2017 Ford F-150 Complaint Log

2017 2.7L F150 6 speed transmission. After an hour of drive time transmission vehicle got stuck between 3rd and 5th. If continued to drive it would go into “limp mode” stuck in 3rd gear and unable to accelerate. On my way home this occurred at 70mph on the highway and the truck downshifted and caused tires to lock up. Dealership diagnosed this as lead frame failure

The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly jerked while driving and attempting to shift gears. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that the catalytic converter and timing components had failed and needed to be replaced. The vehicle was repaired. The contact later stated that while driving at an undisclosed speed, the vehicle lost motive power, and there was no warning light illuminated. The vehicle was towed back to the independent mechanic, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 140,000.

My 2017 ford f150 6r80 transmission lead frame malfunction causing for the transmission to severely down shift and locking my rear wheels. At the time No check engine or wrench symbol showed on my speedometer dashboard until the following day. I was lucky no vehicles were close to me that could of rear ended me and loose control on the freeway. Took my f150 to my local ford dealership and confirmed that it was my transmission lead frame and fixed it.

Transmission switching gears (downshifting)at highway speeds to lower gears causing the rear wheels to slide on pavement. Transmission will occasionally get stuck in 3rd or 5th gear at red lights causing dangerous interactions in intersections where the truck will not get upto speed fast enough to keep up with flow of traffic.

While driving my truck erratically shifts. I’ve gotten multiple indications stating that Elite frame sensor is bad. I have been traveling 70+ miles an hour down the interstate and my rear wheels lock up the transmission drops in the second gear. This is a major safety hazard as it could cause major accidents. While looking through other complaints, this is a major ongoing condition with the 6R 80 transmissions in 2017 Ford F1 50s that has been reported on numerous occasions.

I own a 2017 Ford F‑150 equipped with the 3.5L EcoBoost engine. The vehicle currently has approximately 70,500 miles. The dealer diagnosed a ticking/rattling noise coming from the top left side of the engine near the timing cover. Using a stethoscope, the technician determined the noise was related to the timing system. The dealer recommended replacing the cam phasers, timing chain guides, and timing tensioners, along with all related seals and gaskets. The total estimated repair cost is $5,957.08. After researching the issue, I found that this cam‑phaser rattle/ticking problem appears to be widely reported by many owners of F‑150 trucks equipped with the 3.5L EcoBoost engine. I also learned that Ford Motor Company issued Customer Satisfaction Program 21N03, which extends cam‑phaser coverage for certain vehicles with this engine. However, when I contacted Ford Customer Service, I was informed that my VIN was not included in the program and that no financial assistance was available. I was directed back to the dealership. Given the relatively low mileage of the vehicle and the number of similar reports from other owners, I believe this may represent a systemic defect in the cam‑phaser/timing system. I respectfully request that this issue be investigated and considered for a recall or broader coverage program so affected owners are not responsible for costly repairs caused by this defect. If the cam‑phaser or timing components fail while driving, it could potentially affect engine performance, create a stall condition, or lead to loss of power, which may pose a safety risk.

My Ford F-150 is having issues that is known to Ford about the cold rattle start which consists of the cam phasers are defective and can cause serious damage to the engine. At the time Ford had put out some customer program and my vehicle has only got 36,000 miles on it and the problem has now just started. I called ford service center and the service man was surprised that mine started going bad at such a low mileage vehicle and pretty much said theirs nothing they can do except pay thousands in repair. And I explained to him that when ford had sent the customer program out my vehicle wasn’t encountering any issues and he said they cannot offer that to me. My truck is in very new condition don’t drive it much so now I’m stuck with a new truck where the engine can die out at any given time. Ford knows this was a problem from the beginning so why didn’t they recall this as this is a very expensive repair. I think this should be taken care of by the dealer as I have a new truck then have to turn around and spend 5,000 dollars on repairs

Truck sometimes roughly downshifts. I always thought it was normal, but I see that others may be experiencing the same transmission issues. It has happened many times. I only have 77,000 miles.

