2007 Ford Expedition Engine Problems

I HAVE TO REPLACE SPARK PLUGS EVERY WEEK. THE ENGINE EITHER KEEPS MAKING THE PLUGS FOUL OUT, OR IT BURNS THE TIP RIGHT OFF THE ENGINE. I'M STARTING TO SEE FROM THE COMPLAINTS THIS IS A COMMON ISSUE. I DON'T FEEL SAFE DRIVING THE VEHICLE WITH MY 6 KIDS BECAUSE OF HOW BAD IT KEEPS MISSING AND TRYING TO DIE. I CHANGE PLUGS THEN DRIVES WELL FOR ABOUT A WEEK.

ENGINE STARTED MAKING NOISE. PULLED IT A PART AND FOUND THE COMMON 5.4 LITER PROBLEM. THE CAM LOBS WAS EATEN UP ROLLER HAD FROZEN UP AND EATEN CAM UP AND TAPET HAS WENT BAD ALSO. VECH WAS IN USE WHEN THIS STARTED.

CAR HAS ALWAYS BUCKED AND TRUCK AND TRIED TO CATCH UP TO IT SELF. NOW I HAVE A TICKING SOUND COMING FROM UNDER MY HOOD. TICKING STAYS THE SAME RUNNING LOW RPM OR AT A HIGHER RPM.

DELEVOPED A TICKING NOISE TIMING CHAINS WERE REPLACED ALL ROCKERS AND LIFTERS ARE IN GOOD SHAPE THE TRUCK LOOSES POWER IT STARTS UP ROUGH AT ABOUT 1800 RPM YOU CAN HEAR THE TICKING LOUD PAST 2000 RPM THE TICKING GOES AWAY I HAVE RECENTLY BEEN NOTIFIED THAT THESE ENGINES HAVE CAM PHASER PROBLEMS IT RECENTLY DEVELOPED A P0022 CODE WHICH IS INT CAM POSITION TIMING OVER RET BANK 2 I HAVE REPLACED THE VVT SELONOIDS AND STILL HAS THE SAME PROBLEM VEHICLE LOST POWER ON HIGHWAY SPEED DROPPED FROM 70 AND WOULD NOT GO PAST 30 VERY UNSAFE INCEDENT ON THE INTERSTATE

THE ENGINE HAS CAUSED THE VEHICLE TO HAVE COMPLETE LOSS OF POWER. IT IS STALLING OUT AND WILL NOT DRIVE AT ALL.

MY TRUCK WAS PURCHASED NEW AND I HAVE RECENTLY HAD MORE FUEL GAS WASTE QUICKLY IN THE PAST YEAR. I RECENTLY HAD THE FUEL LINE CHANGED IN JUNE 2017 BECAUSE A SPARK PLUG BURNT OUT AND CAUSED IT TO HAVE A LEAK THAT WAS DANGEROUSLY CLOSE TO THE GAS TANK. I HAVE 123K MILES ON IT AND THE CHECK ENGINE LINE COMES ON EVERY TIME AFTER HALF A GAS TANK IS DONE. I HAD THE TRUCK DRIVING AND IT SHUTS OFF ON ITS OWN. SOMETIMES IT WILL HAVE A STRONG SHAKING OF THE MOTOR OR NO WARNING AT ALL WHILE DRIVING ON THE ROAD. I'M VERY CONCERNED BECAUSE WE THOUGHT IT WAS THE CAMSHAFT WHICH IS WHAT THE ERROR CODE POPS UP AND THE SPARK PLUGS AND COILS HAVE BEEN REPLACED. EVERY THING ELSE HAS BEEN MAINTAINED BUT I'M STILL HAVE THE ENGINE AND FUEL PROBLEM. THE GAS GOES SO FAST AND THIS IS A V8 WHERE I USUALLY DRIVE A 6 MILE TO WORK NOW SAYS IT HAS BEEN A 40 MILE DRIVE. DON'T KNOW WHAT ELSE TO DO AND MAY TAKE IT BACK TO TRADE FOR ANOTHER VEHICLE BRAND. I HAD TO PARK THE TRUCK AFTER IT SHUT OFF ON ME AGAIN ON A SIDE STREET BEFORE GETTING ON THE HIGHWAY.

