Toyota · Sequoia · 2004
9
Recalls
377
Complaints
-
Not Rated
The 2004 Toyota Sequoia has 9 recalls and 377 owner-reported complaints on file with NHTSA. Most reported issue: structure (56 reports).
Source: NHTSA Public Records · Updated Apr 22, 2026
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.
Remedy Status
Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.
Tenneco Automotive (DRiV) is recalling certain aftermarket ball joints for 2004-2007 Toyota Sequoia and 2004-2006 Toyota Tundra vehicles, MOOG part number K80521, K80522, NAPA part number NCP2601633, NCP2601634, ACDelco part number 45D2344, and 45D2345. The ball joint housing may have inadequate hardness, causing premature failure.
Remedy Status
DRiV will work with distributors to return unsold parts. Dealers will inspect and replace the ball joint as necessary, free of charge. Owner notification letters were mailed on March 17, 2022. Owners may contact DRiV customer service at 1-877-489-6659 or at RECALL.SUPPORT@DRIV.COM.
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
Remedy Status
2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
Remedy Status
2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy Status
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.
Remedy Status
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Remedy Status
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Remedy Status
Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
Remedy Status
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Rust! Frame completely rusted, even though the CRC was applied back in 2013.
The contact owns a 2004 Toyota Sequoia. The contact stated that while completing an inspection and emissions test on the vehicle, the mechanic informed the contact that there was severe rust on the rear subframe of the vehicle, near the control arm, and several other areas on the subframe. The contact stated that there were several holes on the subframe caused by the extreme rust. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 203,000.
See attached document for complaint.
See attached document for complaint.
TOYOTA frame is falling apart due to the use of faulty metal to manufacture those frames they ran a limited service campaign to replace some of the frames and they denied many other owners that right please help by telling TOYOTA North America to take care of this very hazardous issue thank you
Frame is rotting out
The undercarriage is rotten you help my thanks
Frame has rust issues throughout. Frame not properly treated at the factory and now I am suffering because it has virtually rusted through in front of the drivers side rear wheel which was pointed out to me at Toyota when my car was in for service.
Frame
The contact owns a 2004 Toyota Sequoia. The contact stated while driving at approximately 35 MPH, the brake pedal was depressed and went to the floorboard. The contact stated that the check brakes and a traction control warning lights illuminated. The contact stated that the failure was intermittent at first but had become a recurring failure. When Toyota issued a recall for the braking issue, the contact did not receive notices, so the contact called them and was told it was a few selected 2004 Toyota Sequoia recalled for those who had complained but, it was not broadcasted like that. The contact had taken the vehicle to a local dealer, but the vehicle was not yet diagnosed. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 07E023000 (Service Brakes, Hydraulic). The manufacturer was informed of the failure. The failure mileage was approximately 143,000.
The frame is rusting away due to poor grade of metal that it is built from.
Rotting frame!
The tail gate will not open. I had the vehicle since 2018 and it was working and now it's not working. I taken it to toyota dealership and the cost is to much for at this point. I was wondering is there anything that can be done?
