2005 Ford Escape Steering Problems

Hello, The engine cradle subframe on my 2005 Ford Escape has completely rusted through on the right hand side where it attaches to the steering control arm. As I was driving the subframe broke which made it impossible to steer the car. This pulled my car off the road to the passenger side. Fortunately I was not injured. Having now researched this issue, it is a common problem with 2005 Ford Escapes. This is very dangerous, and it should be addressed as it creates a life threatening situation.

WAS DRIVING LESS THAN 15MPH WHEN SUDDENLY I LOST ALL CONTROL OF STEERING ON THE FRONT PASSENGER SIDE. WHEN I WAS ABLE TO GET HELP AFTER SITTING ON THE SIDE OF THE ROAD FOR 16 HOURS, I WAS INFORMED THAT ONE OF THE THREE WHEEL BEARINGS HAD SNAPPED. I DID A LITTLE RESEARCH AND FOUND THE RECALL FOR THE PASSENGER SIDE WHEEL ASSEMBLY AND BEARINGS. I ENTERED MY VIN NUMBER AND IT DIDN'T SAY WHETHER OR NOT IT WOULD BE FIXED. I TAKE PRIDE IN MY VEHICLES AND KEEP THE MAINTENANCE UP TO DATE, THEREFORE I CAN SAY THEY THIS HAPPENED DUE TO FAULTY PARTS AND FEEL LIKE I SHOULD BE ABLE TO HAVE IT FIXED.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT UNDISCLOSED SPEEDS, THE VEHICLE DRIFTED TO THE LEFT AND TO THE RIGHT WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO INFORMED THE CONTACT THAT THE CASE FRAME CROSS-MEMBER RUSTED OUT SEVERELY AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT FAILURE WAS RELATED TO MANUFACTURER COMMUNICATION NUMBER: 10013366 (STEERING), HOWEVER, THE 2005 FORD ESCAPES WERE NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE WHO INFORMED THE CONTACT THAT THERE WERE NO RECALLS ON THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 159,000.

THE PASSENGER SIDE SUBFRAME RUSTED OUT AND CORRODED CAUSING THE SUBFRAME TO BREAK, RESULTING IN A VERY UNSAFE AND HAZARDOUS VEHICLE.

THE ELECTRIC POWER STEERING SYSTEM FAILED IN THE MIDDLE OF AN INTERSECTION AND ALMOST CAUSED AN ACCIDENT INVOLVING OTHER VEHICLES.

WHILE DRIVING HER 2005 FORD ECAPE AFTER COMING TO AN ABRUPT STOP AT A TRAFFIC LIGHT. MY DAUGHTER FOUND STEERING EXTREMELY DIFFICULT, WITH VEHICLE PULLING EXTREMELY TO THE RIGHT THEN SWERVING INTO THE OTHER LANE TO THE LEFT UPON TRYING TO CORRECT FOR THE PULL. SHE PULLED THE CAR OVER AND FOUND THAT WITH THE STEERING WHEEL STRAIGHT AHEAD THE RIGHT FRONT WHEEL WAS POINTING OUTWARD TOWARD THE CURB WITH THE TOP OF THE WHEEL TILTED INWARD TOWARDS THE ENGINE. THE VEHICLE WAS UNDRIVABLE AND WAS TOWED HOME. VISUAL INSPECTION BY AN EXPERIENCED MECHANIC FOUND THAT EXTREME CORROSION OF THE SUBFRAME AT THE LOWER CONTROL ARM FRONT MOUNTING POINT HAD CAUSED THE SUBFRAME TO SEPERATE AND ALLOW THE LOWER CONTROL ARM TO BEND OUTWARDS AND CAUSE EXTREME MISALIGNMENT.