The contact owns a 2017 Ford F-150. The contact stated that while driving 70 MPH and depressing the accelerator pedal, the transmission unexpectedly downshifted from sixth gear to third gear, causing the rear wheels to lock up temporarily for several minutes. The transmission fault warning light was illuminated. The vehicle was pulled over to the right side of the road and turned off for ten minutes. The vehicle was restarted and operated as intended. Neither an independent mechanic nor a dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The contact stated that the failure had occurred four times. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 190,598.

My 2017 F-150 had only 87k Miles on it. I don't tow boats or anything heavy. Two months ago my transmission started giving me problems banging when putting in gear and causing my rear end to lock up. Took to Ronnie Thompson Ford dealership in Elijay Ga and they had to replace my rear end. 3500.00 less then 3 weeks later the transmission was not acting right causing shifting and vibration issues. Took to same Dealership in Elijay Ga as I was outta twn again at my second home. They said My transmission was failing and I needed at min a new torque converter. As I could not afford the high price of the Ford Dealership repair I Came back home to South FL and had the Transmission rebuilt for 5500.00 at Gold Coast Transmission in Fort Lauderdale, FL. Ive now Spent over 9K dollars in the last two months to fix this problem. Im a recently retired Ft Lauderdale cop and I cant afford to buy a new vehicle so I've had to put all this money into this prob. Im a Ford guy, my last Ford f150 was a 2000. I put 267k miles on it and had it 18 yrs before I bought this truck. Prior to that I had a 94' Ford Ranger. I put 197k miles on it and before that a 72 Cutlass in HS. Im [XXX] old and have had only 4 cars my whole life. I TAKE CARE OF MY VEHICLES. Of the 4 cars this 2017 is the only new car Ive ever owned and have had more problems with it then any. I see you guys are looking at these transmission and I wanted my complaint documented. If there is a recall I feel Ford should have to reimburse me for the transmission and rear end I just had to replace. Thanks for looking out for the little guy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The transmission for this vehicle is failing. When accelerating it shifts to a lower gear without warning. It appears to be slipping into gears that it should not be shifting into. When first putting the vehicle into drive it often lurches forward so a hard braking action is required when shifting from park to drive. Dealer is so overwhelmed by transmission issues they require months in advance to see vehicle. Once received they need a week to just evaluate then “up to two months” to repair it. They indicate it’s a known issue with the Ford 10 speeds. A warning notice is constant and cannot be reset. “See manual”

2017 f150 with only 48,330 original miles. Having issues with transmission stalling,jerking in between gears. After last night I have had enough due to an almost potentially fatal accident. While making a left hand turn the transmission stalled for way too long and an 18 wheeler came over the hill ( it’s a blind spot turn) and came very close to hitting me broad side of my truck. This issue could have costed me my life. The transmission fluid is fine as it was checked very recently at my last service less than 100 miles ago. The dealership wants 200 dollars just to hook it up to a computer just to see if the TCM is showing any codes. I have already had that checked for free somewhere else and it is not. The dealership will not do anything unless I pay for that to be done first. I cannot afford to give away 200 dollars for free. But if I give them 200 dollars then they can give me an estimate for repair that ranges from 1000 to 10,000 dollars which is what other customers have paid or been taken advantage of for that amount.

Transmission downshifts abruptly and severely causing rear tires to screech on pavement and very loud noise in vehicle

The transmission downshifted while driving 60 to 65 MPH and needed repairs. Transmission Specialist changed out transmission electric control unit.

