There are 28 stored owner reports matching the tires & wheels leading-label group for the 2002 Ford Excursion in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 28 of 28 matching reports. The list controls page through the loaded reports only.
Open the full vehicle complaint log (all categories)HAD A B F GOODRICH LT315/75R16D ALL TERRAIN KO, DOT: BFAUHX111211, FRONT LEFT TIRE EXPLODE WITHOUT ANY WARNING, WAS DRIVING NORTH ON HIGHWAY 65, ABOUT 16 MILES SOUTH OF BRANSON, MO. I WAS TRAVELING AROUND 65 MPH IN THE RIGHT HAND LANE ON A CLEAR DRY DAY WITH MINIMAL TRAFFIC. THE TIRES WERE PURCHASED ON 4-23-11, SAM'S CLUB #6361, VEHICLE HAD 91,461 MILES. THE INCIDENT HAPPENED ON 5-8-18, THE VEHICLE HAD 136,896 MILES. (45,435 MILES). WHEN THE TIRE EXPLODED IT SEVERED THE FRONT LEFT BRAKE LINE RESULTING IN THE LOSS OF CONTROL OF THE VEHICLE, CAUSING MAJOR DAMAGE TO THE VEHICLE, RESULTING IN THE VEHICLE BEING TOTALED.
TL* THE CONTACT OWNS A 2002 FORD EXCURSION EQUIPPED WITH TOYO OPEN COUNTRY R/T TIRES (NA), SIZE: LT285/75/R16. WHILE DRIVING 65 MPH, THE REAR PASSENGER TIRE EXPERIENCED TREAD SEPARATION. PRIOR TO THE FAILURE, THE REAR DRIVER'S TIRE WAS REPLACED BY ALLEN TIRE (LOCATED AT 1725 SUPERIOR AVE, COSTA MESA, CA 92627, (949) 646-5236) DUE TO A BULGE IN THE TIRE. THE CONTACT STATED THAT THERE WAS DAMAGE TO THE VEHICLE. THE SET OF TIRES WERE A REPLACEMENT SET. THE TIRE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14T014000 (TIRES). THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 170,000 AND THE TIRE FAILURE MILEAGE WAS 75,000.
TL* THE CONTACT OWNS A 2002 FORD EXCURSION EQUIPPED WITH SUNFULL MONT-PRO HT781 TIRES, SIZE: LT265/75/16. WHILE DRIVING 65 MPH, THE VEHICLE VIBRATED ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR PASSENGER SIDE TIRE TREAD SEPARATED, WHICH CAUSED A BUBBLE IN THE TIRE. WITHIN LESS THAN A THOUSAND MILES LATER, THE FRONT DRIVER'S TIRE ALSO EXPERIENCED THE FAILURE. THE RETAIL FACILITY WHERE THE TIRES WERE SOLD AND INSTALLED WAS NOT CONTACTED. THE TIRE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 166,000 AND THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 4,999.
ON 6/5/2013, I WAS DRIVING ON FREEWAY AT APPROX. 70MPH AND TREAD SEPARATED FROM RT. REAR TIRE CAUSING VEHICLE TO SWERVE INTO ADJACENT LANE. DAMAGE TO QUARTER PANEL AND RUNNING BOARD. THIS IS THE SECOND TIRE FAILURE IN THE PAST 45 DAYS.THE TIRES ARE BFGOODRICH 265/75R/16 COMMERCIAL TA LOAD RANGE E. THE FOUR NEW TIRES WERE INSTALLED ON 2/28/2011 AND HAVE APPROX. 14,300 MILES OF WEAR AT TIME OF FAILURE. THE OTHER TIRE (LEFT FRONT) FAILED ON 4/19/2013. BECAUSE OF STRONG FRONT END VIBRATION, I INSPECTED THE FRONT TIRES. I FOUND THAT IT WAS OUT OF ROUND DUE TO BELT SEPARATION. THE DEALER REPLACED THIS TIRE ALSO. *TR
WHILE DRIVING ON I-84 EAST BOUND, BETWEEN THE DALLES AND PENDLETON OREGON, OUR 2002 FORD EXCURSION EXPERIENCED A TIRE TREAD SEPARATION ON THE RIGHT REAR. WE EXPERIENCED A RECURRING POPPING SOUND JUST PRIOR TO THE TREAD SEPARATION. WE WERE PULLING A LIGHT TRAILER. TREAD SEPARATED BUT TIRE REMAINED INFLATED. I WAS ABLE TO SEE THE TREAD LEAVE THE TIRE IN MY RIGHT MIRROR AS IT HAPPENED. WE WERE TRAVELING UP HILL AT THE TIME SO SPEED WAS APPROXIMATELY 63MPH. DRY ROADS AND 93 DEGREES. *TR
