2020 Chevrolet Silverado Engine Problems

My lifter failed in my Chevy Silverado 1500 on the highway, causing severe shaking while driving and an array of dash lights. After taking it to a local. Chevy dealer, they confirmed a lifter collapse and possible damage to my cam shaft. I have been up to date on all oil changes with premium synthetic oil, and there were no prior dash lights indicating a problem.

Lifters are failing. Engine is making horrible engine noise. Mechanics said it was lifters.

Dfn failure Cylinder 6 140,000 MI oil changes done at 20% using nothing but mobile one full synthetic 0w 20

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated while driving at 35 MPH, the engine started knocking, and the sound grew louder while making a turn. The Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer, where one diagnostic trouble code was displayed, but the vehicle was not repaired. The vehicle was then taken to a second local dealer, who retrieved a code for fuel injector number eight and diagnosed that the engine needed to be replaced; however, the vehicle was not repaired. The vehicle was taken to a third dealership, Knapp Chevrolet, where it was diagnosed that the engine needed to be replaced. The vehicle remained unrepaired. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 94,000.

Engine light came on and off and June 10, 2026 The truck just stole and no power to go

Engine failure from bearings and lower rod from lifters. This is the second engine failure in vehicle for the same exact reason per dealership report. Entire engine replacement both times and all lights on dash were on.

The check engine light indicate P0016 crankshaft camshaft position. It has been diagnosed by a mechanic that the timing belt is stretched. Chevrolet has redesigned these parts due to the premature failure but has not issued a recall to install the redesigned parts.

My 2020 Chevy TrailBoss 6.2L V8 L87, same engine that has been recalled for 2021-2024 literally went dead in the middle of rush hour traffic. The engine has been deemed dead due to the exact current recall reasons. Seeing that was traffic was flowing at 45mph that was not a good scene as the vehicle " locked" itself into park originally so I was stuck in the middle of traffic. The vehicle has been confirmed seized uo by the Portsmouth NH Chevy dealer which is the Key Auto Group. Warranty adjusters representatives from a third party, not GM, will be assessing it this week. I purchased an after market warranty not by GM. I had no warning lights leading into the failure.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at 25 MPH, the vehicle suddenly made knocking sounds. The Check Engine warning light illuminated. Additionally, the vehicle experienced rough idling and a decrease in motive power. The vehicle was taken to an independent mechanic, who determined the lifters had collapsed and bent the push rod. The push rod was replaced, but the newly installed part instantly bent. The mechanic informed the contact that the cam needed to be replaced. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 107,800.

I am filing this complaint regarding a major engine failure in my 2020 Chevrolet Silverado 1500 equipped with the 5.3L V8 engine. At approximately 56,000 miles, my vehicle experienced a failed valve lifter, resulting in loud engine ticking, a check engine light, loss of power, and unsafe driving conditions. The vehicle was no longer operating properly and required immediate repair. Although the vehicle had been regularly maintained and had relatively low mileage for such a significant engine issue, I was informed that the failed lifter damaged the camshaft and related engine components, requiring extensive repairs. The total cost of the repair was $6,180, which I paid out of pocket. My Silverado was just outside Chevrolet's 5-year/60,000-mile powertrain warranty period by time, despite having only 56,000 miles. A major internal engine failure should not occur on a well-maintained vehicle with such low mileage. After researching this issue, I discovered that lifter failures involving the Active Fuel Management (AFM) and Dynamic Fuel Management (DFM) systems in GM's 5.3L engines have been widely reported by other Chevrolet Silverado owners. This indicates a potential design or manufacturing defect rather than normal wear and tear. I am requesting that General Motors provide reimbursement or goodwill assistance for all or a substantial portion of the $6,180 repair cost. I believe customers should not be responsible for paying thousands of dollars to repair a known issue on a low-mileage vehicle. I respectfully request that this matter be reviewed and resolved promptly.

I was driving on I-35 in Norman, Oklahoma, shortly after 7 am, when my 2020 Chevy Trail Boss with the 6.2 engine stopped running. I was in moderate traffic and shifted the gear shifter to neutral, and the motor would not restart, leaving me in traffic. I was able to slowly get on teh shoulder to avoid a collision, and the engine would not restart. I had teh vehicle towed to Ammco in Norman, Oklahoma, where it was determined that a catastrophic engine failure occurred. This is teh same problems that are associated with recalls on the 2021 and up 6.2 GM engine. luckly i was able to get to a safe place and avoid a collision.

Chevrolet dealership diagnosed my truck and said the coolant control valve would have to be replaced.

