2006 Ford Expedition Complaint Log

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 20 MPH THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE FAIL SAFE LIGHT. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 168,000.

TOOK MY 2006 FORD EXPEDITION LIMITED TO THE DEALERSHIP FOR A TUNE-UP AND WAS TOLD OF AN ISSUE THAT THE 5.4L ENGINES HAVE. THEY MENTIONED THAT SOME 2004-2008 F-150, 2006-2008 MARK LT, 2005-2008 F-SUPER DUTY, EXPEDITION, AND NAVIGATOR, WITH 5.4L 3-V ENGINE; 2005-2008 MUSTANG, 2006-2008 EXPLORER, MOUNTAINEER, AND 2007-2008 EXPLORER SPORT TRAC WITH 4.6L 3-V ENGINE; 2005-2008 F-SUPER DUTY, 2006-2008 AND F-STRIPPED CHASSIS, WITH 6.8L 3-V ENGINE MAY EXPERIENCE DIFFICULTY WITH SPARK PLUG REMOVAL. THIS MAY CAUSE DAMAGE TO THE SPARK PLUG AND LEAVE PART OF THE SPARK PLUG IN THE CYLINDER HEAD. AFFECTED ENGINE BUILD DATES ARE AS FOLLOWS: 5.4L 3-V AND 6.8L 3-V BEFORE 10/9/07, 4.6L 3-V BEFORE 11/30/07. FORD APPERANTLY KNOWS ABOUT THIS SINCE THEY PUBLISHED A TECHNICAL BULLITIN (TSB 08-7-6) TO THE DEALERSHIPS. NOW THE CONSUMER, WHO WAS NEVER TOLD ABOUT THIS WHEN THEY PURCHASE THE VEHICLE HAS TO PAY AN ADDITIONAL COST FOR A STANDARD TUNE-UP. WHEN ASKED WHY, THE SERVICE DEPARTMENT MENTIONED THAT THE COST IS FOR THE REMOVAL OF BROKEN PLUGS THAT THEY KNOW THEY WILL BREAK. WHY WOULD I HAVE TO PAY ADDITIONAL MONEY FOR DAMAGE DONE BY THE SERVICE DEPARTMENT FOR AN ISSUE CREATED BY FORD MOTOR CO. IF THE PLUGS ARE DEFECTIVE AND FORD KNOWS ABOUT THIS, THEY SHOULD BE RESPONSABLE OR A RECALL SHOULD BE ISSUED. THIS TO ME IS FRAUD BY HAVING THE COSTUMER PAY FOR THEIR MISTAKES. *TT

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 45 MPH WHEN THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER THE FAILURE BUT WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 80,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION EQUIPPED WITH CONTINENTAL CONTITRAC TR TIRES, SIZED 265/70/R17 WITH A DOT NUMBER OF A3T645RW. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE TREAD ON THE DRIVERS SIDE REAR TIRE SEPARATED AND THE CONTACT BEGAN TO LOSE CONTROL OF THE VEHICLE. AS A RESULT, EXTENSIVE DAMAGED WAS INFLICTED ON THE REAR BUMPED AND TAIL LIGHTS. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS FOR THE STATED TIRES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000.

WHILE DRIVING MY 2006 FORD EXPEDITION ON THE HIGHWAY, THERE WAS A COMPLETE THREAD SEPARATION IN ONE OF THE REAR TIRES, (CONTINENTAL, CONTITRAC SUV, P265-70R17), THE TRIMMING BEHIND THE TIRE WELL WAS DAMAGED. THE VEHICLE'S ODOMETER REGISTERS 43,993 MILES. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS AND THE ENGINE SAFE MODE WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED ON THREE PRIOR OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 82,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING INDICATOR. THE ENGINE RESTARTED AFTER WAITING A FEW MOMENTS. THE SAME FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED SPORADICALLY AND AT DIFFERENT SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS. THE CONTACT WAS NOT AWARE OF THE REPAIRS NEEDED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

2006 FORD EXPEDITION INVOLVED IN HEAD ON ACCIDENT AND AIRBAGS DID NOT DEPLOY. FORD EXPEDITION WAS DRIVING SOUTHBOUND ON A FOUR LANE DIVIDED STREET ABOUT 30-35 MPH WHEN A MINIVAN TRAVELING NORTHBOUND BLINDLY TRIED TO MAKE A LEFT TURN INTO A SHOPPING PLAZA AND TURNED RIGHT IN FRONT OF ME. AN RV WAS SITTING IN THE CENTER MEDIAN BLOCKING HER VIEW. I HIT HER PASSENGER REAR SIDE HEAD ON. I HAD 3 CHILDREN IN THE CAR. NO AIRBAGS DEPLOYED. WHY THE HECK DO I EVEN HAVE THEM IF THEY AREN'T GOING TO WORK WHEN NEEDED? I AM CONCERNED ABOUT THE AIRBAGS NOT DEPLOYING. I DON'T FEEL SAFE IN MY EXPEDITION AND I AM AFRAID TO DRIVE IT AGAIN. I DON'T FEEL IT IS SAFE... ISN'T THE SAFETY EQUIPMENT SUPPOSED TO PROTECT US AND KEEP US SAFE AND WORK?? *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT CARBON BUILT UP AROUND THE SPARK PLUGS AND HE WAS UNABLE TO REMOVE IT SINCE ONE OF THE SPARK PLUGS FRACTURED IN HALF AND THE OTHER PART WAS STUCK IN THE VEHICLE; HOWEVER, IF HE WERE TO REMOVE THEM IT WOULD CAUSE SERIOUS DAMAGE TO THE ENGINE. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR SERVICE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 104,000. THE VIN WAS UNAVAILABLE.