I WAS SIMPLY PARKING MY 2004 TOYOTA SEQUOIA IN PARKING LOT SPACE. LEFT FRONT TIRE FELL COMPLETELY OFF THE CAR WITHOUT ANY PREVIOUS WARNING OF PENDING PROBLEMS! BALL JOINT CATASTROPHICALLY FAILED! PRIOR RECENT NEW TIRES AND ALIGNMENT SHOWED NO PENDING PROBLEMS. DID A CHECK AND FOUND MANY PRIOR BALL JOINT ISSUES FOR THIS CAR AND A PRIOR RECALL YEARS AGO. TOWED TO TOYOTA DEALERSHIP IN CAPITOLA CA. THEY REPLACED BALL JOINT AND RELATED PARTS. THEY CHARGED ME LOTS OF MONEY CLAIMING THAT THIS VEHICLE HAD "PREVIOUSLY BEEN RECALLED AND REPAIRED IN 2007 SO NO LIABILITY ON THEIR PART. I CALLED TOYOTA CORPORATE AND COMPLAINED AND WAS BOUNCED AROUND UNTIL A FELLOW NAMED "GARRET" TOLD ME THE BALL JOINTS HAD BEEN "FIXED" IN 2007 DURING A RECALL. GREAT. THEN WHY DO THESE ISSUES CONTINUE? MY CAR IS DRIVEN ONLY ON PUBLIC STREETS AND THERE WAS NO WARNING OF THIS IMPENDING FAILURE. THE BALL JOINT AND RELATED SIMPLY FAILED CATASTROPHICALLY. I TAKE EXCELLENT CARE OF THIS VEHICLE AS I INTENDED ON KEEPING IT REGARDLESS OF MILEAGE. WHAT BS IS TOYOTA PULLING WHEN THEIR SEQUOIA (AND OTHER SIMILAR TOYOTA VEHICLES) CONTINUE TO CATASTROPHICALLY FAIL WITHOUT WARNING? I WONDER HOW MANY PEOPLE DIED ON THE FREEWAY ETC BECAUSE OF THIS? I HAVE PERSONALLY OWNED AND/OR FAMILY, FRIENDS ETC. MANY CARS, TRUCKS ETC. BALL JOINTS LIKE BRAKES, TIRES HOSES ETC WEAR OUT SLOWLY AND GIVE AMPLE WARNING WHEN THEY NEED REPLACEMENT IE TIRE WEAR IS INCREASED, STEERING DIFFICULTY ETC. NOT IN TOYOTA'S CASE. THERE WAS NO WARNING AT ALL BEFORE THE WHEEL JUST FELL OFF THE VEHICLE. THESE CATASTROPHIC FAILURES OF WHEELS FALLING OFF WITHOUT WARNING AT ANY MOMENT ARE HORRIBLY DANGEROUS AND YET COMMON KNOWLEDGE INCLUDING PRIOR RECALL(S) AND YET THEY STILL ARE ALLOWED TO CONTINUE. THIS IS RIDICULOUS!
LEFT FRONT (DRIVERS SIDE) WHEEL BALL JOINT(S) FAILED CATASTROPHICALLY CAUSING WHEEL TO FALL OFF AND WEDGE UNDER CAR WHILE PULLING INTO A PARKING SPACE. NO PRIOR WARNING, NO PRIOR NOISE, NO PRIOR STEERING ISSUES, NO STRANGE TIRE WEAR (TIRES JUST REPLACED 6 MONTHS AGO). JUST INSTANT AND CATASTROPHIC FAILURE!
REAR HATCH DOOR WOULD NOT OPEN DEALER HAS REPLACED LOCK SUB ASSY AND HANDLE ASSY 3 TIMES IN THE PAST 10 YEARS. THIS IS THE FOURTH FAILURE LATCH HAS, 2010, 2014, 2018 AND 2021. THE FIRST THREE FAILURES OCCURRED ABOUT EVERY 4 YEARS THE CURRENT FAILURE WAS 2 YEARS AND 3 MONTHS. OWNED. CAR 6 YEARS BEFORE FIRST FAILURE.
TRAC OFF LIGHT AND VAC TRAC LIGHTS ON ALL THE TIME! GRINDING NOISE WHEN BRAKES APPLIED AT RANDOM TIMES. CAUSE FOR CONCERN! HAVE HAD EVERYTHING REPLACED THAT COULD CAUSE THIS OVER THE PAST 2 YEARS AND STILL HAVING THE SAME ISSUE!
