Chevrolet · Corvette · 2004
4
Recalls
217
Complaints
-
Not Rated
The 2004 Chevrolet Corvette has 4 recalls and 217 owner-reported complaints on file with NHTSA. Most reported issue: fuel system, gasoline (91 reports).
Source: NHTSA Public Records · Updated Apr 22, 2026
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.
Remedy Status
DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT. IF THE TORQUE IS AT SPECIFICATION, THE DEALERS WILL REPLACE THE NUT/WASHER ASSEMBLY ONLY. THE RECALL WILL BEGIN ON AUGUST 25, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339 OR CHEVROLET AT 1-800-630-2438.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Remedy Status
ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
When I start my vehicle, the steering wheel locking system does not disengage and the steering wheel stays locked.
- Fuel tank leaks - gasoline puddles under car, heavy fumes - Fire / explosion hazard - Confirmed by local mechanic as existing problem in that year - Inspected and confirmed by selling dealer - trying to repair - No auto warning, smell of fumes and gas on garage floor day after delivery of car
Strong Fuel smell near the fuel filler when car is parked in the garage.
Fuel tank leaking/fumes. Appeara to be crossover tube connection connecting the 2 tanks.
The contact owns a 2004 Chevrolet Corvette. The contact stated while driving approximately 35 MPH, the odor of gasoline was detected by the contact and his wife. The contact stated no warning light was illuminated. The contact stated that the odor of gasoline was strongest in the cabin after refueling the vehicle to a full tank. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that a cross fill tube needed to be installed. The vehicle had been repaired. The contact stated that the gasoline odor was again detected while driving at various speeds. The contact researched online and related the failure to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The manufacturer had not been informed of the failure. The failure mileage was approximately 44,000.
In 2011 Chevrolet acknowledged an issue with the fuel system as the the attached letter states. I was not the owner of the vehicle in 2011 and since the issue was not elevated to an official recall it did not show up on the car fax report and I thus was unaware of this potential safety hazard. My car has now developed all the symptoms of the fuel tank leak with fumes in the car and gas dripping on the garage floor when parked. Although my car only has 30,000 miles the end date for GM to provide repair was August 11, 2011. The significant risk to passengers, the car, and my home when the car is parked in the attached garage is unacceptable as caused by a faulty engineered fuel modification in this model year. The fuel leak is both a safety and environmental risk and should warrant a recall and GM to mitigate the costs. Their liability for a faulty engineered system should not have a time limit.
Purchased the vehicle in 2015. That same purchased date I filled the vehicle with fuel. The following day my garage was totally covered with gas fumes. No tech could find the problem. On Feb 22 2023 while filling up, gas was pouring out the bottom left side . This is very dangerous. Come to find out that many others have had the same problem. There is a manufacturer defect of the gas tank housing tube . I cannot drive the vehicle because it’s to dangerous and to costly to repair.
The contact owns a 2004 Chevrolet Corvette. The contact stated while driving at slow speeds and approaching a stop, an abnormal odor of fuel was detected. The contact noticed there was fuel leaking in the garage. The vehicle was taken to the local dealer where it was diagnosed that the fuel tank and crossover tube cross connector needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no additional assistance was provided. The contact stated the failure was related to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 41,000. The contact stated that the vehicle was repaired and is seeking reimbursement from the manufacturer for the cost.
Drivers side fuel tank/system leak Leaking fuel in this area can/will result in a catastrophic fire which could lead to injury or death The problem just occurred but is a common problem for this generation Z06 Corvette The odd thing is no warning light, check engine light or messages displayed, just the smell of fuel and 18 inch puddle on the floor beneath the drivers side fuel tank. The fuel level according to the gauge is 1/2 tank.
The contact's friend owns a 2004 Chevrolet Corvette. The contact stated that while his friend was starting the vehicle, the steering wheel seized. The dealer was made aware of the failure but informed the contact that they were unable to assist due to the age of the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 04V060000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 75,000.
A month after I purchased the car with approximately 40k miles, I took the car in for an oil change at the dealership and was told there was a major leak in the left fuel tank and at the crossover tube. This leaking fuel is leaking onto the exhaust. It would cost at least $4,000 to repair. I can not afford this. It is too dangerous to drive. I have no other car. Supposedly, my vin number is 200 numbers away from being included in the recall for the same issue and that you have 43 pages of complaints about. Did I mention that the crossover tube is a backordered part because so many are needed because when you pull the current one out, it breaks and a new one is needed?
