2005 Chevrolet Silverado Complaint Log

THE SPEEDOMETER ON MY 2005 CHEVY SILVERADO DOES NOT ACCURATELY DISPLAY THE SPEED OF THE VEHICLE. IT MAY READ ANYWHERE FROM 0 TO 120 MPH REGARDLESS OF THE ACTUAL SPEED OF THE VEHICLE. I FIRST BECAME AWARE OF THE INACCURATE READINGS WHILE DRIVING ON THE EXPRESSWAY AT AN INDICATED 72 MPH. I NOTICED THAT I WAS PASSING THE FEW OTHER VEHICLES ON THE ROAD AND BECAUSE OF THE SPEED AT WHICH I WAS DOING SO I CHECKED THE SPEED READING ON MY GPS AND FOUND THAT I WAS DOING ALMOST 100 MPH. THIS A SAFETY ISSUE. I AM ALSO AWARE OF SEVERAL OTHER GENERAL MOTORS TRUCKS OF THE SAME YEAR WITH THE SAME PROBLEM. AND ALSO THAT THE 2003 AND 2004 GM TRUCK HAVE THE SAME PROBLEM WITH THE IDENTICAL PART FOR WHICH GM HAS INSTITUTED A CUSTOMER SATISFACTION RECALL. *TR

THE FRONT RIGHT AIR BAG SENSOR IN MY 2005 CHEVY SILVERADO FAILED FOR NO APPARENT REASON CAUSING THE AIR BAG SYSTEM TO BE DE-ACTIVATED UNTIL THE SENSOR WAS REPLACED. THE VEHICLE IS 4 YEARS OLD AND HAS 35,000 MILES ON IT AND WAS NOT INVOLVED IN ANY ACCIDENTS TO MY KNOWLEDGE. THE ISSUE IS THAT WHEN A SENSOR FAILS, THE ENTIRE AIR BAG SYSTEM IS DE-ACTIVATED UNTIL REPAIRS ARE COMPLETED, CAUSING OWNERS TO DRIVE THE VEHICLE WITHOUT THE SAFETY FEATURE. GENERAL MOTORS MADE IT VERY CLEAR THAT THEY HAD NO INTENTION OF CORRECTING THE PROBLEM FOR FREE. REPLACEMENT OF THE SENSOR COST $275 FOR LABOR AND PARTS. A SERVICE REQUEST WAS FILED WITH GENERAL MOTORS ASKING FOR THEM TO PAY FOR THE REPAIR AND THE REQUEST WAS DENIED. I COULD AFFORD THE REPAIR, HOWEVER MANY PEOPLE MAY NOT BE ABLE TO AND WILL END DRIVING THEIR VEHICLE WITHOUT AN IMPORTANT SAFETY FEATURE. *TR

BAD SPEEDOMETER. STICKS. *TR

2005 CHEVY 2500 HD SPEEDOMETER FAILURE @44,000 MILE. THE SPEEDOMETER WENT TO 120 MPH AT 55 MPH, SITTING STILL IT WOULD STILL READ 60 MPH. DASH CLUSTER HAD TO BE REPLACED UNDER MY EXTENDED WARRANTY. *TR

ON TWO DIFFERENT OCCASIONS WITH MY 2005 CHEVROLET SILVERADO 2500 I EXPERIENCED POWER STEERING AND BRAKE LOSS AFTER STARTING THE ENGINE AND BEGINNING TO DRIVE.. STEERING WAS VERY HARD AND I HAD TO "STAND" ON THE BRAKE PEDAL TO STOP THE VEHICLE. AFTER A FEW MINUTES IT ALL BEGAN TO WORK AGAIN BUT I WAS WITHOUT POWER STEERING AND BRAKES FOR SEVERAL MINUTES. I TOOK IT TO MY DEALER AND THEY REPLACED THE BRAKE UNIT AND REPLACED A HOSE ON THE POWER STEERING PUMP. PARTS ARE PROBABLY NOT AVAILABLE AS I LEFT THEM AT THE DEALER. NOW I AM GETTING A SLIGHT SURGE WHEN BRAKES ARE APPLIED AND THIS IS ONE OF THE EVENTS THAT HAPPENED BEFORE THE FAILURE CAUSING ME TO FEAR THAT FAILURE MIGHT HAPPEN AGAIN. *TR