12/31/2025 NHTSA, I am writing to formally report a serious safety issue involving my Ford F-150. On [XXX] in rural Alaska, my Ford F-150 experienced a flat tire in extreme winter conditions (approximately –15°F). I was traveling with my [XXX] child. When we attempted to change the tire, the lug nuts could not be removed using the factory tools provided with the vehicle. A tow truck was dispatched from the only available service on a holiday evening, which was 45 minutes away. The tow operator was then unable to remove the lug nuts with any of his professional equipment. We were subsequently informed that this is a known issue with Ford’s chrome-capped, two-piece lug nuts swelling or deforming, making them incompatible with standard sockets. As a result, what should have been a routine roadside tire change became a prolonged and dangerous situation for my child and me in life-threatening cold. We were stranded for 3 hours and nearly ran out of gas keeping the vehicle warm. It took a blowtorch provided by a passing Good Samaritan to complete the tire changeover. This failure created a significant safety hazard. A vehicle that cannot have a flat tire serviced during an emergency—especially in extreme weather—poses an unacceptable risk to occupants. This was not due to misuse, improper maintenance, or lack of tools, but rather an apparent design or materials defect that rendered the lug nuts unusable. Vehicle details: - Year/Model: 2017 Ford F-150 - VIN: [XXX] - Location of incident: Miles outside of Willow, Alaska This situation placed a minor child at risk in extreme winter conditions and should not occur in any Ford vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Frequently I will be driving at highway speeds and the truck will unexpectedly downshift. This will happen around every 500 miles. I have only had it drop from 6th to 5th/4th, never any lower at highway speeds. I have had this occur multiple times at slower speeds but it will go away. During each time the code P0720, output speed sensor, will appear and I will have to clear the code and it will work like normal again. There has only been one instance, in my 2 months of ownership, in which the unexpected downshift happened, I then came to a stop and then the truck stalled at a stop light. The truck is available for inspection. My safety and others were put at risk since I lost the ability to control my throttle making my acceleration and deceleration erratic. Also, when I was stalled at the green light it was on a road that had a speed limit of 70 which I could have been hit by another vehicle predicting me to drive away from the stop light when I could not. It hasn't been confirmed by a dealer or independent service center but matches the description of the NHTSA investigation into the issue. The vehicle component has not be inspected yet. Prior to the issue, no warning lights have popped up. It is only when the issue occurs and I feel the truck unexpectedly downshift and no longer upshift that a yellow wrench will show up with the code i had mentioned previously.

While driving ~70mph on I-80 in central Wyoming, my truck suddenly and unexpectedly downshifted to a low gear, causing RPMs to spike to 8000+ and making me swerve and nearly go off the road. No warning lights or cautions appeared. I pulled over, turned off the ignition, and checked my engine compartment to see if I could find any issues but everything appeared normal. I resumed driving and everything felt normal. Approximately 100 miles later a check engine light appeared. No other cautions or messages appeared. My transmission and engine oil temperature gauges showed readings in the middle of the normal range. I was 10 miles from the nearest town and immediately stopped at a mechanic shop to diagnose the issue. After several days trying to diagnose the issue, they told me that my transmission had severely overheated, was near failure, and needed to be replaced. I had a regular transmission service less than 12 months prior at a Ford dealership and no issues were noted. I am writing this because I am aware of many other F-150 owners experiencing similar problems and I believe Ford needs to address this clearly systemic issue with the 10R80 transmission.

The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly shifted into gear. The contact stated that the transmission shifted into a lower gear. No warning lights were illuminated. The contact stated that the vehicle was driven to the shoulder of the road and turned off. The contact stated that while attempting to start the vehicle, the vehicle started, and the transmission was independently reset. The contact stated that the failure also occurred while the vehicle was parked. The contact stated that the transmission independently shifted into gear, and the failure was displayed on the instrument cluster. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the failure was a known failure. The manufacturer was made aware of the failure. The contact was informed that the repair was not covered under the recall. The failure mileage was approximately 110,000.

