2016 Ford Edge Complaint Log

The contact owns a 2016 Ford Edge. The contact stated while driving approximately 10 MPH, the vehicle lost automotive power. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed with coolant intrusion into the engine, and the engine needed to be replaced. The contact researched online and was made aware of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 51,000.

The contact owns a 2016 Ford Edge. The contact stated that upon starting the vehicle, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed the vehicle and determined that there was coolant intrusion into the engine block. The mechanic referred the contact to a dealer for repairs. The vehicle was taken to a local dealer, where it was confirmed that the engine needed to replaced due to coolant intrusion. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was approximately 60,000.

The contact owns a 2016 Ford Edge. The contact stated while driving 35 MPH, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, and the contact was informed that the failure might be related to a head gasket leak. The vehicle was not repaired. The vehicle was driven back to the residence. The vehicle was then towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced due to coolant intrusion. The dealer informed the contact that the manufacturer had denied coverage of the repair due to the age of the vehicle. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, and a case was filed. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was 50,148.

The contact owns a 2016 Ford Edge. The contact received notifications of NHTSA Campaign Numbers: 25V544000 (Service Brakes, Hydraulic) and 25V572000 (Back Over Prevention); however, parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was shifted into reverse(R), the rear-view camera intermittently displayed a blank or distorted image. The dealer was contacted but offered no assistance. The manufacturer was made aware of the failure. The failure mileage was unknown.

The contact owns a 2016 Ford Edge. The contact stated that while reversing out of a driveway at 5 MPH, the brake lines ruptured. There were no warning lights illuminated. The vehicle was taken to an independent mechanic for the rear brake hose replacement. The local dealer was contacted regarding a refund, which was declined due to the recall remedy not being available. The vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic). The manufacturer was not contacted. The failure mileage was approximately 91,000.

The contact owns a 2016 Ford Edge. The contact stated while driving 20 MPH, the check engine warning light illuminated. A local dealer was contacted. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into cylinder #2. The contact was informed that the engine block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The manufacturer declined to cover the cost of the repair. The approximate mileage was 52,000.

The contact owns a 2016 Ford Edge. The vehicle was taken for a routine oil change and the mechanic stated that the water pump was leaking. After further inspection, it was determined that coolant was leaking into the engine. The vehicle was not repaired. The contact stated that coolant was added to the reservoir twice within 3,000 miles. The manufacturer was not informed of the failure. The failure mileage was approximately 85,400.

A recall was performed on 01-17-23 at roughly 54,000miles by Krause Ford Woodstock, GA – Brake lines were replaced. The passenger rear rubber hose has already failed where the hose is crimped at the fitting by the steel hose that comes from the master cylinder. Driver almost crashed due to not being able to stop in a normal distance due to the pedal going to the floor and the brake system failing due to no fluid pressure to the brakes. This was yesterday around [XXX] ). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Ford Edge. The contact stated that while driving 70 MPH, the vehicle vibrated abnormally with the check engine warning light illuminated. The contact stated that on a separate occasion, while driving 50 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light was illuminated. In addition, the contact stated there was an abnormal sound coming from the engine. The contact stated that two weeks later, while starting the vehicle, there was white smoke coming from the exhaust, with an abnormally sweet odor coming from the exhaust. The vehicle was not diagnosed or repaired. Most recently, the contact stated that while driving 50 MPH, the vehicle jerked and stalled. The contact was able to coast to the side of the road. The vehicle restarted, and the contact was able to drive the vehicle to the residence. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into cylinder #1, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The vehicle was taken to a local independent mechanic, where it was confirmed that the engine needed to be replaced due to coolant intrusion. The vehicle was not repaired due to the cost. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The contact stated that the failure persisted. The vehicle remained at the residence and had not been driven since the latest failure. The failure mileage was approximately 127,000.

The contact owns a 2016 Ford Edge. The contact stated that the vehicle was violently shaking while cold starting the engine. The contact stated that the failure persisted, with the check engine warning light illuminated. The vehicle was taken to the local dealer where a mechanic discovered coolant intrusion in cylinder #3. Upon investigation, the contact linked the failure to Technical Service Bulletin: 22-2229. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 68,000.