I HAVE A 2004 TOYOTA SEQUOIA. THE VEHICLE HAS BEEN WELL TAKEN CARE OF WITH NUMEROUS RECEIPTS TO PROVE IT. UPON FURTHER INSPECTION OF THE VEHICLE, I HAVE OBSERVED A 'ROT' HOLE IN THE REAR PART OF THE FRAME. THE WHOLE IN THE FRAME IS APPROXIMATELY THE SIZE OF A DOLLAR BILL AND SPREADING. THERE ARE OTHER PARTS OF THE FRAME THAT WILL NEED ATTENTION IN THE FUTURE. TOYOTA HAS RECALLED SEQUOIA MODEL YEARS 2005 AND UP AND HAVE NEGLECTED TO INCLUDE THE 2004. IT IS APPARENT THAT THE 2004 SEQUOIA IS SUBJECT TO THE SAME FAULTY FRAME MANUFACTURING AS OTHER MODELS/ YEARS OF NUMEROUS TOYOTA'S. MY VEHICLE HAS APPROXIMATELY 137,600 MILES ON IT. I HAVE MAINTAINED VEHICLES FROM FROM THE 90S THAT HAVE BETTER FRAME CONSTRUCTION THAN MY TOYOTA. I BELIEVE THAT THE FRAME ON MY 2004 SEQUOIA WILL NEED FRAME PATCHES IN THE FUTURE AS WELL AS MANY OTHER METAL COMPONENTS CONNECTED TO THE FRAME REPLACED.
WHEN TURNING LEFT OR RIGHT, AND AT LOW SPEEDS, VTS IS TURNING ON AND CAUSING THE VEHICLE TO LOSE POWER. THIS HAPPENS WHEN PULLING OUT IN FRONT OF TRAFFIC AND I CANNOT SPEED UP UNTIL THE VEHICLE IS STRAIGHT. *TR
TOOK 2004 SEQUOIA TO KINGS TOYOTA FOR THE AIRBAG RECALL AS WELL AS DIAGNOSTIC EVAL OF VSC ABS LIGHTS ISSUE. RECEIVED A PHONE CALL THAT THE TECH COULD NOT DETERMINE THE ELECTRICAL PROBLEM UNLESS WE PAID AN ADDITIONAL $360 FOR MORE TIME TO DIAGNOSE AND THAT THE FRAME WAS RUSTED THROUGH WITH LARGE HOLES. WONDERED IF WE WANTED TO PURSUE THE ELECTRICAL ISSUE WITH THE LARGER SAFETY ISSUE WITH THE FRAME. ORIGINAL ISSUE OCCURRED WITH LIGHTS COMING ON (HAD HAPPENED SEVERAL TIMES PREVIOUSLY) FOLLOWED BY THE POWER WINDOWS CEASING TO WORK, SEVERAL HOURS LATER THE WIPERS AND WINDOW SEEMED SLUGGISH AND THE CAR LOST ALL POWER. HAD TO JUMP THE CAR SEVERAL TIMES TO GET OFF THE ROAD AND THEN WHEN JUMPING NO LONGER WORKED, WE HAD TO PUSH THE VEHICLE INTO A CHURCH PARKING LOT. AFTER BEING TOLD BY MR. HOWARD THAT THEY DON'T SEE VEHICLES COME INTO SERVICE WITH LARGE HOLES IN THE FRAME, I RESEARCHED ONLINE AND FOUND THAT 10S OF THOUSANDS OF TOYOTA TRUCKS, INCLUDING 05-08 SEQUOIAS, HAVE BEEN RECALLED - CRC APPLIED AND FRAMES REPLACED AS WELL AS TOYOTA BUYING BACK 95-00 TRUCKS WITH RUSTED FRAMES FOR 1.5 TIMES THE BLUE BOOK VALUE. 04 SEQUOIAS MENTIONED MORE THAN 300 TIMES FOR THE VSC, TAILGATE AND RUSTED FRAME ISSUES THAT ARE PREVALENT IN THIS MODEL - MY VEHICLE HAS ALL 3. SPOKE WITH COLIN, THE SERVICE MANAGER, WHO REITERATED WHAT I FOUND ONLINE. TOYOTA WILL DO NOTHING SINCE THE RECALL IS CLOSED AND DID NOT INCLUDE THE 04 MODELS.
Showing 1–20 of 25 complaints
The 2004 Toyota Sequoia has 9 recalls recorded by NHTSA.
NHTSA has received 377 owner-reported complaints for the 2004 Toyota Sequoia.
NHTSA has not published a safety rating for the 2004 Toyota Sequoia.
The most commonly reported complaint categories for the 2004 Toyota Sequoia are structure (56 reports), electronic stability control (esc) (30 reports), suspension (21 reports).
Yes. NHTSA has 9 recalls on record for the 2004 Toyota Sequoia. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.