I WAS DRIVING ALONG WHEN THE CAB FILLED WITH SMOKE AND A BURNING PLASTIC SMELL. I SAW SMOKE COME FROM UNDER THE PASSENGER SIDE DASHBOARD. THE BLOWER MOTOR RESISTOR HARNESS HAD CAUGHT FIRE. I WAS ABLE TO PUT IT OUT WITH DAMAGE TO ONLY THE HARNESS AND RESISTOR. IT WAS REPLACED UNDER THE EXTENDED WARRANTY I HAD PURCHASED FROM GM. FAST FORWARD TO MAY 9, 2010 AND 50,000 MILES LATER, THE SAME THING HAPPENED AND GM CORPORATE TOLD ME THERE WAS NOTHING THEY COULD DO EVEN THOUGH THIS SAME MODEL VEHICLE HAS BEEN RECALLED IN CANADA FOR THE SAME PROBLEM. I WAS QUOTED $300.00 FOR THE REPAIR. ON MAY 10.2010, MY DEALER CALLED AND SAID HE RECEIVED AN E-MAIL FROM GM STATING THAT GM WAS IN THE PROCESS OF OFFERING A 10 YEAR 150,000 MILE WARRANTY ON THE BLOWER MOTOR AND HARNESS REPAIR. HAVE NOT RECEIVED ANY NOTICE FROM GM YET BUT DEALER SAID THEY WOULD FIX IT NO CHARGE.

2005 SILVERADO INSTRUMENT PANEL FAILS. THE FIRST REPLACEMENT WAS AT 23K MILES (MAR 07). THE ENGINE HOURS KEPT RESETTING. NOW MY VEHICLE HAS 43K MILES AND ALL GAUGES ARE FAULTY. THE GAS GAUGE GOES FROM FULL TO EMPTY AND BACK REGARDLESS OF THE AMOUNT OF GAS IN THE TANK. THE ENGINE HOUR KEEPS RESETTING BACK TO ZERO AND THE TEMP GAUGE MOVES FROM HOT TO COLD AND BACK. THE SAME THING IS HAPPENING ON OUR OFFICE VEHICLE. ACCORDING TO GM SPECIAL BULLETINS THIS IS COVERED FOR 03 AND 04 MODELS USING THE SAME IPC. WHY ISN'T THIS COVERED FOR 05 MODELS AS WELL? IF THERE IS AN ELECTRICAL PROBLEM SHORTING OUT THE IPC IT NEEDS TO BE FIXED BY GM AND NOT THE CONSUMER. THIS IS ONLY ONE OF MANY PROBLEMS I'VE HAD WITH THIS 2005 MODEL. *TR

2005 CHEVY SILVERADO SPEEDOMETER STOPPED WORKING. I WAS DRIVING AND THE SPEEDOMETER SHOWED 20MPH LESS THAN ACTUAL SPEED. WHEN I STOPPED IT SHOWED 120MPH. GM HAD RECALL FOR THIS FOR 2004 AND SOME 2005 MODELS, GM SAYS MY VIN NUMBER IS NOT COVERED. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING THE SPEEDOMETER BEGAN TO MALFUNCTION. THE VEHICLE REGISTERED A SPEED OF 120 MPH WHILE DRIVING 35 MPH; HOWEVER, IN A SCHOOL ZONE IT REGISTERED 80 MPH. THE SPEEDOMETER RECENTLY READ 0 MPH AND WOULD NOT INCREASE BEYOND THAT SPEED. THE DEALER STATED THAT THERE WAS NO RECALL OR WARRANTY AVAILABLE. THE DEALER ALSO STATED THAT THE REPAIR COST WOULD BE OVER $500 NOT INCLUDING THE LABOR COSTS. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 64,964 AND THE FAILURE MILEAGE WAS APPROXIMATELY 64,000.UPDATED 03/10/09.*LJ THE CONSUMER STATED THE SPEEDOMETER WAS STUCK AT 20 MPH. UPDATED 03/10/09.*JB

AT 57,055 MY 2005 CHEVY SILVERADO SPEEDOMETER QUIT WORKING AND SINCE I HAD RECEIVED A LETTER ABOUT A CLASS ACTION SUIT I REFERRED TO THIS LETTER HOWEVER IT ONLY COVERED THE 2003 AND 2004 MODELS. I FEEL THAT THE SPEEDOMETER IS AN ESSENTIAL PART IN THE SAFETY OF A VEHICLE AND THEREFORE AM PAYING MY $200 DEDUCTIBLE TO HAVE THE SPEEDOMETER FIXED UNDER MY EXTENDED WARRANTY PLAN, BUT I ALSO FEEL THAT GM IS AWARE OF THAT THIS PROBLEM EXTENDS BEYOND THE 2004 MODELS AND IS FAILING IN THEIR CUSTOMER SERVICE BY NOT EXTENDING THE WARRANTY TO COVER ALL AFFECTED VEHICLES. *TR

