2019 BMW 3 Series

The contact owns a 2019 BMW 330I. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle had not been diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while driving up to a red light, the vehicle became inoperable. The "Call Roadside Assistance", "Starter System Failure" and "Engine Could Not Start" messages were displayed. The vehicle was able to restart; however, upon arriving to the residence, the vehicle became inoperable. The failure mileage was 81,652.

Vehicle shudders under acceleration no warning lights or errors . Changed transfer case oil and same problem continues. No recall from manufacturer for issu

I am reporting a premature failure of two critical engine components: the Heat Management Module (Coolant Pump/Thermostat assembly) and the Oil Filter Housing. Despite the vehicle's low mileage (40,000 miles), the Heat Management Module began leaking coolant, posing a significant risk of engine overheating and sudden loss of power while driving. Simultaneously, the Oil Filter Housing has developed a leak, allowing oil to seep onto the engine block and potentially onto the serpentine belt. Both failures represent a safety hazard: Coolant Leak: Risk of thermal engine damage and being stranded in traffic due to overheating. Oil Leak: Risk of oil contacting hot exhaust components (fire hazard) or causing the serpentine belt to slip/fail, resulting in a sudden loss of power steering and charging systems. These components appear to have failed due to manufacturing or material defects rather than standard wear and tear for a vehicle of this age and mileage

Description of the Problem: •Component/system that failed: The engine starter, which is subject to an open recall issued September 23, 2025. The starter was not replaced during a service visit. The vehicle no longer exists due to the fire, but the VIN and service records are available for inspection. •Safety risk: The starter malfunction caused the vehicle to catch fire while parked, creating a serious safety risk to myself, my child, and others nearby. •Problem reproduction/confirmation: The fire and defect were confirmed by BMW’s inspection as originating from the starter irregularity tied to the recall. •Inspections: The vehicle was inspected by BMW North America’s engineering team after the fire, and insurance representatives confirmed the total loss. •Warning signs prior to failure: There were no warning lamps, messages, or symptoms indicating the starter defect before the fire. Additional context: The vehicle was serviced at an authorized BMW dealership on December 3, 2025. I was not informed of the recall, and the starter was not replaced. The vehicle caught fire on December 19, 2025, resulting in a total loss. While my insurance resolved the ACV, this incident was caused by BMW’s recall-related defect and procedural failure. I have escalated this matter to BMW North America and am requesting a resolution that restores me to a comparable position (replacement vehicle or financial support). Official confirmation: BMW North America confirmed in a confidential letter that the fire originated from the starter defect tied to the open recall. This letter is available for review upon request.

The contact owns a 2019 BMW 330i. The contact stated that while driving at 60 MPH on a three-lane highway, traveling in the exit lane, and using the hands-free calling system to speak with his wife, the vehicle crashed into an unknown metal object in the roadway, which tore the undercarriage. The driver-side air bag exploded without warning, resulting in him sustaining a concussion, and the vehicle came to a stop. The emergency call system failed to activate. His wife was able to contact 911, who was delayed in locating the incident site. The fire department, ambulance, and police department were on the scene. The contact was treated at the scene by the ambulance. The contact went to a walk-in clinic the next day, where medical attention was provided. There was no reported fire or police report filed due to the lack of identification of any damage. The vehicle was towed to the local dealer, who determined there was damage to the undercarriage. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had written a letter to send to the manufacturer. The failure mileage was approximately 51,443.

The contact owns a 2019 BMW 330I. The contact stated that upon starting the vehicle, the check engine warning light illuminated intermittently. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 91,000.

My parked vehicle, with the ignition off, caught fire while I was inside the gym. Within10-15 mins of entering the gym, the gym intercom announced that a car matching the description of my vehicle was on fire on the parking lot. When I went outside, firefighters were actively extinguishing the flams and cutting in the hood of the car. The vehicle was ultimately destroyed and considered a total loss. The vehicle has an active recall warning of a potential fire risk, even when the car is parked and turned off. The fire occurred without any action on my part, and I could have been seriously injured or killed. Also, others as well.

See attached document for complaint.

The contact owns a 2019 BMW 330I. The contact had received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact called the local dealer and the manufacturer and was advised that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

The contact owns a 2019 BMW 330I. The contact recently purchased the vehicle. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated while driving 60 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The message "Drivetrain Malfunction" was displayed. The contact stated that on a separate occasion, when the vehicle was started, the vehicle vibrated and jerked abnormally with several unknown warning lights illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure became progressively worse, and the vehicle was no longer being driven. The manufacturer was not made aware of the failure. The approximate failure mileage was 54,000.

The issue at hand is the oil filter housings on the B 58 and B 48 motors that BMW manufacturers. These oil filter housings are known to break after four years or 60,000 miles. can range from the engine overheating to oil leaks. The engine overheating can total the motor and the oil leaking can become a fire hazard. I was fortunate enough to be able to replace mine while BMW replaced another common failure point which is the heat management module. However, this is not as big as an issue as the oil filter, housing, because if the oil leaks, it can become again a fire hazard. There are several forum posts online about this issue I would like for NTHA please look at this thank you.