CROSS OVER ON PASSENGER SIDE RUSTED IN HALF,THE EXACT SAME THING THAT WASTE CALLED ON THE 2001-2004,MY WIFE WAS DRIVING WITH TWO OF MY GRANDCHILDREN WITH HER WHEN IT BROKE,THIS IS VERY DANGEROUS AND SERIOUS SITUATION,I FEEL FORD SHOULD FIX MY VEHICLE,IT WAS MANUFACTURED IN2004,I WILL TAKE IT TO COURT IF NECESSARY, INNOCENT PEOPLE COULD GET KILLED,IT IS THE EXACT SAME RECALL AS THE YEAR BEFORE AND WAS MANUFACTURED IN THAT YEAR OF THE RECALL MY ESCAPE HAS NO OTHER RUST ON IT ANYWHERE,I HAVE PICS TO PROVE IT,MY WIFE WAS JUST GETTING READY TO TURN INTO A DRIVEWAY FROM A CITY STREET

TAKATA RECALL THE 01 THRU 04 WERE RECALLED FOR SAME PROBLEM THE FRONT SUBFRAME RUSTED IN TO CAUSING THE RIGHT FRONT WHEEL TO WONDER ALL OVER IF DROVE ANY MORE WOULD HAVE CAUSE A SERIOUS WRECK I WAS DRIVING VEHICLE WHEN I NOTICED THAT IT FELT LIKE THE FRONT WHEEL WAS COMING OFF LUCKILY I WAS ONLY A COUPLE MILES FROM HOME THE DAY BEFORE I TOOK MY GRANDSON TO CHARLESTON WV TO MEET HIS MOM IF IT WOULD HAVE BROKEN ON I 77 AT 70 PLUS MILES AN HR COULD HAVE BEEN TRAGIC IT BEING THE SAME ISSUE WITH EARLY MODELS AND FORD SENT A BAR TO TRY N FIX IT A JOKE JUST LEARN THIS ON INTERNET

LAST YEAR I NOTICED THE RUST AROUND DOORS AND WHEELS, IM RETIRED & A DISABLED 77 YR OLD MAN SO I DRIVE IT ONCE A WEEK. OVER THE SUMMER I NOTICE IT HANDLING FUNNY, HAD IT SERVICED AND INSPECTED. I WAS ON ROUTE 30 A MILE FROM MY HOUSE IT STARTED SHAKING & MAKING A HORRIBLE NOISE, THE STEERING WHEEL WAS VIBRATING, I BARELY MANAGED GETTING WHEELS TO TURN IT OFF THE HWY, I THOUGHT TO MYSELF, THIS [XXX] THING FEELS LIKE IT'S GONNA FALL APART, HOME WAS 1/4 MILE, NOISE & VIBRATING CONTINUED, STRUGGLED TURNING WHEEL INTO MY DRIVEWAY, PARKED IT, GOT OUT AND FRONT PASSENGER SIDE WHEEL IS TILTED WAY OUT. MY SON JACKED IT UP AND SAID MY LOWER CONTROL ARM IS COMPLETELY RUSTED OUT OR THRU AND BROKEN OFF AND IT IS ALL RUSTED BAD UNDERNEATH & SAID IT'S SCRAPE. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

WHILE GOING ONTO A FREEWAY ONRAMP AT APPROXIMATELY 45 MILES PER HOUR, THE VEHICLE SUDDENLY LOST ALL POWER, ALL LIGHTS CAME ON, THE ABILITY TO STEER AND BRAKE WAS AFFECTED BY TOTAL POWER LOSS. THE VEHICLE DID NOT DISPLAY ANY ISSUES LEADING UP TO THIS BUT NEARLY RESULTED IN AN ACCIDENT BY THE INABILITY TO CONTROL THE VEHICLE AND GET IT OFF TO THE SIDE OF THE ROAD. AFTER BEING TOWED, THE AUTO SHOP DIAGNOSED A P0354, P0351, P0355, P0352 IGNITION COILS, AND PCM FAILURE. MY RESEARCH SHOWS THERE ARE MULTIPLE CLAIMS OF THIS OCCURRING AND IT IS DEFINITELY A SAFETY ISSUE.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING AT 10 MPH, THE ENGINE STALLED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. THE CONTACT STATED THAT THE POWER STEERING AND BRAKING ABILITY SEIZED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TAKEN TO (BEACH FORD 2717 VIRGINIA BEACH BLVD, VIRGINIA BEACH, VA 23452 (757) 486-2717) BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000.

WHILE DRIVING THE CAR ON CITY ROADS MY DAUGHTER NOTICE THAT THE CAR WOULD PULL TO THE RIGHT WHIKE SKING WHILE DRIVING. SHE ALSO NOTICED INCREASE RPM. THE SYMPTOMA KEPT GETTING WORSE UNTIL WE TOOK IT TO LES SCHWAB FOR DETAILED INPECRION.