FALSE ACTIVATION OF "ENGINE FAILURE MODE" SYSTEM. ENGINE WENT TO IDLE SPEED, ALL GAUGES READ NORMALLY AND NO WARNING LIGHTS CAME ON. ENGINE TEMPERATURE WAS IN NORMAL RANGE. "ENGINE FAILURE MODE" MESSAGE WAS DISPLAYED ON MESSAGE PANEL. I WAS ABLE TO SAFELY COAST OFF THE ROAD AND STOP THE VEHICLE. I TURNED THE IGNITION OFF, AND OBSERVED THAT THE ENGINE COOLANT LEVEL IN THE COOLANT TANK WAS NORMAL. I THEN RESTARTED THE ENGINE, AND VEHICLE THEN OPERATED NORMALLY.

I WAS COMING ACROSS ARIZONA, INTERSTATE 10 IN MY 2006 EXPEDITION HEADING HOME TO SAN DIEGO WHEN MY "ENGINE FAILSAFE MODE" INDICATOR CAME ON, THE ENGINE WARNING LIGHT WAS ON AND SHUT THE ENGINE DOWN. THE ENGINE WARNING LIGHT NEVER WENT OFF UNTIL I TOOK IT TO A MECHANIC THE FOLLOWING MORNING. THE MECHANIC STATED THAT I NEED TO HAVE THE THROTTLE CLEANED OUT AND MAY NEED A NEW SENSOR FOR THE SIDE OF THE THROTTLE REPLACED. I HAVE 59K MILES ON MY VEHICLE AND HAVE THE MAINT. COMPLETED EVERY 4K TO 6K AND HAVE OWNED THIS VEHICLE FROM THE START. I HAD 2 MILES ON THE VEHICLE WHEN WE PURCHASED THIS VEHICLE IN OCT 2005. AFTER READING ABOUT THIS PROBLEM WITH OTHER OWNERS I THINK FORD SHOULD BE ABLE TO REPAIR OR REPLACE THE PROBLEM WITHOUT CHARGING THE CUSTOMER. THIS IS THE SECOND TIME THIS HAS HAPPENED TO ME. BOTH TIMES WE HAD THE CRUISE CONTROL TURNED ON. AFTER STOPPING IN THE MIDDLE PART OF ARIZONA ON THE SIDE OF THE ROAD, WE RESTARTED THE MOTOR AND MADE IT BACK HOME AFTER OUR VACATION. *TR

THERE IS NO WARNING - MY FORD EXPEDITION JUST GOES INTO ENGINE FAIL SAFE MODE AND SHUTS OFF - NO ABILITY TO STEER, DRIVE ETC. WAS TRAVELING ON HIGHWAY AT HIGHWAY SPEEDS (55+ MPH) WHEN THIS HAPPENED. THE ENGINE FAIL SAFE HAD COME ON BEFORE BUT WAS A BIT SCARY UPON DRIVING AT A SPEED. THE DEALERSHIP STATES THAT THE THROTTLE BODY NEEDS TO BE REPLACED. MY VEHICLE ONLY HAS 55000 MILES ON IT - AND FROM READING OTHER FORUMS I SEE THAT THIS IS A PROBLEM WITH A LOT OF FORD EXPEDITIONS. IT IS IN THE SHOP NOW (AT A COST OF $700) BEING FIXED, I AM GOING TO REQUEST TO HAVE THE OLD PARTS SAVED SO I CAN KEEP FOR FUTURE REFERENCE. I BELIEVE THIS IS A MAJOR DEFECT THAT NEEDS TO BE FIXED AS IT WILL CAUSE A DEATH ONE DAY SOON - AS THE VEHICLE SHUTS OFF DURING DRIVING. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY. THE VEHICLE WAS MOVED FROM THE ROADWAY AND WHEN THE CONTAC EXITED, THERE WAS AN ABNORMAL BURNING ODOR AND BLACK SMOKE EMITTING FROM THE TAILPIPE. THE POLICE WERE DISPATCHED AND WHEN THEY ARRIVED AND OPENED THE REAR DRIVER SIDE DOOR, THICK BLACK SMOKE WAS POURING OUT FROM THE INSIDE OF THE VEHICLE. THERE WERE ALSO FLAMES FROM THE INTERIOR AND UNDER THE FRAME. THE FIRE WAS EXTINGUISHED BY THE LOCAL FIRE DEPARTMENT. THE FIRE CHIEF ADVISED THAT THERE WAS A HOLE IN THE FUEL LINE AND AN ELECTRICAL PROBLEM THAT COULD HAVE CAUSED THE FIRE BUT THE RESULTS WERE INCONCLUSIVE. THE VEHICLE WAS TOWED BY THE CONTACTS INSURANCE COMPANY. THE INSURANCE ADJUSTER INFORMED THE CONTACT THAT THE VEHICLE WAS DESTROYED AND THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FIRE. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT CONTACTED TO REPORT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE STALLED. THE ENGINE SAFE MODE LIGHT ILLUMINATED AFTER THE FAILURE AND THE VEHICLE WAS TOWED TO THE DEALER. THE MANUFACTURER WAS CONTACTED TO REPORT THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 114,000 AND THE CURRENT MILEAGE WAS 116,000.

