There are 11 stored owner reports matching the electrical system leading-label group for the 2003 Ford Explorer Sport Trac in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 11 of 11 matching reports.
Open the full vehicle complaint log (all categories)TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE IGNITED IN FLAMES WHILE PARKED IN THE DRIVEWAY. THE CONTACT DID NOT DISCLOSE HOW THE FIRE WAS EXTINGUISHED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.
RUSTING WIRES ON THE DRIVERS SIDE STEP PLATE. *TR
RUSTING WIRES UNDER THE DRIVERS SIDE STEP PLATE. *TR
TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE ABNORMALLY DECELERATED TO 40 MPH. IN ADDITION, THERE WAS SMOKE COMING FROM THE FRONT END OF THE VEHICLE. THE CONTACT WAS INFORMED BY ANOTHER DRIVER THAT SPARKS WERE COMING FROM UNDER THE VEHICLE. THE CONTACT MANEUVERED THE VEHICLE TO THE SHOULDER AND DISCOVERED THAT THERE WERE FLAMES UNDER THE DRIVER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW YARD AND WAS NOT REPAIRED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 182,000.
SITTING AT A STOP SIGN VEHICLE WENT INTO ACCELERATION GAS PEDDLE WENT TO FLOOR. FOOT WAS ON THE BRAKE. CHECKED NO CARPET STUCK UNDER THE GAS PEDDLE. FOOT WAS NOT TOUCHING GAS PEDDLE. IT WAS ALMOST LIKE THE CRUISE CONTROL WAS PRESSING THE GAS PEDDLE. CRUISE CONTROL WAS OFF. SHUT VEHICLE OFF THEN BACK ON ISSUE WENT AWAY. THIS HAS HAPPENED OTHER TIMES TO MYSELF AND MY WIFE. SOMETIMES WHILE PUSHING THE GAS THE GAS PEDDLE LEAVES YOUR FOOT AND CONTINUES TO THE FLOOR ON ITS OWN, PRESSING THE BRAKE AND TURNING VEHICLE OFF SEEMS TO RESOLVE THE ISSUE. THIS ISSUE HAPPENS SO IN FREQUENTLY THAT IT IS HARD TO REPRODUCE FOR SERVICE SHOP. *TR
WHEN I PULL DOWN MY STEERING WHEEL, THE LEFT BLINKER DOES NOT WORK NEITHER DOES THE BRAKE LIGHTS. IF THE WHEEL IS UP EVERY THING WORKS. *TR
VEHICLE ENGINE STOP WHILE DRIVING ON THE ROAD. DRIVING AS NORMAL, APPROX 30 MPH WHEN VEHICLE JUST STOPS. EXTREMELY DIFFICULT TO STEER OR BRAKE. PERFECT WEATHER, NO ENVIRONMENTAL ISSUES--NORMAL TEMPERATURE, ETC. INCIDENT OCCURRED TWICE, APPROX ONE YEAR APART. TOOK INTO REPAIR SHOP TO DIAGNOSE, NO CODE LEFT ON COMPUTER. *TR
ANTS HAVE EATEN INTO THE COMPUTER ON MY 1994 FORD EXPLORER LAST YEAR . THIS YEAR EVEN THOUGH I PUT OUT POISON ON THE GROUND AND SPRAYED THE MOTOR AND INSIDE OF BOTH VEHICLES THEY GOT INTO THE DASH OF MY 03 AND STARTED EATING THE (LOOMS) WHAT EVER THAT IS AND THE WIRING TO MY AIR BAGS. HAS ANYONE ELSE HAD THIS PROBLEM AND WHAT DID THEY DO TO STOP IT? WHAT ARE THEY MAKING THE WIRING OUT OF. *NM