WHILE DRIVING DOWN THE INTERSTATE, MY TRUCK WOULD NOT GO INTO OVERDRIVE. A LITTLE FARTHER DOWN THE ROAD, WHILE SHIFTING INTO 3RD GEAR THE TRUCK WOULD SLIP INTO GEAR. EVENTUALLY 3RD, 4TH AND OD WENT OUT, THE ONLY GEARS THAT WORKED ARE 1ST AND 2ND. THE DEALER SAID IT WOULD COST OVER $2500 TO REBUILD BECAUSE OF THE DAMAGE OR REPLACEMENT WOULD COST $2800. THE TRUCK ONLY HAD 85000 MILES ON IT. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 80 MPH ON NORMAL ROAD CONDITIONS, THE SPEEDOMETER FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE DEALER WOULD REPAIR THE FAILURE FOR FREE; HOWEVER, THE VEHICLE WAS EXCLUDED FROM THE FREE REMEDY BECAUSE THE MILEAGE EXCEEDED THE 70,000 REQUIREMENT. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 102,400 AND CURRENT MILEAGE WAS 106,000. 4/01/09 *NJ UPDATED 04/06/09.*JB

2005 CHEVY SILVERADO 2500 HD. AT APPROX. 50,000 MILES, THE SPEEDOMETER STARTED ACTING UP. STUCK AND REGISTERED INCORRECT SPEED. I WAS ABLE TO "RESET" IT. NOW AT 78,000 MILES, THE SPEEDOMETER WILL NOT STAY CORRECT. *TR

SPEEDOMETER NOT WORKING PROPERLY. HAVE 65,000 MILES AND IT IS REGISTERING 120 MPH AND AT STOP SIGNS 60 MPH. DEALER SAID NOTICE WAS ONLY GOOD FOR 2003-2004 MODELS - DEALER SAID THE 2005 MODELS WERE FIXED--THAT IS NOT SO AND I'M PROOF. VERY DISAPPOINTED THAT CHEVROLET DOES NOT ACCEPT RESPONSIBLITY FOR THEIR MALFUNCTION. THIS COULD CREATE A SERIOUS CRASH AS WELL AS TICKETS. *TR

SPEEDOMETER FAILURE. WAS DRIVING 2005 CHEVROLET SILVERADO AND SPEEDOMETER STARTING GOING HIGHER UNTIL IT WAS SHOWING 120 - AT STOP SIGNS - SHOWING 60MPH - NOT WORKING CORRECT. VEHICLE HAS 65,000 MILES ON IT. *TR

SPEEDOMETER FAILURE. *TR

I HAVE A 2005 CHEVROLET SILVERADO HD2500 PICKUP WITH 32660 MILES ON IT. THE SPEEDOMETER SUDDENLY WENT WILD WHILE I WAS DRIVING. I HAD JUST EXITED A 75 MILE AN HOUR FREEWAY AND IMMEDIATELY HAD TO REDUCE TO 25 MILES AN HOUR. THE SPEEDOMETER REGISTERED ALL OVER THE CHART. I AM LEARNING IT IS THE INSTRUMENT CLUSTER AND GM HAS NOT ISSUED A RECALL. IT WILL COST $500 TO GET REPAIRED. I AM NOT DRIVING IT NOW. I HAVE ALSO LEARNED THIS IS A COMMON COMPLAINT. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE INSTRUMENT PANEL FAILED ALONG WITH THE HEAT IN THE VEHICLE. SHE CITED IT AS AN ELECTRICAL PROBLEM; NONE OF THE GAUGES WERE FUNCTIONING. SHE NOTICED THAT THE SPEEDOMETER SEEMED TO HAVE BEEN REPLACED PREVIOUSLY. SHE TOOK THE VEHICLE TO THE DEALER AND SHE WAS TOLD THAT THE ENTIRE INSTRUMENT PANEL NEEDED TO BE REPLACED. SHE CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY COULD NOT ASSIST HER. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT MILEAGE WAS 31,015. THE FAILURE MILEAGE WAS APPROXIMATELY 29,000. UPDATED 01/1410 *BF UPDATED 01/20/10.*JB

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT CAME TO A COMPLETE STOP. HOWEVER, THE SPEEDOMETER DISPLAYED 120 MPH AND REMAINED AT THIS SPEED ALL THE WAY TO HER RESIDENCE. WHEN THE CONTACT ARRIVED AT HOME, SHE TURNED OFF THE VEHICLE AND THE SPEEDOMETER GRADUALLY BEGAN DECREASING TO 0 MPH. THE DEALER STATED THAT THERE WERE NO RECALLS PERTAINING TO THIS FAILURE. THE VEHICLE WAS NOT INSPECTED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS 45,500 AND FAILURE MILEAGE WAS 45,450. UPDATED 12/30/08 *CN UPDATED 12/30/08. *JB

