There are 5 stored owner reports matching the suspension leading-label group for the 2002 Ford Excursion in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 5 of 5 matching reports.
Open the full vehicle complaint log (all categories)As I was driving the transfer case and drive shaft dropped out of truck. Broken bolts and no warning.
WHILE DRIVING 30 MPH THE CONSUMER LOST CONTROL OF THE VEHICLE AND ENDED UP IN A DITCH. THE CONSUMER STATED THAT THE VEHICLES TIRES LOSE AIR PREMATURELY. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
THE VEHICLE HAS A FRONT SUSPENSION PROBLEM WHICH CAUSES THE VEHICLE TO VIBRATE, THE VEHICLE HAS BEEN TO THE DEALER 3 TIMES BUT THE PROBLEM STILL EXIST, BOTH DRIVER SIDE DOORS ARE MISALIGNED WITH RESPECT TO THE FENDER TRIM, THE DIFFERENTIAL WAS ORIGINALLY MISALIGNED WITH RESPECT TO THE REAR FENDER TRIMS, NOW THE DIFFERENTIAL IS PROPERLY ALIGNED AND THE CONSUMER QUESTIONED THE TECHNICIANS WHO STATED THAT THEY DID NOTHING TO CORRECT THE MISALIGNMENT, THE CONSUMER FEELS THIS IS A DEFINITE SAFETY PROBLEM IF THE DIFFERENTIAL GOES IN AND OUT OF ALIGNMENT ON IS OWN, THE A/C WAS NOT COOLING AND NEEDED TO BE RECHARGED, THE CONSUMER CAN HEAR STATIC IN RADIO WHEN TURNING ON THE REAR TV SWITCH, A/C AND TURN SIGNAL, STEERING GEAR AND HYDRO BOOST LINE REPLACED, TIRE OUT OF BALANCED CAUSING VIBRATION AT 75-70 MPH, STEERING OUT OF ADJUSTMENT (OFF CENTER), CALIPERS REPLACED, TRANSMISSION EXPERIENCING A DELAY WHEN SHIFTING, BOTH WIPER BLADES OFF CENTER, DRAIN PLUG LEAKING OIL, WEATHER STRIPPING ON RIGHT REAR DOOR FAILED, HEADLINER IS COMING LOOSE ON THE LEFT SIDE, WINDSHIELD WASHERS INOPERATIVE, FUEL GAUGE READ INCORRECTLY, FAULTY ACCELERATOR PEDAL CAUSED THE VEHICLE TO STALL WHEN COMING TO A STOP. NLM
WHILE DRIVING 50 MPH AND ROLLING OVER BUMPS/POT HOLES, AND ROUGH SURFACES, IT CAUSES VEHICLE TO VIRATE SEVERELY AND LOSE STEERING CONTROL. DEALER AND MANUFACTURER HAD NOT BEEN NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
THE VEHICLE EXPERIENCED ELECTRICAL AND SUSPENSION PROBLEMS. THE SUSPENSION PROBLEM CAUSED THE TIRES TO WEAR PREMATURELY. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: May 3, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.