I HAVE THE 5.4 ENGINE IN MY 2007 FORD EXPEDITION WITH ONLY 70,000 MILES WHICH I PURCHASED IN 2007. I AM NOW EXPERIENCING CAM SENSOR PROBLEMS, THROTTLE BODY PROBLEMS AND NEED MAJOR REPAIRS. I HAVE VISITED MANY SITES AND UNDERSTAND THAT FORD HAS BEEN SUED BECAUSE OF COMPLAINTS WITH THIS PARTICULAR ENGINE AND NOTHING CAME FROM THIS SUIT. THIS STARTED AROUND 2-3 WEEKS AGO, I HAD BEEN TRAVELING FOR 2-1/2 HOURS AND JUST PULLED OFF THE HIGHWAY TO ENTER INTO MY HOUSING PLAN, WHEN MY CAR LOST RPMS, BECAME VERY ROUGH, AND THEN STALLED. WHEN THE VEHICLE IS ON OPEN IT ROAD IT RIDES GREAT UNTIL YOU SLOW DOWN AND THE RPM FALLS, THEN IT STUMBLES AND STALLS. I HAD AT THE DEALERSHIP A COUPLE OF TIMES, BUT UNTIL CHECK ENGINE LIGHT CAME ON, I COULD NOT GET IT DIAGNOSED. OVER THE WEEKEND THE CHECK ENGINE LIGHT FINALLY LITE AND AS I STATED IT IS THE CAM POSITION SENORS AND STATES THAT THE SYSTEMS TOO RICH. I TALKED WITH A FORD REP TODAY AND THIS WILL BE ABOUT A $2000 REPAIR BILL, BUT UNTIL I CAN GET IT TO THEM AND THEY PLACE ON THEIR COMPUTER, THEY CANNOT GIVE ME THEIR FINAL ESTIMATE IF IT CAN BE REPAIRED OR I NEED A NEW ENGINE. I HAVE MANY MISGIVINGS ABOUT THIS SINCE ALL THAT I HAVE READ ON THE INTERNET ABOUT ALL THE PROBLEMS WITH THIS PARTICULAR ENGINE. FORD SHOULD BE HELD ACCOUNTABLE FOR A FAULTY ENGINE, AND BUYERS SHOULD BE MADE AWARE OF THIS PROBLEM ESPECIALLY WHEN THEY ARE BUYING A USED VEHICLE FROM A FORD DEALERSHIP WHO IS DEFINITELY AWARE OF THIS PROBLEM.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING, THE CONTACT STATED THAT THE OUTSIDE TEMPERATURE GAUGE DISPLAYED 106 DEGREES. THE CONTACT STATED THAT THE PASSENGER SIDE FLOOR BOARD WAS EXTREMELY HOT TO THE TOUCH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THERE WAS NO HEAT SHIELD COVERING THE CATALYTIC CONVERTERS. THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 122,700.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS, AN ABNORMAL NOISE WAS HEARD FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CAM PHASER FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A STRONG FUEL ODOR COMING FROM THE FRONT PASSENGER SIDE. WHILE DRIVING THE VEHICLE, THE CONTACT NOTICED THE SMELL OF FUEL IN THE VEHICLE AND THE FUEL MILES PER GALLON DROPPED. AFTER FURTHER INSPECTION OF THE ENGINE, THE CONTACT NOTICED THAT FUEL WAS LEAKING FROM THE FUEL RAIL ON THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 97,500. ..UPDATED 02/01/16 *BF *JS

2007 FORD EXPEDITION. BEGAN TO SPIT AND SPUTTER GOING 45MPH. ENGINE LIGHT CAME ON. TOOK TO AUTO SHOP FOR REPAIR. COST WAS $1,100 TO REPLACE 8 SPARK PLUGS AND WIRES. FORD USED A DEFECTIVE SPARK PLUG IN THIS VEHICLE. THE PLUG BREAKS OFF IN THE ENGINE WHEN REMOVING THEM. FORD KNEW OF THE ISSUE AND DID NOTHING ABOUT IT. THIS ISSUE WITH THESE PLUGS BEGAN IN EARLY 2000'S. FORD SHOULD HAVE RECALLED THESE PLUGS LONG AGO. THERE ARE MANY CLASS ACTION LAWSUITS ONGOING RELATED DIRECTLY TO THE FAULTY SPARK PLUG. IF I HAD KNOW ABOUT THE PLUGS BEFORE I BOUGHT THE TRUCK, I WOULD HAVE HAD FORD REPLACE THEM BEFORE I EVEN DROVE IT. *TR

