2010 Volkswagen Passat Fuel System Problems

The contact owns a 2010 Volkswagen Passat. The contact stated while driving at various speeds, there was a strong fuel odor inside and outside the vehicle. The contact stated that the failure persisted while the vehicle was parked and turned off. The check engine warning light was illuminated. The contact stated that the strong fuel odor had caused her to have headaches while driving. The vehicle was taken to an independent mechanic, where it was diagnosed that the fuel pump module had failed, causing the fuel pump to leak. Additionally, the contact stated that the vehicle had failed to start and was undrivable. The dealer was notified of the failure and advised the contact to bring the vehicle to their location for the repairs. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline) had already been completed on the vehicle. The failure mileage was approximately 148,000.

The contact owns a 2010 Volkswagen Passat. The contact stated that while her son was driving at an undisclosed speed, the vehicle inadvertently lost motive power. The driver was able to coast to the shoulder of the roadway, where the vehicle was able to be restarted. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the thermostat. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 61,000.

I was in my car driving , as soon as I go for a turn my car stalled on me infront of everyone , almost causing a wreck.

TL* THE CONTACT'S DAUGHTER OWNS A 2010 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT HER DAUGHTER HAD HER FUEL PUMP REPLACED ON FIVE SEPARATE OCCASIONS. AFTER THE MOST RECENT FAILURE, THE CONTACT HAD THE VEHICLE TOWED TO SCHUMACHER VOLKSWAGEN OF WEST PALM BEACH (3001 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33409) WHERE THREE RECALL REPAIRS WERE PERFORMED ON THE VEHICLE; NHTSA CAMPAIGN NUMBERS: 15V483000 (AIR BAGS), 17V509000 (FUEL SYSTEM, GASOLINE), AND 18V148000 (AIR BAGS). DESPITE THE RECALL REPAIRS, THE CONTACT WAS INFORMED THAT THE FUEL PUMP WAS DEFECTIVE AND GIVEN AN ESTIMATE FOR THE REPAIR. THE CONTACT'S DAUGHTER THEN TOWED THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC INFORMED HER THAT AN UNKNOWN PART NEAR THE STEERING COLUMN FRACTURED AND THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. DUE TO THE DISCOVERY, THE CONTACT HAD THE VEHICLE TOWED BACKED TO THE DEALER AND WAS GIVEN AN ESTIMATE FOR THE REPAIR OF THE VEHICLE. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

AS I DRIVE THE CAR "HESITATES". ITS ALMOST AS IF IT ACCELERATES AND DECELERATE ON ITS OWN. AS I LOOK ONLINE I SEE THERE WAS A RECALL REGARDING THIS ISSUE AS ITS A FUEL PUMP BUT AS I CALL THE DEALERSHIP THEY STATE THERE IS NO RECALL ON MY SPECIFIC VEHICLE. *TR

TL* THE CONTACT OWNED A 2010 VOLKSWAGEN PASSAT. THE CONTACT STATED WHEN DRIVING AT APPROXIMATELY 25-30 MPH THE ENGINE STALLED. THE CONTACT STATED THAT THE FIRE EMITTED FROM UNDER THE HOOD AND WITHIN A MOMENT THE ENGINE WAS ON FIRE. THE QUINCY FIRE DEPARTMENT WAS PRESENT AND WAS ABLE TO EXTINGUISH THE FIRE. THE CONTACT STATED THAT THE FIRE DEPARTMENT ADVISED THAT THE FIRE STARTED IN THE FUEL LINE. THE VEHICLE WAS TOWED. THE CONTACT'S INSURANCE COMPANY DESTROYED THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 129,000.

02/03 CAR STALL DUE TO DEFECTIVE FUEL PUMP MODULE 02/04 CAR SENT TO DEALERSHIP TO PERFORM RECALL - DEALERSIP ADVISOR CONFIRM RECALL HAS BEEN DONE 02/05 CAR STALLS AGAIN - ADVISOR CONFIRM FUEL PUMP MODULE IS NEW AND HAS BEEN REPLACED - CAR SENT BACK TO DEALERSHIP UPON REQUEST OF ADVISOR FOR FURTHER INVESTIGATIONS 02/06 ADVISOR STATES THANK FUEL PUMP ASSEMBLY NEEDS TO BE CHANGED - COST FOR REPAIRS IS $1120 + TAX - REPAIR IS DECLINED - CAR IS PICKED UP AND BROUGHT BACK HOME 02/07 PURCHASE NEW THANK FUEL PUMP ASSEMBLY 02/13 NEW THANK FUEL PUMP ASSEMBLY DELIVERED TO MY HOME 02/14 CAR IS SENT TO REPAIR SHOP WHY GO TO THE DEALER FOR EVALUATION - NEW THANK FUEL PUMP ASSEMBLY IS INSTALLED - REPAIR SHOP CONFIRMS FUEL PUMP MODULE HAS NEVER BEEN REPLACED - DEALERSHIP PROVIDE APPARENTLY NEW FUEL PUMP MODULE TO REPAIR SHOP GO TO THE DEALER - REPAIR SHOP INSTALL NEW FUEL PUMP MODULE AS RECOMMENDED PER RECALL - CAR IS PICKED UP AT THE DEALERSHIP 02/24 CAR NOT ABLE TO START DUE TO DRAINED BATTERY, FAULTY FUEL PUMP MODULE 02/25 COMPLAIN IS SENT BY EMAIL TO DEALERSHIP SHOP FOREMAN FRANK MARCELLO - NO FOLLOW UP 03/01 CAR NOT STARTING DUE TO DRAINED BATTERY - CALL SHOP FOREMAN AND LEFT MESSAGE