While returning from a camping trip my engine lost power. luckily I was close to an exit and managed to get it off the expressway and to a parking lot. I was able to leave the camper in the lot and have the truck towed to a dealer 30 miles away. I was informed by the dealer that the engine had sustained major berring failure. I was over 500 miles from home and I had 2 options, wait 2 weeks for a new engine to be installed or trade it in for a new truck. I opted for the trade in because I didn't want to wait 2 weeks. I figure I lost $7000 in trade in value and had to spend $2000 to have my new truck fitted for a 5th wheel hitch.

This was a 6.2L V8 that is actively under investigation and recall for model years 2021-2024. it is a part of the same GM generation of engines 4th Generation, GMT T1XX. I was not told about the active recall for other members of the generation by the dealership in which i purchased it at in august of 2025. I purchased this vehicle less than a year ago and the engine has now suffered a catastrophic failure consistent with known 6.2L issues.

The contact owns a 2020 Chevrolet Silverado. The contact stated that when her husband turned the vehicle on the vehicle stalled immediately. The vehicle was not able to restart. The vehicle was towed to a independent mechanic where it was diagnosed that the engine had locked up. The vehicle was not repaired. The vehicle then towed to a dealer where it was diagnosed that there was an engine, cam shaft, and barring failure related to Manufacture Recall Number : N252494000, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 50,000.

while driving pulling a trailer with my kid in the car engine began knocking and lost power. upon investigation it was a failed lifter causing bent pushrod

-My 2020 Trail-boss 6.2 Engine broke and stopped producing power and shut off, it is available for inspection and has been inspected by my local Chevy Dealer Tom Gibbs Chevrolet. -My son was crossing a railroad track and it shut off as he topped the tracks it shutoff at the tracks and he was able to coast down out of the way. If it shut off a second earlier he would have been stuck on the tracks and there is a list of what if's. My grandson in the car seat, my son gets out breaks his ankle and can't get my grandson out there is so many things that could have happened. -The dealer stated the 6.2 engine is known to have mechanical failures -The local dealer stated valve cover was removed and no movement in valve train needs new engine at a cost of $21,343.24 They realized that the original $250 rubber serpentine belt outlasted the engine with 123K miles on it -No warning lights, no rough running, no sounds just shut off no power.

* same part gone bad as other recalled vehicles. "Coolant control flow valve bad". Engine fan is staying on high blast, message displaying " engine power is reduced" truck will not drive at full power because the truck thinks its overheating because of bad part. If i remember correctly, it is code p1098. Bad part is intermittent. It Will happen randomly driving down the road. It comes and goes. I believe this is a safety factor . There is a special warranty or recall regarding this part with my year truck, but not my vin? Why not? Same part going bad with same codes and same problem ? Please consider looking into this concern and expanding the recall or concern for this reduced engine power safety concern. Thank you for looking into this.

September 2020 received new vehicle ( purchased platinum extended warranty at time of sale that expires 9/22/2027)-December 2022 heard loud ticking & misfires & check engine light on took to dealer who found #2 cylinder intake lifter collapsed at that time was under warranty (9924 miles) and dealer replaced not only damaged lifter but all lifters and guides (I have this repair invoice from 12/2022) On March 31 2026 (19,000 miles)ticking came back took silverado to dealer to be checked 4/3/26 they kept truck and had to take top of engine apart where they found that the #2 cylinder lifter has collapsed again the technician went ahead & replaced lifter before getting authorization from warranty company, GM or us to do repair dealer told us that they can put old damaged lifter back in truck & we can take truck back if we want- we are waiting for the inspector that warranty company wants to send to inspect the truck they still have truck 2 1/2 weeks later the warranty company wanted to see all receipts & log for all 7 oil changes which i gave to dealer 4/13/26 was passed to warranty company who accepted all & they want to send an independent inspector to see truck on 4/20/26 we are waiting to hear if he came This is a serious safety issue as this engine 6.2 (L87) Z71 has been prone to lifter failures since 2019, we only found this out now when the same lifter collapsed a second time & that this engine has been known to shut engine down while driving & severely damaging it & even possibly causing an accident If we get no satisfaction from dealer or warranty company as a next step we will be asking for a GM regional representative to come inspect the truck see the repeat lifter failure, open a case with a corporate representative & look into the Lemon Law as this is a recurring issue-- it also affects the value & resale value of our Silverado

My truck has been in the shop for two weeks. Blown up, oil everywhere. I was told to file a complaint because GM has issues a recall for these engines, but I am not in the years it has been issues for. I was told this case is open and could then cover my engine. EA25007 is the number I was given.