Volkswagen · Passat · 2001
4
Recalls
431
Complaints
-
Not Rated
The 2001 Volkswagen Passat has 4 recalls and 431 owner-reported complaints on file with NHTSA. Most reported issue: engine and engine cooling (68 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2001 Volkswagen Passat page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is engine and engine cooling with 68 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Remedy Status
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Remedy Status
DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Remedy Status
DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Remedy Status
DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
The driver's side airbag of my 2001 VW Passat spontaneously deployed while I drove on Hwy 494 in Woodbury MN. Sometime within 24 hours before the airbag deployed, the airbag fault light turned on in the car's dashboard display. Within 15 minutes before the incident, the car's a...
Preview excerpt
TOOK CAR TO VW DEALER TO HAVE TIMING BELT REPLACED AND WAS NOTIFIED THAT THERE WERE SEVERAL OPEN RECALLS AND THEY OFFERED TO TAKE CARE OF THEM FREE OF CHARGE. HOWEVER, THEY WERE UNABLE TO PERFORM RECALL #08V156. MANUFACTURER #26E5. THEY INSTALLED THE HEAT SHIELD BUT COULD NOT PER...
Preview excerpt
ABS LIGHT ON AND BREAK LIGHT FLASHING
STARTED SMELLING GAS AND MILEAGE STARTED DROPPI G BAD AROUND THE END OF NOVEMBER. WE SEE THAT THERE HAS BEEN RECALLS ON THE GAS TANK AND FUEL LINES FOR 01 VOLKSWAGEN PASSATS BUT UNFORTUNATELY NOT FOR THIS VIN # WHICH HAPPENS TO BE MY SONS CAR. NOW ITS AT THE SHOP BECAUSE ITS GAS ...
Preview excerpt
FAULTY CAM CHAIN TENSIONER FAILED AND CAUSED SEVERE ENGINE DAMAGE TO VALVES, PISTONS, CAMSHAFT, CAM TIMING CHAIN. I WAS STATIONARY WAITING AT A RED LIGHT WHEN I HEARD A SUDDEN LOUD GRINDING NOISE FROM INSIDE THE ENGINE COMPARTMENT, THE ENGINE BEGAN TO SHAKE AND SPUTTER. THE CA...
Preview excerpt
MY 2001 VOLKSWAGEN PASSAT HAS HAD AN R5 RECALL FOR FUEL LINES, FUEL TANK, AND A HEAT SHIELD. THE HARD (LOW PRESSURE FUEL RETURN?) LINE, THE MIDDLE ONE OF THE MOUNTING BRACKET ATOP THE FIREWALL, HAS FAILED CATASTROPHICALLY. IT NOW SPRAYS GASOLINE DIRECTLY DOWN ONTO THE CATALYTIC C...
Preview excerpt
MY CAR IS A 2001 MODEL, AND I'D LIKE TO KNOW IF IT HAS TAKATA AIRBAGS IN IT, EVEN IF IT ISN'T COVERED BY THE RECALL. DEALER DOESN'T KNOW IF THE AIRBAGS ARE TAKATA OR NOT. CAN YOU GIVE ME THIS INFORMATION?? I HOPE SO, OTHERWISE I DON'T KNOW HOW TO FIND OUT. THANKS [XXX] *DL INF...
Preview excerpt
ABS CONTROL MODULE FAULT
AS MY SON GOT ON THE HIGHWAY THE TRANSMISSION FELT LIKE IT WAS SLIPPING AND JERKING TO THEN CATCH BACK UP TO THE ORIGINAL SPEED I WAS GOING. WHEN HE PUT HIS FOOT ON THE GAS PEDAL THE CAR WOULD STRUGGLE TO GO, 5 SECONDS LATER IT WOULD GET UP TO SPEED BUT THEN SLOW BACK DOWN. AT ...
Preview excerpt
TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE TRANSMISSION WOULD SLIP AND THEN THE VEHICLE STALLED. THE ENGINE CONTINUED TO RUN, BUT THE VEHICLE WOULD NOT MOVE. THE VEHICLE WAS TAKEN TO A DEALER AND IT WAS DETERMINED T...
Preview excerpt
Showing 10 recent complaints from 431 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2001 Volkswagen models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2001 Volkswagen Passat has 4 recalls recorded by NHTSA.
NHTSA has received 431 owner-reported complaints for the 2001 Volkswagen Passat.
NHTSA has not published a safety rating for the 2001 Volkswagen Passat.
The most commonly reported complaint categories for the 2001 Volkswagen Passat are engine and engine cooling (68 reports), electrical system (47 reports), service brakes, hydraulic (38 reports).
Yes. NHTSA has 4 recalls on record for the 2001 Volkswagen Passat. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.