2017 Ford Explorer Complaint Log

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, there was an excessive amount of white smoke coming from the exhaust. The driver pulled over to the shoulder of the roadway. The vehicle was taken to an independent mechanic, who diagnosed a failure with the turbo charger. The vehicle was not repaired. The contact stated that the two turbo chargers had previously been replaced 16,000 miles prior to the failure. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 91,000.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

1. The cylinder head gasket (2.3L Eng Standard EJ7Z-6079-F) had cracked due to a problem that my mechanic said was common for engines of this make / year. 2. If this had not been fixed could have damaged the cylinder head and totaled the vehicle, is my understanding. 3. Yes 4. No 5. I noticed the engine felt different and the check engine light was sporadically on and off. First occurred Nov, 2024.

The transmission stops switching gears after going 70 mph on the highway no acceleration was possible Just stopped working. I had my kids with me I had a tractor trailer behind me and in front of me and beside me on a very busy highway going 70 mph and the transmission just stopped working no gas was it was just redlining when it was supposed to be accelerating no gears were reached I had to throw it in park throw it back into sports mode they're back into drive they're back into sports mode they're back in the drive before it kicked in and would go all while in the middle of a busy highway and not able to get off the road and declining in speed. The manufacturer or Ford did purchase the vehicle from me and made me roll over my negative equity from that car into a new car was my only option or paying 10 grand to get it fixed. Nothing no lights were displayed no lights came on at all no warning signs nothing Just happened. When I took it in to get it looked at the mechanic immediately told me that I need to trade the car in and that I shouldn't have this vehicle it's transmission has been having multiple issues over four times in one year it was in the shop for transmission issues they told me nothing was wrong and they drove my car 200 mi they gave it back to me not even two weeks later this happened no lights and nothing was pulling on the codes The mechanic Harper from Malloy Ford is the one that told me that I should need to trade it in he contacted the Ford company they offered $2,000 to help with the cost to get the car fixed but it wasn't going to fix the problem from happening again and it was traumatizing to have to go through that with my kids I didn't want to put my kids back in that vehicle because we literally could have died. PLEASE REACH OUT WITH ANY ADDITIONAL QUESTIONS with my phone or email .. THE CAR HAS HAD TRANSMISSION ISSUES SINCE I BOUGHT IT.THE DEALERSHIP REFUSED TO TAKE THE CAR BACK AFTER I PURCHASED IT TO PUT ME IN SOMETHING ELSE

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact noticed smoke coming from the engine. There was no warning light illuminated. The vehicle was able to restart; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed that the engine failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened and the contact was referred to the NHSTA Hotline for assistance. The approximate failure mileage was 100,685.

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side rear toe link fractured. The contact stated that the rear end of the vehicle swerved to the left. The contact stated that it was difficult to control the vehicle. The vehicle was driven to the shoulder of the roadway. The contact exited the vehicle. The contact stated upon inspecting the vehicle, the contact noticed that the driver's side rear suspension was on the ground underneath the vehicle. The vehicle was towed to the dealer, where it was diagnosed with a fractured driver's side rear toe link. The contact was informed that the driver's side rear toe link needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the ABS and the wheel bearing needed to be replaced prior to the recall repair being performed. The contact had received notification NHTSA Campaign Number: 21V537000 (Suspension); however, the contact was advised that the ABS and the wheel bearing needed to be replaced prior to the recall repair being performed. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 92,500.

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds, the vehicle was lagging while changing gear. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed that the torque converter had failed. The contact was informed that the torque converter needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was 62,000.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact heard a loud air sound coming from the front windshield. The contact was concerned that the windshield would cave in while driving. The contact stated that there was no visible evidence that the exterior A-pillar trim had detached. In addition, the contact stated that the failure was persistent, and the noise was extremely loud. The dealer was made aware of the failure; however, the contact was informed that the parts were not available. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the repair was not available. The contact stated that the recall had been initiated for over a year, and the parts had not been made available for more than a year. The manufacturer was not made aware of the failure. The failure mileage was unknown.The VIN was not available.

The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the exterior A-pillar trims and trims surrounding the windshield were fractured and partially detached. The dealer was contacted and informed that the recall remedy was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 40 MPH, the transmission jerked, and the vehicle shuddered. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that the torque converter needed to be replaced. The vehicle was repaired; however, the failure occurred. The vehicle was towed back to the dealer, and diagnosed with torque converter failure. The contact was informed that the torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 118,000.