The contact owns a 2016 Ford Edge. The contact stated while his wife was driving 35 MPH, the check engine warning light was illuminated. Upon inspecting the vehicle, the contact noticed that the coolant reservoir was empty. The vehicle was taken to dealer, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and offered to provide a refund after the contact had paid for the repair. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 90,000.

This has happened 2x where I am driving and there is loud noises coming from the fuel tank area and the car stalls. I am able to get it off the road. I turn the car off and it doesn't immediately restart. When I try and push in the fuel tank there is a lot of air that comes out.

This issue is one that was made a recall already as of recent, I had gotten my brake lines flushed and refilled and filled to correct amount and yet soon after or not to too long after I had the issue with breaking, I thought it was my brake pads but it indeed was not when I got home and the engine cooled down I checked the brake fluid reservoir and it had been almost empty, I added more and filled it again and since then it hasn’t been a problem again, but when it was a problem, I was going highway speeds when I then felt the car was off on the braking I was actually concerned if I was going to be able to stop in time especially when i was hitting the exit ramp. It no longer has been an issue since I refilled the reservoir but i don’t know if it’ll happen again or not and when and where I’ll be next time it happens. Since I now know it’s a recall and it wasn’t just a one off with just my car I am now reporting this.

The contact owns a 2016 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that there was coolant intrusion into the cylinders, resulting in engine damage. The contact was informed that the engine needed to be replaced. The vehicle was repaired. After investigating the failure, the contact related the failure to the Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.

The contact owns a 2016 Ford Edge. The contact had received notification of NHTSA Campaign Number: 24V031000 (Structure). However, the part to do the recall repair was not yet available. The contact stated that when the vehicle was purchased, the windshield was cracked. The contact bought the vehicle and, after a while, contacted Safelite to replace the windshield. The Safelite employee removed the interior and exterior brackets on the windshield and placed a black tarp on the top part of the windshield. Most recently, the contact stated that after a rainstorm, water leaked inside the vehicle from the A-pillar. The vehicle was not repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 162,000.

The contact owns a 2016 Ford Edge. The contact stated that while driving approximately 45 MPH, the contact depressed the brake pedal, and the brake pedal felt spongy and depressed to the floorboard. There was no warning light illuminated. The contact was able to stop and exit the vehicle. The contact then observed a puddle of fluid by the passenger’s side rear wheel well. The vehicle was towed to a local dealer, where the vehicle was diagnosed and determined that the passenger’s side rear flexible brake line had ruptured. The dealer replaced the brake line, and the vehicle was repaired. The manufacturer was not informed of the failure. The contact recently received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); and related the failure to the recall. The failure mileage was 117,490.

Wife picking up grandkids from school called to say brake pedal had been going to the floor. Told her not to move it. As I pulled up behind the car noticed the R/R ground was wet. Master cylinder was low on fluid. Had towed to private shop. Diagnosed as R/R brake hose leaking. The hose wasn't damaged but was leaking where the fittings are attached to the hose. Shop said it's a manufacture's defect.

Rear passenger side brake line failure, leaked out brake fluid and brake pedal went to the floor during commute home. No accident.

What happened with your engine? My engine malfunctioned unexpectedly at just 79,000 miles, despite no history of major engine problems. The final diagnosis showed a blown head gasket. Were there any warning signs beforehand? Yes—about two to three weeks before the malfunction, I received multiple cylinder misfire codes and a low coolant warning. I had both issues checked out and believed they were resolved at the time, as the car was running fine afterward. Did the car stop running completely? Yes. After everything seemed okay for a bit, the car suddenly wouldn’t start. We ruled out the battery, as it had already been tested and was functioning correctly. Were there other warning lights or concerns? Yes. Right before a planned trip, my tire pressure light came on. I had it checked and everything looked fine. After about 10 miles, the light turned off, but it began flashing again intermittently, along with the engine light, even after restarting the car multiple times. What was the final outcome? After further inspection, it was confirmed that the root issue was a blown head gasket, which led to the engine failure.