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

MILLIONS OF.COMPLAINTS ON. INTERNET ABOUT THIS VEHICLE AND ITS BACKFIRING ENGINE AND CONSTANTLY REPLACING SPARK PLUGS. CR THROTTLES.ALOT NO MATTER HOW MANY TIMES FIXED. PULLS NO MATTER WHAT PROBLEM YOU FIX THE NEXT ONE EMERGE. TYPICAL VEHICLE PROBLEMS FOR THESES OWNERS. SO MUCH MONEY. *TR

WHILE DRIVING ON THE INTERSTATE OR FWY AT ABOUT 55-60 MPH - I START TO INCREASE IN SPEED, WHILE GOING WITH THE FLOW OF TRAFFIC MY EXPEDITION EDDIE BAUER MODEL SPURTS/HESITATES/LOSES POWER "BUT NEVER CUTS OFF" EVERY TIME BEFORE THE SPEED INCREASES. WE TOOK IT TO THE FORD DEALER SEVERAL TIMES AN THEY ARE UNABLE TO DETERMINE WHAT IS WRONG WITH THE VEHICLE. THE FORD DEALER TOLD US THEY CAN'T DO NOT ABOUT IT UNTIL THE ENGINE LIGHT COMES ON. WE SUGGESTED TO THE FORD DEALER THAT IT MAYBE THE FUEL FILTER OR O2 SENSOR BUT THEY TOLD US THIS MODEL VEHICLE DOES NOT HAVE A FUEL FILTER AND OUR O2 SENSORS ARE GOOD. MY ISSUE IS WHY SHOULD I HAVE TO WAIT TILL THE VEHICLE BREAKS DOWN WHEN IT DOES THIS ALL THE TIME. *TR

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE SPARK PLUGS DETACHED FROM THE VEHICLE AND HAD TO BE REMOVED BY THE DEALER USING A SPECIAL TOOL. THE CONTACT STATED THAT THE SPARK PLUGS HAD BECOME STUCK. THE FAILURE AND THE CURRENT MILEAGE WAS 130,000.

I WENT TO PICK MY SON UP FROM DRIVERS ED AND WE WERE LEAVING THE PARKING LOT AND THE VEHICLE DIED. I WAITED A LITTLE AND THEN RESTARTED IT AND IT STARTED BUT IT WAS ROUGH. I THEN CONTINUED TO DRIVE MY WAY BACK HOME AND IT WAS DRIVING ROUGH AND NO LIGHTS CAME ON INDICATING I HAD A PROBLEM. I WAS DRIVING DOWN THE ROAD AND IT DIED AGAIN SO I HAD TO JUST LET IT COAST TO GET OFF THE STREET. LUCKILY I WAS ABLE TO COAST INTO DELON AND SON'S SECOND DRIVEWAY (REPAIR SHOP). I WAITED FOR THEM TO COME HELP AND WHEN THE REPAIR MAN CAME OUT HE WAS ABLE TO START IT AND TOLD ME HE WAS GOING TO RUN SOME TEST ON IT TO SEE WHAT WOULD HAVE CAUSED IT. AFTER 2HRS HE CAME AND SAID THAT IT INDICATED IT WAS THE FUEL PUMP, BUT THAT IT SHOWED IT FIXED ITSELF SO HE WANTED TO TEST DRIVE IT BEFORE I WOULD GO HOME......WELL NOT EVEN TWO MINUTES AFTER HE LEFT HIS COWORKER CAME IN AND SAID THAT HE JUST BROKE DOWN IN MY VEHICLE. SO HE BUMPED UNDER THE TANK AND IT STARTED BACK UP. SO THIS TO HIM INDICATED THAT IT WAS FOR SURE THE FUEL PUMP. I LEFT IT FOR THEM TO FIX IT AND WHEN IT WAS DONE HE CALLED ME AND TOLD ME THAT.....I WAS VERY LUCKY THAT IT DIDN'T EXPLODE BECAUSE THE WIRES WERE MELTED ON THE FUEL PUMP AND HE HIMSELF SAID THAT HE WAS LUCKY SINCE HE TEST DROVE IT AS WELL. I DOUBT FORD WOULD PAY FOR THIS FUEL PUMP FAILURE IT SEEMS TO BE A COMMON PROBLEM WHEN YOU LOOK ON-LINE. MY TOTAL BILL FOR THIS WAS $790.00 OUCH :( CONSIDERING WE ARE IN THE PROCESS OF ADOPTING A CHILD. *TR