I PRESENTLY OWN A 2005 CHEVY SILVERADO CREW CAB, PRESENT MILEAGE IS 55,000. AS I WAS DRIVING, I NOTICED MY SPEEDOMETER NEEDLE SHOT UP TO 100 AND THEN PROCEEDED TO MOVE PAST 120 MPH LINE. IT IS CURRENTLY STUCK PAST THE 120MPH LIMIT. THIS IS A SAFETY ISSUE THAT'S NEEDS TO BE CORRECTED. THERE ARE OTHER CONSUMERS WITH THE SIMILAR PROBLEM AND YET THERE IS NO FACTORY RECALL ON THIS. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT NOTICED THAT THE SPEEDOMETER DISPLAYED 120 MPH. SINCE THIS FIRST INCIDENT, THE SPEEDOMETER REGISTERS THE VEHICLE'S SPEED AT 100 MPH, EVEN WHILE AT A COMPLETE STOP. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER AGREED AND STATED THAT THEY WERE NOT LIABLE FOR THE REPAIRS. THE VEHICLE HAS NOT BEEN REPAIRED AND THERE HAS BEEN NO DEFINITIVE DIAGNOSIS. THE CURRENT MILEAGE WAS 69,032 AND FAILURE MILEAGE WAS 68,500.

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE BRAKE PADS WERE EATING UP THE ROTOR ON HIS FRONT BRAKES. THE FAILURE CAUSES UNEVEN WEAR AND TEAR. HE HEARD SQUEALING NOISES AND THE PADS WERE NOT TOUCHING THE ROTOR TO STOP THE VEHICLE PROPERLY. THE CONTACT WILL TAKE THE VEHICLE TO THE DEALER SOON FOR A DIAGNOSTIC. THE FAILURE MILEAGE WAS 53,000.

TRANSMISSION FAILURE AT 53,000 MILES. VEHICLE ENGINE RUNS HIGH RPM BUT FAILS TO SHIFT, ESPECIALLY FROM 2ND TO 3RD GEAR. DEALER SAYS IT WILL HAVE TO BE REPLACED. THE PROBLEM IS DANGEROUS, ESPECIALLY IN CITY TRAFFIC WHERE TRYING TO NEGOTIATE AT TRAFFIC LIGHT IS A HIT OR MISS PROPOSITION. *TR

SPEEDOMETER ERRATTIC, STICKS AT 120MPH AT APPROXIMATELY 20 MPH, WILL NOT GO TO ZERO. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHEN THE VEHICLE WAS STARTED IN COLD TEMPERATURES, THE VEHICLE WOULD NOT WARM UP. THE ANTIFREEZE WAS LOW AND REFILLED BY THE CONTACT, BUT THE FAILURE CONTINUED. THE DEALER STATED THAT THE ANTIFREEZE WAS LEAKING DUE TO A CRACKED HEAD GASKET. THE REPAIR COST WAS ESTIMATED AT $4,200. THE MANUFACTURER COULD NOT ASSIST WITH REPAIRS. ALTHOUGH THERE WAS AN EXTENDED WARRANTY ON THE VEHICLE, SHE WAS UNABLE TO HAVE REPAIRS PERFORMED UNDER WARRANTY BECAUSE THE COMPANY WAS UNDER LIQUIDATION. THE WARRANTY COMPANY ALSO STATED THAT THEY WOULD NOT COVER THE REPAIRS SINCE THE FAILURES WERE RECURRING ISSUES. NO REPAIRS HAVE BEEN PERFORMED. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 90,000. UPDATED 5/7/09 *CN UPDATED 05/12/09.*JB

