, I am hoping NHTSA can help me in anyway.

NHTSA CAMPAIGN ID: 13V235000 Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall is expected to begin late July 2013. Owners may contact Toyota at 1-800-331-4331. Toyota is no longer honoring this recall. They think it is acceptable for me to drive around with unsafe and defective brakes.

The contact owns a 2010 Toyota Prius. The contact stated that while driving at various speeds and the brake pedal depressed, the vehicle lunged forward. On a most recent occasion, the contact was attempting to park the vehicle and after shifting into the park position, the vehicle lunged forward as the brake pedal was depressed causing a minor collision with a curb and another vehicle. The contact mentioned the brake pedal required excessive force in order to come to a stop and that there was an abnormal noise present. The contact was concerned that the failure would progress causing a severe accident. A police report was not filed and there were no injuries sustained. The vehicle was taken to an independent mechanic where it was diagnosed that the ABS System failed and advised the vehicle be taken to a dealer. The vehicle was not repaired. A dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was not available.

The rear axle beam broke off near the passenger side rear wheel. The wheel flops around and the vehicle is totally unsafe to drive.

In 2015 I purchased my Toyota Prius in VA. I now live in Indiana and had my car checked for a possible sensor issue because the traction, brake & abs light were coming on and off. The diagnostic showed a brake accumulator leak malfunction. I contacted Toyota dealership once I was told there was a recall. The dealership said that it was showing it was replaced in 2013 from the previous owner in VA. It was listed then as a recall. I contacted Toyota Corporate and they said that it went from a recall to customer support with a maximum of 150,000 miles. I did not have any more problems until just recent. My argument is once a recall it should still be repaired. The part appears to be the problem. It is a safety issue and I need Toyota to fix the problem. Thank you!

The contact owns a 2010 Toyota Prius. The contact stated while driving approximately 40 MPH and depressing the brake pedal, the brake pedal was stiff and required excessive force to depress. The contact stated that the ABS, Stabili-trac, and Parking Brake warning light was illuminated. Additionally, the contact stated that a chime sounded and could not be turned off. The contact stated that the failure had been intermittent but was a recurring failure. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 13V235000 (Service Brakes). The manufacturer was not informed of the failure. The failure mileage was approximately 77,000.

The car suddenly threw a C1391 code yesterday with no previous warning. The traction, parking brake, brake system, and ABS lights are all lit on the dashboard. As this vehicle is my daily commuting vehicle, I must have the costly repairs performed, which are estimated at roughly $2,400. I will ask to retain the parts for inspection. The brakes are softer, and the breaking distance required has increased by approximately fifteen feet.

In August of 2024, my 2010 Prius with less than 100,000 miles - all the brake warning lights on the dash suddenly came on - without any prior warning. The brakes felt a little "funny" at the time, so I took it to my mechanic immediately because my safety or the safety of other was at risk if the brakes completely failed. My mechanic informed me that there was a TSB for the brake booster with master cylinder and brake booster pumps that Toyota new about. I felt that it was imperative that this was repaired immediately. Apparently Toyota knew about this issue but did not notify me in any way at any time. I bought this Prius new and have had regular service check ups. I had to pay nearly $5,000.00 to have this repaired which I feel that Toyota should reimburse me, and any others who had this problem.

The ABS Pump( Accumulator and booster) are regularly failing on all Toyota Prius( 2010-2015). When the ABS pump starts to fail, the warning lights for Traction control, Brake and ABS come on. These lights come on at all speeds and its very hard to bring the vehicle to a complete stop when this happens. The brakes completely stop working and the brakes become rock solid. The brakes become so hard that they can’t be possibly be depressed to stop in time. I nearly missed getting killed from this as I am out of country and Toyota is refusing to fix it since its not a recall and I am in Canada. Toyota is asking $3500 in parts and $1500 in labor to repair. I can not afford it and this issue is on all Prius from 2010-2015. This is a major safety hazard and can cause serious injury and damage. Toyota is refusing to repair it since they believe the cars are out of warranty. However Toyota has been notified about this safety hazard arising on all Prius(2010-2015) but decline to respond or take action. I urge NHTSA to take action and get this resolved as the ABS brakes failing on the Prius can be really dangerous and can cause life threatening accidents.

