2008 Ford Edge Fuel System Problems

My vehicle 2008 Ford edge had a safety recall from 2012 and the gas tank that the previous owners never had taken care of it or resolved. I purchased a car in February. I filled the gas tank. I parked it in my condo and I used my secondary car to go to work that day. Well, the management called me and said that my gas tank exploded and that there was fuel all over the condo parking lot. Had the fire department come and secure the car they took care of the gasoline in the parking lot and then I had it towed to Miller Ford when we found out that there was a recall on that gas tank. This car has been at this dealership three times it’s going tomorrow. This will be the fourth time for the same issue. I feel that this car is not safe. I feel that because nobody addressed this safety recall since 2012 that everything was corroded. I almost got into three accidents because the car stalled on me on three different occasions.

Had 2008 Ford Edge Limited AWD looked at while servicing for oil etc. Fuel smell noted at rear of vehicle. When looked at noticed wet fuel tank. Fuel tank is still on vehicle. (Ford wants $4400 to replace it) Independent shop JP Automotive in North Haven CT and Bob Thomas Ford in Hamden CT confirm tank is leaking. Bob Thomas Ford says not part of Ford TSB #14S22 (NHTSA #10076517) or Ford TSB #14R02 (NHTSA #10076296) A fuel leak in the presence of an ignition source may result in a fire. Causing danger to myself, my passengers, and others on the road. No warning lamps etc. Just a fuel smell at the rear of the vehicle that started.

The contact owns a 2008 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle started to jerk, and the contact became aware of a burning odor. The contact pulled over off the roadway. The check engine warning light intermittently illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the water pump had failed. The water pump was replaced however, the failure recurred. The vehicle was taken back to the independent mechanic where it was diagnosed and determined that the brakes had failed and needed to be replaced; however, the failure recurred. The check engine warning light illuminated, and the low oil pressure warning light illuminated. The contact stated that after a week, the failure recurred, and the vehicle failed to shift into the intended gear. Additionally, the contact stated that the vehicle hesitated and stalled. The vehicle was towed to the independent mechanic where it was diagnosed that the engine failed and needed to be replaced. Additionally, the contact stated that she was informed by the dealer of the NHTSA Campaign Number 14V682000 (Fuel System, Gasoline). The vehicle was not repaired. The dealer nor the manufacturer were notified of the failure. The failure mileage was unavailable.

Safety Recall [XXX] My vehicle falls into this recall yet the dealership and ford is saying it dose not. The vehicle was built at the Oakville Assembly Plant during the time of recall specs. I believe June 2007. The vehicle is in Wisconsin which also falls into the recall specs. The fuel tank has the leak in the areas spoke of in the recall, Ford is not doing anything about it. We received a case number 6 months ago and never heard back from them. This is a serious issue. The dealership gave us a estimate of almost $4000. something we can not afford. Please help. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle has corrosion and is leaking gas. Recalls are shown for vehicle and supposedly fixed. Ford says they will not re open a recall and state recall is not for my car

Fuel neck rusted out under mount bracket causing fuel to drip on hot muffler. Fire hazard could cause a fire

The contact owns a 2008 Ford Edge. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V682000 (Fuel System, Gasoline) on November 4, 2021. However, the vehicle experienced a fuel leak. The contact stated that the dealer applied a corrosion preventative to the fuel tank instead of replacing the fuel tank as expected. The dealer was not notified of the failure. The manufacturer was made aware of the failure. The failure mileage was 150,000.

The contact owns a 2008 Ford Edge. The contact stated after refueling the vehicle, once he parked the vehicle in the garage, he smelled a strong odor of gasoline coming from the vehicle. The contact looked underneath the vehicle and became aware of a fuel leak. The vehicle was not diagnosed. The contact informed the dealer that the vehicle was experiencing the failure stated in NHTSA Campaign Number: 14V682000 (Fuel System, Gasoline). The contact was informed that the vehicle was inspected however, the vehicle had not experienced the failure at the time of inspection. The manufacturer was contacted, and a case was filed. The failure mileage was 213,000.