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN PASSAT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME AS THE RECALL NOTICE WAS RECEIVED OVER A YEAR AGO. THE DEALER (EAST COAST VOLKSWAGEN, 8756-C US HIGHWAY 17 BYPASS SOUTH, MYRTLE BEACH, SC 29588) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS CONTACTED SEVERAL TIMES AND WAS UNABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN PASSAT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE DEALER (MCKINNEY VOLKSWAGEN, 855-402-5098) WAS CALLED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

FUEL PUMP CRACKS AND LEAKS FUEL. FUEL PUMP RESIDES UNDER REAR PASSENGER SEAT. FUEL PUMP CONTROL MODULE SITS ON TOP OF FUEL PUMP. FUEL PUMP CONTROL MODULE GETS REALLY HOT AND MAY IGNITE LEAKING FUEL???

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN PASSAT. WHILE DRIVING 70 MPH, THE VEHICLE LOST POWER. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO VOLKSWAGEN OF ALAMO HEIGHTS (LOCATED AT 1402 NE LOOP 410 EXPRESSWAY, SAN ANTONIO, TX 78209, (210) 828-1201) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 180378267. THE APPROXIMATE FAILURE MILEAGE WAS 109,982. *TT CONSUMER STATED FUEL PUMP MODULE WAS IN A RECALL AND REPAIRED.*JB

THERE IS A KNOWN ISSUE WITH THE FUEL PUMP CONTROL MODULE. VOLKSWAGEN HAS BEEN AWARE OF THIS SINCE 8.16.2017. ON CERTAIN VEHICLES, THERE COULD BE AN INTERRUPTION IN ELECTRICAL POWER TO THE FUEL PUMP CONTROL MODULE. THIS COULD RESULT IN THE FUEL PUMP RUNNING CONTINUOUSLY, RESULTING IN A DRAINED BATTERY AND/OR A NO START CONDITION, OR CAUSE A LOSS OF MOTIVE POWER WHILE THE VEHICLE IS IN MOTION, WHICH COULD INCREASE THE RISK OF A CRASH CAUSING INJURY AND/OR DAMAGE TO PROPERTY. THE SOLUTION IS TO REPLACE THE FUEL PUMP CONTROL MODULE, HOWEVER, AS OF TODAY, MY VEHICLE IS STILL NOT SHOWING AS ELIGIBLE FOR THIS REPAIR, DESPITE THE FACT THAT THIS HAS BEEN A KNOWN ISSUE FOR MORE THAN 8 MONTHS.

WHILE DRIVING THE VEHICLE NUMEROUS TIMES AT VARIOUS SPEEDS INCLUDING IDLING AT STOP LIGHTS/SIGNS, IT WOULD SPUTTER AS IF TO SHUT DOWN AND STALL. SOMETIMES, I COULD "GAS" IT SO IT DIDN'T STALL, SOMETIMES IT WOULD STALL. IT HAPPENED AT BUSY INTERSECTIONS OF A STOP LIGHT AND PROVED TO BE DANGEROUS WHEN STALLING TRYING TO ACCELERATE WHEN LIGHT TURNED GREEN. IT SPUTTERED NUMEROUS TIMES IN THIRD GEAR, 50ISH MPH, AS IF TO STALL AND WAS VERY UNERVING WORRIED IT DIDN'T STALL IN FLOWING TRAFFIC. IT FINALLY STOPPED RUNNING AND WAS TOWED TO VOLKSWAGON DEALERSHIP WHERE I HOPED THEY WOULD REPAIR RECALL, 20AE. INSTEAD, THEY DIAGNOSED OTHER ISSUES TOTALING THOUSANDS OF DOLLARS THAT I CAN'T AFFORD. I AM HOPING TO HAVE RECALL FIXED BEFORE OTHER DIAGNOSES AND SEE IF THAT WAS THE PROBLEM. THANK YOU