The contact owns a 2010 Toyota Prius. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. In addition, the contact stated that several unknown warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with brake system failure. The contact was informed that the braking system needed to be replaced. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer for service. The contact was made aware of Customer Satisfaction Program: C1391. The vehicle was taken to the dealer where the vehicle was diagnosed with brake system failure. The contact was informed that the braking system needed to be replaced. The contact was informed that the repair was not covered under the Customer Satisfaction Program: C1391, because the mileage had been exceeded. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 166,000.

ABS Lights turned on and need replacement. This is my 3rd Prius that have the Issue.

Passenger side low beam headlamp has continued to need to be replaced. I was not made aware of a "customer service protection program" on this and when I contacted Toyota they said it was too late for the repair, electrical harness, to be covered by their extended warranty. I never received information regarding the extended warranty. They stated they sent it to the correct address. But just because you mail something doesn't always mean it is delivered to that address. Also, I had my car serviced many times at Toyota dealerships and they never informed me of this extended warranty. If I had been made aware of the extended warranty I would've had it repaired in a timely manner. I have spoken to two representatives of Toyota and they stated they could not help me. I'm wondering why this is not considered a recall issue as it does affect the safety of driving a vehicle and the lights stop working. This may not be the right place to ask this question but I'm hoping someone in your organization can help me.

The contact owns a 2010 Toyota Prius. The contact stated that while driving at 55 MPH, with the brake pedal was depressed and went to the floorboard. The contact stated that the brakes failed to adequately slow the vehicle. The ABS warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the brake booster. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 13V235000 (Service Brakes) however, the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 120,000.

The contact owns a 2010 Toyota Prius. The contact stated while at a complete stop and attempting to depress the accelerator pedal, there was an abnormal vibration coming from the brake pump. The contact also stated that when the vehicle was turned off, the vibration on the brake pump occurred, triggering the alarm on the vehicle at least one time per day, each day. The vehicle was taken to an independent mechanic where the failure was related with an unknown recall. The vehicle was not repaired. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 196,000.

My car accelerated significantly on its own while I was pulling into a parking stall in a private parking lot. It caused my vehicle to jump a curb and accelerate up a dirt divider and push over a bush that was planted in the dirt divider. Depressing my brakes did not Decelerate the car, so I pressed the Park button to eventually stop the vehicle. I’m not sure what speed it was traveling when it accelerated, but I could smell burning rubber at the end of the incident. I’m not sure when the smell first occurred.

Brake booster assembly failure. Code C1391 - accumulator pressure leak. Toyota previously agreed to extend the warranty on this part on this year of Toyota Prius due to the known issue and the time limit for this repair was set to be in 2019. Toyota agreed to replace the unit only if it fails before that timeframe. My Toyota got recently affected by this issue resulting in over $3,000 estimate for a repair as Toyota no longer covers this repair for my vehicle. That’s a known issue with this part, Toyota knows it’s faulty and yet no recall has been issued. Now I have to pay for a repair out of pocket. I can’t drive the vehicle until it’s fixed. This should be handled as a recall with all faulty units being replaced regardless of millage. A few people opened lawsuits on this issue before and some got a settlement. I believe there is enough evidence that this should be classified as a recall and a free of charge repair should be provided to the owners. The brake booster unit has been buzzing a lot for quite a few months ( due to the pressure leak it had to work more than normal). Now it completely failed with the leak being so excessive that the brakes are very soft.

The contact owns a 2010 Toyota Prius. The contact stated while driving at various speeds, the brake pedal would depress to the floorboard initially without warning. Over time, the brake pedal had become stiff upon depression with several warning lights illuminated on the instrument panel. The vehicle was taken to an independent mechanic where a code reader confirmed a defect with the braking system. The vehicle was then taken to another independent mechanic where the vehicle was diagnosed with a defective brake booster. The mechanic then informed the contact of NHTSA Campaign Number: 13V235000 (Service Brakes) which was linked to the failure. The dealer was notified of the failure and informed the contact that the vehicle was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 153,000.

