There are 9 stored owner reports matching the brakes leading-label group for the 2004 Chevrolet Aveo in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 9 of 9 matching reports.
Open the full vehicle complaint log (all categories)OVERALL, AN EXCELLENT SMALL CAR! MY CAR HAS A BRAKE PROBLEM WHEN FIRST STARTED IN THE MORNING OCCASIONALLY. THERE ARE NO POWER BRAKES AND YOU HAVE TO PUT BOTH FEET ON THE PEDAL TO STOP THE CAR! KNOWING THIS(THE PEDAL IS SUPER HARD WHEN YOU PUT YOUR FOOT ON THE BRAKE TO PUT IT IN GEAR) I HAVE BEEN ABLE TO GIVE MYSELF PLENTY OF ROOM TO STOP AND THE CONDITION HAS NOT CAUSED AN ACCIDENT! THIS CONDITION USUALLY GOES AWAY AFTER A FEW MILES AND THE BRAKES RETURN TO NORMAL! BY THE TIME I CAN GET TO A GARAGE, EVERYTHING IS FINE AND IT DOESN'T DO IT CONSISTENTLY! WEATHER DOES NOT SEEM TO BE A FACTOR AND IT ONLY DOES IT ON STARTUP AFTER IT SITS OVERNIGHT! *TR
MY PASSENGER REAR SHOE BROKE IN HALF. IN THE FOLLOWING MONTHS, APPROXIMATELY ONCE EVERY WEEK TO TWO WEEKS MY SPRINGS AND SELF ADJUST FALL OFF. WHEN THE DRUM IS PULLED OFF THEY ARE EITHER COMPLETELY DETACHED OR HANGING BY A HAIR. THEY ARE NOT CONNECTED NOR ARE THEY DOING ANY GOOD FOR THE BRAKING SYSTEM. IN THE 7 MONTHS THAT I HAVE HAD THE CAR, I HAVE HAD IT WORKED ON 18 OR MORE TIMES ON THE EXACT SAME BRAKE. *TT
AIR BAG INDICATOR LIGHT CAME ON IN MID JANUARY 2008 AND HAS REMAINED ON. THE CAR JUST WENT OUT OF WARRANTY IN AUG 2007. SINCE I HAVE BEEN DEPLOYED FOR 15 MONTHS, I WAS NOT ABLE TO DISCOVER THIS PROBLEM WHILE IT WAS STILL UNDER STANDARD WARRANTY. AFTER CONTACTING CHEVROLET ABOUT SEVERAL ISSUES WITH THE BRAKES AND AIR BAG LIGHT, THEY INSTRUCTED ME TO GET IT DIAGNOSED. THE DIAGNOSIS REVEALED AN ECW FAILURE BUT NOTHING COULD BE FOUND WRONG WITH THE BRAKES. RECOMMENDATION FROM CHEVROLET SERVCO IS TO HAVE ECW FIXED. AFTER THE OCCURRENCE WITH THE BRAKES, MY HUSBAND BEGAN DRIVING THE VEHICLE. *TR
REAR BRAKES LOCKED ON APPLICATION, LUCKILY RIGHT IN MY DRIVEWAY. RELEASED BY ROCKING BACK AND FORTH, ONLY TO LOCK AGAIN....PULLED DRUMS MYSELF TO FIND ALL FOUR LININGS DELAMINATED FROM SHOES! PHONED GM CANADA AND GOT ABSOLUTELY NOWHERE UNTIL I MENTIONED THE FACT THAT I CAREFULLY TOOK PICTURES AND IT WAS LUCKY THAT NO ONE WAS KILLED! HAVING A SUDDEN CHANGE OF HEART, THEY PHONED MY DEALERSHIP AND ARRANGED FOR A FREE SET OF SHOES, WHICH I INSTALLED, SINCE I LIVE THREE HOURS FROM A DEALERSHIP. I'M SATISFIED WITH THE PROCESS, EXCEPT FOR THE FACT THAT THIS COULD CONCEIVABLY HAPPEN TO ANY AVEO AT ANY TIME! MINE HAD 70000 KMS. (45,000 MILES) ON IT AT THE TIME, 85% LININGS! HAVE YOURS CHECKED!! NO DUST IN THE DRUMS, EITHER. SCARY!! *TR