I AM THE ORIGINAL OWNER OF A 2002 FORD EXCURSION THAT IS EQUIPPED WITH THE FIRESTONE STEELTEX A/T TIRES LT 265/75R16 119/116R LOAD RANGE D; WITH ABOUT 60K MILES. ON FRIDAY NIGHT I EXPERIENCED A TIRE BLOWOUT WHILE OPERATING AT HIGHWAY SPEEDS (55 MPH). IT APPEARS THAT THE TREAD SEPARATED FROM THE TIRE. IN CHECKING THE WEB SIGHTS THIS EVENING THERE APPEARS TO HAVE BEEN A "SAFETY IMPROVEMENT" FOR THIS TIRE. I HAVE YET TO RECEIVE IT. WHO CAN ADDRESS MY ISSUES OF REPLACING MY TIRES AND OR REPAIRING THE DAMAGE. *TR
THE CONSUMER RECEIVED LETTER REGARDING RECALL # 03T0020000. HOWEVER, BRIDGESTONE/FIRESTONE HAS NOT COOPERATED WITH THE CONSUMER. THE RIGHT REAR PASSENGER TIRE BLEW OUT. CHUNKS OF THE TIRE DAMAGED UNDERNEATH THE VEHICLE, AND FORD SAID THERE WAS NOTHING THEY CAN DO. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB
FIRESTONE STEELTEX TIRES EXPERIENCED TREAD SEPARATION. *BF THE OWNER REQUESTED REIMBURSEMENT. *SC *JB
TRAVELING EAST BOUND ON I-84 10 MILES FROM MOUNTAIN HOME, IDAHO WHEN MY LEFT REAR TIRE TREAD SEPARATED FROM THE TIRE AND THEN THE TIRE BLEW. TIRE TYPE WAS A FIRESTONE LT 365/75R16 LOAD RANGE D STEELTEX R4S MODEL. THE THREAD DAMAGE MY QUARTER PANEL, WHEEL WELL SPLASH GAURDS AND PAINT ON VEHICLE. I WAS TRAVEL AT 75 MPH WITH MY TIRE PRESSURE SET AT RECOMMENDED PRESSURE SET BY FORD AT 45 PSI FRONT AND 55 PSI IN THE REAR. VEHICLE WAS 2002 FORD EXCURSION XLT. I FILE A INSURANCE CLAIM FOR REPAIR AND THEY COMPLETED ON SEPT. 10, 2004. ON SEPT 14, 2004 I CONTACT FIRESTONE TECH SERVICES ABOUT THE TIRE. THEY WILL SEND A COMPLAINT AND INSTRUCTION HOW FILE A CLAIM.
THE CONSUMER STATED THE TIRES ON HIS VEHICLE HAD IRREGULAR WEAR AND MADE A LOT OF NOISE. HE READ THAT THE MANUFACTURER WAS RECALLING THESE TIRES, SO HE TOOK THEM TO THE DEALER AND HAD THEM CHECKED, AT WHICH TIME HE WAS ADVISED TO GET MORE TIRES, BECAUSE OF THE IRREGULAR WEAR. THE CONSUMER STATED HE DID PURCHASED MORE TIRES, AFTER CONSULTING THE MANUFACTURER WHO AT THAT TIME ADVISED HIM OF WHAT TO DO TO GET REIMBURSED FOR THE BAD TIRES. THE CONSUMER IS NOW HAVING A HARD TIME TRYING TO GET REIMBURSEMENT. BRIDGEPORT/GOODYEAR LT 265/75 R 16 LRD. *JB
CONSUMER RECEIVED RECALL 03T 002 000 CONCERNING FIRESTONE, STEELTEX A/T, LT265/75R16 LOAD RANGE D FROM THE MANUFACTURER ON MARCH 2004. CONSUMER WAS TOLD BY DEALER AND MANUFACTURER THAT THE TIRES NEEDED WERE NOT AVAILABLE. IT HAS BEEN ALMOST SIX MONTHS AND CONSUMER WAS CONSTANTLY BEING TOLD THE SAME IN 30 DAY INCREMENTS.*AK
CONSUMER RECEIVED A RECALL LETTER REGARDING FIRESTONE STEEL TEX RADIAL TIRES, LT265/75R16 LOAD RANGE D. PRIOR TO RECEIVING THE RECALL LETTER CONSUMER REPLACED ONE OF THE TIRES. MANUFACTURER WON'T HONOR THE EXPENSES CONSUMER PAID TO REPLACE THE TIRE. *AK