I had begun to notice a slight shimmy at highway speed for a few days, but it wasn't pronounced enough to cause concern, especially since the weather was very windy and already subjecting the car to heavy crosswinds. On Monday, [XXX], the shimmy became suddenly more pronounced, so I pulled off the highway ([XXX]) and parallel-parked on street in Cambridge, MA. While parking, I heard a loud creaking and grinding sound, and the car no longer responded to steering inputs. I exited the car and noticed the rear driver's side wheel protruding at a strange angle from the wheel well. I called AAA and the tow truck driver discovered that, behind the wheel, where the wheel meets the rear axle, the arm had rusted clean through. In other words, the wheel had completely fallen off, and was being held to the car only by the brake line. I was towed to a mechanic in Salem, MA. Both the Salem mechanic and the AAA tow truck driver said that they had never seen anything like this in all the years they'd been servicing cars. I told them that the car had never been in a flood or otherwise involved in the kind of extraordinary event that would cause more than typical rust exposure. Had the wheel come off at highway speed, I could have been seriously injured or killed. The issue did not seem to have been caused by driver/owner oversight or normal wear and tear. It seems highly unusual and potentially indicative of a defect or manufacturing error. I hope other 2010 Prius owners are aware of the vehicle's susceptibility to this issue. And I would like Toyota to take some responsibility for the high cost of repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I’m encountering multiple dash lights with the brakes being very unreliable and no that’s no regenerative breaking. I checked with an obd2 kit and the app shows that I have a code C1391.

see all over the internet that 2010 Prius have a recall for Inverter. I called the dealer they said no recall with my vin. I was told that a new inver is almost $5000 dollars. i NEED HELP i HAVE BOUGHT 3 TOYOTA ALREADY. Please help me with good will or warrenty the inverter like you have so many other people with 2010 Prius. If not I willand my family will never buy a Toyota again. Please call or email me [XXX] [XXX] The Prius died when driving and we almost got in a major accident because it stalled with no warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2010 Toyota Prius. The contact stated that while driving at an undisclosed speed and attempting to slow the vehicle, he became aware that the brake pedal required excessive force to bring the vehicle to a complete stop. The service brake warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the brake booster and brake master cylinder. The vehicle was not repaired. The vehicle was then taken to an independent mechanic, who confirmed the diagnosis and additionally found that there was a leak in the brake fluid accumulator, resulting in low brake fluid pressure. The vehicle was taken back to the dealer, who added brake fluid to the braking system, which seemed to temporarily resolve the failure. The manufacturer was not notified of the failure. The failure mileage was 140,000.

Total malfunction at highway speeds. Very unsafe, the car completely shut off. This may have resulted in a highway fatality due to collision as the vehicle was in the fast lane. NTSA please do your due diligence and investigate the faulty, defective HYBRID system as I believe the faulty inverter recall is much more larger than the original recall

The contact owns a 2010 Toyota Prius. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The check engine warning light and the check hybrid warning light illuminated. The vehicle was taken to the dealer. The contact was unaware whether the vehicle was diagnosed. The vehicle was repaired under NHTSA Campaign Number: 18V684000 (Hybrid Propulsion System). The contact stated that after the vehicle was repaired the failure recurred. The contact stated that the vehicle had not been repaired as the recall repair stated. The manufacturer was made aware of the failure but offered no assistance. The failure mileage was approximately 152,000.

Faulty brake boosters that crack and leak, making brakes unusable and draining the battery (diagnostic code C1391). There was a Toyota service repair where they exchanged the faulty brake boosters with properly working ones, but it has lapsed.

I drove the car to my destination without any issues. An hour later, when I restarted the vehicle to leave, the following dashboard lights were on (slip indicator, ABS warning light, and brake system warning light). When I drove the vehicle, the brakes had diminished stopping power. It took farther for the vehicle to come to a full stop when applying the brakes. When we had it checked by the Toyota dealer we were informed that there was an abnormal leak in the accumulator assembly (system diagnostic code C1391) and it would need brake booster/master cylinder assembly with accumulator pump replacement.

A warranty extension went out a few years back that said one might receive a "CHECK PCS SYSTEM" warning on the dash. This has happened to us, along with 7 other lights on the dash. Between the brakes being much less responsive, and all of the pre-crash warning / adaptive cruise / radar features being disabled, this could have caused an accident. The dealer checked out the car and states that the brake actuator has a leak and that it will be a costly repair - no less than $3000. This suspiciously all happened *just* outside of the warranty window (we are within the allowed number of miles but just out of time), and also suspiciously after Toyota released an upgraded version of the actuator, and *also* after a bunch of people are experiencing the same failure. Our best assessment at this time is that the brake actuators have a factory defect and that a recall should be done.

