2019 Audi A6

My 2019 Audi A6 sedan displays warnings for the Start/Stop system malfunction indicated in Audi's document: "Emissions Service Action Code: 27BQ" [XXX] I'm still waiting to hear if this has been elevated to Recall status. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident Summary for NHTSA Complaint Component Involved: Electrical System: Alternator / Charging System Vehicle State: In motion (City street/Highway) Speed at Failure: Approximately [Insert Speed] MPH Narrative Description: The vehicle suffered a catastrophic electrical failure while in motion, resulting in an immediate and total engine stall in live traffic. This failure occurred without sufficient warning to safely maneuver the vehicle to the shoulder, creating an immediate safety hazard and risk of collision. This is a recurring safety defect: Repeat Failure: This is the second time this specific VIN has suffered a mid-traffic alternator failure. An Audi-certified replacement was installed by an authorized dealer (Audi Arlington) in 2022 following an identical incident. That replacement part has now failed. Failure of "Service Action" (27BQ): Despite an active Service Action for this component, the vehicle was not repaired during multiple prior service visits at authorized dealerships. The manufacturer failed to proactively address the defect, leading to this second roadside emergency. Cascading Electrical Instability: This VIN has a documented history of systemic electrical and safety system failures, including a gasket failure that compromised safety electronics and a total fuel system replacement due to sensor failure. The manufacturer (Audi) has classified this sudden loss of power in traffic as "non-critical," despite the clear risk of high-speed collision and physical injury. I am requesting a formal investigation into the recurring failure of the 27BQ component and the adequacy of the manufacturer's current service remedy.

My water pump failed at 49,000 miles. I have been advised by Audi that it is not covered by the extended warranty for some similar cars.

The rear electronic child safety lock on my 2019 Audi A6 does not function as intended. When activated, the lock does not reliably engage or disengage, allowing the rear door to be opened from the inside when it should be locked. We only began using the child safety lock after having a baby, at which time the malfunction was discovered. This creates a potential child safety risk, as the rear door may be opened from the inside when the child safety lock is expected to prevent this. The vehicle has not been modified, and the issue occurs under normal operating conditions. The dealer inspected the vehicle and advised that the repair would require replacement of the rear door latch/actuator but declined coverage due to the vehicle being out of warranty.

Yellow battery indicator light came on while driving car in 35 degree weather after a week of sitting in garage (holidays). I pulled over, read the manual and it said this could cause battery light to illuminate. I called the dealership service to ask them, they said possible reason. I decided to drive across city to dealership, 25 minutes away. On HOV lane, red warning lights flashing to pull over then 5 seconds later everything went black. No electrical, no engine, car died. VERY DANGEROUS!! Read later that this has been happening on Audi A6 (& other models) for 2+ years. Towed to dealership and they have had 1.5 weeks and still not fixed.

255/40/R20 Tires thread separated Tires were purchased 10/14/2021 At Audi of Fort Myers

Audi is aware of the starter-alternator issue which is documented in Audi's Emissions Service Action Code: 27BQ dated 4/30/24. Audi didn't communicate this to the effective users until October 2024. I personally experienced the defect in my starter-alternator on 10/21/24 and proceeded to have my car repaired.

The car was purchased in 2019, brand new from Audi dealership. Last service showed a serious issue: REPLACE WATER PUMP VACUUM LINES WITH SOLENOIDS AND VACUUM RESERVOIR. Dealership claims out of warranty and wants to charge $5000. VW settled class action lawsuit with consumers due to faulty water pump, and there is a Technical service bulletin dated 11/21/2023 that states the water pump leaks coolant and needs to be repaired. Consumer should have been made aware that vehicle was at risk of faulty water pump that could have been replaced at time of bulletin issue because it would have been under the 4 year mark.