DEALER WANTS $800 TO CHANGE SPARK PLUGS AS THEY WILL BREAK OFF IN ENGINE. BECAUSE A DIS SIMILAR METAL WAS USED. EXHAUST MANIFOLD BOLTS BREAK AND CAUSE LOUD EXHAUST LEAK AT THE REAR OF THE EXHAUST MANIFOLD DEALER WANTS $850 TO FIX. *JS

THE VEHICLE BEGAN TO IDLE REAL ROUGH TO THE POINT OF BOUNCING IN AN UNCONTROLLED MANNER. A KNOCKING NOISE STARTED COMING FROM THE ENGINE. WHEN YOU TRIED TO INCREASE SPEED TWO CYLINDERS MISSED. WHEN THE VEHICLE WAS MANUFACTURED INCORRECTLY, IT CAUSED THE OIL TO BE DISTRIBUTED UNEVENLY THROUGH THE ENGINE AND THE ENGINE TO HEAT UNEVENLY. THIS STARVATION OF OIL OVER TIME TO THE ENGINE ALLOWED FOR METAL TO SHRED AND CONTAMINATE THE ENGINE AND THE ENGINE HAS TO BE REPLACED IN A 5 YEAR OLD CAR. IF THE ENGINE IS NOT REPLACED THE CONDITIONS WOULD CONTINUE TO INTENSIFY AND THE OUTCOME IS UNKNOWN. AFTER INVESTIGATION INTO THE PROBLEM I LEARNED THAT FORD HAD SENT OUT A TECHNICAL ADVISORY BULLETIN TO HELP SERVICE DEPARTMENTS IDENTIFY THE PROBLEM SO OBVIOUSLY THIS IS NOT A ONE TIME BASED FAILURE. *TR

THE 5.4L ENGINE HAS A TAPPING NOISE COMING FROM THE TOP HALF OF THE MOTOR ON THE PASSENGER SIDE. IT OCCURS WHEN THE ENGINE IS IDLING AT A STAND STILL. IT HAPPENS RANDOMLY. HAVE BEEN SPEAKING WITH FORD WARRANTY AND DEALERS TRYING TO GET FIXED AND BECAUSE IT IS INTERMITTENT THEY DO NOT WANT TO WORK ON. WE HAVE TAKEN TO 2 DEALERS A TOTAL OF 3 TIMES AND SPOKEN WITH FORD WARRANTY AND THEY REFUSE TO PAY TO HAVE THE MOTOR OPENED UP AND LOOKED AT. *TR

I PURCHASED A 2007 FORD EXPEDITION WITH A 5.4 TRITON ENGINE IN FEBRUARY 2008 THAT WAS STILL UNDER WARRANTY. THE CAR STARTED HERE LATELY TO MISFIRE AND JUMP AND STALL. I PURCHASED SPARK PLUGS AS I DO WITH ALL MY VEHICLES. UPON REMOVAL OF THE ORIGINAL PLUGS THEY BREAK OFF IN THE MOTOR OR THE HEAD WHICH THEN COST LOTS MORE MONEY TO REPLACE. UPON SPEAKING TO AND RESEARCHING ON THE INTERNET THIS PLUG DESIGN IS A FLAW WITH ALL THE ENGINES THAT FORD HAS DESIGNED. EVERY PERSON WHO HAS HAD TO REPLACE THESE PLUGS HAS ENCOUNTERED THIS AWFUL AND COSTLY FLAW WHICH FORD SHOULD BE ACCOUNTABLE FOR. AS I WILL AS WELL AS MANY CONTINUE TO PAY FOR THE POOR WORKMANSHIP AND DESIGN THAT FORD SHOULD BE LIABLE FOR. IN THESE DAY AND TIMES AND WITH THE WIDE VARIETIES OF MASS COMMUNICATIONS, I WILL NEVER AND ENCOURAGE MY FRIENDS TO NEVER BUY A FORD VEHICLE AGAIN. I HAVE FOUR KIDS AND THIS IS A COST THAT WE CANNOT STAND FOR. I WILL GO TO THE HOUSTON TEXAS MEDIA WITH THIS AS WELL. AS I AM SURE IN THE HOUSTON AREA MANY MANY MANY CONSUMERS HAVE THESE SAME ISSUES. *TR