The engine block is leaking coolant into piston cylinder #4. This caused misfires resulting in reduced power when needed causing a few close call accidents. The loss of coolant could have also cause the engine to overheat and catch fire due to the loss of coolant. Yes, the check engine light came on in early March 2025 so I took it to Advanced auto and O'Reilly's for for diagnoses at first, both advised to replace spark plugs and wires. Since plugs and wires were new, I took my 2016 Ford Edge 2.0L ecoboost to my local dealership. Yes, the local ford dealership diagnosed the problem as coolant leaking into cylinder #4 with the fix as being an engine replacement.

The contact owns a 2016 Ford Edge. The contact stated that upon starting the vehicle, the vehicle was shaking abnormally. There was no warning light illuminated. The failure persisted, and the check engine warning light illuminated. The vehicle was taken to an independent mechanic. The mechanic discovered coolant intrusion into several cylinders. The vehicle was then diagnosed with a defective long block which had caused the engine failure. The manufacturer was notified of the failure and the contact was informed that the vehicle was not covered under warranty or recall. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was 89,315.

The power steering suddenly stopped working while I was driving. The steering became extremely stiff and difficult to control. At one point, the power assist abruptly returned, causing the steering wheel to jerk, and I nearly hit a pedestrian. It was a frightening and extremely dangerous situation. Brought the car to my mechanic multiple times, but the issue kept coming back. After 3 times, I brought the car to the ford dealership/ford mechanics and they confirmed the issue with the power steering was the fault of the rack and pinion. There was no indication of an issue prior to the power steering going out, however, as the steering goes out the power steering alert comes up on the cars dashboard, as wall as the loss of traction power.

The contact owns a 2016 Ford Edge. The contact stated while driving 20 MPH, the power steering failed to function as intended. In addition, several unknown messages were displayed on the instrument panel with several unknown warning lights being illuminated. With help from neighbors, the vehicle was taken to the residence. A dealer was not contacted; however, the vehicle was not diagnosed or repaired. The contact related the failure to Ford Recall: 19S26/NHTSA Campaign Number: 19V632000 (Steering); however, the VIN was not included. The manufacturer was made aware of the failure but denied assistance in covering the cost of the repair. The contact was informed of an unknown recall; however, the VIN was not associated with the recall repair. The failure mileage was approximately 90,000.

My cars check engine light came on, went to autozone and they diagnosed it as a coil 3 needed to be replaced, ordered the coil and replaced, but light was still illuminated, got the same part and replaced it again, however check engine light remained on, took car to dealership where we were told I needed a new engine due to coolant leak and sludge build up, did not have the money to replace. This happened at approximately 126,000 miles

The contact owns a 2016 Ford Edge. The contact stated while driving at an undisclosed speed, the low coolant warning light illuminated. The contact parked and inspected the vehicle and refilled the coolant reservoir. The coolant level was frequently low and consumed one gallon of coolant weekly. The vehicle was purchased as a used vehicle a year prior, and the failure began two months after the vehicle was purchased. A document was found in the vehicle from the previous owner which indicated that the vehicle was diagnosed with engine failure. The dealer who performed the diagnostic test was contacted and confirmed the failure. The contact was informed that the vehicle was auctioned off by the previous owner. In addition, the contact researched and stated that it was a known failure with the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000.

The contact owns a 2016 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic and DTC: P0302 and P0316 were retrieved. Additionally, the contact was informed that there was coolant intrusion in cylinder #2. The vehicle was not repaired. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 114,094.

The contact owns a 2016 Ford Edge. The contact stated there was a loud clunking sound while opening the front driver's side door. The vehicle was taken to the local body shop to be diagnosed, and the contact was informed that the front driver's door interior spot weld had become unsecured, and the door needed to be re-attached and re-welded. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not yet contacted. The failure mileage was 52,000.

My car was having issues and still is having issues starting after refueling. After putting fuel in the vehicle my car stalls out. I restart the car I have to give it gas before hurrying up and putting it in drive just to keep the car on. Due to a potential internal leak in the canister purge valve this can cause excessive vacuum in the fuel tank and can potentially lead to a crack in the tank, which can lead to a fuel leak and or fire. The check engine light came on reading one code. And because I'm unable to afford to have it repaired because of how expensive it is, I now have three codes coming off the check engine light. I smell fuel when I turn my car off or I'm running I'm running low on gas. My VSA light has also been on during all of this as well. I would gladly bring the vehicle to anyone to get it completely diagnosed by any professional of your choice.

