2004 Volkswagen Beetle Air Bags & Restraints Problems

AIR BAG LIGHT NEVER GOES OFF, STARTED AT 33650 MILES, RIGHT AFTER MY MOM SIGNED OVER THE CAR TO ME.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED AND REMAINED ILLUMINATED FOR TWO MONTHS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE AIR BAG SENSOR WHICH WAS A PART OF THE DRIVER'S FRONTAL SEAT BELT SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE PART NEEDED FOR THE REPAIR WAS ON BACK ORDER. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.

AIR BAG LIGHTS ON AND SEEMS THE DEALER CANNOT GET PARTS TO FIX ??

VW CHECK ENGINE LIGHT ON, OBD SENSOR PORT NOT READING, BATTERY LIGHT CAME ON, AND ABS LIGHT CAME ON, NOW RADIO IS GOING ON AND OFF. STARTED YESTERDAY MORNING,WHILE DRIVING TO WORK THE ABS STARTED AFTER WORK ON THE WAY HOME.

AIR BAG LIGHT CAME ON LAST YEAR, RESOLVED. BACK ON, I SEE OLD RECALL? WHAT TO DO?

1. AIR BAG: THE AIR BAG INDICATOR LIGHT IS ILLUMINATING. 2. SUNROOF DRAIN SYSTEM CLOGGED: THERE IS LEAKAGE THROUGH THE SUNROOF OF THE PASSENGER SIDE. ALL RAIN WATER IS COMING IN FROM THE PASSENGER DOOR. AFTER ABOUT 2 WEEKS OF THUNDER STORMS THE CAR HAS WATER ALL OVER THE INSIDE AND THE CEILING AND SMELLS BAD. (AS SOON AS I FOUND OUT THE SUNROOF LEAKAGE PROBLEM OF THIS CAR, I FOUND THAT HE U.S. COURT OF APPEALS FOR THE THIRD CIRCUIT HAS APPROVED A $69 MILLION SETTLEMENT STEMMING FROM A CLASS-ACTION LAWSUIT THAT STARTED IN 2007 OVER LEAKING SUNROOFS. HTTP://WWW.CARCOMPLAINTS.COM/NEWS/2014/VOLKSWAGEN-SETTLES-LAWSUIT-LEAKING-SUNROOFS.SHTML)

MY TRANSMISSION WENT OUT ALL AT ONCE MY AIRBAG/SEATBEILT LIGHT ON ALL THE TIME

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING AT 40 MPH, THE AIR BAG AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 03V356000 (AIR BAGS), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 117,600.

AIRBAG SERVICE LIGHT ON DASH CAME ON. THIS MEANS THE AIRBAGS WERE DISABLED. DEALERSHIP IDENTIFIED THE SEAT BELT CLASP ON THE DRIVER SEAT AS THE PROBLEM. THE ELECTRONICS IN THE CLASP WERE NOT COMMUNICATING CORRECTLY CAUSING THE AIRBAG TO BE DISABLED. THE SEATBELT AS A SAFETY MECHANISM ITSELF WAS NOT COMPROMISED. THE DEALERSHIP REPRESENTATIVE INDICATED THAT THIS WAS A KNOWN AND COMMON ISSUE WITH THIS VEHICLE MAKE AND MODEL AND THAT THE FIX WAS TO REPLACE THE SEATBELT CLASP AT A COST OF ABOUT $300.00. THE CAUSE OF THE SEATBELT CLASP TO FAIL WAS THE MOTION OF MOVING THE SEAT BACKWARDS AND FORWARDS. TO ACCESS THE REAR SEATS OF THE CAR THE SEAT MUST BE MOVED BACKWARDS AND FORWARDS AS IT IS A TWO DOOR CAR. OVERTIME, THIS ACTIVITY WORE OUT SOME ELECTRONICS IN THE CLASP CAUSING THE AIRBAG TO BE DISABLED. THIS IS NOT A NORMAL WEAR AND TEAR ITEM THAT IS CUSTOMARILY REPLACED SUCH AS TIRES, BRAKE PADS OR WIPER BLADES. THE MANUFACTURE SHOULD RECOGNIZE THIS CRITICAL SAFETY ISSUE AND OFFER TO VOLUNTARILY RECALL THE VEHICLES AND/OR OFFER TO PAY FOR A FIX IN OUR CASE. *TR