Side marker light in headlight stopped working

After heavy down pour, the car was driven while the streets were still very wet. The car was driven through a 2 - 3 inch puddle of water that lasted less than 1 second, which caused a splash to the passenger side of the car, (the middle of the street did not have an accumulation of water) and within 30 secs caused the power steering warning light came on. This was not a flooded street, just the normal accumulation of water on the side of a residential curbed street. The steering immediately started to stiffen up and required increased effort to turn the steering wheel. The first warning lamp was yellow and stated that continued driving was still allowed, but after about 3 min the lamp turned red, and the message indicated "Steering malfunction, Do not drive vehicle". This occurred on a street where the speed limit was 30 mph, so safety at that time was not a big issue, but if this had happened on street where increased speed and more turning was required, safety could be a big issue if this happened suddenly. I was able to get the car to a nearby shop within 5 min, and the next day moved the car to the Audi West Houston. Audi has identified the power steering rack as faulty is in the process of replacing the electric power steering rack assembly. This car is a 2019 AUDI A6 with only 41k miles.

Electrical malfunction warning. Steering wheel got tight. Transmission failure warning. Then the the car began to stop. all types of various warnings were popping up on the heads up display. It is in the process of getting taken to the nearest dealer.

When backing up the car the cameras don't turn on and often times the collision sensors go off randomly. On the highway the emergency brakes go off randomly when a car passes by on the right-hand side of the vehicle.

Car flashed several warning signs, electrical system malfunction, steering malfunction, lane assist malfunction, and finally powertrain system malfunction where car was barely driveable at very slow speed, died and I luckily was able to pull over and coast into a parking spot.

Car slowed down and shut off in the middle of the road.

The car gave me electrical malfunction warning while driving on the highway, then all the screens turned black, and the car completely shut down while driving. The steering was still working, although heavier than usual, and the breaking also worked. The car slow down to a complete stop at the shoulder of the highway. This was very concerning, and thankfully happened close on exit with a shoulder at the side in which I was able to park the car.

Warning light came on for electrical malfunction and many other malfunction lights car then shut down.

The car couldn't start and stopped abruptly on the way through bunches of errors on the dashboard with check engine light and steering was firm and could not lock the Car or open the door Here are the warning list for 2019 Audi A6: Electrical system malfunction Electrical system malfunction Parking aid malfunction Transmission malfunction Rear spoiler malfunction Drive system: malfunction Traction control malfunction Tire pressure monitoring system malfunction Parking brake malfunction Automatic start/stop system malfunction Start/stop system malfunction

A yellow warning light went on stating"electrical system malfunction" start/stop is not working. Within 5 miles a red warning light went on that stated pull over when safe then within 100 yds multiple warnings went off and i lost power steering, power brakes etc. I was able to get stopped but the car would not start nor was I able to even put it in neutral to have it towed. I researched the issue and it seems to be a well known issue with the alternator. There has been several state lawsuits in regards to the issue. But no recalls or information sent to owners.

The car gave me a written error message on the dashboard that there was an electrical system malfunction. I thought to myself, "Gotta get that checked out. Let's see if it goes away." I drove a short distance home and parked. The next day I began to drive to work. I got the electrical system malfunction message again. I decided to pull into a parking lot and make an appointment to get it fixed by the dealer. Then, I began to drive back home (didn't want to risk driving to work). The car then gave me a new message that the electrical system was not working and to pull over safely. I drove for 30 or so more seconds as all the systems began to shut down. The car completely stopped within a minute or 2 of the error message, stranding me in the middle of the road. It was impossible to shift it into neutral to safely move it. If I had been driving on the highway, it would have been REALLY bad! There was almost no time to get the car to a safe spot and no chance to put it into neutral to move it. The car has since been diagnosed with a faulty generator that needs to be replaced.

Electrical fault dash warnings (steering, transmission, braking and many other things too numerous to mention came on while driving the car and it went into limp mode and forced the car to stop and would not restart. The car had to be towed to the dealership where they diagnosed the problem to be the "alternator" which is more accurately what is known as the "belt starter generator" BSG. The BSG runs the start stop feature of the car and charges the mild hybrid 48v battery system that runs many of the critical features of the vehicle. They do not have the part in stock and do not know how long it will take to get in. I understand that there is NOT an upgraded part available that will fix this issue, only the same part that they are continuing to put on all of the V6 engine models since 2019 to today. The A6,7 and A8 and Q5,7 and Q8 models in particular are being affected. This is an extremely dangerous problem that has not been remedied by Audi/VW to this point and the NHTSA should issue a recall.