My 2010 Toyota Prius hatchback suddenly had 4 or 5 warning lights appear on the dashboard and my brakes failed to function properly. It felt like the power brakes was turned off ! Although I did get the vehicle stopped, it surely was a dangerous situation. I understand that Toyota knows about this problem, and have read that it was warranted if this happened before 150,000 miles. My Prius has approx 167,000 miles right now and to replace the Brake Actuator, the cost will be $ 3 - 5 thousand dollars…absurd amount in my opinion. Since this critical feature (brakes) has a long known history of being faulty on Toyota vehicles it should be warranted for at least 25 years and at least 300k ! My Prius is “unsafe to drive” and is nothing more than a paperweight…I repeat, Toyota knows, and has known about this defective brake actuator problem for years and years!!! Please lean on Toyota to up the warranty of this faulty brake problem for the MANY, MANY Toyota owners who have purchased the Toyota product and and NOT screwing the public like they are doing now !

The brake accumulator has failed on my prius which then deactivates regenerative braking, traction control, abs, and stability control. The lights for traction control, ABS, and stability control and parking brake are shown on the dash. The result for the driver is that the brake pedal has the same pressure, but does nothing until about 25% of pedal travel. At this point, the mechanical brakes will engage and provide a very sudden and jerky application to the brakes. In other words, a very non-linear brake control is present and is incredibly difficult to predict. If this vehicle is operated on the motorway, the safety of the vehicle's occupants as well as others on the road is greatly reduced. Street Toyota has confirmed this issue and its effects. They want to charge $3600 to fix this issue even though the car is only worth $5k. This problem has been investigated in the past buy Toyota and the NHTSA. Toyota has applied an extended warranty for this part meaning that they will only replace it once it goes out. They also failed to notify their consumers about this matter. It is a serious issue that has put many lives at risk and has caused multiple injuries. It is a matter that should not be ignored by either the NHTSA or Toyota.

I noticed that the ratcheting parking brake pedal has stopped ratcheting correctly, and I planned to have it inspected on the next scheduled maintenance. Recently, the brake system illuminated the traction control, ALB and "BRAKE" lights simultaneously, and the braking power diminished by more than half, with no braking until the pedal was halfway down. I depressed the parking brake pedal a few times, which cleared the "BRAKE" symbol and the problem stopped and normal braking returned. This has now happened three times with the same fix. It appears that when the "BRAKE" symbol is no longer illuminated, the problem goes away. This appears to be a software problem that triggers a braking problem to engage the traction control and ABS icons when the "BRAKE" icon associated with the parking brake is illuminated. This web site has other instances reported with the same symptoms, and Toyota had a service bulletin, which has expired, which leads to a $2000-$3000 repair bill to replace a brake booster. It appears to be software related to me, not mechanical. It poses a safety risk because braking performance is severely compromised with no warning. NHTSB needs to look into this, as rear end accidents can easily happen if strong braking in heavy traffic is required to avoid a collision. I recommend that a recall be established to fix this. An alternative cause may be a misaligned micro switch in the parking brake mechanism, which has been experiencing problems. This could lead to the "BRAKE" light being illuminated, and sending a bad signal to the computer.

The contact owns a 2010 Toyota Prius. The contact stated that while driving 60-65 MPH, the vehicle lost motive power and went into LIMP Mode. The coolant temperature and several unknown warning lights were illuminated, and the message "Check Hybrid System" was displayed. The contact pulled to the side of the road, where he disconnected and reconnected the battery to reset the Hybrid system. The contact was able to drive to the residence; however, the failure recurred. The contact used an OBD reader to retrieve diagnostic test code: P261B. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 18V684000 (Hybrid Propulsion System) however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 148,469.