In June 2025 and again in December 2025, when my truck stopped at a Red Traffic Light and I applied my brakes to stop the vehicle, my two rear wheels/tires started to spin rapidly non-stop for 60 seconds or the duration of the traffic light, causing a great deal of smoke and noise. My truck acted like a "Drag Racing" machine on a short track revving its engine and spinning its tires for a very short burst of speed down the track. Cars behind me kept their distance and I thought my truck would bolt forward at any time causing a serious accident. I applied my brakes as firmly as possible, praying my truck would not lose control and bolt forward into the lane of traffic. In June, my mechanic thoroughly inspected my vehicle for four hours, going on a test drive, pulled off all the wheels and checked every pertinent component, ran 3 diagnostic code assessments and found nothing. When it happened again on December 11, 2025, I contacted another mechanic who told me he could not address the issue since it was a known Ford Issue and to contact NHTSA and Ford (PE25-002). Finally, there were no warning lights on my dashboard when it happened during these two incidents.

While driving, my 2017 Ford F‑150 experienced a sudden loss of the Output Shaft Speed (OSS) sensor signal, causing the transmission to stay stuck in a higher gear and triggering the wrench light. The truck lost power and would not shift properly. A diagnostic scan showed two transmission codes: one for the OSS sensor and a second code indicating an intermittent electrical signal drop. I contacted a Ford dealer before the repair, described the symptoms, and asked for an estimate. The service advisor did not disclose any known issues and never called me back after saying he would check parts availability. These symptoms match the known failure pattern of the molded lead frame in the 6R80 transmission. My truck exhibited intermittent behavior, harsh shifting, and unsafe drivability. I had to pay $1,250 out of pocket to replace the lead frame to restore normal operation. I later learned that NHTSA has opened an Engineering Analysis into 2015–2017 F‑150 trucks for this exact issue (OSS signal loss due to internal electrical degradation of the lead frame). My vehicle’s symptoms, diagnostic codes, and required repair are consistent with the defect under investigation. This failure creates a safety hazard because the truck can suddenly lose the ability to accelerate or shift correctly, especially in traffic or at highway speeds. I am requesting that NHTSA include my vehicle in the investigation and that Ford be required to address this defect.

The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission failed to properly shift gears. The check engine and power train warning lights were illuminated. The contact stated that while driving at various speeds, the vehicle unexpectedly downshifted while the accelerator pedal was depressed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. Upon further investigation, the contact related the failure to the Ford Customer Satisfaction Program: 19N01 and NHTSA Campaign Number: 19V075000 (Power Train); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 150,000.

The CDF drum bushing slipped, which seems to be a constant problem on the F150's, causing my truck transmission to fail while on the freeway. Looking online, several of these instances have occurred to other truck owners. The cost to repair this is astronomical and if Ford has been aware of the problem for so long, they should have recalled the trucks and fixed the problem.

Since the brake recall was performed when driving the brake light will come on in the instrument cluster. When the light comes on the brake pedal gets stiff. Like it's stuck and takes a little effort to break free. This is not present when the light is off. Before the recall was performed I never had an issue with the brakes or the light coming on. Also. The door ajar light in the instrument cluster comes on when all the doors are completely closed. Will turn off after pulling over and turning the truck off, and back on. Sometime it comes on for a whole day no matter how many times I restart it, then be fine the next time I use the truck.

Fords around the 2017 year have an issue with their backup cameras not working which is the issue mine is having. When putting truck in reverse backup camera is fully fuzzy with green lines or just goes fully back. It still beeps and can detect something close, but the actual camera doesn't work anymore.

Vehicle was sitting in driveway running. I turned on the front and rear defroster to clear windows before driving. Approximately 60 seconds after turning on rear defroster, the back window shattered. Multiple reports online indicate this is a common occurrence in F-150 and should be looked into further.