MY AIR BAG WARNING LIGHT CAME ON YET AGAIN. THIS HAS HAPPENED IN THE PAST AND WAS FIXED BY A VW DEALER BY CHANGING THE INFREQUENTLY USED PASSENGER SIDE SEAT BELT BUCKLE. THE COST OF THIS REPAIR WAS $360. THE WARNING LIGHT CAME ON AGAIN LESS THAN ONE YEAR LATER. IT WAS BROUGHT BACK TO THE DEALER AND SCANNED AND FOUND TO BE A DEFECTIVE AIR BAG CONTROL MODULE. THE ESTIMATE FOR THE FIX WAS ABOUT $800 WITH THE ADVISORY THAT IT MIGHT NOT BE FIXED WITH THAT PART REPLACEMENT. THE SERVICE REPORT READS, "AIRBAG CRASH SENSORS MAY NEED TO BE REPLACED AS WELL IF SOFTWARE IS DIFFERENT FROM NEW MODULE." IT SOUNDS LIKE THE VW TECHNICIANS THEMSELVES ARE GUESSING ABOUT THE REPAIR. THERE IS REPORTEDLY A VW RECALL ON THE 2003-2005 BEETLE AIRBAG CONTROL MODULE BUT THE VW DEALER AS WELL AS VW CUSTOMER SERVICE (800-374-8389) BOTH TELL ME THAT IT DOES NOT APPLY TO MY VEHICLE. THE INTERNET VW BEETLE FORUMS ARE REPLETE WITH REPORTS OF AIRBAG SYSTEM PROBLEMS. I AM SUBMITTING THIS COMPLAINT TO ADD TO THE CURRENT LIST OF SUCH COMPLAINTS WITH THE HOPES THAT VW WILL TAKE RESPONSIBILITY FOR WHAT APPEARS TO BE A SERIOUS SAFETY RELATED DEFECT IN THEIR DESIGN AND/OR MANUFACTURING PROCESS OF THE 2004 VW BEETLE. *TR

DRIVER'S SIDE SEAT BELT WIRING HAS FAILED THUS ILLUMINATING THE AIR BAG LIGHT. THE SEAT BELT WIRING IS OF MINUTE DIAMETER WITH LITTLE SHIELDING AND POOR CONDUIT. BECAUSE THE SEAT BELT MUST FLEX WHEN MOVING THE SEAT FORWARD, THE STRAIN ON THE WIRING IN THE SEAT BELT RIPS THE WIRING FROM IT'S SOLDERED JOINT. THIS CAUSES THE AIR BAG LIGHT TO ILLUMINATE AND CAUSES THE AIR BAG SYSTEM TO REVERT TO A BACKUP ALGORITHM THAT PUTS THE DRIVER IN A DANGEROUS ENVIRONMENT. THIS "BACKUP" ALGORITHM WILL NOT MONITOR VEHICLE SPEED AND WILL AUTOMATICALLY DEPLOY THE AIRBAG AT A DEFAULT AMOUNT OF FORCE REGARDLESS OF IMPACT FORCE. THIS MEANS THAT A MINOR FENDER BENDER THAT REACHES THE AIRBAG FORCE THRESHOLD COULD DEPLOY THE AIRBAG AT A FORCE TOO GREAT AND CONVERSELY A HIGH SPEED IMPACT MAY DEPLOY THE AIRBAG WITH INSUFFICIENT FORCE. THIS IS AN EXTREMELY COMMON PROBLEM ON THIS MODEL YEAR VEHICLE. A QUICK INTERNET SEARCH WILL ALERT YOU AS TO HOW COMMON THIS PROBLEM IS. AFTER CALLING MY LOCAL DEALERSHIP, THEY TOLD ME "WE REPLACE A TON OF THOSE SEATBELTS." VOLKSWAGEN SHOULD ACKNOWLEDGE THIS EGREGIOUS MANUFACTURING DEFECT AND RECALL THIS DEFECTIVE PART BEFORE FATAL CONSEQUENCES FURTHER PROVE THIS IS A DEADLY AND EXTREMELY COMMON PROBLEM. *TR