The contact owns a 2008 Ford Edge. The contact stated that fuel was leaking from the fuel tank. The check engine warning light was illuminated. The manufacturer was contacted and referred the contact to the NHTSA. The contact related the failure to NHTSA Campaign Number: 14V682000 (Fuel System, Gasoline) however, the VIN was not included. The failure mileage was approximately 176, 000.

IT WAS DISCOVERED THAT THERE ARE TOXIC FUMES AND FUEL LEAKAGE COMING FROM THE FUEL TANK AREA. MOST PREVALENT WHEN THE FUEL TANK IS FULL. NOTICED WHILE IN TRANSIT OR WHILE STATIONARY. DANGEROUS INHILATION TO PASSENGERS IN OR AROUND THE VEHICLE HAS CAUSED HEADACHES AND LABORED BREATHING. THIS ERROR WAS OCCURRING IN PREVIOUS YEAR MODELS AND OPENING THE EARLIER RECALL FOR THIS PROBLEM IS NECESSARY FOR SAFETY AND CUSTOMER SATISFACTION. DIRECT CONTACT WITH FORD MOTOR COMPANY HAS NOT PERFECTED A SOLUTION TO REMEDY THIS PROBLEM.

MY FUEL TANK LEAKS . IT ONLY LEAKS WHEN I FILL MY TANK WITH GAS. I HAVE TO IT AT HALF A TANK

I HAVE A 2008 FORD EDGE WITH A GAS TANK LEAK, THE GAS TANK NEED TO BE REPLACED DUE TO THE INSIDE BEING COMPLETELY RUSTED AND EROSION. THERE IS A RECALL 14V682000 - HOWEVER MY VEHICLE IS NOT A PART OF THIS RECALL ALTHOUGH IT WAS ORIGINALLY PURCHASED IN CONNECTICUT, IT WAS BUILT AT THE OAKVILLE ASSEMBLY PLANT. I WAS INFORMED BY FORD THAT IT MAY BE INCLUDED AT A LATER DATE. THAT IS NOT HELPING ME WHEN MY VEHICLE IS OUT OF SERVICE NOW AND HAS TO BE FIXED.

TL* THE CONTACT OWNS A 2008 FORD EDGE. THE VEHICLE WAS TAKEN TO COGGIN FORD JACKSONVILLE (9650 ATLANTIC BLVD, JACKSONVILLE, FL 32225 (904) 747-8996) FOR THE NHTSA CAMPAIGN NUMBER: 14V682000 (FUEL SYSTEM, GASOLINE). THE FUEL TANK WAS REPAIRED WITH A WAX SEAL. ONE MONTH LATER THE CONTACT NOTICED A LARGE FUEL LEAK FROM UNDER THE FUEL TANK. THE CONTACT CALLED THE DEALER AND GOT A RETURN APPOINTMENT. THE DEALER TRIED TO CHARGE THE CONTACT $1,600 FOR THE FUEL TANK EVEN AFTER THE INITIAL RECALL REPAIR WAS COVERED UNDER A 12 MONTH 12,000 MILE WARRANTY. THE DEALER REFERRED THE CONTACT BACK TO THE MANUFACTURER. THE CONTACT GOT A CASE FROM THE MANUFACTURER WHO STATED KNOWLEDGE ABOUT THE RECALL WARRANTY. THE MANAGER AT CUSTOMER RELATIONS AT THE MANUFACTURER STATED THERE WAS NOTHING THEY COULD DO ABOUT THE ISSUE AND HUNG UP ON THE CONTACT. THE RESULT WAS THAT THE VEHICLE HAD BEEN AT THE DEALER FOR TWO WEEKS AND WAS STILL UNREPAIRED. THE CONTACT JUST SPOKE TO THE DEALER TODAY AND WAS TOLD THAT THERE WAS NO REPLACEMENT FUEL TANK FOR THE REPAIRS AND TO COME TOW HIS VEHICLE AWAY AND FIX IT HIMSELF WITH A USED PART.