2017 F150 Super Crew 4x4 brought into dealership for brake master cylinder recall. ( no lights on dash) Dealership changed both the master cylinder and brake booster at no charge. The same day the vehicle was picked up, I returned it to the dealership. The vehicle was having issues with keeping straight on the highway and when I slowed down when coming to a full stop, the steering wheel turned completely to 1 side on its own. These symptoms were not present when vehicle was initially dropped off. Dealership is now telling me that the ABS module is bad and that I need to pay for that repair. The local Ford dealership submitted documentation (Special Service Support Center Assistance Request) to Ford to cover related damage, but request was denied. I called Ford corporate to re-open case and appeal decision. Ford corporate would not re-open. I requested a field service engineer to review my situation, Ford said No. I asked for good will assistance, Ford said no. I asked if Ford could do anything to assist, Ford said no. It has now been over 45 days without my vehicle. The steering wheel rotating on its own after braking is a critical safety concern. The local dealership has changed the recall to complete and left me with a vehicle that is not safe to use. They claim the ABS module is bad and I have to pay out of pocket, but they have yet to provide any documentation or reports including any OBD2 codes that indicates this is not as a result of the recall work performed. In summary, I left my vehicle at dealership for recall on master cylinder and after repairs the vehicle is having issues with related components that were not present before dropping off. All I ask is that Ford can assist by covering the needed parts and labor to get my vehicle back on the road performing safely.

The contact owns a 2017 Ford F-150. The contact stated that while driving at various speeds, the vehicle momentarily lost motive power while shifting into gear, and the transmission shifted hard. The power train warning light was illuminated, and the vehicle went into LIMP Mode. The warning light was illuminated after each failure. The vehicle was taken to the dealer, where it was diagnosed that the transmission CDF drum had failed. The dealer had not yet provided an estimate for the repair. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 139,000.

I was driving my truck around 40 MPH and a wrench came up on the dash, the fan sounded like it kicked in on high for the duration of the wrench being on, the light indicating whether the truck was in P, R, N, D, M, 2, 1 was no longer illuminated. After a while it stopped but the problem has persisted. This last time, I was driving my truck around 55 MPH and the exact same thing happened but this time the truck seemed to downshift into either first or second gear and obviously the RPM was extremely high. After this happened, I took the truck to the Fairway Ford in Evans, Georgia and was notified that the molded lead frame needed to be replaced, costing nearly $2,300. This sudden downshift was an extremely concerning safety issue that could have resulted in a crash and endangered not only myself and my children, but others that wouldn’t have been able to prevent an accident. I hope this issue is addressed before someone loses their life over the poor quality of a Ford manufactured and Ford endorsed product with potentially dangerous consequences when it fails suddenly.

The contact owns a 2017 Ford F-150. The contact stated that while reversing, the rearview camera failed to display an image, comprising the back over prevention system. No warning lights were illuminated. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was taken to the dealer, who diagnosed a failure with the rearview camera. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V572000 (Back Over Prevention), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was unknown.

I was driving 70 mph down the interstate when my truck unexpectedly shifted into 1st. A couple weeks later, I was driving down the interstate when my truck unexpectedly shifted into neutral and then the reverse camera came on. I took it to a local mechanic shop yesterday when the truck unexpectedly shifted into neutral again. This is completely unacceptable and is very dangerous. It is currently being worked on to replace the lead frame but this is a huge safety issue and id like Ford to cover my repair cost. It has left me stranded three times now. I did the recall not too long ago and this DID NOT fix the issue. Ford clearly knows about the issue and decided to only update the software. Id also like to add my truck is only driven maybe once a month so its not heavily driven.

Transmission Lead Frame causing sudden shift to first gear during travel, no start, erattic shifting. This seems to be an on going issue with Ford 6 speed transmissions.

The transmission down shifted from 5th to first while going approximately 50 mph out of nowhere and without warning. This caused a rapid deceleration while on a busy road and scared the crap out of me. The truck stayed in a reduced power mode until I shut it down and restarted. I used my auto scan tool to look up if any fault codes were registered. Fault code P0722:00-68 was registered (Output Shaft Speed Sensor Circuit No Signal) which indicates a problem with the molded lead frame in the transmission. Why has Ford not issued a safety recall for this known problem? This can cause a catastrophic failure/safety issue while driving.