VEHICLE HAS BEEN SPUTTERING WHEN ACCELERATING AT ABOUT 40MPH. SPARK PLUGS ARE "SEERED" AND FORD MECHANIC TELLS US ITS A KNOWN PROBLEM, BUT NOT COVERED UNDER THE WARRANTY BECAUSE SPARK PLUGS ARE CONSIDERED MAINTENANCE. THE MANUAL SAYS WE THE SCHEDULED MAINTENANCE IS 100,000 MILES AND WE ARE ONLY AT 76,000. IF THEY ARE KNOWN TO BE FAULTY AND WE ARE NOT NEAR THE SCHEDULED/RECOMMENDED MAINTEANCE THEN SHOULDN'T THIS BE A WARRANTY ISSUE? I THINK FORD IS MILKING ITS CUSTOMERS WITH FAULTY PARTS AS I HAD THE SAME ISSUE WITH MY BRAKES. IT FEELS AS IF I AM LANDING A PLANE WHEN I COME TO A STOP WITH ALL THE SHAKNIG AN RATTLING. I WAS TOLD THIS IS A KNOWN ISSUE WITH THE FORD BRAKES - THEY JUST WARP. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE SPARK PLUGS WAS CAUSING DAMAGE TO THE ENGINE. THE DEALER ADVISED THE CONTACT TO HAVE THE SPARK PLUGS REMOVED AND REPLACED WITH A DIFFERENT MODEL SPARK PLUG. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 45,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT STATED THAT THE FAIL SAFE MODE SYMBOL ILLUMINATED ON THE DASHBOARD AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. A PRIVATE MECHANIC DIAGNOSED THE VEHICLE WITH A THROTTLE BODY FAILURE. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 102,000.

THE VEHICLE ENTERS ENGINE FAIL SAFE MODE. AT THIS POINT, THE VEHICLE WILL SHUT OFF AND YOU WILL LOSE ENGINE POWER AND STEERING CAPABILITIES. THIS IS PARTICULARLY DANGEROUS WHEN DRIVING 70 MILES PER HOUR ON THE HIGHWAY. IT WILL EVENTUALLY KILL SOMEONE IF IT HAS NOT ALREADY. FORD HAS DROPPED THE BALL ON THIS ONE. THE REPAIR IS A $600 - $800 THROTTLE BODY ASSEMBLY. FORD SHOULD BE EATING THIS COST.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WOULD RECUR SPORADICALLY WHEN TRAVELING AT VARIOUS SPEEDS. THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS TAKEN TO THE DEALER WHO REPAIRED THE THROTTLE BODY AND MOTOR ASSEMBLY, STATING THAT THE VEHICLE HAD ENGAGED IN FAIL-SAFE MODE. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE CURRENT MILEAGE WAS APPROXIMATELY 51,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 50,500.

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THE COOLANT HOSE IN THE VEHICLE WAS LEAKING INTO THE VEHICLE. THE FAILURE CAUSED THE RADIATOR TO MALFUNCTION. THE CONTACT TOOK THE VEHICLE DEALER TO HAVE THE HOSE REPLACED, THE DEALER STATED THE HOSE WAS NO LONGER AVAILABLE. THE CONTACT STATED THE VEHICLE WOULD SHUT OFF INTERMITTENTLY DUE TO THE FAULTY HOSE. THE FAILURE MILEAGE WAS 85,000.

2006 FORD EXPEDITION. CONSUMER STATES VEHICLE WILL ACTIVATE THE ENGINE FAIL SAFE MODE AND VEHICLE WILL SHUT DOWN WHILE DRIVING *TGW THE CONSUMER STATED WHEN THE VEHICLE SHUT DOWN, LOSS OF POWER STEERING OCCURRED. THE CONSUMER STATED UPON STOPPING, HE DISCOVERED THAT TURNING THE IGNITION SWITCH TO THE OFF POSITION AND TURNING IT BACK TO THE ON POSITION, THE ENGINE WOULD RE-START. THE DEALERSHIP WAS UNABLE TO FIND ANY PROBLEM BY RUNNING A DIAGNOSTIC CHECK. THE CONSUMER STATED NO WARNING LIGHTS APPEARED, EXCEPT WHEN THE ENGINE FAIL SAFE MODE ACTIVATED. THE ENGINE SAFE MODE WARNING DISAPPEARED UPON STARTING THE VEHICLE. *JB

2006 FORD EXPEDITION E.B. AND ENGINE FAILSAFE MODE 1. THE EVENTS LEADING UP TO THE FAILURE: THERE ARE NO DETECTABLE EVENTS PRECEDING WHATEVER CAUSES THE VEHICLE TO GO INTO "ENGINE FAILSAFE" MODE. THE VEHICLE RUNS FINE AS IT ALWAYS DOES AND THEN IT JUST HAPPENS RANDOMLY. 2. THE FAILURE, HOW OFTEN IT OCCURS, ITS CONSEQUENCES: FAILURE OCCURS AT RANDOM AND IS NOT PREDICTABLE IT JUST HAPPENS. THE VEHICLE OPERATES NORMALLY AS IT SHOULD AND IN A SPILT SECOND IT IS LIKE THE VEHICLE JUST SHUTS OFF, THE INFORMATION CENTER DISPLAYS "ENGINE IN FAILSAFE MODE". THE ENGINE IS ACTUALLY RUNNING IN FAILSAFE MODE BUT ONLY AT AN IDLE, THE POWER STEERING AND BRAKES FUNCTION HOWEVER THE THROTTLE IS TOTALLY UNRESPONSIVE IN FAILSAFE MODE, THE VEHICLE SLOWS TO A CREEP AND WILL STOP AT THE SLIGHTEST INCLINE. WHEN THE VEHICLE STOPS THE ONLY AVAILABLE OPTION IS TO TURN THE KEY OFF AND RESTART. THE VEHICLE ALWAYS RESTARTS AND RESUMES NORMAL OPERATION AND DRIVEABILTY IS FINE, JUST AS THOUGH NOTHING EVER HAPPENED. THE OCCURRENCE FIRST HAPPENED EARLY IN JANUARY 2010, AGAIN IN LATE JANUARY, THEN IN SEPTEMBER 2010 THEN AGAIN ON FEBRUARY 26 THEN TWICE TODAY FEBRUARY 28 ABOUT 20 MINUTES APART. THE CONSEQUENCES: SCARY, DANGEROUS, HAZARDOUS. FEELS LIKE AN INSURANCE CLAIM AND/OR A LAWSUIT WAITING TO HAPPEN. WHEN A VEHICLE UNDER POWER JUST SHUTS OFF INSTANTLY FOR NO APPARENT REASON IT IS LOGICAL SERIOUS INJURY OR WORSE IS A REALISTIC CONSEQUENCE. 3. WHAT WAS DONE TO CORRECT THE FAILURE: SO FAR JUST A LOT OF FORD GUESSWORK. THE INTERNET HAS A SIGNIFICANT NUMBER OF CONSUMER POSTS REGARDING VARIOUS REPAIRS MADE. THE REPORTED REPAIRS RANGE FROM SENSORS, SPARK PLUGS, COILS, CATS,FILTERS, CONVERTERS AND MORE. THE COMMON THREAD IN THESE CONSUMER REPORTS IS THE PROBLEM STILL EXISTS AND OCCURS RANDOMLY AFTER REPAIR. *TR