Complaint Description: My 2016 Ford Edge 2.0L EcoBoost is experiencing a catastrophic engine failure due to "coolant intrusion" into the engine cylinders, a known manufacturing defect associated with the open-deck engine block design in this model year (referenced in Ford TSB 19-2346). The Failure: While driving at highway speeds (65+ MPH) on California freeways, the vehicle intermittently and suddenly enters "limp mode," drastically reducing power and acceleration without warning. This makes it impossible to merge safely or keep up with traffic, creating a life-threatening safety hazard for myself and other motorists. History & Diagnosis: The issue began in early 2025 with a Check Engine Light, which was initially misdiagnosed by a mechanic as a non-critical boost leak. The condition worsened significantly in Q4 2025, leading to dangerous stalls in power. A new independent inspection confirmed the root cause is not a boost leak, but internal coolant leakage into the engine block cylinders. This defect has caused permanent engine damage requiring a full engine replacement. The failure mode is identical to thousands of other complaints regarding the 2.0L EcoBoost engine, yet no safety recall exists to address the sudden loss of motive power.

The contact owns a 2016 Ford Edge. The contact stated while driving at approximately 35 MPH, the vehicle stalled. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 107,000.

The contact owns a 2016 Ford Edge. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the vehicle was overheating, prompting the contact to momentarily discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion into various cylinders had resulted in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was not notified of the failure. The failure mileage was 67,000.

Engine misfires while driving. Code found P0302. misfire in cylinder 2. cylinder checked by dealer with camera and found to be leaking coolant inside the cylinder. TSB 22-2220 2.0L Ecoboost found. Steps followed, dealer recommeded replacing Engine long block.

The passenger side rear brake hose is leaking severely, causing soft breaks. Making it very difficult to stop. This happened suddenly and did not experience any issues prior to the hose starting to leak. It will be towed to Ford for inspection and repair. We had no warning lamps or messages prior to the hose leaking.

For the 3rd time in 9 years, my car's brakes stopped working. Submitted complaint to NHTSA back in 2020 the 2nd time it happened (the 1st time under warranty). In January 2025 left work to drive 17 miles home, only to find that the minute I drove into traffic my brakes weren't working again, straight to the floor! Drove 20 minutes to nearest dealer in traffic with hazards on while consistently pulling the emergency brake - it was an awful experience! Next day they say brake hoses were broken and fluid was EVERYWHERE! I heard one employee tell another, "What is going on with these cars and their brake hoses?" This time I had to pay over $1,000 to get it fixed. I'm warning everyone I know NOT to buy this car! My 3 experiences have been so horrid that it absolutely has made me realize that Ford is just not for me or my family!

i have 2 issues. 1. cil comes on randomly i was told by my local parts place it had a code for a fuel cyliniod thing that purges the air as i do not have a gas cap. 2. just started 01/10/2025,

The contact owns a 2016 Ford Edge. The contact stated that while her daughter was driving the vehicle out of a parking lot, the "Power Steering Assist Fault" message displayed on the instrument panel. The driver parked the vehicle, and had the vehicle towed to a local dealer to be diagnosed. The contact was informed that the power steering module was faulty and needed to be replaced. The contact referenced NHTSA Campaign Number: 15V250000 (STEERING) as probable cause for failure; however, the VIN was not included. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 41,000.

The contact owns a 2016 Ford Edge. The contact stated that the check engine warning light remained illuminated, and the vehicle was taken to a local dealer to be diagnosed. The contact was informed that the engine needed to be replaced due to coolant intrusion. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 84,024.

The contact owns a 2016 Ford Edge. The contact stated while at a stop sign and depressing the accelerator pedal, the vehicle failed to respond. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and filed a case. The contact was referred to the NHTSA Hotline to report the failure. The approximate failure mileage was 42,000.

The oil pan is made of metal and plastic and the plastic warps over time and causes major oil leaks requiring frequent expensive replacement. There are no after market parts, only the plastic. Major oil leaks are hazardous.

The contact owns a 2016 Ford Edge. The contact stated upon starting the vehicle, the check engine warning light illuminated. The vehicle was taken to a local dealer to be diagnosed and the dealer retrieved DTC codes: P0301 and P0316. The dealer determined that there was a coolant intrusion in cylinder #1, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 123,749.