While traveling at approximately 20 mph, the vehicle experienced a sudden loud pop from the engine bay, immediately followed by multiple dashboard warning lights. The vehicle was safely brought to a stop, and AAA was contacted to arrange towing to the nearest available repair facility. A diagnostic inspection identified the failure of the crankshaft vibration damper. According to the repair facility, this component is essential to maintaining the structural integrity and operational balance of the engine. At the time of failure, the vehicle had approximately 37,000 miles on the odometer—well below the expected service life of such a critical part. Had this failure occurred at highway speeds, the resulting mechanical disruption could have led to a loss of engine function and increased the risk of a serious accident or death. The nature and mileage of this failure raise concerns about a potential defect or design flaw. I am requesting that the National Highway Traffic Safety Administration review this incident and consider whether similar cases have been reported. Failures of this type should be reviewed for broader safety implications.

Seat restraint malfunction that prevents the air bag from working properly. Dealer is aware of this problem but has not been able to correct it.

Vehicle is relatively new and kept in great shape. No damage nothing, one day the sensor for passenger airbag malfunction appears indicating that passenger airbag will not deploy in event of a crash. Dealership says it’s not covered under warranty and have to pay to replace out of pocket costing multiple thousands of dollars. Error seems manufacturer defect.

The contact owned a 2019 BMW 330I. The contact stated that while the vehicle was parked on the driveway, the vehicle caught fire. The contact called the fire department, and the fire was extinguished. The vehicle was towed to an impound lot and was declared a total loss by the contact's insurance provider. The contact stated that recently he had received a recall notice from the manufacturer for NHTSA Campaign Number: 25V636000 (Electrical System). The contact related the fire to the description of the recall of the fire risk when parked. The manufacturer was informed of the failure. The failure mileage was approximately 57,000.

I had a coolant leak so I took car in for repair. Mechanic says I have a crack in the oil filter housing. Mechanic told me to check with BMW to see if there was a recall because the oil filter housing was made of plastic and he claimed he heard of recalls for this particular problem. I called BMW and they stated there were no recalls currently on my vehicle, but the plastic housing in BMW's are known to be prone to failure and there were recalls, but not for my vehicle. The warning message initially stated low coolant. Now it states low oil level.

The contact owns a 2019 BMW 330I. The contact stated while driving at approximately 35 MPH, the brake pedal was depressed and there was an abnormal sound. The contact stated that while the brake pedal was depressed, the brakes failed to engage as designed. No warning light was illuminated; however, the "Electronic Stability Control System Malfunctioning" message was displayed on the instrument panel. The vehicle was taken to a dealer to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

BMW updates the car software by sending Remote Software Updates (RSU) using the the Over The Air (OTA) method. The updates include Driver Assistance updates and fixes. My car amongst many other BMW owners worldwide are reporting on the internet that the RSU process is not working and that the updates download OTA to the car but they do not do the final installation step. FYI OTA is currently the only method BMW uses to send updates to the vehicles . BMW replies to queries about the failure by directing owners to their dealers. The dealers than update the latest RSU at their facility . Cars in warranty are not charged by the dealers , but cars out of warranty are quoted in excess of $400 to install the updates. FYI updates are sent several times per years so those which require dealer service to install are faced with excessive cost for the updates. I currently refused to pay the dealer to install the latest RSU and my car is now at risk of not receiving the latest safety updates. Below is a snapshot of my car screen showing the update in limbo and requiring a dealer fix to perform "step 3" [XXX] Thank you , [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2019 BMW 330i experienced a serious malfunction. The car intermittently blacked out upon pressing the start engine button, and then it began accelerating on its own without pressing the accelerator pedal. This occurred multiple times, and the issue has not been resolved or explained by the service center, which has resulted in a significant safety concern. What component or system failed or malfunctioned, and is it available for inspection upon request? It appears that the issue might be related to the car's ignition and acceleration system. How was your safety or the safety of others put at risk? The car began accelerating on its own without pressing the accelerator pedal. This could be extremely dangerous if it happened while driving, as it could lead to loss of control and a potential accident. Fortunately, I was parked when this occurred. Has the problem been reproduced or confirmed by a dealer or independent service center? BMW Mountain View, CA service center were not able to reproduce it. They just changed the 12V battery but were not able to provide concrete reason or reproduce the issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by the service center but not by the manufacturer, police, insurance representatives, or others. Despite multiple requests from both myself and the dealership for further examination, BMW North America is not willing to involve their engineering team. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or messages prior to the issue. This situation could have been very serious if the unintended acceleration happened while driving. I was fortunately parked at the time and did not try to put the car in gear to avoid any potential accidents.

My 2019 BMW 330i has a recurring cooling system defect, including coolant leaks, heater inoperative, and risk of engine overheating. The defect began while the vehicle was under warranty and was repaired by BMW, but it recurred. BMW later instructed me not to drive the vehicle due to safety concerns, yet declined responsibility and transportation. The vehicle remains unsafe to operate.