While driving lost transmission gear selection on the cluster and would no longer go into 1st gear. wrench light flashed and showed see owners manual. When decelerating for a stop the truck does not downshift into 1st gear, when your expecting a downshift it makes it very hard to stop at intended spot. Dealership mentioned this being a known issue (Lead Frame Replacement needed) but has only been recalled for 2014 and below year models.

I had a check engine light come on for an oss sensor. Shortly after that started my truck would aggressively downshift to lower gears and lock up. I’m now having to replace the transmission.

The contact owns a 2017 Ford F-150. The contact stated that upon shifting the vehicle into reverse, the vehicle started rolling forward, prompting the contact to not attempt to drive the vehicle. The power train warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 126,000.

The powertrain/transmission is not receiving the signal from the engine to accelerate. It can be inspected. The vehicle is slow to accelerate or will not accelerate at all, causing lurching motions and slow movement of the vehicle. This can cause my vehicle to rapidly accelerate or me to slowly decelerate, causing me to possibly run into others or be hit by others. No one has reproduced or assessed the problem. The problem occurred multiple times before a warning message was displayed. The signal appeared after two weeks of the failure occuring.

Complaint Summary (What Happened): The cam phasers (variable camshaft timing system) failed on my 2017 Ford F-150 4x4 with the 3.5L EcoBoost engine. This is a widely known issue on these engines. The failure causes a loud rattling/knocking sound during startup and can lead to engine timing problems or internal damage. My truck only has 108,000 miles, has been well maintained, and is just outside of the extended warranty coverage Ford issued for this exact issue. Safety Risk: The cam phaser failure causes erratic engine timing, which can lead to power loss or stalling during operation. This creates a safety hazard while merging, towing, or driving at highway speeds. The loud knocking sound and hesitation also distract the driver and reduce confidence in the vehicle’s reliability and acceleration when needed for safety. Problem Confirmation: Yes, the problem was confirmed by a Ford dealership. They diagnosed cam phaser failure and quoted approximately $6,300 for the repair. Inspection: The vehicle has been inspected by a Ford dealership service department. Ford Motor Company was contacted but declined to assist financially since the issue occurred just after the extended warranty expired. Warning Signs: No warning lights or messages appeared before the failure. The first symptom was a loud rattling/knocking noise on cold start, which worsened over time. The issue started around 85,000 miles. The check engine light just came on at 108,000 miles. Availability for Inspection: The failed components remain installed on the vehicle and are available for inspection upon request. However, I am looking to get this fixed as soon as possible.

While driving my 2017 Ford F150, on or about 10/16/2025 the vehicle began jerking significantly. It was intermittent smoothing out then jerking severely again. The problem persisted so I took it to Ford of Spartanburg, SC. They diagnosed a slip found with the torque converter under load. they recommended replacing the torque converter and replacing the transmission filter. I only had 80,006.0 mileage on my truck when this happened.

Transmission had been shifting erratically & wrench appeared on dash. Had truck towed to dealership & was told lead frame was bad. Replaced for $2054. After one day wrench appeared on dash. Took back to dealership and was told clutch pack exploded & required new transmission. Mileage 120,308.

Complete loss of transmission power, and gear indicator in the instrument cluster starts flickering like it is shorting out. The vehicle has been experiencing this for 2 weeks. This happens under acceleration mainly, and first occurred while entering a highway. The symptoms seem to match those presented regarding the Lead Frame issues presented on many forums.

Truck downshifted on its own from 6th gear to first gear. This caused rear wheel lock up around 55 mph. Vehicle became unsafe and difficult to control.