I AM TRYING TO FIND OUT WHAT IS WRONG AND IF THERE ARE ANY RECALLS..MY SUV HAS A VIBRATION WHEN I EXCEL RATE AND LET OFF IT WHICH SHAKES THE WHEEL.I HAD IT CHECKED AND THEY CAN'T FIND ANYTHING..WHAT IS THIS PROBLEM,I HAVE JUST BOUGHT THE CAR IN DEC 17..TY

TERRIFYING! POTENTIALLY FATAL . POWER JUST CUT OUT ON HIGHWAY WHILE GOING APPROXIMATELY 55 MPH. NO STEERING, NO BRAKES. NO POWER. ALL WARRING LIGHTS ABLAZE, BUT NO WARNING BEFOREHAND! GRATEFULLY, I WAS IN THE RIGHT LANE AND MANAGED TO GET THE CAR INTO THE MEDIAN. AFTER SEVERAL MINUTES, CAR RESTARTED. LUCKILY I WAS ONLY 1/4 MILE FROM THE EXIT. I READ ABOUT THIS WELL KNOWN ELECTRICAL PROBLEM. IT IS THE PCM. APPARENTLY FORD USED FAULTY SPARK PLUGS. THE FIX IS TOO COSTLY. I WILL HAVE TO PURCHASE A NEW VEHICLE. FORD RECALLED THE 2005 ESCAPE HYBRID BUT NOT THIS MODEL? CRIMINAL

AFTER BREAKING WHILE IN TRAFFIC, MY CAR SWERVED UNEXPECTEDLY ON TO SHOULDER OF THE ROAD AND AFTERWARDS MY STEERING WHEEL WAS AT A STRANGE ANGLE. I IMMEDIATELY TOOK MY CAR TO A REPAIR SHOP WHERE IT WAS DETERMINED THAT THE CAR HAD EXCESSIVE CORROSION OF FRONT SUBFRAME CROSSBRACE AND LOWER CONTROL ARM RESULTING IN A SIGNIFICANT LOSS OF STEERING CONTROL. A RECALL WAS ISSUED ON 2001-2004 FORD ESCAPES WITH THE SAME PROBLEM AS MY 2005 FORD ESCAPE. 2005 MODELS SHOULD ALSO BE INCLUDED IN THE RECALL

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER STEERING ABILITY WITHOUT WARNING. THE CONTACT, AN INDEPENDENT MECHANIC, STATED THAT THE IDLER PULLEY BOLT FRACTURED IN HALF AND CAUSED THE VEHICLE TO OVERHEAT IMMEDIATELY. THE CONTACT PULLED THE VEHICLE OVER TO THE RIGHT SIDE OF THE ROAD AND THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND STATED THAT THE VEHICLE WAS OUT OF WARRANTY AND THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 136,000. *LN

POWER STEERING COMPLETELY SHUTS DOWN IN THE MIDDLE OF DRIVING OR MAKING TURNS. NO DIAGNOSTIC CODES APPEAR WHEN YOU TRY TO FIND THE PROBLEM. IF YOU TURN OFF THE CAR POWER STEERING RETURNS BUT IT GOES OUT AGAIN SHORTLY DOWN THE ROAD.

WHILE DRIVING THE POWER STEERING WILL COMPLETELY FAIL UNEXPECTEDLY AND A YELLOW WRENCH WILL APPEAR ON THE DASHBOARD. THIS IS VERY DANGEROUS AS IT COMES UNEXPECTEDLY BUT WILL COME BACK ON WHEN THE VEHICLE IS TURNED OFF AND ON AGAIN. THE STEERING IS EXTREMELY DIFFICULT TO MUSCLE THROUGH WHEN THE POWER STEERING FAILS. THE STEERING CAN FAIL AT ANY TIME WHILE DRIVING OR PARKED WHEN THE VEHICLE IS ON AND IT HAPPENS ALMOST 100% OF THE TIME THAT I DRIVE THE VEHICLE. IT SEEMS TO BE WORSE IN HOT WEATHER.

POWER STEERING FAILURE WHILE PARKED ON CITY STREET.

THE ELECTRONIC POWER STEERING ASSIST SUDDENLY STOPPED FUNCTIONING ,