I was driving , when I heard a strange noise. Luckily I was about a mile from work. I listened more, Checked my check engine lights, as I was passing the local ford dealership. They were not on. I proceeded to the stop light. My car began to miss. I had just put gas in, I assumed it was bad gas, still no engine lights. I made it 3 blocks it started missing bad, going through an intersection. Now its making a bubbling noise. No check engine, but the heat gage is half the way up. I stop in a driveway. put it in park for 15 minutes, to cool it down. I restart my car, I move it 4 yards to park along the street. Now my car will not move at all. We had it towed to the dealership. My engine is ruined. I did not drive my car more then a mile after the noise of what the dealership said, was system blowing up, that's in the engine. As a result this has blown my engine and I now need a new one. We had just been on vacation from Ohio to the Sault Saint Marie, Michigan. My husband checked fluids, added a little of both oil and Antifreeze before we left on Oct 17, 24. There was no antifreeze in the oil or oil in the antifreeze. We were only back a day when this happened . When the radiator blew up, it never set off my check engine lights. Even when the vehicle could no longer move, there were no check engine lights on. My vehicle was making a bubbling sound, yet my hot gages never went completely to hot. At the most the were about 3/4 of the way. The radiator blew and in a few short minutes my engine completely locked, this happening within a mile. Lucky for me, I was in a small town, when it occurred. Its been 3 weeks and I am still waiting on an engine. I have been told its because so many of the explores are having the same issue. I have to come up with 10,000.00 to replace the engine of a vehicle I still owe on. It just turned 100,000 miles in Michigan

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at an undisclosed speed, the passenger's side and driver's side windshield exterior A-pillar trims separated from the vehicle and flew off. The vehicle was taken to the local dealer to be inspected. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 121,000.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. No further information was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Front window trim/ A pillar detached while driving on October 18,2024. Contacted dealership for replacement at the end of October 2024, and each month following, they brought vehicle in for inspection but have never replaced the trim piece. It has now been 9 months, I have called the dealer every month to follow up and have been told every time they still do not have the part to fix it. I am concerned that the trim on the other side of the car could fly off and cause damage to my vehicle or others.

Powertrain fail while driving on the highway

The contact owns a 2017 Ford Explorer. The contact stated that the vehicle was taken to the dealer and the windshield trim was removed. The contact was informed that parts to perform the recall repair would be available within two weeks. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact stated while stopped at a traffic signal, the contact depressed the accelerator pedal, and the vehicle hesitated before responding as needed. The contact stated that the vehicle was vibrating and was jerking into gear. The contact stated that the failure was intermittent but was a recurring failure. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission was leaking from the case and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 48,000.

Received letter on February 2024 regarding recall notice 24S02/NHTSA Recall 24V031. The exterior pillar trim which borders the right side of the windshield flew off while driving on the interstate and could have caused a major accident. We went to our local Ford dealership several times to inquire if they could assist with getting the needed parts in also. I called the vehicle safety hotline and reported this incident (case # 11629172). We were told that someone would be in touch with us and NO ONE HAS RESPONDED TO THIS URGENT AND VERY DANGEROUS INCIDENT!! We are afraid to now drive the vehicle because of the danger of the left exterior pillar trim flying off and causing a major crash critically injuring or killing someone. We do expect a response to this critical issue ASAP!!

The contact owns a 2017 Ford Explorer. The contact stated that while driving at undisclosed speeds, the trim on the passenger’s side front windshield detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the dealer had removed both trim pieces and had broken the trim pieces and had not replaced the parts. The failure mileage was 33,787. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds, the air bag warning light illuminated. The contact stated that the air bag warning light intermittently illuminated while driving at various speeds. The vehicle was taken to the dealer and was diagnosed with air bag light row #2 inflatable found on higher wire circuit installed, and the was fuse replaced. Additionally, row #2 buckle, rear center row passengers seat, rear driver seat would not buckle, and that the passenger seat buckle was internally fractured, and the buckle assembly needed to be replaced. The vehicle was not repaired. The dealer informed the contact that the parts were on backorder. The manufacturer was made aware of the failure. The failure mileage was approximately 104,000.

In 2022 I had the water pump replaced on my 2017 Ford Explorer as it was leaking and i was getting fluids into the oil tank. The mechanic advised that it could destroy the entire engine and cause massive safety issues when driving. Had repairs done at Forder Dealership. On September 26, 2024, I took my 2017 Ford Explorer into the Ford Dealership for another issue and found out that my water pump was cracked again, leaking antifreeze, and that it needed to be replaced. Again, if not replaced massive safety issue could occur when driving. Earlier in September when driving the vehicle on the highway the entire vehicle shut down, lost the power steering, and the vehicle literally died in the parking lot of a tire shop. Replaced the alternator but still had issues with the engine after the replacement which now I learned could have been from the antifreeze leaking out of the water pump. Ford will not cover the replacement of the water pump because it 9 months past the warranty.