ANTILOCK BRAKE SYSTEM ENGAGES AT VEHICLE SPEEDS OF UNDER 10 MPH ON DRY CONDITIONS. I PREVIOUSLY OWNED A 2001 CHEVROLET TAHOE WITH THE SAME PROBLEM. ONE WOULD THINK THAT GM WOULD CORRECT THIS PROBLEM. VEHICLE HAS 13,000 MILES, BUT IS OVER 36 MO. OLD, SO IS NO LONGER COVERED UNDER WARRANTY. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING 75 MPH ON A CROSS COUNTRY TRIP, THE ABS INDICATOR ILLUMINATED. THE DEALER STATED THAT THE INBOARD RETENTION NUT THAT WAS USED TO MAINTAIN THE HUB BEARING ASSEMBLY LOOSENED, WHICH RESULTED IN THE ABS INDICATOR ILLUMINATING, NOISE, AND/OR WHEEL SEPARATION. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07E106000 (WHEELS:CAP/COVER/HUB). THE MANUFACTURER AND DEALER STATED THAT THE REPAIR WOULD COST $711. THE CONTACT WILL PAY FOR THE REPAIR, BUT FEELS THAT HIS VEHICLE SHOULD BE INCLUDED IN THE RECALL SINCE THE FAILURES ARE IDENTICAL. THE FAILURE MILEAGE WAS 61,764. UPDATED 12/11/08. *LJ UPDATED 12/11/08. *JB

I HAVE A 2005 CHEVY SILVERADO. LAST WINTER MY SPEEDOMETER BEGAN TO MALFUNCTION (STICK). NOW IT IS STUCK AT 120 MPH ALL THE TIME. THIS IS UNSAFE AND APPEARS TO BE A PROBLEM AMONG A LOT OF THE 05 SILVERADO'S. THERE IS A RECALL ON THE 03 MODEL AND 04 MODEL. I'VE DONE RESEARCH ONLINE AND THERE IS A LOT OF PEOPLE AT THE MOMENT WAITING ON A RECALL. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN LOSING POWER. A MECHANIC STATED THAT THE FUEL PUMP WAS POSSIBLY DEFECTIVE. THE DEALER AND THE MANUFACTURER HAVE NOT BEEN NOTIFIED. THE CAUSE OF THE FAILURE HAS NOT BEEN DEFINITIVELY DIAGNOSED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

I AM FILING THIS COMPLAINT FOR MY FATHER. HE HAVE A 2005 CHEVY SILVERADO. MY FATHER WAS DRIVING STRAIGHT DOWN A STREET AT ABOUT 35 MPH WHEN THE DRIVERS SIDE REAR AXLE AND TIRE CAME OFF THE VEHICLE. THE RESULT WAS BODY DAMAGE TO THE VEHICLE. LUCKILY NO BODILY INJURY OR PROPER DAMAGE OCCURRED OTHER THAN THAT DONE ON MY FATHER VEHICLE. AS IT TURNS OUT THE RETAINER BUTTON ON THE END OF THE AXLE SHAFT WAS BROKEN OFF ALLOWING THE AXLE TO COME OUT OF THE AXLE HOUSING. A POLICE REPORT WAS FILED AND AN INSURANCE CLAIM WAS MADE. THE VEHICLE HAS APPRX. 90,000 MILES AND WAS PURCHASED FROM A DEALER 1450 MILES PRIOR TO THE ACCIDENT. (APPROXIMATELY 2 MONTHS AFTER THE PURCHASE) THE VEHICLE IS CURRENTLY BEING REPAIRED BY THE DEALER DESANTIS CHEVY IN BROCKTON MA. THEY WILL NOT COVER THE COST OF THE DAMAGE. I AM THINKING THAT A COMPLAINT HAS BEEN FILED LIKE THIS BEFORE. REFERENCE. HTTP://WWW.ABOUTAUTOMOBILE.COM/TSB/2005/CHEVROLET/SILVERADO LINE NUMBER 151 151 TSB NO.:3364 NHTSA NO.:10014953 TSB DATE:N/A DATE ADDED TO FILE:MAY 12, 2005 FAILING COMPONENT: POWER TRAIN:AXLE ASSEMBLY SUMMARY: REAR AXLE RETAINER BUTTON BREAKAGE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE ANTI-LOCK BRAKING SYSTEM HAS FAILED FOR APPROXIMATELY TWO YEARS. OCCASIONALLY, WHEN THE CONTACT APPROACHED A STOP SIGN AND DEPRESSED THE BRAKE PEDAL, THE BRAKES WOULD NOT ENGAGE. THE DEALER STATED THAT THEY COULD REPAIR THE VEHICLE AT THE OWNERS EXPENSE. THE FAILURE MILEAGE WAS 22,000 AND THE CURRENT MILEAGE WAS 38,000.

