There are 13 owner-reported air bags & restraints complaints for the 2012 Volvo S60in NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
The contact owns a 2012 Volvo S60. The contact stated that while driving approximately 10 MPH, the driver’s side rear door opened unintendedly without the driver touching the door handle. The contact pulled over to the side of the road and inspected the vehicle. Additionally, the contact stated that on several occasions when the seat belt tongue was inserted inside the buckle, the seat belt failed to latch properly. The contact stated that the latch plate latched securely after several attempts. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 150,000.
The drivers seat belt to lock in place or unlock gets stuck ! Makes it very difficult to ge try out of my vehicle daily. This is a major concern if i am ever in an emergency and cannot get out of my seat
I have a 2012 S60R. I just received the recall notice for the front seat belts last week. In September of 2021, the warning light on the dash board intermittently comes on with a warning sound stating that my rear seat belt is not in use. This happens while starting the car and driving. There are no passengers riding in the rear seats of my car when this happens. I have tried to fasten the rear seat belts, but they do not fasten. I can not have passengers in the car due to the malfunction of the rear seat belts which is a safety issue. My vehicle is available for inspection upon request.
I was on my was home from work and I Engine Started to malfunction In the middle of the street I got help to push out of the street waited a few minutes and it started back up thank God it got me home but now I’m still having problems
RECALL NOTICE ON 11/2019 TO REPLACE ALL DOORS DUE TO A SAFETY ISSUE (RECALL #: R89978: DOOR LATCHES). RECENTLY ON 12/1/2019, 12/23/2019 AND 1/5/2020 I NOTICED THAT MY REAR RIGHT DOOR SLIGHTLY OPENED WHILE CITY DRIVING IN SUBURBAN NEIGHBORHOOD (LOTS OF STOPS) AND THE DOOR SIGNAL DID NOT INDICATE. THEY DID NOT FULLY OPEN BUT THE LATCH SEEMS TO HAVE AN ISSUE. HAVE BEEN REACHING OUT TO SERVICE AND VOLVO DOES NOT HAVE THE PARTS NEEDED.
TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V378000 (SEAT BELTS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. NAPLETON'S MID RIVERS CHRYSLER DODGE JEEP RAM (44951 VETERANS MEMORIAL PKWY, SAINT PETERS, MO 63376 (636) 242-1471) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V378000 (SEAT BELTS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED TOM WOOD VOLVO (4620 E 96TH ST, INDIANAPOLIS, IN 46240; (317) 848-7447) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
CPSC: ON SEPTEMBER 8, 2018 AROUND 4:30PM ON A SATURDAY, I WAS RUNNING ERRANDS AND SUDDENLY MY CURTAIN AIRBAGS ON MY 2012 VOLVO DEPLOYED. THERE WAS A HIGH PITCH, LOUD SCREECHING NOISE, A LOUD POP AND ALL THIS DEBRIS SPRAYED ALL OVER ME AND THE INSIDE OF MY CAR AND THESE WHITE PLASTIC AIRBAGS (CURTAINS) BUSTED THROUGH THE ROOF OF MY CAR. *DT *JS
LIGHT ON THE INSTRUMENT PANEL INDICATES I NEED TO SERVICE MY AIRBAG IMMEDIATELY. THE AIRBAG HAS NEVER BEEN DEPLOYED. VOLVO SERVICE SAYS I NEED TO PAY TO REPLACE IT WHEN ITS NEVER BEEN USED.
TL* THE CONTACT OWNED A 2012 VOLVO S60. WHILE DRIVING APPROXIMATELY 40 MPH, ANOTHER VEHICLE CUT IN FRONT OF THE CONTACT. AS A RESULT, THE CONTACT CRASHED INTO A POLE ON THE SIDE OF THE ROAD. THE AIR BAGS DID NOT DEPLOY. THE LOCAL POLICE AND THE FIRE DEPARTMENT WERE AT THE SCENE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. PRIOR TO THE CRASH, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V075000 (ELECTRICAL SYSTEM) AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE AIR BAG SENSOR MAY NOT HAVE BEEN IMPACTED, HENCE NO DEPLOYMENT. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 29,000.
Our seat belts have been problematic because the passenger side is sticky and has to be moved around before it will disengage. When I took it to a dealer they said it was fine and just needed a little lubrication. Lubrication did not help the problem
ON JUNE 1ST ANOTHER CAR FAILED TO YIELD THE RIGHT OF WAY AND PULLED INTO THE PATH OF MY CAR WHILE I WAS GOING APPROX. 45MPH. I HIT THE BRAKES HARD AND TURNED TO THE LEFT TO TRY AND AVOID THE CAR AND COLLIDED WITH THE OTHER CAR. I ESTIMATE THE SPEED OF AT LEAST 35MPH AT IMPACT. THE RIGHT FRONT OF THE CAR TOOK MOST OF THE IMPACT. THE DRIVER'S SIDE AIRBAG DEPLOYED AND BURNED MY ARM. HOWEVER, DESPITE THE PASSENGER SIDE OF THE CAR TAKING THE BRUNT OF THE IMPACT, THE PASSENGER AIRBAG DID NOT DEPLOY. THE PASSENGER (MY FIANC) WAS DIAGNOSED WITH A CONCUSSION DUE TO THIS ACCIDENT. I BELIEVE THE CONCUSSION MAY HAVE BEEN AVOIDED HAD HER AIRBAG DEPLOYED. VOLVO INSPECTED THE VEHICLE AND CLAIMS FOR SOME REASON THE AIRBAG SHOULD NOT HAVE DEPLOYED IN THIS ACCIDENT. I SUSPECT THEY ARE COVERING UP A PRODUCT FAILURE. I HAVE PICTURES OF THE ACCIDENT AVAILABLE FOR YOUR REVIEW. *TR
ON AUGUST 24, 2013, I WAS INVOLVED IN A CAR ACCIDENT. A CAR STOPPED SHORT ON THE HIGHWAY. THE CAR IN FRONT OF ME HIT THAT CAR. I THEN HIT THE CAR IN FRONT OF ME. I HAD ONLY A FEW SECONDS TO REACT. ANOTHER CAR THEN RE-ENDED ME. MY AIRBAG NOR SEATBELT PRETENTIONERS DEPLOYED. I HAD DIFFICULTY TURNING THE CAR OFF. THE CAR WAS TOTALED. WITHIN A FEW WEEKS OF THE INCIDENT, I REPORTED THE MATTER TO VOLVO. THEY SENT AN INVESTIGATOR OUT. VOLVO CLAIMS THAT SENSORS WERE NOT ACTIVATED SINCE THE DAMAGE WAS ABOVE THEM, AND THERE WAS NOT ANY PROBLEM. HOWEVER, AT THE SPEED I HIT, THERE IS NO EXCUSE FOR WHY THE AIRBAGS SHOULD NOT HAVE DEPLOYED. EITHER THE CAR IS DESIGNED IMPROPERLY IN TERMS OF WHERE THE SENSORS ARE PLACED OR THERE IS A MANUFACTURING DEFECT. AS I UNDERSTAND IT, OTHER S60S (NOT MY VID#) HAVE BEEN RECALLED FOR AN ELECTRICAL PROBLEM THAT COULD CAUSE AIRBAGS NOT TO DEPLOY. *TR
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 26, 2026