AIR BAG MODULE LITE STAYS ON. TOOK TO DEALER AND WAS TOLD IT WOULD COST 800 TO REPLACE MODULE. THIS VEHICLE AT THIS HAS ONLY 71802 MILES AS OF JUNE 26,2013. I FEEL THIS IS A MAJOR SAFETY AND SHOULD BE REPLACED BY A VW DEALERSHIP FREE OF CHARGE. *TR

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 59,000. THE CURRENT MILEAGE WAS 79,000. UPDATED 05/28/14*LJ UPDATED 8/17/17*CN

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG SENSOR LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 08V178000 (AIR BAGS). THE FAILURE MILEAGE WAS 75,000. *TR

AIRBAG LIGHT CAME ON AND STAY ON(CONCERNED ABOUT NOT WORKING PROPERLY IN EVENT OF ACCIDENT) TAKEN INTO DEALERSHIP FOR CODE READ: AIRBAG MODULE SHORTED. FRONT PASSENGER SEAT AND CARPET NEED TO BE REMOVED FOR REPLACEMENT OF AIRBAG BECAUSE WIRE UNDER THE SEAT IS TOO SHORT THAT IT TORN WHEN THE SEAT WAS MOVED FORWARD TO ALLOW ACCESS TO REAR SEAT. THIS SHOULD BE A MANUFACTURED FAULT. *TR

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN NEW BEETLE CONVERTIBLE. THE CONTACT STATED THAT THE AIRBAG LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO PERFORMED A DIAGNOSTIC TEST AND STATED THAT THE FAILURE WAS LOCATED AT THE AIRBAG CONTROL MODULE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 27,000 AND THE CURRENT MILEAGE WAS 32,631.

VEHICLE IS A 2004 VW NEW BEETLE - PROBLEM IS AIRBAG LIGHTS ARE ON DUE TO A BROKEN WIRE IN THE WIRING THAT LEADS INTO THE DRIVER'S SIDE SEAT BELT LATCH. I HAD THE CODE DIAGNOSED BY A MECHANIC AND I VISUALLY INSPECTED THE 4 WIRES UNDER THE SEAT BELT BUCKLE AND THE YELLOW WIRE IS BROKEN. AN OBVIOUS MANUFACTURING FLAW AS THIS PART GETS A TREMENDOUS AMOUNT OF MOVEMENT DUE TO THE SEATBACK MOVING FORWARD AND BACKWARD WHEN PUTTING THE SEAT UP TO GET INTO THE BACK SEAT. MY CAR ONLY HAS 14,000 MILES ON IT SO IT HAS NOT BEEN DRIVEN VERY MUCH IN THE 7 YEARS WE HAVE HAD IT. I CONTACTED THE DEALER WHERE I PURCHASED THE VEHICLE AND THEIR RESPONSE WAS - WE SELL ALOT OF THOSE DRIVER'S SIDE SEAT BELT LATCH ASSEMBLIES DUE TO THE SAME PROBLEM. THEY WOULD NOT REPAIR FOR FREE AS THERE IS NO RECALL AND NO BULLETIN ON THE ISSUE. READ NUMEROUS SITES AND ENTRIES ALL OVER THE WEB AND IT APPEARS MANY OWNERS OF THESE CARS (MANY DIFFERENT MODEL YEARS) ARE ALL HAVING THE SAME PROBLEM. CALLED VW AMERICA TO SEE IF THEY WOULD AT LEAST PROVIDE ME WITH A FREE PART AS I WOULD DO THE REPLACEMENT MYSELF. THEY CHECKED AND DENIED MY REQUEST. AS THE AIRBAGS WILL NOT WORK WHEN THE AIRBAG LIGHT IS ON, THIS IS A DANGEROUS SITUATION. A RECALL SHOULD BE PLACED ON THE SEATBELT LATCHES AS THE WIRING USED AND THE DESIGN ARE NOT AT ALL INDUSTRIAL ENOUGH TO HOLD UP OVER TIME. *TR