SPEEDOMETER WILL ONLY GO UP AND NOT DOWN. IT STICKS UPON SHUTDOWN, AND WILL GO DOWN IF I RESTART THE VEHICLE 20 TIMES BEFORE I LEAVE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. WHILE ACCELERATING TO 10 MPH, THE CONTACT HEARD A LOUD VIBRATING NOISE. AFTER HAVING THE VEHICLE INSPECTED BY A REPAIR SHOP, HE WAS ADVISED THAT THE BRACKET IN THE TRANSFER CASE FAILED. AS A RESULT, THE SPRINGS IN THE FOUR WHEEL DRIVE TRANSFER CASE PUNCTURED A HOLE IN THE ALUMINUM HOUSING. THE DEALER STATED THAT THE CONTACT WOULD HAVE TO PAY $1,463 TO REPLACE THE TRANSFER CASE BECAUSE IT WAS OUT OF WARRANTY. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 82,000. UPDATED 12/11/08. *LJ UPDATED 12/11/08. *JB

2005 CHEVROLET K1500 PICKUP SPEEDOMETER READS BETWEEN 90-120MPH WHEN MOVING EVEN AT SLOW SPEEDS. AT A STOP IT READS 80MPH. 67,000 MILES WHILE LOOKING ONLINE IT LOOKS LIKE THERE ARE MANY OTHER 2003-2005 CHEVROLET OWNER WITH THIS SAME SAFETY ISSUE AND NO RECALL HAS BEEN MADE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE HEATER WOULD NOT ACTIVATE. THE DEALER STATED THAT NUMEROUS SILVERADOS WERE EXPERIENCING THE SAME FAILURES. THE CONTACT WAS INSTRUCTED TO REMOVE THE HEATING PANEL AND HE FOUND BURNED AND MELTED WIRES NEAR THE RESISTOR PLUG. THE DEALER ADVISED HIM TO PURCHASE THE REPAIR KIT OFFERED TO THOSE WHO WERE EXPERIENCING THE SAME FAILURES. THE REPAIRS WOULD COST OVER $114. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 43,000. UPDATED 11/07/08. *LJ UPDATED 11/07/08. *JB

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT ATTEMPTED TO START THE VEHICLE, BUT WAS UNSUCCESSFUL. THERE WERE NO WARNING INDICATORS ILLUMINATED AND NO POWER. SHE HAD THE VEHICLE TOWED TO THE DEALER AND THEY STATED THAT THE STARTER MOTOR FAILED. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. SHE NOTED THAT SHE PREVIOUSLY EXPERIENCED ELECTRICAL FAILURES WITH THE VEHICLE. THE STEREO SYSTEM HAD TO BE REPLACED THREE TIMES AS WELL AS WIRES WITHIN THE ENGINE AND HEATING SYSTEM. THE MANUFACTURER OFFERED HER NO ASSISTANCE. THE CURRENT MILEAGE WAS 65,873 AND FAILURE MILEAGE WAS 65,870.

I BEGAN TO HAVE TROUBLE WITH MY LIGHT BULBS. WHEN I TRIED TO CHANGE BULB I FOUND EVIDENCE OF POOR CONNECTION WITH THE PLASTIC OF THE BULB AND OF THE SOCKET SOMEWHAT BURNED. THE FILAMENTS OF THE BULBS WERE OK. A FRIEND OF MINE ADVISED ME TO COAT THE CONNECTION WITH SILICONE GREASE. RECENTLY A VIRGINIA STATE TROOPER STOPPED ME FOR TWO BULBS NOT FUNCTIONING. SAME PROBLEM. LUCKILY HE WAITED WHILE I REMOVED THE ASSEMBLY AND, YES, THE BULBS WERE FINE BUT NOT MAKING GOOD CONTACT. HE EXPLAINED THAT HE ALSO HAS A CHEVROLET TRUCK AND HAS THE SAME PROBLEM. A FORMER EMPLOYEE OF GM IN AIKEN GA TOLD ME THAT GM WAS SUPPOSED TO APPLY THIS GREASE TO ELECTRICAL CONTACTS BUT FAILED TO DO SO. THIS IS A SAFETY PROBLEM OR THE TROOPER WOULD NOT HAVE STOPPED ME! *TR

SPEEDOMETER FAILURE ON 2005 CHEVY SILVERADO SPEEDOMETER REGISTERS WRONG SPEED AT 60MPH READS 20MPH. *TR

MY SPEEDOMETER SOME TIMES READS 60 WHEN IM ONLY GOING 40 OR IT READS 120 AT IDLE AND SOME TIMES IT DOESNT READ AT ALL. IT HAPPENS AS MUCH AS TREE TO SIX DAYS OF WEEK. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT USED THE LIGHTER INSTALLED IN THE VEHICLE TO LIGHT A CIGARETTE. MINUTES LATER, HE NOTICED BLUE SMOKE EMANATING FROM THE INSTRUMENT CONTROL CLUSTER. UPON FURTHER INSPECTION, HE NOTICED THAT THE WIRING IN THE FUSE BOX MELTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE WIRING HARNESS AND FUSE BOX NEEDED TO BE REPLACED AT THE COST OF OVER $2,500. THE VEHICLE HAS NOT BEEN REPAIRED. HE IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 64,000.