THE DEALERSHIP REPLACED THE FRONT AND REAR TIRES, MANUFACTURER AND CONSUMER SPLIT THE COST OF THE TIRES. ONE YEAR LATER CONSUMER RECEIVED A RECALL LETTER, ON FIRESTONE, STEELTEX A/T, 265/75R16, BUT MANUFACTURER REFUSED TO REIMBURSE THE MONEY THAT HE ALREADY PAID ABOUT A YEAR AGO. *AK
FORD AND FIRESTONE ARE REFUSING TO HONOR VEHICLE RECALL. THE MANUFACTURER SAYS THE CONSUMER'S TRUCK IS NOT PART OF THE RECALL. CONSUMER HAS THE STEEL TEX R4SII LT265 LOAD RANGE D ORIGINAL EQUIPMENT.*MR
4/4/04 I REC'D A FLAT TI,E TOLD IT WAS IRREPARABLE SINCE AIR WAS SEEPING OUT OF THE SIDEWALL. 4/5/04, I RECEIVE LETTER FROM FIRESTONE/FORD REAGRDING TIRE RECALL ON MY 2002 FORD EXCURSION.. 4/6/04 I PHONE 3 FORD DEALERSHIPS AND 5 FIRESTONE STORES TRYING TO LOCATE REPLACEABLE TIRES. TOLD THEY HAD NO IDEA WHEN TIRES WOULD BE AVAIL. I CALLED FORD CORP., THEY BLAME FIRESTONE, CALL FIRESTONE HOTLINE, THEY BLAME FORD. FORD CORP- KEISHA, CUST. SERVICE TOLD ME TO - DRIVE AS LITTLE AS POSSIBLE, WEAR MY SEAT BELT, CK AIR IN TIRES AND DRIVE UNDER THE SPEED LIMIT. 4/6/04 I ORDERED 5 NEW RECOMMENDED B.F. GOODRICH TIRES FROMJIM BABBITT FORD, FLAGSTAFF, AZ. I CK EACH WK ON ORDER. STILL HAVE NO IDEA WHEN TIRES WILL BE IN. CALLED FORD CORP., CUST SERVICE -CHARMAINE TODAY & WAS TOLD "IT IS NOT FORD PROBLEM", EVEN THOUGH THE REPLACEMENT TIRES WERE ADVISED & ORDERED THRU FORD. FORD CERTAINLY DOES NOT TAKE THIS TIRE REPLACMEENT SERIOUSLY NOR CARES !! MEANWHILE I AM DRIVING WITH NO SPARE DUE TO A FAULTY TIRE ALREADY !
MY DAUGHTER DRIVES A 2002 FORD EXCURSION AND WITH VERY LOW MILES THE WEAR OF THE TIRES IS UNACCEPTABLE. THEY ARE WEARING FAST AND UNEVEN AND MAKE NOISE. PLEASE LOOK INTO THESE TIRES BECAUSE SHE TRAVELS WITH MY PRECIOUS GRANDCHILDREN DAILY. SHE HAS TWINS THAT ARE 2 YEARS OLD AND ANOTHER SON THAT IS 3 THAT ALL RIDE IN CAR SEATS. THANK YOU. *AK
FIRESTONE STEELTEX TIRES FOR 2002 FORD EXCURSION RECALLED. CONSUMER HAD ALREADY REPLACED TWO OF THE TIRES WITH MICHELIN. FORD DEALER SAYS REPLACE ALL 5 TIRES INCLUDING MICHELIN WITH PROPOSED B. F. GOODRICH OR NO TIRES REPLACED. CONSUMER PREFERS KEEPING MICHELIN TIRES. NO COMPENSATION OFFERED. CONSUMER EXPERIENCED A BLOW OUT WITH FIRESTONE STEELTEX ON PREVIOUS MODEL EXCURSION (2000) AND FILED COMPLAINT AND DID NOT RECIEVE ANY RESPONSE. FORD SHOULD ALLOW ME TO REPLACE THE 3 DEFECTIVE TIRES, UNDER THE RECALL, AND KEEP THE REPLACED TIRES, IN FACT, CONSUMER SHOULD BE REIMBURSED.
I DRIVE A NEW 2002 FORD EXCURSION AND WITH VERY LOW MILES THE WEAR OF THE TIRES IS UNACCEPTABLE. THEY ARE WEARING FAST AND UNEVEN AND MAKE NOISE. PLEASE LOOK INTO THESE TIRES AS I HAVE 2 YEAR OLD TWINS AND A 3 YEAR OLD THAT TRAVEL WITH ME EVERYDAY. THANKS.*AK
WHILE DRIVING AT NORMAL SPEED. FIRESTONE STEEL TEX, SIZE LT235/75R16 DOT# UNKNOWN TREAD SEPARATED, FORCING THE CONSUMER TO PULL OUT THE ROAD. *AK
OUR FIRESTONE TIRES ARE FALLING APART NEAR THE LETTERING ON THE SIDEWALLS. WE FIRST NOTICED IT ON A TRIP TO CHICAGO. THEY ARE FIRESTONE STEELTECK R4S. *LA
Showing 1-20 of 28 loaded complaints
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: May 3, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.