2004 Toyota Tundra Electrical System Problems

I HAVE PROBLEM WITH MY TOYOTA 2004 TUNDRA, THAT THE DEALERSHIP AND ANOTHER REPAIR GARAGE CAN'T SEEM TO FIND THE PROBLEM. WHEN I DRIVE THE TRUCK, DOESN'T MATTER HOW LONG , EVERY ONCE IN A WHILE WHEN I STOP AND TURN IT OFF ALL THE ELECTRONICS GOES DEAD. I CAN'T START THE TRUCK BECAUSE THE BATTERY IS DEAD AND THEN SOMEWHERE BETWEEN 15 MINUTE TO OVERNIGHT, EVER THING COMES BACK ON. NO JUMPING OF THE BATTERY. HAD BATTERY CHECKED, ALTERNATOR CHECK AND OTHER THINGS WIRING AND EVERY THING IS WORKING FIND. THE DEALERSHIP AND OTHER MECHANIC FROM ANOTHER SHOP SAID THEY CANNOT FIND THE PROBLEM UNLESS IT IS ACTING UP AT THE TIME THEY CHECK IT. HAD TO CALL AND GET A TOW AND BY THE TIME THE TOW TRUCK GOT THE VEHICLE TO THE REPAIR SHOP, IT STARTED UP. KIND OF SCARED TO DRIVE IT ANYWHERE. [XXX] REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V285000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAS EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

ANYTIME IT RAINS WATER LEAKS IN BEHIND THE DASHBOARD ON THE PASSENGER SIDE, LEAKING WATER THROUGH THE ELECTRICAL WIRING AND INTO THE FLOORBOARD OF THE TRUCK THERE ARE LOTS OF WIRES AND A BLOWER MOTOR IN THIS AREA WHERE FIRE COULD CAUSE ANY NUMBER OF UNSAFE CONDITIONS. THE CAUSE HAS BEEN NARROWED DOWN TO ONE OR BOTH OF TWO THINGS. THE FIRST IS A CRACK THAT ORIGINATES IN THE SEAM BEHIND THE DASH BOARD OF THESE VEHICLES DUE TO PRODUCTION ERROR. THE SECOND IS ROTTING GROMMET PLUGS UNDER THE WINDSHIELD WIPER COWL. THE FIRST BEING MUCH MORE SEVERE AS IT COULD ALSO CAUSE STRUCTURAL INTEGRITY.

STARTED TRUCK, CONNECTED SMALL TRAILER TO HITCH. I NOTICED LIGHTS ON TRAILER NOT ON GOT OUT OF TRUCK TO PLUG AND UNPLUG CONNECTOR. LIGHTS CAME ON. ENTERED TRUCK , PUT FOOT ON BRAKE TO PUT IN GEAR. THE ENGINE REVVED UP AND THE TACH. WAS FLUCTUATING BETWEEN 1000 AND 6500 RPM WITHOUT EVER TOUCHING THE ACCELERATOR. I TURNED THE IGNITION TO THE OFF POSITION. SCARED TO RESTART, I LET IT SIT FOR FIVE MINUTES THEN STARTED ENGINE. EVERYTHING RAN NORMAL AND I PROCEEDED TO DRIVE HOME. THIS HAD NEVER OCCURRED BEFORE OR SINCE THIS INCIDENT. I DID NOT REPORT THIS TO TOYOTA SINCE THE RECALL MODELS WERE OTHER THAN MY 2004 TOYOTA TUNDRA . *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT THERE WAS A SHORTAGE IN THE ELECTRICAL SYSTEM IN HIS VEHICLE. THE FAILURE AFFECTED THE CRUISE CONTROL, DOOR LOCKS, POWER WINDOWS, AND ALL OTHER ELECTRICAL COMPONENTS. HE CALLED THE DEALER AND MANUFACTURER AND WAS INFORMED THAT THE FAILURE WAS NOT UNDER WARRANTY; THEREFORE, HE WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THERE WERE NO RECALLS AVAILABLE. THE FAILURE MILEAGE WAS 61,000.

2004 TOYOTA TUNDRA. CONSUMER STATES ELECTRONICS MALFUNCTION. TAPE ENCLOSED. *TGW THE CONSUMER STATED WHEN THE VEHICLE WAS IN OVERDRIVE, THE RPM'S WERE 2,000 AND WHEN THE OVERDRIVE WAS TURNED OFF, THE RPM'S READ 3,000 WHICH WAS OPPOSITE OF THE NORMAL FUNCTION. *JB UPDATED 09/24/10