The transmission would randomly shift into first regardless of speed. several times this occurred at highway speeds causing a sudden decrease on speed nearly leading to a rear end collision. The problem worsened to the point it would suddenly hunt for a gear. Fortunately this did not occur on the highway as it probably would have led to a serious accident. The problem was confirmed and repaired by an independent shop by replacing the molded lead frame in the transmission. There was no warning when the dangerous condition would occur.

I took my 2017 F150 pickup to Aaron Ford in Poway to perform the following: 1) Resolve recall #25V236 Ford Brake Booster 2) Provide an estimate for resolving the "wrench" cockpit display icon Aaron Ford had my vehicle for 3 days they claim, investigating #2 and provided an estimate of $10,000 to rebuild a transmission with <85,000 miles. The recall was NOT investigated nor resolved even though the dealer had the required parts in stock. I would like to file a formal complaint on Aaron Ford's failure to complete the specified recall work as request.

I work on route 95 doing road construction and I am usually running highway speeds. When leaving work heading up 95 the truck threw itself in second gear out of nowhere. Almost got hit in the fast lane because I could not maintain speed and RPM’s went to 7500. Had to pull over turn the truck off and on and it was fine. It can drive fine for a few hours or a few minutes then the transmission will downshift again out of nowhere while just throwing up a wrench light when it happens that then turns off. It has happened about ten times now. Sitting in driveway. Nice truck to scary to drive.

Shift hard while driving. Hesitates from the stop position to go when pressing the gas

I just paid 2129.05 to have the separator plate on my 2017 Ford F-150 3.5l /10-speed replaced. The issue was the though bolts in the torque converter were making rotational contact with the stationary separator plate within the bell housing. Ford has a TSB concerning this issue. The number is; SSM52295 ,TSB 19-2230. This specifically cites 2018-2023 models with 3.5l or 5.0l engines, similar issues and symptoms [3.5l/10-speed] occur on 2017 models. It seems this is a known flaw yet there is no financial consideration for this expensive repair. This is not a wear item. It is stationary. This situation has developed over the past several months with most notable audible evidence occurring upon very cold weather initial start-up.

Automatic transmission having major jerking and shuttering issues

There was an unknown problem with a fuel injector that resulted in the a vapor lock of the engine. This incident happened in traffic while idling at a stop light. There was zero stress on the engine at the time of the incident. This was a busy intersection, and I could have been pushed into oncoming traffic. There were no warning lights(check engine or otherwise) indicating and engine related failure or that an issue could be present in the fuel or engine systems. Upon trying to restart after what appeared to be a simple stall out, all indicator lights were on and every warning possible was present My local service center reviewed the truck and did confirm the resulting issues. They have also advised they would have expected such issues to trigger a warning light. I believe this was a catastrophic failure on Fords part and as a result has landed me as the consumer with concerns for the safety and a large bill for the work needed just to get it back on the road.

Lead frame malfunction Vehicle downshifts into lower gears and won't shift afterwards Have not taken to service center as of today just started happening recently No inspections have been performed A service warning came on after the sudden downshift

While I am driving in normal drive when my vehicle is in 6th gear cruising there is a shutter in the transmissionthat happens (like running over rumble strips)and only sixth gear. When I have 4 wheel drive locked in the transmission shutter happens in 3-6th gear and only happens at lower cruising rpms and trying to accelerate when I'm either using the pedal or cruise control. When I am in normal driving mode I have to leave 6th gear unselected so the rpms aren't too low to keep the transmission shutter from happening. Brought to the ford dealership and during the ride along with the tech he admitted he could feel it and could be 1 of 3 things the transmission, the torque converter or the torque converter control module. After picking my truck back up they said since I have no codes and they found a flaw in my rim. And that is what is causing the only sixth gear low rpm transmission shutter. And the shutter doesn't happen during higher rpms even at the same speeds. I have read up on this shutter and everyone was saying the same feeling in there f150s and was a transmission shutter. Don't want my transmission locking up at interstate speeds could cause losing control or causing an accident due to lock up