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 3 MPH, THE VEHICLE STALLED AND THE INSTRUMENTAL PANEL ILLUMINATED. THE VEHICLE WAS PUSHED INTO A PARKING LOT BUT DID NOT RESTART. THE VEHICLE WAS TOWED TO THE VOLKSWAGEN OF PANAMA CITY DEALER (850-763-5495, LOCATED AT 3605 E 15TH ST, PANAMA CITY, FL 32404) WHERE THE TECHNICIAN STATED THAT THE HIGH PRESSURE FUEL PUMP WAS FAULTY AND WAS NOT COVERED BY THE RECALL. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND WOULD LOOK INTO THE MATTER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS ABOUT 120,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION IN OCTOBER OF 2017. THE DEALER (AUTOBARN VOLKSWAGEN OF COUNTRYSIDE, 6161 JOLIET RD, COUNTRYSIDE, IL, 60525) WAS CONTACTED AT 708-354-6600 AND STATED THAT THE PARTS WERE UNAVAILABLE FOR THE REPAIR. THE MANUFACTURER CONFIRMED THAT THE PARTS WERE UNAVAILABLE FOR THE REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *LN WORK HAS BEEN COMPLETED, SEE INVOICE. UPDATED 8/22/18*JB

THERE IS A RECALL ON THE FUEL PUMP FOR VOLKWAGEN PASSAT AUGUST 30, 2017. MY FUEL PUMP IS NOT WORKING PROPERLY. I HAVE BEEN TRYING SINCE AUGUST TO GET IT REPLACE. I HAVE CALLED CORP SEVERAL TIMES BUT THEY "DO NOT HAVE A FIX FOR IT YET" MEANWHILE I AM TOLD BY THE LOCAL VOLKWAGEN REPAIR SHOP MY ISSUES WITH LOSING POWER DRIVING IS THE FUEL PUMP. I CAN HAVE IT FIX BUT I WILL NEED TO PAY FOR IT AND I AM TOLD IT IS $2000 AND THEN "TRY TO GET REIMBURSED FROM VOLKSWAGEN". PLEASE HELP!!!!

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN PASSAT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN PASSAT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE). THE CONTACT CALLED VOLKSWAGEN GALLERY AT 888-459-6014 (1200 PROVIDENCE HWY, NORWOOD, MA 02062) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

UPON ACCELERATION, MY PASSAT SPUTTERED LIKE IT WAS COUGHING, NOT GETTING ENOUGH GAS THROUGH THE SYSTEM. VERY CONCERNING TO ME, LUCKILY I WAS IN A SMALL TOWN ON A ROAD WITH NOT MUCH TRAFFIC. IT THEN WENT BACK TO NORMAL OPERATION, WITHIN A NUMBER OF SECONDS .

MY CAR STALLED AS I WAS STARTING TO ACCELERATE THROUGH A BUSY INTERSECTION ON THE WAY TO WORK AND CAUSED AN ONCOMING CAR TO LOCK UP HIS TIRES AND SWERVED TO AVOID HITTING ME. THE CAR WOULD RESTART BUT NOT RUN ENOUGH TO CLEAR INTERSECTION FOR 10-12 ATTEMPTS. AFTER CLEARING INTERSECTION I WAS ABLE TO PARK CAR AND LEAVE IT FOR REST OF DAY. WHEN RETURNING TO CAR IT STARTED AND RAN FINE ON THE WAY HOME FROM WORK. I CONTINUED TO DRIVE THE CAR FOR NEXT 2 DAYS WITH SAME FAILURES HAPPENING ONLY 1 TIME A DAY BUT NOT AT SAME TIME OR PLACE WITH NO WARNING OR CHECK ENGINE LIGHT. ON 3RD DAY A CHECK ENGINE LIGHT OCCURRED AND UPON READING WITH OBD II COMPUTER IS WAS P2293 FUEL PRESSURE REGULATOR 2 PERFORMANCE ERROR. I HAVE SINCE TAKEN THE VEHICLE TO THE VW SHOP AND THEY ARE STATING I HAVE A BAD ELECTRIC FUEL PUMP ISSUE IN THE TANK AND NEED TO REPLACE IT ALONG WITH THE CONTROL MODULE AT A COST OF $900. IN ADDITION THEY ARE SAYING MY REAR MAIN ENGINE SEAL NEEDS TO BE REPLACE AT A COST OF $1600 ALTHOUGH NOT RELATED TO STALLING ISSUE. THEY FUEL PUMP I HAVE FOUND VERY SIMILAR ISSUES DESCRIBED ON INTERNET WITH SIMILAR YEARS AND IT IS A SAFETY ISSUE. IT SHOULD BE A WARRANTY RECALL NOT A USER RESPONSIBLE ISSUE. I WORK FOR A LARGE GLOBAL AUTOMOTIVE SUPPLIER TO AND NO THAT THIS FAILURE NOT ACCEPTABLE FOR VW AND DEFINITELY SHOULD NOT BE FOR ITS CONSUMERS. I CALLED VW CUSTOMER CARE AND THEY SAID THEY WILL NOT DO ANYTHING FOR THE COST OF EITHER REPAIR SINCE IT IS OUT OF WARRANTY. THIS WILL LIKELY BE THE LAST VW I WILL EVERY PURCHASE.