2005 CHEVY SILVERADO 1500 EXPERIENCING ERRATIC FUEL GAUGE READINGS. VEHICLE HAS APPROX. 25K MILES AND HAS BEEN ACTING ERRATICALLY FOR ABOUT 2 WEEKS. FUEL GAUGE, FUEL LIGHT, AND TEXT DISPLAY SEEM TO BE IN SYNC, SO IT MAY BE THAT THE PROBLEM IS ORIGINATING FROM THE TANK OR THE COMPUTER. EITHER WAY, IT'S NEARLY IMPOSSIBLE TO TELL HOW MUCH FUEL I HAVE AT ANY GIVEN TIME...EVEN AFTER A FILL-UP. IN FACT, I JUST FILLED UP YESTERDAY AND THE GAUGE SHOWED EMPTY WITH THE FUEL LIGHT ON BY THE TIME I GOT HOME. ONCE IN THE DRIVEWAY, THE GAUGE ROSE TO HALF-FULL. THIS IS A SERIOUS PROBLEM. LIVING IN ALASKA, KNOWING THE VEHICLE'S FUEL STATUS IS CRITICAL, ESPECIALLY IN WINTER WHEN THE SAFETY OF A WARM VEHICLE MAY BE THE ONLY PROTECTION FROM THE ELEMENTS. *TR

RECEIVE AN INTERMITTENT "SERVICE BRAKE SYSTEM" WITH ABS & PARK BRAKE DASH LIGHT ILLUMINATED, AND THE AURAL ALARM SOUNDS. WHEN THIS HAPPENS THE ABS SYSTEM IS MADE INOPERABLE. THE ERROR DOES NOT CREATE A DTC CODE AND IS NOT STORED ON THE VEHICLE COMPUTER. AN INDEPENDENT SHOP AND THE LOCAL CHEVROLET DEALER COULD NOT IDENTIFY THE DEFECTIVE PART BE. EACH REPLACED THE SPEED SENSOR AND ABS COMPUTER (2 WEEKS APART). THE INDEPENDENT SHOP WAS ABLE TO IDENTIFY THE 200 MILLI-SECOND ELECTRICAL FAULT BUT COULD NOT FIND THE SOURCE. THE INDEPENDENT SHOP UPDATED THE COMPUTER FIRMWARE. SINCE THE ERROR COULD NOT BE RECORDED THE DEALER COULD NOT DO ANYTHING ELSE AND GAVE UP. THE PROBLEM CONTINUES. IF IT IS RAINING OR IT IS WARM SPRING DAY THE ERROR HAPPENS EVERY COUPLE OF MILES. IT APPEARS TO BE TIED TO THE THROTTLE AND DOES NOT REACT TO ANY OTHER VEHICLE CONDITION. IT REACTS AT CONSTANT THROTTLE WHEN THE FOOT IS REMOVED OR REDUCED PRESSURE ON THE THROTTLE PEDAL. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHEN THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE, THE SPEEDOMETER STOPPED WORKING. THE DEALER STATED THAT THE SPEEDOMETER MODULE NEEDED TO BE REPLACED. THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 37,000. UPDATED 01/06/09. *LJ UPDATED 01/06/09.*JB

SPEEDOMETER FAILURE ON 2005 CHEVROLET PICKUP WHICH COULD LEAD TO TICKET FOR SPEEDING OR EVENTUALLY ACCIDENT. DEALERSHIP SAID THIS WAS A COMMON OCCURRENCE ON THESE VEHICLES. FOUND OUT THAT THERE IS A RECALL FOR 2003 AND 2004 MODELS. THIS IS AN EXPENSIVE ITEM FOR ME TO PAY OUT OF MY POCKET. WHY IS THERE NOT A VEHICLE RECALL FOR 2005 MODELS WHEN THIS OCCURS ALL THE TIME? MY VEHICLE CURRENTLY HAS 69,000 MILES. *TR

