2000 Ford F-250 Electrical System Problems

Odometer Fraud. The contact purchased a 1999 N/A Ford F-250. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 176,369. The contact stated that the odometer was inoperable. The contact stated that the odometer only operated while the 4WD feature was activated. Upon further investigation, the contact became aware that when the previous owner purchased the vehicle in 2023, the mileage was 167,697. The correct odometer reading was unknown.

The contact owns a 2000 Ford F-250. The contact stated that while standing next to the vehicle a burning odor was present coming from under the hood. Upon inspection of the vehicle, it was discovered that several wiring harnesses were saturated with leaking brake fluid. The contact was concerned that the saturated wiring harnessed had caused electrical failures within the vehicle. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 240,000.

TL* THE CONTACT OWNS A 2000 FORD F-250. WHILE THE VEHICLE WAS PARKED WITHOUT THE KEY IN THE IGNITION, IT ATTEMPTED TO START INDEPENDENTLY. THE CONTACT MENTIONED THAT THE CONNECTORS TO THE BATTERY TERMINAL HAD TO BE REMOVED TO PREVENT THE VEHICLE FROM INDEPENDENTLY STARTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

TAIL LIGHT BULB SOCKET BURNT. NOTICED THAT BULB ACTS LIKE IT'S BLOWN BUT RESEATING ALLOWS IT TO FUNCTION AGAIN. THIS HAPPENS ABOUT ONCE A MONTH. NO FUSES ARE TRIPPED WHICH IS ODD. HOWEVER THE FIRST TIME I CHECKED THIS I NOTICED THE SOCKET WAS SCORCHED YET WIRING LOOKS OK. I ASSUMED IT WAS JUST MY VEHICLE BUT SINCE HAVE HEARD SAME REPORT FROM OTHERS ON THEIR TRUCKS AND CARS. THERE IS NO INDICATION OF DANGER UNTIL YOU REMOVE TAIL LIGHT TO CHECK BULB.

APPROXIMATELY 1 HOUR AFTER BEING PARKED IN PARKING STALL AT MY RESIDENCE, NEIGHBORS NOTICED FIRE COMING FROM THE HOOD AND UNDERNEATH THE VEHICLE (THE FIRE ORIGINATED ON THE DRIVER'S SIDE).THEY ATTEMPTED TO PUT OUT THE FIRE AND CALLED 911. SAN JOSE FIRE DEPARTMENT RESPONDED TO THE CALL AND FINISHED PUTTING OUT THE FIRE. THE VEHICLE HAD VISIBLE BURNT WIRING, RIGHT SIDE FENDER DAMAGE FROM HEAT (INSIDE AND OUTSIDE) AND THE RIGHT DRIVER'S SIDE TIRE SUSTAINED DAMAGE DUE TO MELTING DEBRIS FALLING ON TIRE. THE FIRE DEPARTMENT TOOK A REPORT OF THE INCIDENT. AS I HAVE RELAYED THIS EVENT TO OTHERS, THEY HAVE MENTIONED THAT THIS IS PROBABLY A "RECALL FIRE" AND THAT I SHOULD REPORT THIS INCIDENT. *TR

TL* THE CONTACT OWNS A 2000 FORD F-250 4X4. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, A LOUD NOISE WAS HEARD COMING FROM THE ENGINE AND SMOKE EMITTED FROM THE TAIL PIPE. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC, WHERE THE DIAGNOSTIC TEST INDICATED THAT THE WIRING INJECTOR WAS MELTED FROM A FIRE. THE SAME FAILURE OCCURRED ON THREE SEPARATE OCCASIONS. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 134,179. UPDATED 10/31/11 *BF THE CONSUMER STATED EVERY TIME THE WIRING HARNESS FAILED, THERE WAS NO WARNING AND THE VEHICLE INSTANTLY LOST POWER. UPDATED 01/18/12

TL* THE CONTACT OWNS A 2000 FORD F-250 SD. THE CONTACT STATED THAT HE HEARD A CLICKING NOISE AND THE LIGHTS ON THE INSTRUMENT PANEL FLICKERED ON AND OFF. ONCE HE TURNED THE HEATER CONTROL OFF, THE FLICKERING STOPPED BUT RECURRED WITHIN A FEW MINUTES. THE CONTACT PARKED THE VEHICLE AND WHEN HE RETURNED, THE VEHICLE WAS ATTEMPTING TO START INDEPENDENTLY. HE REMOVED THE POSITIVES AND NEGATIVES FROM THE SOLENOID TO CORRECT THE FAILURE. HE THEN REATTACHED AND THE FAILURE RECURRED. IN ADDITION, SMOKE WAS EMITTING FROM THE VEHICLE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 218,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 217,000.

