There are 13 owner-reported fuel system complaints for the 2000 Toyota Tundrain NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
TL* THE CONTACT OWN A 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THE REAR FUEL TANK STRAP SEPARATED FROM THE VEHICLE. THE CONTACT WAS ABLE TO REINFORCE THE FUEL TANK WITH A TEMPORARY STRAP. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FUEL STRAP WAS NOT REPLACED BY THE DEALER. THE FAILURE MILEAGE WAS 210,000.
TL* THE CONTACT OWNS A 2007 JEEP LIBERTY. THE CONTACT STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 13V252000 (FUEL SYSTEM, GASOLINE, STRUCTURE). THE CONTACT DID NOT EXPERIENCE THE FAILURE; HOWEVER SHE WAS CONCERNED THAT SHE COULD BE CRASHED INTO FROM THE REAR DUE TO FAST MOVING TRAFFIC. THE FAILURE AND CURRENT MILEAGE WAS 34,000. THE VIN WAS NOT AVAILABLE. *TR
TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS BEING REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 09V444000 (STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS). WHILE REPAIRING THE VEHICLE, THE DEALER STATED THAT THE FUEL TANK WAS RUSTED AND LEAKING. NEITHER THE DEALER NOR MANUFACTURER OFFERED ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 108,000.
2000 TOYOTA TUNDRA LIMITED ACCESS CAB 4WD TRD. FUEL LINE LINK DETECTED AFTER SHORT TRIP. EXCESSIVE FUEL POURING FROM DRIVER SIDE REAR DOOR OF EXTENDED CAB. LEAKED WAS SLOWED WHEN GAS CAP WAS REMOVED. LEAKED CONTINUED AT A MUCH SLOWER PACE AS DUE TO LOWER PRESSURE IN PRESSURIZED FUEL LINE. LEAK WAS LIMITED TO THE CAB AREA ONLY. FRAME WAS RECENTLY REPLACED IN RECALL CAMPAIGN. MUCH OF THE UNDERBODY COMPONENTS - LEAF SPRING, AXLE, SPRINGS, BRAKE COVERS, ETC. - ARE DETERIORATING DUE TO RUST. THESE COMPONENTS WERE NOT COVERED UNDER THE FRAME RECALL. FUEL LINE APPEARED TO HAVE RUST BUT COULD NOT DETECT PERFORATION AND COULD NOT DETERMINE ACTUAL LOCATION OF LEAK. CAR BROUGHT TO DEALER FOR REPAIR WITH AN ESTIMATE OF $850 TO REPLACE FUEL LINES. *TT
TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH OVER A ROAD HUMP WHEN HE HEARD A LOUD POPPING NOISE. AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE FRONT FUEL TANK STRAP WAS SEVERELY RUSTED AND FRACTURED. THE VEHICLE WAS ABLE TO BE DRIVEN APPROXIMATELY 10 MPH AND WAS TAKEN TO THE DEALER WHO REPLACED THE FUEL TANK STRAP. THE MANUFACTURER WAS CONTACTED AND REIMBURSED THE CONTACT FOR THE PART. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. UPDATED 02/22/12*LJ THE CONSUMER STATED THE VEHICLE HAD SEVERE FRAME RUST, INCLUDING THE CROSS MEMBER, GAS STRAPS, BRAKE LINES, PROPORTIONAL VALVE ETC. UPDATED 03/01/12
FUEL TANK OR SYSTEM FAILURE.*TR
I HAVE A TUNDRA 2000. MOST OF THE FRAME ARE CORRODED DUE TO RUST. WHILE DRIVING, HIT A POT HOLE AND THE GAS TANK STRAPS LET GO DUE TO CORROSION. GAS TANK DROP TO THE GROUND, LUCKILY I PULL TO THE SIDE AND NO ACCIDENT HAPPEN. THANKS GOD. *TR
I HAVE BEEN AWARE OF PROBLEMS WITH EARLY MODEL TOYOTA TUNDRA FRAME RUST PROBLEMS AND HAVE FOLLOWED WITH INTEREST TOYOTA'S RESPONSE [NONE]HOWEVER, I FEEL OBLIGED TO INFORM YOU THAT ON FRIDAY 25TH THE GAS TANK STRAPS FAILED WHILE DRIVING AND THE GAS TANK FELL OF THE VEHICLE AS LUCK WOULD HAVE IT I WAS SLOWING DOWN TO MAKE A TURN SO THE CONSEQUENCES WERE LIMITED. BUT, 30 SECONDS EARLIER AT 55 MPH THIS MOST LIKELY WOULD NOT HAVE BEEN A LIMITED CONSEQUENCE SITUATION. *TR UPDATED IVOQ 06/30/10.*JB
FUEL LINE ON DRIVER SIDE ON 2000 TUNDRA PERFORATED DUE TO RUST. NOTICED WHILE BRAKING ON DOWNGRADE PORTION OF LARGE HILL. VEHICLE STOPPED VERY POORLY, ALMOST RESULTING IN LOSS OF CONTROL. HAD TO PAY TO TOW AND REPLACE FUEL LINE ON VEHICLE. *TR
THIS VEHICLE WAS PURCHASED AT GREENSBURG TOYOTA, GREENSBURG, PA. THIS VEHICLE HAS HAD BRAKE LINES REPLACED, FUEL LINES REPLACED, THE FRAME CORRODED AND RUSTED OUT, FUEL LINES RUSTED OUT, THE TIE RODS RUSTED OUT, THE TAILGATE RUSTED OUT, THE ELECTRICAL OUTLETS FOR THE BACKUP AND TAIL LIGHTS WERE SHORTING OUT, THE ENTIRE BODY ON THIS VEHICLE IS RUSTING. THIS VEHICLE IS A COMPLETE MENACE TO THE TOYOTA COMPANY. THIS VEHICLE HAD THE FRONT AXLES RUSTED OUT AND THE WHEEL FELL OFF WHILE DRIVING IT.
GAS TANK ON 2000 TOYOTA TUNDRA ACCESS CAB - LIMITED DEVELOPED A RUST SPOT AND WAS LEAKING GASOLINE. THE TANK HAD TO BE REPLACED.*AK
GAS TANK SEEPING GAS AT THE POINT WHERE TOP AND BOTTOM PORTION WIELDED TOGETHER. TANK WAS REPLACED I HAVE THAT TANK IN MY POSSESSION IF YOU NEED TO EXAMINE IT. *AK
CONSUMER STATED THAT PROBLEM CANNOT BE DUPLICATED AT THE DEALERSHIP. WHEN HE IS CRANKING VEHICLE FOR A LONG PERIOD OF TIME. THERE IS A LOT OF RAW GASOLINE SMELL COMING INSIDE OF VEHICLE. *AK
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 25, 2026