FOR THE FOURTH TIME IN THE PAST 2 YEARS THE SUV HAS SHUT DOWN WHILE DRIVING THE VEHICLE. THE DASHBOAD LIGHTS UP, THE STEERING WHEEL LOCKS UP, AND COMPLETELY SHUTS DOWN WHILE IN TRAFFIC. NO WARNING. HAVE TAKEN THE VEHICLE IN TWICE, BUT NO CODES HAVE SHOWN UP ON THE DIAGNOSTICS. THIS IS EXTREMELTY UNSAFE AND COULD RESULT IN A AN ACCIDENT HARMING MY FAMILY, ANOTHER FAMILY OR BOTH. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS EXPERIENCED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO LOCATED A FAILURE WITHIN THE THROTTLE BODY. THE LOCAL MECHANIC CLEANED THE FUEL SYSTEM AND REPLACED THE THROTTLE SENSOR. THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED A SECOND TIME. THE FAILURE MILEAGE WAS 36,849 AND THE CURRENT MILEAGE WAS 92,000.

I WAS DRIVING MY 2006 FORD EXPEDITION & THE FAIL SAFE ENGINE LIGHT CAME ON & THAT STOPS THE GAS PEDAL FROM WORKING. YOU THEN COAST OVER TO THE SIDE OF THE ROAD & TURN THE TRUCK OFF & RESTART IT LIKE NOTHING HAPPENED. THIS HAS HAPPENED 2 TIMES ABOUT 3 MONTHS APART. I HAD THE TRUCK CHECK BY BOB BOYD FORD & THEY SAID IT NEEDED THE THROTTLE BODY & GAS PEDAL SENSOR REPLACED,I CALLED FORD & FILED A COMPLAINT OF HOW DANGEROUS THIS IS, ESPECIALLY IF YOU ARE MAKING A LEFT TURN IN ON COMING TRAFFIC( MY FORD CASE NUMBER [XXX]) I THEN WENT ON A FORD TRUCK FORUM & FOUND THAT MANY OTHERS HAD THE SAME PROBLEM WITH FORD F-150 & EXPEDITIONS ALL 2006 MODELS. A PERSON RECOMMENDED THAT I REPLACE THE THROTTLE POSITION SENSOR ,SO I DID AT BOB BOYD FORD FOR $196.58. I ALSO KEPT THE OLD PART.THE NEW PART IS DIFFERENT IN SIZE & HAS METAL KEY HOLES INSTEAD OF PLASTIC. THE FAIL SAFE ENGINE IS ONLY SUPPOSE TO COME ON IF THE ENGINE COOLANT IS VERY LOW ACCORDING TO THE FORD OWNERS MANUAL, THERE WAS NO REASON FOR IT TO COME ON AT ANY TIME IN MY SUV TRUCK. FORD WROTE ME & THE OHIO ATTORNEY GENERALS OFFICE & SAID THAT I HAVE FIXED THE PROBLEM BY REPLACING THE THROTTLE POSITION SENSOR ON MY OWN & ME PAYING FOR IT ( CASE CLOSED). FORD NEVER SAID ANY THING TO ME ABOUT REPLACING THE THROTTLE POSITION SENSOR TO FIX THIS PROBLEM. AGAIN THEY SAID IT WAS THE THROTTLE BODY & GAS PEDAL SENSOR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS PREPARING TO MAKE A LEFT HAND TURN INTO A BUSY OFFICE COMPLEX, AND THE ENGINE IN MY 2006 FORD EXPEDITION CUT OFF. THE SYSTEM GENERATED CODE WAS 'ENGINE FAILSAFE MODE". I TURNED ON MY HAZARDS, PUT THE CAR IN PARK AND WAITED A FEW MINUTES TO RESTART. THE ENGINE CAR STARTED, BUT THE FACT THAT IT CUT OFF, WITHOUT WARNING IS EXTREMELY ALARMING. I'VE CONTACTED FORD CORPORATE WHO SAID THAT THERE WERE NO RECALLS, AND THAT I NEEDED TO GO TO A SERVICE CENTER. AFTER RESEARCHING THE INTERNET AND THIS SITE, I AM CONVINCED THAT THIS ISSUE SHOULD PROMPT A RECALL, BUT FORD'S COST-BENEFIT ANALYSIS INDICATES THAT IT IS WAITING UNTIL THERE ARE ENOUGH FATALITIES TO MAKE THE DETERMINATION TO FIX WHAT APPEARS TO BE A $600-800 ISSUE. FORD SHOULD BE AND CAN BE HELD LIABLE FOR GROSS NEGLIGENCE IN THEIR DELIBERATE DECISION TO DISREGARD THE ENGINE FAILURE COMPLAINTS. I HAVE BEEN A LOYAL FORD CUSTOMER FOR SEVERAL DECADES. THAT IS NO LONGER THE CASE. *TR