THE AIR BAG WARNING LIGHT CAME ON. THIS WAS THE SUBJECT OF AN EARLIER RECALL DUE TO SENSORS. WE WERE TOLD THAT THIS WAS DUE TO A FAULTY SEAT BELT BUCKLE AND NOT DUE TO SENSORS. WE WERE ALSO ORIGINALLY TOLD IT WAS DUE TO A FAULTY BATTERY. HOWEVER, THE BATTERY WAS CHECKED BY AAA AND WAS NOT FAULTY. EVENTUALLY VW AGREED TO REPLACE THE SEAT BELT BUCKLE ON THE DRIVERS SIDE. *TR

THIS VEHICLE WAS SUBJECT TO A RECALL FOR THE AIR BAG SENSORS. WE HAD PREVIOUSLY HAD THE SENSORS REPLACED (THE VEHICLE WAS JUST OUT OF WARRANTY BASED ON TIME). VW REFUSED ULTIMATELY REIMBURSED US FOR THE REPAIRS AND REPLACEMENT OF THE SENSORS. IN JANUARY OF 2011 THE AIR BAG LIGHT CAME ON. THE DEALER CHARGED A FEE TO DO A DIAGNOSTIC TEST. THEY DETERMINED THAT THE LIGHT WAS DUE TO THE FAILURE OF THE DRIVER SIDE SEAT BELT BUCKLE, AND THE FACT THAT THE BATTERY WAS DISCHARGED AND NEEDED TO BE REPAIRED. THEY WANTED APPROXIMATELY $480 TO REPLACE THE SEAT BELT BUCKLE, AND $245 TO REPLACE THE BATTERY. I CALLED VW CUSTOMER SERVICE AND THEY AGREED TO REPLACE THE BUCKLE FOR NO CHARGE, BUT WOULD DO NOTHING ABOUT THE BATTERY. VW OPENED A CASE # 110006836 AND REGIONAL MANAGER LISA WAS THE CONTACT. WE HAD AAA COME TO DO A TEST ON THE BATTERY. THE BATTERY AND CHARGING SYSTEM BOTH PASSED THE TEST. THEY RECOMMENDED THAT A TRICKLE CHARGE WOULD BRING THE BATTERY TO A FULL CHARGE. IN ADDITION, VW AGREED TO DO A ONE TIME COURTESY REPLACEMENT OF THE CONVERTIBLE ROOF SINCE THE FABRIC HAD SEPARATED FROM THE REAR WINDOW. A CLIP RECALL HAD ALREADY BEEN PERFORMED, BUT THE HEADLINER WAS HANGING DOWN AND HAD SEPARATED FROM THE REAR WINDOW. WE FEARED THAT THE WINDOW COULD SEPARATE FROM THE ROOF AT HIGHWAY SPEEDS. STATEMENT INDICATES THAT VW PERFORMED 61.07-02 TECH BULLETIN TO PERFORM MODIFICATIONS TO THE REAR WINDOW.

VW BEETLE, AIR BAG LIGHT CONTINUES TO MALFUNCTION FOR MY 2004 MODEL. I'VE TAKEN THE CAR FOR REPAIR FOR AT LEAST 4-TIMES IN THE PAST 4-YEARS. I BELIEVE THE INITIAL RECALL # 03V3S6000 WAS NEVER CORRECTED AND COMPANY IS NOT CONCERNED IN FIXING IT EVER. *TR