SPEEDOMETER STOPPED WORKING AFTER IT RAN AT 120 MPH FOR AWHILE.*TR

2005 CHEVY 2500 DIESEL TRUCK HAS A FUEL INJECTOR PROBLEM CAUSED BY A SHORT IN THE ELECTRICAL WIRING DUE TO FRAYING OF THE WIRE BUNDLE. *NJ THE CONSUMER STATED THE VEHICLE DEVELOPED A LOUD KNOCK IN THE ENGINE DURING WARM-UP AND WHILE DRIVING. THE KNOCK WAS INTERMITTENT. THE CONSUMER STATED IF FRAYING ON THE OUTSIDE OF THE WIRE BUNDLE HARNESS WAS EVIDENT IT COULD BE RE-WRAPPED AND RE-ROUTED. IT CURRENTLY IS ATTACHED TO A VERY SHARP POST ON THE ENGINE MANIFOLD WITH A NYLON PULL TIE. AS THE MOTOR RUNS, THE WIRE RUBS AGAINST A SHARP EDGE OF THE POST AND FRAYS WHICH CAN CAUSE A SHORT AND MAKE THE FUEL INJECTOR MISFIRE. *JB

SHORTLY AFTER TRUCK PASSED 36,000, THE SPEEDOMETER STOPPED SHOWING THE CORRECT SPEED. IT WILL FLUCTUATE SHOWING BETWEEN 90 AND 120 MPH. WHEN SEARCHING FOR INFORMATION IN THE INTERNET, I FOUND THIS IS ACTUALLY A COMMON PROBLEM WITH THE SILVERADO TRUCKS. *TR

RE:CHEVY 2005 INSTRUMENT CLUSTER FAILURE ABOUT 6 MONTHS AGO, MY 2005 CHEVY SILVERADO 200 TRUCK STARTED EXPERIENCING THE SPEEDOMETER FAILURE ISSUE. AT THAT TIME I CALLED IN THE DEALERSHIP TOM JUMPER WHERE I PURCHASED THIS VEHICLE AND THEY TOLD ME THAT THEY KNOW ABOUT THIS ISSUE AND IT WOULD COST ABOUT $600 TO GET THIS FIXED. THEY ALSO INFORMED ME THAT THERE WAS A LITIGATION AGAINST GM FOR THE SPEEDOMETER ISSUE AND HAD ME CALL GM DIRECTLY TO GET THIS ISSUE FIXED TO AVOID OUT OF POCKET EXPENSES. THIS DEALERSHIP HAS CLOSED AND OUT OF BUSINESS. I DID CALL GM ACCORDING TO THEM THERE HAS BEEN LITIGATION GOING ON AND THEY DIRECTED TO ME TO THIS WEBSITE TO FIND OUT THE STATUS PERIODICALLY. THE WEBSITE NOW INFORMS THAT THERE WAS A SETTLEMENT NOTICE ISSUED AND FOR PEOPLE WHO HAVE PAID FOR THIS REPAIR WORK SHOULD CLAIM THEIR REIMBURSEMENTS. I REFUSE TO PAY OUT OF POCKET AND ASKED THEM TO GET MY VEHICLE FIXED AS ITS A MANUFACTURER PROBLEM ON SUPPLYING DEFECTIVE PARTS. THEY ARE ASKING ME TO GO TO CHEVY DEALER AND GET IT DIAGNOSED PAID BY ME AND THEN THEY WILL DETERMINE IF THEY I AM ELIGIBLE FOR THIS REPAIR WORK. I FOUND THIS ABSOLUTELY UNACCEPTABLE AND FRAUDULENT AS PER KEEPING THEIR CLIENT AS A HOSTAGE TO THEIR DEMANDS. I WANT SOME ACTION DONE TO HELP PROTECT CONSUMERS LIKE ME WHO ARE ESSENTIALLY PAYING FOR THE BAILOUT OF THESE COMPANIES IN THE CURRENT ECONOMIC CONDITION. PLEASE HELP IN THIS MATTER. THANKS . (WWW.SPEEDOMETERSETTLEMENT.COM). *TR

SPEEDOMETER STOPPED WORKING ON MY 2005 CHEVY SILVERADO. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THE WIRING HARNESS CONNECTED TO THE BLOWER MOTOR BECAME HOT AND BEGAN TO MELT. A PRIVATE MECHANIC REPAIRED THE RESISTOR IN OCTOBER 2008; HOWEVER, THE FAILURE OCCURRED AGAIN. IN JANUARY 2011, THE CONTACT HAD THE WIRING HARNESS AND THE RESISTOR QA REPLACED BY A PRIVATE MECHANIC SINCE HE SMELLED A BURNING ODOR AND HAD TO DISCONNECT THE WIRING HARNESS IN ORDER TO PROTECT IT FROM MELTING. THE DEALER NOR MANUFACTURER WERE NOTIFIED. THE CURRENT MILEAGE WAS 119,000. THE APPROXIMATE FAILURE WAS 80,000. THE VIN WAS UNAVAILABLE.