2006 FORD EXPEDITION ON 2/2/11 WHILE I WAS DRIVING ON FREEWAY THE VEHICLE GOES INTO "ENGINE FAIL SAFE MODE." NOT KNOWING WHAT THIS MEANT I WAS GOING TO PROCEED TO EXIT UP AHEAD WHICH WAS AN EXIT UP A HILL. WHEN I STEPPED ON THE GAS I REALIZED THE ENGINE WAS OFF. I WAS ABLE TO MOVE SLIGHTLY TO THE LEFT TO STOP ON THE SHOULDER AT THE BOTTOM OF THE EXIT. THIS IS VERY DANGEROUS AND FORD NEEDS TO MAKE A RECALL BEFORE A LIFE IS LOST! *KB

2006 FORD EXPEDITION SHUTS OFF WHILE DRIVING. EXTREMELY DANGEROUS. CAR WILL START BACK UP WITHOUT ANY PROBLEMS BUT WILL SHUT DOWN SPORADICALLY. *TR

'06 EXPEDITION WENT INTO ENGINE FAIL SAFE MODE AS MY WIFE WAS ATTEMPTING TO MAKE A LEFT HAND TURN CROSSING 2 LANES OF TRAFFIC AT A BUSY INTERSECTION. AFTER COASTING INTO A PARKING LOT, SHE TURNED IT OFF AND TURNED IT BACK ON. IT STARTED RIGHT UP AND SHE WENT ON HER WAY. TOOK IT TO A MECHANIC WHO SAID HE COULD FIND NOTHING WRONG. UPON FURTHER INVESTIGATION, I HAVE FOUND 100'S OF '06 EXPEDITIONS WITH THE SAME PROBLEM AND IT SEEMS TO POINT TO THE THROTTLE BODY. A RECENT AC REPAIR TO THIS CAR WAS ALMOST $800.00 AND NOW I AM HEARING TO REPAIR THE THROTTLE BODY IS UPWARD TO $700-$800. $1500 OF REPAIRS ON A CAR WITH ONLY 45,000 MILES IS UNACCEPTABLE. THE THROTTLE BODY PROBLEM IS VERY DANGEROUS AND FORD SHOULD RECALL THESE CARS AND FIND OUT WHY THIS IS HAPPENING BEFORE SOMEONE GETS HURT OR EVEN WORSE, KILLED. *LN

MY WIFE WAS DRIVING HER 2006 FORD EXPEDITION DOWN A BUSY ROAD AT A SPEED OF ABOUT 40 MPH. SHE WAS DRIVING WITH ANOTHER FRIEND AND OUR 2 CHILDREN (18 MONTHS AND 1 WEEK!) A WRENCH SYMBOL WARNING LIGHT CAME ON AND THE VEHICLE SHUT DOWN. SHE PUT ON HER HAZARDS AND WAS ABLE TO SAFELY COME TO A STOP. SHE TURNED THE IGNITION KEY TO THE OFF POSITION AND THEN WAS ABLE TO START THE ENGINE AGAIN. AFTER TALKING TO A MECHANIC AND DOING INTERNET RESEARCH I FOUND THIS IS A VERY COMMON PROBLEM WHICH CONSISTS OF THE ELECTRONIC CONTROL OF THE THROTTLE. THE FIX IS UPWARDS OF $500; SO A RECALL OF SOMETHING THAT EXPENSIVE CAN EASILY BE BRUSHED UNDER THE TABLE BY FORD. THIS PROBLEM NEEDS TO BE ADDRESSED BY FORD. IF MORE VEHICLES KEEP SHUTTING DOWN ON THEIR OWN SOMEONE WILL SOON BE INJURED OR KILLED. *TR

WAS INVOLVED IN A (3) THREE VEHICLE ACCIDENT IN JANUARY 2011 ON STATE ROUTE 28 ON BLACK ICE CONDITIONS. VEHICLE #1 HIT BLACK ICE AND LOST CONTROL STRIKING MY 2006 FORD EXPEDITION SEVERAL TIMES AND THEN MY EXPEDITION WAS REAR-ENDED BY ANOTHER VEHICLE DURING THE COLLISION. I DID HAVE MY SEAT BELT ON AND LUCKILY WAS NOT SEVERELY INJURED. NEITHER OF MY FRONT AIR-BAGS DEPLOYED AND MY EXPEDITION SUFFERED $14,000 DOLLARS IN FRONT END DAMAGE ALONE. THE AIRBAG SENSOR WAS DAMAGED AND SHOULD OF DEPLOYED THE AIR-BAGS BUT DID NOT. MY VEHICLE WAS REPAIRED BUT REPAIR SHOP AND STATE POLICE WERE BOTH SURPRISED AIR BAGS DID NOT DEPLOY. NOW I AM HAVING PROBLEMS WITH THE AIRBAG SENSOR AS IT LIGHTS UP ALL THE TIME AND NO PROBLEMS CAN BE FOUND WHEN DIAGNOSED. THIS IS A SERIOUS SAFETY CONCERN AND NEED TO BE ADDRESSED. I STILL OWN MY EXPEDITION AND WORRY FOR SAFETY IF ANOTHER COLLISION OCCURS WILL THE AIR-BAGS DEPLOY TO SAVE A LIFE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20-60 MPH, THE SAFE MODE OPERATION ENGAGED AND CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INDEPENDENT MECHANIC FOR DIAGNOSIS, AND NEITHER WAS ABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. THE CURRENT MILEAGE WAS APPROXIMATELY 98,000. THE VIN WAS UNAVAILABLE. .. UPDATED 02-07-13 *BF UPDATED 02/13/2013 *JS

