There are 27 stored owner reports matching the lighting leading-label group for the 2011 Toyota Tacoma in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 27 of 27 matching reports. The list controls page through the loaded reports only.
Open the full vehicle complaint log (all categories)1.) Headlights are yellowing. 2.) Hard to see at night. 3.) Everyone has the same problem. The government should mandate going back to glass headlights for safety reasons. Buffing them only lasts a short period of time and the elderly can't afford to buy new OEM headlights every 6 years as they are very, very expensive. This is a safety issue, as yellow lenses equal more nighttime accidents, fact. This should have been addressed years ago.
The contact owns a 2011 Toyota Tacoma. The contact stated that the driver's and passenger's side headlights were inoperable. Upon inspection, the contact noticed that the headlight assemblies were extremely hot and had melted. The vehicle was taken to the dealer where it was diagnosed that the driver's and passenger's side headlight assemblies needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 210,000.
BOTH LEFT SIDE AND RIGHT SIDE DAY TIME RUNNING LIGHT LENS INSIDE HEAD LIGHT ASSEMBLY ARE BURNED AND DISCOLORED. HEAD LIGHT ASSEMBLY LENS ARE CRACKED.
MY DAYLIGHT RUNNING LIGHT KEEPS BURNING OUT AND SPLITTING THE LENS. IT'S THE SECOND SET OF LIGHT I'VE HAD TO REPLACE THEM.
I HAVE HAD TO REPLACE MY HEADLIGHTS 4 TIMES IN TWO YEARS.
DAYTIME RUNNING LIGHTS BUBBLING AGAIN AFTER RECALL AND REPLACEMENT. NOTICED IT YESTERDAY (8/15/18). THE TRUCK HAS 80,812 MILES AND THE RECALL NOTICE SAID WARRANTY ONLY GOOD UNTIL 5 YEARS OR 70,000 WHICHEVER COMES FIRST. SEEMS TO ME THEY PUT NEW BAD ONES IN WHEN THEY REPLACED THEM UNDER THE RECALL. NOT SURE EXACTLY WHEN THEY STARTED BUBBLING AGAIN.
THE INNER DAYTIME RUNNING LIGHT/TURN SIGNAL LENS BECOMES DISTORTED AND BUBBLED WITH A BROWN, SCORCHED RESIDUE WHICH OBSCURES AND/OR DIMINISHES THE RUNNING LIGHT AND TURN SIGNAL FUNCTIONS TO ON-COMING TRAFFIC. ADDITIONALLY, THE INNER LENS IS CRACKED AND/OR SEPARATED. TOYOTA DID OFFER A WARRANTY EXTENSION ON THIS DEFECT SO IT HAS BEEN ACKNOWLEDGED AS A PROBLEM. THIS WARRANTY EXTENSION HAS SINCE EXPIRED ALTHOUGH THE PROBLEM STILL EXISTS FOR THESE VEHICLES.
TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. THE CONTACT STATED THAT THE DAYTIME RUNNING LAMPS BECAME REALLY HOT. THE CONTACT THEN NOTICED THAT THE DAYTIME RUNNING LIGHTS TURNED BROWN AND MELTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED TEMECULA VALLEY TOYOTA AT (951) 694-0575 (26631 YNEZ RD, TEMECULA, CA 92591) AND WAS INFORMED TO CALL THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE WARRANTY ENHANCEMENT HAD EXPIRED. THE APPROXIMATE FAILURE MILEAGE WAS 93,000. *TT *TR
MY DAYTIME RUNNING LIGHTS QUIT WORKING BECAUSE THEY GOT TOO HOT AND BURNED THE LENS AND BULB SOCKET. THIS CAUSED MY FRONT AND REAR RIGHT BLINKERS TO CEASE WORKING AND COULD HAVE HAD DISASTROUS RESULTS.
DAY TIME RUNNING LIGHTS ARE TOO HOT. THE BULBS HAVE MELTED AND BUBBLED THE PLASTIC HOUSING. CALLED TOYOTA AND THEY SAID IT WAS OUT OF WARRANTY AND THAT A NOTICE WAS SENT OUT ABOUT THIS ISSUE WHICH I NEVER RECEIVED. TOOK MY TRUCK TO TWO DIFFERENT DEALERSHIPS AND WAS NEVER TOLD ABOUT ANY ISSUE. TOYOTA WILL NOT COVER ANY REPAIRS OR REPLACEMENTS.
THE PLASTIC HEADLIGHT HOUSING OVER THE DAYTIME RUNNING LIGHTS IS MELTING / BUBBLING. THE TRUCK HAS ONLY 40,000 MILES. TOYOTA WILL NOT REPLACE OR REPAIR UNDER WARRANTY ENHANCEMENT. POSSIBLE FIRE HAZARD.