I DID NOT OWN THIS VEHICLE WHEN THE RECALL WAS PRODUCED I HAVE OWN THIS CAR FOR ABOUT 2 YEARS WITH NO PROBLEM UNTIL ABOUT 2 WEEKS AGO I DISCOVERED THAT THERE IS GAS LEAKING FROM THE BRACKET OF THE GAS TANK. ONCE IN PARK YOU CAN EITHER SMELL A STRONG ODOR OF GAS AND YOU CAN SEE WHERE THE THE GAS HAS BEEN LEAKING ONTO THE GROUND

THE GAS TANK IS SLOW LEAK HAS BECOME INCREASINGLY DANGEROUS. ALSO THE SLOW HAS INCREASED

FUEL IS LEAKING, 1 BELIEVE FROM THE FUEL TANK. THE VEHICLE WAS IN PARK, BUT LEFT ON FOR ABOUT 30 MINUTES. WHEN I RETURNED AND REVERSED OUT THE PARKING SPOT I NOTICED A PUDDLE AT THE BACK END OF THE PARKING SPOT. I SMELLED THE PUDDLE AND IT WAS FUEL.

I WAS IN MOTION HEADING TO WORK, AS I WAS APPROACHING A SIGNAL LIGHT , AND TAPPED THE BRAKES, I STARTED TO SMELL A RUBBER GAS LEAK SMELL. THIS IS HAS BEEN OCCURING FOR THE LAST SIX MONTHS IVE HAD THE BRAKES CHANGE. STILL THE SMELL OF BURNT TAR OR GAS FUMES IS LOUD WHENEVER THE BRAKES, A/C, OR HEAT IS ON.

REC'D INITIAL SAFETY RECALL (14S22) LETTER DEC. 2014 & 2ND NOTICE APRIL 2016 FOR THE VEHICLE TO BE SERVICED BY MY AUTHORIZED DEALER, RAMSEY FORD. MAY 16TH RAMSEY'S PPWORK INDICATES THE A SEALANT WAS APPLIED. MY VEHICLE FAILED INSPECTION THIS APRIL BECAUSE THE GAS TANK WAS CORRODED AND LEAKING GAS! I CALLED FORD & SPOKE TO THEIR CUST. SER. REP, WHO REFUSED TO ACCEPT THAT THIS TANK WAS NOT REPAIRED PROPERLY & THAT THEY SHOULD REPLACE IT AT NO COST. THEY REFUSED TO ACCEPT THE RESPONSIBILITY. I HAVE PHOTOS OF THE TANK, BUT THEY ARE TOO LARGE TO INCLUDE WITH THIS FORM!

TAKATA RECALL 16S26/ NHTSA RECALL 16V-384. MY CAR WAS SOLD TO ME A VEHICLE EXCHANGE IN PHX AND NOW I HAVE ALL SORT OF PROBLEMS WITH THE FUEL TANK, TIMER, IT LEAKS COOLANT AND ALSO THE DOME LIGHTS WON'T GO OFF . I NEED TO GET THIS FIXED ASAP. CONTACT ME AT [XXX], MY NAME IS [XXX]. MY CAR ALSO OVERHEATS AND THE AIR CONDITIONING ONLY BLOWS OUT REALLY HARD ON THE PASSENGER SIDE. PLEASE HELP ME I HAVE TWIN AND MY WIFE AND I NEED A RELIABLE CAR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2008 FORD EDGE. AFTER THE FUEL TANK WAS REPLACED PER NHTSA CAMPAIGN NUMBER: 14V682000 (FUEL SYSTEM, GASOLINE), THE FUEL GAUGE DID NOT REGISTER THE CORRECT AMOUNT OF FUEL IN THE VEHICLE. THE VEHICLE WAS RETURNED TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SENDING UNIT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS RETURNED TO THE DEALER APPROXIMATELY SIX TIMES FOR THE SAME FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 178,000.