[XXX] We took in 2010 Prius to Toyota Dealership in Pharr Texas because road hazard light, ABS , Brake and low tire alarm came on while driving car. They ran diagnostic and found out that the brake pump assembly and brake cylinder assembly has to be replaced. We called Toyota Cooperate to ask for assistance to pay for cost and after 4 weeks of reviewing issue they said they could not help us because the CSP had expired. This car was given to us by a friend of ours and they had not used it for 2-3 years so we got it we repaired and got car running again. After we drove it we came across this problem with the brakes. This car was was built in the same plant as the other recalled cars going by by the vehicle number . We believe that the CSP should be extended or changed to a Recall? Will you help us or direct us to whom we can contact with this safety issue? I have the Toyota diagnostic report from Toyota and Toyota Corporate Letter on email. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2010 Toyota Prius. The contact stated while driving 45-50 MPH and depressing the brake pedal, the ABS, the traction control, and the check engine warning lights were illuminated. The contact stated that the vehicle experienced reduced braking power and the vehicle failed to respond as needed. The contact stated that upon engaging the brake, the vehicle decelerated, and the contact pulled to the base of an inclined side street, where the vehicle was able to stop. The contact was able to safety park and inspected the vehicle. The contact was able to drive to the residence at slow speeds. The vehicle was taken to the dealer, where it was diagnosed that the brake booster and master cylinder had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 94,000.

Video recording

I was in my 2010 Toyota Prius with my two children when I suddenly lost my brakes, with luck I was able to let off my gas and coast to a stop. Now I am left with a 3,000 dollar repair. I now know what the price of my children and my life is worth to Toyota! To find that this has already been a problem with no notification is ludicrous!

All the lights on my dash board came on suddenly, and the brake emergency, traction control and ABS lights stayed illuminated. Upon exiting the interstate I could not come to a complete stop at the end of the exit, which was very scary. Fortunately the cars driving on the road the exit merges into did, so we avoided a terrible accident. The brakes were spongy and not operating properly after that. The next day with all the lights still on, I slowly drove (20 mph) to the local Toyota Dealer , who claimed that error code (C1391) was being displayed and according to Toyota, that means the Booster is or will be leaking. Therefore the Pump and Booster needs to be replaced (estimated at $3K). No lights or errors were given before the incident, the brakes just suddenly malfunctioned. However Toyota apparently is aware that the booster and pumps fail without warning, because I discovered with an on-line search that code had a "customer extension" warranty (by googling the code C1391), I called customer service but they refuse to help. They claimed I was mailed a letter in October 2018 (they didn't offer to supply a copy.) However, I never received a letter or any notice from Toyota or the Toyota dealer that I have repeatedly used since I bought the car in 2010 (I have had brakes replaced there when it was under 150k and no one said anything!) Now they are stating that the extension has expired as it was only good up to 150,000 miles or 10 years which ever came first. I can't understand why they have a known brake issue and not replace the part when the vehicle is already at the dealer (It's there for every oil change 3 x a year!) Brakes are an important part of a vehicle, a failure like this should have been recalled, and Toyota should have been made to replace the faulty parts!

Recently, I had ABS failure in my vehicle and warning lights came up on my dash with code C1391 which indicates a problem with brake booster assembly and pump. Now I am afraid to drive it because the brakes seem that they could fail at any time and I cannot break quickly when needed. Toyota is aware there is a problem with the brake booster assembly and pump based on prior Customer Support Programs (my vehicle was not included since warning lights were not present at the time), class action lawsuits, and petitions to NHTS about this issue. I believe the problem is prevalent enough and brakes are significant for driver safety that there should be a safety recall. My vehicle has less than 150,000 miles. I called Toyota to complain about the problem as I know it is very common among Prius owners, but they have said there is nothing they can do.

The contact owns a 2010 Toyota Prius. The contact stated that while driving 50-55 MPH, the ABS, traction control, and brake warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic and the contact was informed that the brake booster assembly needed to be replaced. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 139,999.

Prius Gen III has a known defect with failing Brake booster parts. In Nov 2023, while driving my 2010 Prius (~160K miles), suddenly brake, ABS, Traction control, skid indicator lights popped up on the dashboard and I have lost the ability to brake effectively. There was a brake pressure loss and I had to slam hard the brakes to slow the car. The error code was 'C1391' and the mechanic diagnosed it as failure of Brake booster parts ABS Brake booster pump (accumulator) - part#47070 47060 and Brake master cylinder (actuator), part#47050-47140 and he replaced both these parts. Toyota is aware of these failures which are very frequent and hence they issued a brake booster “customer service program” ZJB - which extended the warranty for these parts. But many of us were not covered by this warranty either because of the time or mileage restrictions. This was a costly repair and we had to fix it out of pocket at the cost of ~$3000 as this is safety hazard without proper braking. To make matters worse, 3 months after the repair, the newly installed parts failed again and I had to go through the same repair. I called to Toyota to complain about this and they cannot do anything about it and advised me to report it to NHTSA.