I WAS TRAVELING DOWN THE ROAD HIT BLACK ICE AND THEN SLIDE INTO A TREE HEAD ON. BOTH THE DRIVERSIDE AND PASSENGER SIDE AIRBAGS FAILED TO DEPLOY. I WAS WEARING MY SEAT BELT BUT STILL SUFFERED FACIAL TRAUMA. I RECEIVED SEVERAL SUTURES IN MY LIPS AND THE INSIDE OF MY MOUTH. I THINK FORD SHOULD INVESTIGATE AND DO SOMETHING ABOUT THIS PROBLEM. I FEEL THAT IF MY AIRBAGS WOULD HAVE DEPLOYED I WOULDN'T HAVE SUFFERED THE TRAUMA TO MY FACE. *TR

I AM FILING A COMPLAINT DUE TO MY 2006 FORD EXPEDITION. OVER THE FEW YEARS THAT I HAVE OWNED THE S.U.V., FOR NO APPARENT REASON THE VEHICLE JUST QUITS RUNNING, ENTERS A FAIL SAFE MODE, AND ALL POWER IS LOST TO THE VEHICLE. THIS HAS HAPPENED NOW ON MANY OCCASIONS AND WITHOUT ANY WARNING. ITS HAPPENED ON INTERSTATES, BRIDGES, AS WELL AS CROSSING MULTIPLE LANED HIGHWAYS. THIS IS A TREMENDOUS SAFETY ISSUE THAT NEEDS TO BE ADDRESSED. AT FIRST I THOUGHT MY CASE MIGHT BE ISOLATED, BUT THEN AFTER SOME RESEARCH, I FOUND THAT THOUSANDS ARE HAVING THE SAME PROBLEM WITH THEIR EXPEDITION AS WELL. I FEEL FORD SHOULD FIND THE PROBLEM AND FIX IT BEFORE LIVES ARE DESTROYED. MY WIFE AND CHILDREN ARE IN THIS VEHICLE EVERYDAY. PLEASE IF THERE'S ANYTHING YOU CAN DO.....HELP US!! *TR

2006 FORD EXPEDITION, "ENGINE FAIL SAFE MODE" CAR HAS SHUT OFF WHILE DRIVING 5 TIMES IN THE LAST 6 MONTHS. THE ONLY WAY TO GET THE CAR MOVING IS TO START IT AGAIN. EXTREMELY UNSAFE. THIS VEHICLE WAS COVERED UNDER AN EXTENDED WARRANTY AND HAS GONE IN FOR SERVICE TO CORRECT THE PROBLEM. FORD CANNOT IDENTIFY THE PROBLEM! COMES UP WITH "NO CODE". I'M NOW OFF WARRANTY AND STUCK WITH A VERY UNSAFE VEHICLE! FORD NEEDS TO ADDRESS THIS PROBLEM IMMEDIATELY! *TR

COMPLAINT FILED REGARDING A PERSONALLY OWNED 2006 FORD EXPEDITION XLT, OWNED FROM 2/2010 TO PRESENT (12/2010)> THREE SEPARATE INSTANCES WHEN DRIVING THE VEHICLE WHEN THE "FAILSAFE MODE" WARNING LIGHTS AND ALL LOSS OF VEHICLE CONTROL:STEERING, BRAKES, ACCELERATION, ETC. OCCURRED/ RANDOMLY DURING THIS PERIOD OF OWNERSHIP WITH NO APPARENT REASON. VEHICLE RESTARTED IMMEDIATELY. ALL INSTANCES OF THE CONDITION OCCURRED WHEN OUTSIDE TEMPERATURE WAS BELOW FREEZING (WINTER MONTHS) INTO A RIGHT OR LEFT TURN. NO EVIDENCE OF LOSS OF ANTIFREEZE, ENGINE OVERHEATING, COOLANT LEAKS, ETC. MECHANIC ASSESSMENT COULD NOT FIND A REASON FOR THE ENGINE FAIL SAFE ACTIVATION. THIS IS A SIGNIFICANT, POTENTIAL SAFETY PROBLEM FOR THE DRIVER/PASSENGERS OF 2006 FORD EXPEDITIONS EXPERIENCING THE RANDOM OCCURRING ENGINE FAILURE ATTRIBUTABLE TO THE FAILSAFE FEATURE OF THIS VEHICLE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WOULD ENGAGE INTO SAFE MODE WHEN STARTED, CAUSING THE VEHICLE TO STALL. THE FAILURE WAS RECURRING OVER A THREE YEAR SPAN. THE VEHICLE WAS TAKEN TO A DEALER AND REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE WAS 70,000.