The vehicle has a fuel leak. I just purchased this vehicle a few weeks ago, it's 16 years old and has only 36,000 miles on it. It smelled terribly of fuel when I purchased it. I had the vehicle looked at and it has a fuel leak where the quick connectors connect to the fuel tanks. Anyhow, there's a special coverage adjustment which extended the warranty to 10 yrs/100,000 miles. I'm obviously outside of those parameters, but I feel that since the manufacturer admitted fault and stated that my particular VIN is affected, they should be held accountable for fixing a safety issue with my vehicle. How they got away with issuing a special coverage adjustment for such an issue rather than a simple recall is beyond me.
Have been in contact with 2 employees from GM, called and left voicemails and sent emails. No reply after it was requested that I take the Corvette to my local dealership for diagnosis. The ECL motor is not working property, causing the steering wheel to lock up and fuel supply to shut off. Sent attachment with diagnosis; however, no reply. GM indicated that this was previously fixed, but it obviously was not. My assertion is that there should not be a expiration date on safety recalls, and the ECL motor is not working properly creating a very dangerous situation. This happens every time that I drive the car. There have been several instances of me starting the car, pulling into traffic, and then the car shuts down. It has been very scary as I pull the key and wait 10 seconds to restart the car. Sometimes I have to do it twice. It is my contention that GM should be responsible for fixing this problem that was previously identified by GM as an issue/concern.
leaking left fuel tank
GAS SMELL COMING FROM REAR OF CAR AFTER DRIVING. NO VISIBLE LEAKS, BUT LEAKING FUEL VAPOR.
WHILE TRAVELING DOWN THE FREEWAY AT AROUND 80 MPH ON A STRAIGHT FLAT SURFACE, THE CORVETTE SHARPLY VEERED TO THE SIDE AS I HEARD A LOUD SCREECH FROM ONE OF THE BRAKES IT LASTED FOR ABOUT A SECOND. THE TURN WAS SO ABRUPT I THOUGHT I WAS GOING TO ROLL BUT AFTER FISHTAILING WAS ABLE TO GET THINGS GOING STRAIGHT. IMMEDIATELY A SERVICE ACTIVE HANDLING SYSTEM MESSAGE POPPED UP. HAPPENED ABOUT A WEEK LATER GOING ABOUT 60 MPH NOT QUITE AS ABRUPT. THIS CONDITION COULD HAVE LEAD TO A FATALITY.
GASOLINE LEAK FROM A CROSSOVER PIPE CONNECTION CONNECTING THE TWO GAS TANKS. DRIPPIG RAW FWEL ONTO A HOT EXHAUST SYSTEM AND TRANSMISSION. COMMOM PROBLEM ON TNIS YEAR AND MODEL. REPAIR WAS COVERED FOR FIRST 10 YEARS AND 100,000 MILES BY MANUFACTURER. STILL AND ISSUE WITH CARS NOT REPAIRED.
THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED WHILE DRIVING 35 MPH, THE CONTACT SMELLED AN ABNORMAL FUEL ODOR COMING FROM THE ENGINE COMPARTMENT. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL TANK CROSSOVER PIPE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE CONTACT RELATED THE ISSUE TO AN UNKNOWN MANUFACTURER’S RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING, THE SERVICE COLUMN LOCK INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO CASEY CHEVROLET (11700 JEFFERSON AVE, NEWPORT NEWS, VA 23606, (757) 320-1476), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.
PREPURCHASE RECALL SEARCH.
Showing 1–20 of 25 complaints
The 2004 Chevrolet Corvette has 4 recalls recorded by NHTSA.
NHTSA has received 217 owner-reported complaints for the 2004 Chevrolet Corvette.
NHTSA has not published a safety rating for the 2004 Chevrolet Corvette.
The most commonly reported complaint categories for the 2004 Chevrolet Corvette are fuel system, gasoline (91 reports), fuel/propulsion system (49 reports), steering (25 reports).
Yes. NHTSA has 4 recalls on record for the 2004 Chevrolet Corvette. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.