A couple weeks ago we were driving our 2010 Toyota Prius and 3 brake lights came on: BRAKE, ABS, and a car with squiggly lines behind it. We took the car into the Toyota dealership ($209) to perform a diagnostic. Their results are as follows and I quote: "Hydraulic Brake Booster Pump DTC C1391 Abnormal leak in accumulator. Has T-SB and CSP that are both expired. Recommend perform repair outlined. Recommend R&R Brake Actuator Assy, Booster Pump Assy and perform ABS ECU Reflash. We wouldn't have purchased this car had we known a few years later we'd be facing a $4400 charge Toyota wants to charge. We don't have the funds let alone go now and purchase another car.

The contact owns a 2010 Toyota Prius. The contact stated that while driving at an undisclosed speed, the traction and ABS warning lights illuminated. The contact stated that the brakes were inoperable. The contact stated that he was driving at a low speed and was able to safely stop the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with a failed brake booster. The contact was informed that the brake booster needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but did not assist. The failure mileage was approximately 227,000.

My brakes behave strangely cause i experience inconsistent brake feel after actuation during slow and steady application after brakes on rough or slick surfaces.also, All three lights ABS light,brake light and VSC come on and off on dashboard at the same time.

Hi I want submit issues with the master cylinder and abs pump assy I have 2 vehicles same model with average same mileage and both had issues with this system if I drove any distance below 25 mph in a constant time the dash lights comes on traction control, abs light, brake light , and the brake pedal goes low and barely brakes make this situation dangerous when I stop if you try turn it off the engine and on again lights stay there but if I reset the codes the pump works again for some while and then again when you don’t expected lose pressure and I am really afraid for my safety and my family, and I am not the only one with this problem is too many Prius owners who have the issues I went from dealer and they advice $3000 dlls fix situation who motivate people to lose money for $1200 in parts and $1800 dlls in labor for something they can resolve it because in reality is an manufactured defect

While operating the vehicle at normal highway speeds, the car suddenly had the ABS, Traction Control, and Brake lights all come on. The vehicle did not operate or sound any differently at the moment all the lights came on. However, over the next week there developed a mild humming coming from somewhere in the engine bay approximately behind the dashboard. My mechanic identified the problem as the brake booster and pump assembly failing and informed me that the vehicle may drive normally for sometime but the brakes will fail suddenly once the brake booster and pump fully fail. Thus, making operating the vehicle extremely dangerous. I am currently waiting for a Toyota specialty mechanic to become available to replace the brake booster and pump assembly at a cost of +$3,000. Please investigate this issue, there are many people experiencing this issue with the 2010 Prius models.

The contact owns a 2010 Toyota Prius. The contact stated while driving at various speeds and depressing the brake pedal, the brake pedal was firm and difficult to depress. The contact stated that that the brake pedal was pumped to stop the vehicle. The contact stated that the ABS and stabili-trak warning lights were illuminated and an “Exclamation Mark" message was displayed. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the brake master cylinder and brake booster pump needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 10V039000 (Service Brakes, Air). The manufacturer had not been informed of the failure. The failure mileage was approximately 138,000.

Due to insufficient corrosion protection, the rear brake line of my 2010 Prius burst as I pressed the brake pedal in my driveway. It dumped ALL of the brake fluid onto the ground within a couple of minutes. Imagine if I had been driving!! There could have been a serious crash!! This was sudden. There were no brakes! Pedal lost all pressure and went to the floor when pressed. Lots of warning lights and alarms screaming inside car. The vehicle has been inspected and repaired at the Toyota dealer as of 10/03/2023. I have pictures of the failed part when it was installed on the car. If the dealer is contacted quickly, they might still have the actual failed brake line (which I was charged disposal fees for.) This was very scary and numerous lives could be at risk due to the popularity of this car and its use in rideshare/taxi service. There were no warnings prior to this. Brakes worked normally. Car is well maintained with dealer service records. There is no excuse for not properly trading such a critical part for corrosion, just to save money. Peoples lives are at stake!! It's the BRAKES of the car!! Someone needs to investigate this! I have pictures and receipts I can provide.