SES LIGHT COMES ON NOT DESCRIBING THE PROBLEM. THE FUEL SYSTEM IS MALFUNCTIONING, GAS ESCAPES SOMEWHERE, NOT GETTING THE ACTUAL GAS MILEAGE FOR THE VEHICLE. FILL UP ON WED OF ONE WEEK, USE ONLY 34 MILES, MUST FILL UP BY TUESDAY OF NEXT WEEK, THE BRAKES MAKE LOUD NOISE LIKE BRAKES ARE GOING OUT, MORE OF STEEL RUBBING, PULLS EXCESSIVELY TO THE RIGHT. TOOK VEHICLE IN FOR REPAIR ON THE BRAKES, WAS TOLD DUST WAS ON THE ROTORS, CLEANED OUT, PROBLEM STILL EXIST, NOW A BUCKLING IS FELT WHEN BRAKES ARE APPLIED. AS FOR THE GAS PROBLEM, CAR WAS LEFT OVERNIGHT, I TOLD THE DEALERSHIP, I DO NOT WANT MY CAR BACK UNTIL THEY FIND THE PROBLEM.. CHECK THE FUEL INJECTORS, THE GAS TANK, CHECK THE FUEL PUMP, CHECK ALL THE COMPONENTS OF THE GAS LINE.. I DO NOT SMELL GAS, THERE IS NO GAS ON THE GROUND. I HAVE A LOANER CAR FOR NOW. AS FOR THE SES LIGHT, I SHOULD DESCRIBE WHAT THE PROBLEM IS SO THAT THE DEALERSHIP SERVICE DEPT CAN GO STRAIGHT TO THE PROBLEM. THE CAR PULL EXCESSIVELY TO THE RIGHT AND LEFT, THIS TOO WILL BE CHECKED OUT BY THE DEALERSHIP. NO UPDATE RESOLUTION SO FAR. WILL KEEP YOU POSTED. THE CLOCK MALFUNCTIONED. A NEW CLOCK WAS REPLACED THE CAR WAS PURCHASED NEW, AUG 2003, WITH 6 MILES ON THE ODOMETER. TODAY, 2 YEARS, 2 MONTHS LATER, I HAVE 9766 MILES ON THE ODOMETER AND MY CAR HAS BEEN TO THE SERVICE DEPT 7 TIMES FOR MALFUNCTIONING PROBLEMS. *JB
DT: CONTACT OWNS A 2004 CHEVROLET AVEO . THE VEHICLE HAD A WHISTLING IN THE BRAKES. THEN THERE WAS NOISE IN THE IGNITION. THIS HAS BEEN GOING ON FOR AWHILE. EVERY TIME WHILE BACKING OUT FROM THE DRIVEWAY THERE WAS A SMALL NOISE. MANUFACTURER'S RECALL 04069. WAS ISSUED. AT THIS TIME CONSUMER'S VEHICLE WAS TAKEN TO THE DEALERSHIP FOR RECALL REPAIRS. THE NEXT PROBLEM CONCERNED TRANSMISSION FLUID BEING OVER FILLED WHICH COULD CAUSE A FIRE. THE TRANSMISSION AXLE WAS BEING CHECKED .*AK
BRAKE CALIPER BROKE WHILE VEHICLE WAS BEING DRIVEN. VEHICLE WAS TOWED, DUE TO SAFTEY REASONS, TO THE DEALERSHIP THAT SOLD THE CAR. CAR WAS BOUGHT 2 WEEKS PRIOR TO FAILURE AND HAD 12 MILES ON THE CAR WHEN PURCHASED. CAR NOW HAS JUST UNDER 500 MILES.*AK
CONTACT STATES; THE BRAKES SQUEAL AND WHEN STOPPING THE BRAKES DON'T WORK. WHEN TAKING FOOT OFF THE BRAKES THE CAR JUMPS, FEELS LIKE THE BRAKES LOCK. THE CAR JUMPS UP ND DOWN. HAD VEHICLE IN THE SHOP AT 4 DIFFERENT TIMES FOR BRAKES PROBLEMS. HOWEVER, PROBLEM RECURRED. *AK
BRAKE PEDAL TO CLOSE TO THE ACCELERATOR. RESULTING IN CONSUMER TO ACCELERATE WHILE ATTEMPTING TO STOP. *PH *MR
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.