2.3L 4 cylinder engine has coolant intrusion causing a blown head gasket and requiring a super expensive repair that should be falling to Ford not the consumer. This is a design flaw and should be fixed ASAP. Coolant should not be intruding and leaking. This engine has around 76,000 miles and has only been owned for 1 year. Very disappointed in this.

Front windshield cowl is made or substandard materials and is cracking. You do a google search or YouTube search and you will see that many are having this exact issue. It is a safety hazard. If the cowl breaks it can surprise or cover the windshield of the driver that can result in injury or death.

I was driving in the Columbia Gorge on highway and the Drivers Keyless entry trim Blew off, and broke in half, the top half hit the car behind me dented his hood and put a nick in his window. I'm very thankful the piece that broke did not cause an accident or kill anyone. The lower half (with the keypad) was flapping in the wind being held on by electrical wires. The keypad blew a fuse, sending me signals that the lift gate was open and I had 4 dogs in the back. Luckily the lift gate did not open, tossing my dogs or belongings on the highway, causing more road hazards.

Hello there’s. Since I got the recall letter I keep going and calling to the Central ford dealership to replace the windshield molding, they keep saying that the moldings aren’t available but I know that they have been replaced them. My left moldings is very loose, I’m afraid that it will fall causing an accident. Could you do something about it? I just went a week ago. They said that they will call me when they get them. They been saying that since the first time Thank you.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle lost motive power, prompting the contact to pull over to the shoulder of the roadway. After a visual inspection of the engine compartment, the contact observed that the oil dipstick had been ejected, allowing the orifice to leak oil onto the engine. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who was able to determine that the engine was building excessive internal pressure but was unable to determine the cause of the failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer but was not yet diagnosed. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 121,000.

For over a year the windshield of my car had a “rattle” or wind-like noise. I figured this was due to the weather stripping around the windshield degrading and falling off. I heard about the recall and the very next day I was driving down the interstate and the plastic piece (A-Pillar) flew off and the car behind me swerved to miss the piece. A day or so after this occurred, large rains came through our area which resulted in water entering my vehicle. I took my car to the dealership a day or 2 later where they had to inspect to see if the vehicle met the recall and order the parts. This was over 3 months ago. I called Ford about 1 month after my vehicle was inspected and spoke to a representative who informed me that the parts are in stock and are being shipped out upon ordering from the dealership. The dealership placed the order the same day they inspected the car. I have not heard any communication from Ford regarding this. I am cornered about water damage in my vehicle due to prolonged issue with not only the weather stripping but also missing the plastic piece (A-Pillar). I have contacted the dealership multiple times and their hands are tied due to not having the parts needed to fix the recall.

I HAVE BEEN TRYING TO GET MY VEHICLE FIXED FOR SAFETY RECALL 24S02 FOR MONTHS AND THE DEALER KEEPS TELLING ME THEY DO NOT HAVE THE PARTS. I CANNOT USE MY CAR TO GO ON TRIP OR ON FREEWAYS BECAUSE OF THE WINDSHIELD NOISE AND I AM AFRAID OF SOMETHING COMING OFF AND CAUSING A WRECK.

The inside rear brake pads sustained a 66% loss of material in 9260 miles of normal driving. The vehicle was serviced on 10-03-23, 53,446 miles, the fronts pads had 7mm and the rears had 6mm. The vehicle was again service on 09-11-24, 62,706 miles, the front pads had 6mm and the rear had 2mm. I had the dealer take the rear brakes apart and check everything for why the pads wore down so fast. The findings were that all components were in good working order and the outside rear pads actually had 5mm and the inside rear pads had 2mm.The dealer told me they couldn't find a problem as to the extreme wear. I contacted Ford and they couldn't or wouldn't help due to no problem found and brakes being a wear related part. All work was performed at Lithia Ford of Boise.

Engine shake due for engine mounting damage on transmission and engine mount 3 xplorer 2017 was at the same shop same problem

The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (STRUCTURE) and 25V347000 (STRUCTURE); however, the parts to do the recall repairs were not yet available. The contact stated while driving 50 MPH, the front passenger’s side A-pillar trim detached from the vehicle. The vehicle was not diagnosed or repaired. The contact stated that on a separate occasion, the driver’s side B-pillar trim detached from the vehicle. The local dealer was contacted and replaced the B-pillar trim. The contact stated that weeks later the recall notice for the B-pillar trim was received. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 8,000.