I purchased a 2016 Ford Edge and it has been one problem after another. This particular problem, and the last straw, has to do with coolant leaking from my car. After reading several complaints over a period of years it seems to be the same issue with many owners of the same make and model, a crack in the cylinder or motor (Long Block). I also read that Ford is aware of this problem and nothing has been done towards resolving the situation. This cannot be an ongoing issue. What will it take before a recall is made? After paying for several repairs since purchasing the car, I have exhausted all of my resources and can not afford an engine replacement. Will someone please, please, please, hear our complaints and offer a resolution that will not cost us an arm and a leg as a result of the manufacturer's negligence. I am very disappointed in FORD.

The vehicle has coolant intrusion in cylinder 3 due to a bad design with the engine. This can cause the engine to overheat and shutdown or even catch fire. If either of these happen while driving, especially on an interstate, I could be seriously hurt or killed along with others.

Steering issues, Suspension issues when reversing, power steering, braking system locking. recalls on other edges but not this vehicle

The contact owns 2016 Ford Edge. The contact stated that while driving at approximately 70 MPH, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that there was fluid intrusion into the cylinders from the radiator fluid, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 88,000.

The contact owns a 2016 Ford Edge. The contact stated that upon starting the vehicle, the check engine warning light was illuminated. The contact stated that there was evidence of coolant loss; however, no visible leak was on the ground. The contact added additional coolant. The vehicle was taken to the local dealer, where it was diagnosed that there was a coolant leak. The vehicle was not repaired. The contact called the manufacturer and was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 100,000.

The contact owns a 2016 Ford Edge. The contact stated while driving 35 MPH, a message indicating that the engine was overheating was displayed. The contact was able to drive to the destination. The contact stated upon inspecting the coolant reservoir, the coolant reservoir was empty. The contact's husband added coolant to the coolant reservoir; however, the failure recurred the following day. The vehicle was taken to an independent mechanic, where it was diagnosed that there was coolant intrusion into cylinder #3. The mechanic determined that the engine needed to be replaced, as per TSB Number: 19-2208. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 96,000.

Started hearing like a water sloshing noise when stopping or accelerating. I took it to the shop and coolant was low no apparent leak of any kind. They put coolant in and within a few weeks I started hearing the water noise again added coolant again and check engine light came on. Code read misfire on cylinder 1. Check engine light would pop on and then go off. Started rough cranking took it to the shop and need a new engine. 57,000 miles on this car. Car had been serviced at or around every 3,000-3,500 miles. Started doing research and this particular engine has been recalled but not in the make and year of my car. I really feel I should not have to pay nearly 6,000 for my engine to be repaired when so many issues with this particular engine I called Ford Service to make appt for recalls and told the Service Dept my issues and she off the start stated I needed a new motor without even seeing the car. How did she already know this? Because the motors have been having issues so this wasn’t the first time they have dealt with this particular engine

The contact owns a 2016 Ford Edge. The contact stated while driving at an undisclosed speed, the power steering failed to function as intended. In addition, the power steering fault warning light was illuminated. The vehicle was driven to the nearest gas station; however, the contact attempted to make a turn and the steering wheel seized. The vehicle was towed to the dealer where it was diagnosed with a failed electronic power steering system. The contact was informed that the electronic power steering system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed of an unknown recall; however, the VIN was not associated with the recall repair. The failure mileage was approximately 102,252.

The contact owns a 2016 Ford Edge. The contact stated when the vehicle was started, there was smoke coming from the exhaust with the check engine warning light illuminated. Additionally, the contact stated that there was an extreme amount of smoke as if the vehicle was on fire. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 124,500.

The contact called on behalf of his son who owns a 2016 Ford Edge. The contact stated that while his son was driving approximately 65 MPH, the temperature gauge had risen significantly to hot, and the vehicle started to shut down. The contact stated that his son was able to pull over onto the side of the road, to allow the engine to cool down. The contact stated that after restarting the vehicle, and continuing to drive, the failure persisted. The check engine warning light was illuminated with DTC Code: P0302 displayed. The vehicle was taken to an independent mechanic where the vehicle was diagnosed. The contact was informed that there were cracks between two of the cylinders, allowing coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 44,000.