MY HEADLIGHT ASSEMBLY LENS WERE DISTORTED AND BUBBLED ON BOTH SIDE OF THE VEHICLE. TOYOTA REPLACED THE HEADLIGHTS TWICE ON THE RIGHT & 1 ON THE LEFT. NOW THE ONE ON THE RIGHT IS DISTORTED AND BUBBLED AGAIN AND TOYOTA REFUSED TO REPLACE IT BECAUSE IT IS OUTSIDE THE 5 YEARS/70,000 MI WARRANTY. THIS IS A POTENTIAL FIRE HAZARD AND A DEFECT FROM THE DESIGN. PLEASE SEE ATTACHED PICTURE FOR REFERENCE.
THE BULBS IN THE DAYTIME RUNNING LIGHTS ARE MELTING THE LENSES.
THE RUNNING LIGHT LENS ON DRIVER'S SIDE IS FOGGED AND CRACKED. TOYOTA ISSUED A VOLUNTARY RECALL AND SENT ME A LETTER THAT THEY WOULD REPLACE PART UP TO 5 YEARS OR 70,000 MILES. I HAVE 65,000 MILES BUT MY TRUCK IS GREATER THAN 5 YEARS OLD, AND THEY WOULD NOT REPLACE THE PART AFTER I CONTACTED THEM. ACCORDING TO MY LOCAL DEALER THIS WILL EVENTUALLY HAPPEN TO THE OTHER SIDE AS WELL.
HEADLIGHTS ARE FORMING CRACKS IN LENSES, AND THEY ARE GROWING.
MY 2011 TOYOTA TACOMA HAS APPARENTLY HAS HAD A DESIGN FLAW SINCE EVEN BEFORE 2009 IN THE FRONT TURN SIGNAL HOUSING. THE DESIGN FLAW CAUSES THE LENSE TO MELT FROM EXTREME HEAT BUILD UP IN THE HOUSING CAUSING THE BULB TO BURN OUT AND ULTIMATELY THE SOCKET TO CHAR AND IN MY CASE DEFORM TO THE POINT I COULDN'T REPLACE THE BULB. TOYOTA HAS IN SEPTEMBER 2011 RELEASED A TECHNICAL BULLETIN INSTRUCTING THERE TECHS ON HOW TO REMEDIATE THE OBVIOUS DESIGN FLAW. THERE WAS NO NOTICES SENT OUT TO OWNERS EVEN THOUGH THEY APPARENTLY KNEW BEFORE THEY EVEN BUILT THE 2011 TRUCKS THAT THERE WAS A SERIOUS PROBLEM. TO DO THIS AND NOT MAKE US AWARE IS CRIMINAL TO SAY THE LEAST BECAUSE IN THE CAB IT IS TELLING YOU THAT IT IS WORKING AND YOUR NOT AWARE THAT YOUR FRONT SIGNAL IS NOT WORKING. THINK OF ON COMING TRAFFIC NOT KNOWING THAT YOUR GONNA TURN AND YOU THINK THEY DO. THIS IS CRIMINAL. IMAGES ARE AVAILABLE IF NEEDED. JUST GO TO YOUTUBE.
THE RUNNING LIGHTS AREA DEVELOPED CRACKS AND A ROUND SHAPE CLOUDY AREA IN FRONT OF THE LIGHT BULB LIKE IT MELTING THE PLASTIC. *TR
PURCHASED NEW TOYOTA TACOMA 2011 FROM LOCAL DEALER. PROBLEM IS WITH DAYTIME RUNNING LIGHTS GETTING TOO HOT AND BURNING AND CRACKING LENS. CUSTOMER SERVICE SAYS THEY SENT OUT WARRANTY POLICY BULLETIN (POL14-03) , BUT I NEVER RECEIVED NOTICE. THEY ALSO SAY BOTH WARRANTIES THEY CREATED BECAUSE OF THIS PROBLEM, HAVE EXPIRED, AND WILL NOT PAY FOR REPAIRS. I AM WORRIED THEY MAY START A FIRE BECAUSE OF THE OVERHEATING.
TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. WHILE DRIVING WITH THE DAYTIME RUNNING LAMPS ILLUMINATED, THE CONDENSATION ON THE HEADLIGHTS SPLIT AND MELTED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (PREMIER TOYOTA , 5601 NATIONAL RD E, RICHMOND, IN 47374) WHERE IT WAS DIAGNOSED THAT THE HEADLIGHT/TURN SIGNAL ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND OPENED CASE NUMBER: [XXX]. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 25,000. *TT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
THIS VEHICLE HAS 2 FRONT DAYTIME RUNNING LIGHTS. THE LIGHTS IN THIS AREA ARE OVERHEATING AND CAUSING THE LIGHTING CASE TO HAVE A "BUBBLE" IN THE BULB CASING. THIS IS CAUSING DAMAGE TO BOTH DRIVER AND PASSENGER HEADLAMPS. THIS IS CAUSED WHEN AS SOON AS THE VEHICLE IS TURNED ON AND WHEN PARKED OR DRIVING. *TR
Showing 1-20 of 27 loaded complaints
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 29, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.