DT: THE CONSUMER STATED THAT 2003 FORD EXPLORER SPORT TRAC SPECIAL EDITION WITH AVALANCHE ON THE BACK WAS HAVING A STALLING PROBLEM. THE ANTI-THEFT DEVICE LIGHT BLINKED ON THE DASHBOARD, AND THEN THE VEHICLE SHUT OFF THE POWER. THE CONSUMER TOOK THE TRUCK TO THE REPAIR SHOP SEVEN TO EIGHT TIMES FOR THIS PROBLEM. THE TRUCK HAS BEEN IN THE SHOP LONGER THAN IT HAS BEEN WITH THE CONSUMER. THE DEALERSHIP PUT THE EDR ON THE TRUCK, AND FOUND NO INFORMATION. THE TRUCK STALLED WHEN THE LIGHT CAME ON. THE DEALERSHIP WAS STUNNED BECAUSE THEY COULD NOT FIGURE OUT WHAT THE CAUSE OF THE PROBLEM WAS. THE CONSUMER WAS AFRAID TO DRIVE THE VEHICLE. HE TRIED TO TRADE THE TRUCK IN FOR A NEW VEHICLE, BUT THE DEALERSHIP WOULD NOT GIVE THE CONSUMER ENOUGH MONEY FOR THE TRUCK. THE DEALERSHIP TOLD THE CONSUMER THAT THEY DID NOT WANT THE TRUCK AND WOULD BE AFRAID TO SELL THE TRUCK TO SOMEONE ELSE. THERE HAVE BEEN ENGINEERS FROM FORD TO EXAMINE THE TRUCK AND STILL NO ONE COULD FIGURE OUT THE PROBLEM. SPEED WAS 30 MPH AND UNDER. THE CONSUMER CONTACTED FORD PERSONALLY, AND THEY WERE AWARE OF THE PROBLEM. *AK
ON JULY 28 WHILE MY WIFE WAS DRIVING OUR NEW EXPLORER SPORT TRAC IT JUST STOP RUNNING. SHE STARTED IT UP AND IT RAN FOR ABOUT 1MIN THEN CUT OFF AGAIN STRANDING HER IN THE MIDDLE OF A HIGHWAY IN A TURN LANE WE REPORTED IT TO FORD IT TOOK OVER 2 HRS FOR THEM TO GET A TOW TRUCK TO TOW THE TRUCK TO THE DEALER IT ALSO HAPPENED ON THE 27TH. ALSO THE OWNERS MANUAL PAGES ARE NOT RIGHT WHEN YOU LOOK AT ABOUT HOW TO CHANGE A TIRE IT GIVE YOU A PAGE NUMBER AND IT SHOWS SOMETHING ELSE LIKE HOW TO CHANGE OIL.*AK
JUNE 2, 2003 6:40 PM PICKED UP THE BRAND NEW EXPLORER SPORT TRAC FROM TREADWELL FORD AND DROVE HOME TO WEST MOBILE. JUNE 3, 2003 7:20 AM DROVE THE NEARLY 30 MILE COMMUTE TO WORK IN NORTH MOBILE COUNTY. UPON PARKING THE VEHICLE, IT SMELLED HOT, WITH A NEARLY BURNT ELECTRICAL SMELL. JUNE 3, 2003 ~8:40 PM LEFT WORK AFTER LONG DAY. DROVE APPROXIMATELY 3 MILES, WHEN RADIO CONSOLE WENT BLACK. SHORTLY THEREAFTER, ENTIRE DASHBOARD PANEL LIGHTING, HEADLIGHTS, AND ELECTRICAL SYSTEM STARTED TO ACT ERRATICALLY. PULLED INTO BP GAS STATION, AND VEHICLE COMBUSTION SYSTEM BEGAN TO SPUTTER. BRAKED TO STOP VEHICLE MOTION TEMPORARILY, AND VEHICLE SEEMED TO ACT DRIVABLE AGAIN. ATTEMPTED TO LEAVE BP STATION, BUT VEHICLE STOPPED AND WOULD NOT RESTART. NEEDED ASSISTANCE TO PUSH VEHICLE OUT OF ENTRANCE TO HIGHWAY 43. CREOLA POLICE OFFICER AND ANOTHER MAN WHO BOTH ASSISTED WITH PUSHING THE VEHICLE WHILE I STEERED IT STATED BRAKE LIGHTS WERE ACTING ERRATICALLY. JUNE 4, 2003 ~8:50 AM TALKED WITH DON DAVIS IN TREADWELL FORD SERVICE AND EXPLAINED WHAT HAD HAPPENED LAST NIGHT. JUNE 4, 2003 ~5:30 PM DON DAVIS LEFT A MESSAGE AT MY HOME THAT THEY WERE WORKING ON THE VEHICLE BUT COULD NOT FIND ANY PROBLEM. JUNE 5, 2003 ~11:30 AM DON DAVIS LEFT A MESSAGE AT MY HOME THAT BY DRIVING THE VEHICLE AROUND, HE WAS ABLE TO REPRODUCE WHAT HAPPENED TO ME THE EVENING OF JUNE 3. JUNE 5, 2003 ~5:30 PM DON DAVIS LEFT A MESSAGE THAT THE VEHICLE WAS READY TO BE PICKED UP AS THE ALTERNATOR HAD BEEN REPLACED. *NLM
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 29, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.