2023 Volvo XC90 Electrical System Problems

On the morning of January 12, 2026, I attempted to unplug my 2023 Volvo XC90 Recharge (plug-in hybrid) from my home charging station in order to drive to an appointment. I had turned on the climate control remotely from the Volvo app while inside the house. When I went to unplug the vehicle, the charging connector was locked in the vehicle’s charging port and could not be removed. I contacted Volvo customer service, who instructed me to try several troubleshooting steps, including locking and unlocking the vehicle multiple times with the key fob and resetting the infotainment system. These steps did not resolve the issue. Because the charging plug remained locked, I was unable to use my vehicle and had to borrow a neighbor’s car, causing me to arrive late to a scheduled appointment. While away from home, I contacted my Volvo dealer, whose service representative advised me to use force to remove the plug, stating it would likely break the internal clip in the charging port. When I returned home several hours later and unlocked the vehicle, the charging plug released normally without any physical intervention. This suggests a software or electronic malfunction rather than a mechanical obstruction. The incident temporarily immobilized the vehicle and could pose a safety or reliability concern if it occurs in other situations. Furthermore, we have been experiencing intermittent issues with the infotainment system, including the backup cameras not coming on, random radio stations playing and complete blackout of the screen and/or flickering. The last software update was completed on Aug 15, 2025.

While the vehicle was parked, the trunk opened and the alarm sounded. Using the buttons on the trunk, I shut the trunk and locked the car. A few moments later, the trunk opened and the alarm sounded again. This continued for 40 minutes. Today, if I place a battery in the main black key fob, the trunk will open with the car running. I have an appointment next week at the dealer, however, most correspondence with Volvo has been by phone during the time it occurred. Both key fobs are not recognized by the vehicle unless specifically placed in a vertical direction in the cup holder. While driving, I receive messages that the key is not detected (although, I understand the car should NOT shut off while running after started and this has NOT occurred thankfully.). I will provide further documentation once available but want to report in case others experience this issue.

Odometer Fraud. The contact purchased a 2023 Volvo XC90 on [XXX]. The vehicle was purchased from Guaranteed Motor Cars in Palos Hills, IL. The contact discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 39,019. The contact took the vehicle to the dealer for repairs. When the instrument cluster was installed, it was discovered that the mileage was 111,914. The contact filed a complaint with the State Attorney General's Office. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2023 Volvo xc90 was recalled for issues with the backup camera. Software update was installed twice without success. Finally camera was replaced. No success either.

The vehicle is subject to NHTSA Recall 25V-282 for a rearview camera failure that increases the risk of a crash. First Repair Attempt (August 15, 2025): A Volvo dealership performed the prescribed software update but failed to fix the safety defect. The vehicle was returned to me in the same unsafe condition. Second Repair Attempt (August 20, 2025): The dealership identified the root cause as a failed front parking sensor. They refused to cover the repair, classifying it as "physical damage" despite providing no evidence of an external impact. Manufacturer Refusal (August 22, 2025): Volvo Car USA formally denied my request to have the safety recall completed, improperly claiming the issue was due to "outside influence." They have refused to honor the recall and their new vehicle warranty. The manufacturer and its dealer have failed to remedy this acknowledged safety defect, leaving me with an unsafe vehicle. The dealership returned the vehicle to my home against my wishes while I was at work.

The contact owns a 2023 Volvo XC90. The contact stated that while driving to the residence, the air bag warning light, malfunction light, driver’s side turn signal, parking light, and daytime running light illuminated. The contact stated that the instrument cluster went blank. The contact stated that for approximately five to ten minutes, the scene was visible. The contact called the independent mechanic regarding the missing air bag, but there was no resolution. The vehicle was taken to the local dealer, and the contact was informed that the dealer was unable to service the vehicle because of an open work order on the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was emailed, but there was no response. The failure mileage was approximately 39,397.

The Emergency Flashers on occasion and randomly malfunctions with the red triangle button flashing but the green arrows intermittently blink on the dash screen and the ticking sound also intermittently working. I have a video clip of the issue but can’t upload on this webpage.

Constant malfunction of Infortainment center. Turn indicators do not always work. Lately braking error messages. Volvo said it needs software updates. That has been done multiple times. This time it lasted several days and was completely black. You cannot see any information. No radio, no Bluetooth, no GPS, no data on car systems. Car has had problems for almost 2 years and excuse is always the software.