The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the driver's side and passenger's side windshield exterior A-pillar trims and door exterior B-pillar trims had detached. The contact used tape to secure the trims. The vehicle was taken to the dealer to be inspected. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

The contact owns a 2017 Ford Explorer. The contact stated while driving at undisclosed speeds, the front passenger's side windshield trim clips detached and flew off. The vehicle was taken to the dealer; however, the contact was informed that the parts were not available. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 121,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle jerked violently. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who retrieved DTC code: P0300; and determined that there was an engine misfire. The contact's husband replaced the coil pack and spark plugs; however, the failure persisted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 94,000.

The contact owns a 2017 Ford Explorer. The contact stated that after restarting the vehicle, the message "Power Steering Assist Fault" was displayed, and the steering wheel became difficult to turn in either direction. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 17V530000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The VIN was not available.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact stated while driving 60 MPH, the trim started flapping in the wind. The contact's husband used silicone to secure the trim. The contact had received the recall letter and scheduled an appointment with the dealer. The vehicle was then taken to a dealer, and while removing the silicone, the A-pillar trim was fractured. The vehicle was not repaired. The contact stated that the dealer placed duct tape on the windshield. The failure mileage was approximately 85,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact stated that upon depressing the brake pedal, a warning chime sounded, and the "Low Oil Pressure" message was displayed on the instrument panel. The message disappeared after depressing the accelerator pedal. The vehicle was taken to a dealer for a diagnostic test; however, no fault was found with the vehicle. However, the contact was informed that the oil pressure sensor needed to be replaced, and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN related to the failure. The contact was then referred to the NHTSA Hotline to report the failure. The vehicle was not yet repaired. The failure mileage was 67,000.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at various speeds, the A-pillar trims on the driver’s and passenger’s side rattled while driving. The contact attempted to repair the A-pillar; however, the front driver's side A-pillar trim detached from the vehicle while driving. The contact then received notifications of NHTSA Campaign Number: 24V031000 (Structure) and 25V347000 (Structure); however, parts for the recall repairs were not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown.

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised that the repair was not associated with any recalls. The failure mileage was approximately 80,000.

In addition to the details involving NHTSA Safety Recall 24V031, any trim at the top of the windshield has either deteriorated or fallen completely off, while the material below the windshield is rotting away. This all makes me worry that the windshield could potentially shatter or come off on the road. I am not sure when the problem occurred or started to occur and I just became aware of it.

Driving on the highway heard large rattling noise coming from engine loss of power engine light came on battery light came on no acceleration cause to slow down on highway fortunately I was able to get to shoulder had it towed to service shop had p0012 code tensioner may have broken off on timing belt causing low oil pressure and causing engine rattling noise and engine shut down but service garage don’t do that type of work

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving 70 MPH, the driver's side windshield exterior A-pillar trim separated and flew off. The local dealer was contacted, and an appointment was scheduled for the vehicle inspection. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,000. VIN tool confirms parts not available.

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 20V675000 (Suspension). The contact stated that while his wife was driving 45 MPH, the driver lost control of the vehicle and ended up nearby a ditch. The contact stated that while his wife was driving straight, the vehicle veered off independently. There were no injuries during the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 113,000.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that while driving 60 MPH, the driver's side windshield exterior A-pillar trim separated and flew off the vehicle. Additionally, the contact stated that the exterior trim located at the base of the windshield was detaching. The dealer inspected the vehicle at the residence. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was parked, the contact became aware that the black plastic strip was missing from the passenger’s side window. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 105,000.

The contact owns a 2017 Ford Explorer. The contact stated that the passenger’s side the A-pillar applique trim had a split in the middle causing rainwater and dirt to enter the vehicle. As a result of the failure, the sunroof motor was damaged and then failed to operate. The local dealer was called, and the contact was made aware of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not available. On another occasion, while driving at various speeds, while making a left or right turn there was an abnormal clicking sound coming from the steering. The contact stated that the failure progressively worsened when turning to the right. The vehicle was taken back to the same dealer where it was diagnosed that the A-pillar applique trim was not likely the reason for the failure of the sunroof motor and that a 2-hour diagnostic test needed to be completed to determine the cause of the failure; however, the repair would be paid out of pocket. The contact was reminded that the A- Pillar applique trim part was still not available. The contact was informed that the clock spring had failed and needed to be immediately replaced. The vehicle was not repaired and remained with the dealer. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.