I WAS STOPPED AT A RED LIGHT, CONSTRUCTION TRUCK RAN INTO BACK OF MY 2006 FORD EXPEDITION. THE IMPACT PUSHED ME 20 FEET INTO THE VEHICLE IN FRONT OF ME, SANDWICHING MY VEHICLE IN BETWEEN THE OTHER TWO; THE IMPACT FIRST THREW ME BACK THEN FORWARD & SENT MY GLASSES OFF MY HEAD BUT THE AIRBAG DID NOT DEPLOY. I GOT A CONCUSSION & SHOULDER INJURY DUE TO FORCE. POLICE & MEDICAL PERSONS WERE AMAZED THAT AIRBAG DID NOT DEPLOY. VEHICLE HAD FRONT END & REAR DAMAGE, WAS UNDRIVEABLE & HAD TO BE TOWED AWAY. I AM WAITING TO FIND OUT IF IT WILL BE TOTALED OUT.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE ENGINE FAIL SAFE MODE WARNING LIGHT ILLUMINATED, CAUSING THE VEHICLE TO STALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS 46,000 AND THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS TRAVELING 35 MPH WHEN THE BRAKES ON THE VEHICLE FAILED. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE CONTACT WAS ADVISED THAT THE BRAKE LINES HAD RUSTED THROUGH. THE MANUFACTURER STATED THAT CORROSION DAMAGE TO THE VEHICLE IS WHAT CAUSED THE BRAKE FAILURE. THE CONTACT HAS FILED A COMPLAINT WITH THE MANUFACTURER. THE CONTACT FEELS THAT THE CORROSION SHOULD NOT BE A FACTOR BECAUSE THEY DO NOT LIVE IN A SNOW ENVIRONMENT. THE FAILURE MILEAGE 66710 AND THE CURRENT MILEAGE 68000.

I WAS DRIVING 45 MILES AN HOUR DOWN A MAJOR HIGHWAY WHEN MY ENGINE IN MY 2006 FOR EXPEDITION JUST SHUT DOWN WITHOUT WARNING AND WENT INTO "FAIL -SAFE MODE". THANK GOD I WAS ABLE TO CROSS 3 LANES OF TRAFFIC WITHOUT INCIDENT TO GET TO THE SHOULDER. I SHUT OFF MY CAR AS THE MANUAL TOLD ME TOO. AFTER 20 MINS I WAS ABLE TO RESTART THE CAR. I DROVE TO THE NEAREST DEALERSHIP SO THEY COULD LOOK INTO THE ISSUE. IT WAS DIAGNOSED AS NEEDING A REPLACEMENT THROTTLE BODY. WHEN I ASKED "WHAT HAPPENED? WHY DID THIS HAPPEN?", I WAS TOLD "IT JUST HAPPENS," AND "THERE IS NOTHING PREVENTATIVE THAT CAN BE DONE.". CONVENIENTLY THIS PART WAS NOT COVERED BY MY 100,000 MILE POWERTRAIN WARRANTY THAT FORD IS SO PROUD OF ON ITS USED VEHICLES. THIS REPAIR COST ME $609. THE NEXT DAY I DID SOME RESEARCH AND FOUND NUMEROUS COMPLAINTS ON THE EXACT SAME ISSUE FOR THE SAME MAKE AND MODEL (2006 FORD EXPEDITION) ON THE FOLLOWING WEBSITE: HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2006/FORD/EXPEDITION/ENGINE+AND+ENGINE+COOLING+SYSTEM . I CALLED THE SERVICE MANAGER TO DISCUSS AND HE AGREED HE HAS BEEN SEEING ALOT OF THESE THROTTLE BODY REPLACEMENTS AND ENGINE SHUTDOWNS ON THIS MODEL AND AGREES A RECALL NEEDS TO BE DONE BEFORE SOMEONE GETS SERIOUSLY HURT. I AM JUST THANKFUL MY 3 KIDS WERE NOT IN THE CAR WITH ME AND PRAY THIS DOESN'T HAPPEN AGAIN. THE SERVICE MANAGER GAVE ME THIS WEB ADDRESS TO MAKE AN OFFICIAL COMPLAINT, HOPING A RECALL WOULD TAKE PLACE. *TR

WITH NO WARNING, MY 2006 FORD EXPEDITION WILL LOSE ALL POWER WHILE DRIVING. THE LIGHT ON THE CONTROL PANEL COMES ON SAYING "ENGINE FAIL SAFE MODE." AFTER COASTING TO THE SIDE OF THE ROAD, I RESTART THE CAR AND ALL IS FINE. I HAVE TAKEN IT TO TWO MECHANICS AND THEY SAY THERE IS NOTHING WRONG WITH THE CAR. IT HAS HAPPENED TWICE SO FAR. *TR

MY FAMILY (ME, WIFE AND TWO CHILDREN) WERE ON OUR WAY HOME FROM A RESTAURANT. WE NORMALLY TAKE THE HIGHWAY BUT DECIDED TO TAKE THE SIDE ROAD HOME AND THANK GOD. DRIVING 45 MPH THE "ENGINE FAIL SAFE MODE" CAME ON AND IT COMPLETELY SHUT OFF. I PULLED OVER TO THE SIDE OF THE ROAD AND TURNED THE ENGINE OFF. AFTER A FEW MINUTES, I RESTARTED THE VEHICLE AND IT STARTED FINE AND NO WARNING SIGNS.THIS IS THE FIRST TIME IT OCCURRED BUT I DO NOT WANT THIS TO HAPPEN AGAIN. THE VEHICLE IS INSIDE THE GARAGE AND I'M CALLING THE DEALERSHIP TOMORROW TO MAKE AN APPOINTMENT. THIS IS A FAMILY CAR AND WE ARE ALWAYS ON THE HIGHWAY. THIS IS A FATAL FAIL THAT NEEDS TO BE CORRECTED. THIS FAILURE OCCURRED AT 61,408 MILES. I CHECKED THE FORD WEBSITE AND THERE IS NO RECALL. HOWEVER, THERE ARE NUMEROUS COMPLAINTS ON THE INTERNET FOR THE SAME ISSUE. I'M AFRAID FOR MY WIFE AND CHILDREN WHILE THEY ARE OPERATING THIS VEHICLE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING UNDER 20 MPH WHEN HE APPLIED THE BRAKES. THERE WAS AN INCREASE IN ENGINE RPMS AND THE VEHICLE ABNORMALLY ACCELERATED. THE BRAKE PEDAL WAS APPLIED WITH FORCE AND THE VEHICLE CONTINUED TO ACCELERATE. WHEN THE GEAR SELECTOR WAS SHIFTED INTO THE NEUTRAL POSITION, THE VEHICLE CAME TO A COMPLETE STOP. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS ABLE TO RESUME NORMAL OPERATIONS. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 44,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE ENGINE FAIL SAFE MODE ACTIVATED WITHOUT WARNING WHILE THE VEHICLE WAS BEING DRIVEN, CAUSING THE VEHICLE TO STALL. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES AND THEY HAD NOT BEEN ABLE TO DUPLICATE THE FAILURE. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 77,000.

MY 2006 FORD EXPEDITION HAS SHUT OFF MULTIPLE TIMES SINCE THE SUMMER OF 2010. IT WAS SERVICED IN THE SUMMER OF 2010 AND RAN FINE FOR A WHILE. IN 2011, IT STARTED CUTTING OFF AT RANDOM TIMES. I COULD BE AT A STOP LIGHT, INTERSECTION, DRIVING, OR TURNING THE CORNER. I HAVE HAD THE VEHICLE TESTED ABOUT 3 TIMES OVER THE LAST YEAR AND NO ONE CAN SEEM TO FIGURE OUT THE PROBLEM. THE SCARIEST INCIDENT HAPPENED WHILE I WAS MAKING A LEFT TURN AT A BUSY INTERSECTION AND THE VEHICLE SHUT OFF AND THE POWER STEERING WENT OUT. I TURNED ON THE HAZARD LIGHT, PUT THE CAR IN PARK AND STARTED IT VERY QUICKLY. THE VEHICLE STARTED UP WITH NO PROBLEM. LUCKILY NO ONE WAS BEHIND ME OR COMING TOWARDS ME. THIS PROBLEM NEEDS TO BE FIXED. I HAVE READ MULTIPLE POST ABOUT THIS PROBLEM AND FORD HAS NOT RECALLED THE VEHICLE YET. PLEASE HELP! *TR

TL* CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING AT 50 MPH, THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT IT STALLED A SECOND TIME WITHIN SECONDS. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE CONTACT WAS ABLE TO LOCATE NUMEROUS COMPLAINTS REGARDING THE THROTTLE CONTROL AND BELIEVED IT TO BE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 80,000.

I HAVE A 2006 FORD EXPEDITION AND MY WIFE ALMOST LOST CONTROL AND HIT A CAR WHEN THE BRAKES WENT TO THE FLOOR. THE VEHICLE HAS HAD "SPONGY BRAKES" SINCE I BOUGHT IT AND HAD IT TO THE DEALER TWICE. THERE IS A TSB TO REPLACE THE FRONT CALIPER/ROTOR AND PADS AND FORD DID THIS BUT IT STILL FEELS SPONGY AND IS NOW LEAKING FLUID. THIS HAS BEEN AN ISSUE ON MANY EXPEDITIONS AND SHOULD HAVE BEEN A RECALL RATHER THAN A TSB. THIS IS AN INCREDIBLY DANGEROUS SITUATION WHEN THE BRAKES FAIL. I KNOW I HAVE HAD INSTANCES WHERE I LITERALLY NEED TO STAND ON THE BRAKES TO GET THE VEHICLE TO STOP. *TR

MY WIFE, THREE KIDS AND MYSELF WERE IN OUR 2006 FORD EXPEDITION LIMITED COMING DOWN A MOUNTAIN PASS IN LAKE TAHOE WHEN ALL OF A SUDDEN THE ENGINE STOPPED! A CODE ON THE DASH READ "FAIL SAFE ENGINE MODE". THE STEERING WHEEL LOCKED AND THERE WAS NO POWER, NO ACCELERATION. I WAS LUCKY TO PULL TO THE SIDE OF THE ROAD. THE FOLLOWING DAY, I TOOK THE TRUCK TO THE CARSON CITY, NV FORD DEALER AND PAID FOR A DIAGNOSTIC. NOTES FROM DEALER: ROAD TEST COULD NOT VERIFY. PERFORMED EEC SELF TEST, HAS CODE P0104. PERFORMED WIGGLE TEST AND PINPOINT TESTS. PERFORMED RECORDER-MONITOR TEST ALL THE PIDS LOOKED GOOD. REMOVED THE MAF SENSOR. HAS DEBRIS ON THE MAF SENSOR WIRES. RECOMMEND A NEW MAF SENSOR." I PUT IN A NEW MAF SENSOR AND AIR FILTER. IN DRIVING LESS THAN 3 MILES AFTER THIS WAS DONE, THE TRUCK DID THE SAME THING. THE "FAIL SAFE ENGINE MODE" CAME ON, LOSS OF POWER AND ACCELERATION. I HAD TO TURN THE TRUCK OFF COMPLETELY, REMOVE KEY AND RESTART. THEN THE TRUCK DID NOT HOLD THE IDLE AND DIED. AFTER A SECOND TIME, THE TRUCK RESTARTED. I AM STILL DRIVING WITH THE CHECK ENGINE LIGHT OFF AND HAVE ANOTHER APPOINTMENT WITH THE FORD DEALER TOMORROW MORNING (6-24-10) TO SEE WHAT IS GOING ON. WE ARE SUPPOSED TO LEAVE TOMORROW AND DRIVE 1100 MILES TO RETURN TO DENVER. *TR