I HAD A SPARK PLUG BLOW OUT OF THE CYLINDER HEAD, AS MANY OTHER PEOPLE HAVE. THIS IS A MANUFACTURING DEFECT, AND THEY KNOW IT, SINCE THEY CHANGED THE DESIGN. THERE SHOULD BE A RECALL FOR THIS, SINCE IT IS A SAFETY ISSUE, AND IF I CANNOT FIX IT, IT WILL COST ME $2400 FOR A NEW CYLINDER HEAD. *TR

TL*THE CONTACT OWNS A 2000 FORD F250. WHILE DRIVING APPROXIMATELY 50 MPH, THE INSTRUMENT PANEL CLUSTER STOPPED FUNCTIONING. THE CONTACT NEARLY CRASHED, BUT WAS ABLE TO MANEUVER OFF THE ROADWAY. HE DROVE TO A DEALER, BUT THEY COULD NOT ASSIST. THE CONTACT HAD TO PURCHASE A NEW PANEL FROM THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 89,000.

TL*THE CONTACT OWNS A 2000 FORD F250 HD. EVERY OTHER DAY, THE BRAKE LIGHTS AND TURN SIGNAL LIGHTS STOP WORKING. THE CONTACT MUST CONSTANTLY REPLACE THE FUSES. THE VEHICLE WAS TAKEN TO A MECHANIC AND HE DIAGNOSED FAILURE IN THE WIRING. HE STATED THAT THE FIVE ROUND WIRING HARNESSES IN WHICH TO TOW A CAMPER WAS PUT IN POOLY. THE CURRENT MILEAGE WAS 109,513 AND FAILURE MILEAGE WAS 94,650.

CPS FAILURE WHILE PULLING OUT OF A MAJOR HIGHWAY. *AK

WIFE RETURNED HOME WIITH COMPLAINT OF SMELL AND SMOKE FROM ENGINE COMPARTMENT. I OPENED THE HOOD AND FOUND FLAMES COMING FORM MASTER CYLINDER AREA. UPON FURTHER INSPECTION THE FIRE WAS CENTERED ON THE BRAKE PRESSURE SWITCH, AT THE ELECTRICAL CONNECTION. *AK

TL*THE CONTACT OWNS A 2000 FORD F250. WHEN THE CONTACT TURNS OFF THE VEHICLE AFTER IT HAS BEEN DRIVEN, IT WILL SUDDENLY RESTART AUTOMATICALLY. SHE MUST INSERT THE KEY AND TURN THE IGNITION SWITCH ON AND OFF IN ORDER TO TURN OFF THE VEHICLE. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE PRIOR TO THE FAILURE. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 150,000.

I HAVE A 2000 F 250 DIESEL PICKUP. THE ENGINE HAS STALLS AND THUS YOU LOOSE BRAKES AND POWER STEERING. IT HAS HAPPENED WHILE GOING A LOWW SPEED 2X RECENTLY.ALSO WHILE STOPPED . I HAD THE CAMSHAFT SENSOR WHEN THE TRUCK WAS ABOUT 3 YEARS OLD. IT IS NOW OCCURING MORE OFTEN.

VEHICLE DIED SUDDENLY AND FAILED TO RESTART. CPS WAS REPLACED, VEHICLE RAN. *JB

MY CPS IN MY 2000 7.3L TRUCK FAILED. *JB

SINCE 2006 AND BEFORE, I HAVE HAD UNEXPLAINED INCIDENCES OF BATTERY FAILURES AND DASHBOARD WARNINGS. THE WINDSHIELD WAS REPLACED IN 2006 AT MY REQUEST. MY BATTERY WAS REPLACED IN 2006. I ALSO HAD A TEMPORARY ENGINE SHUTDOWN ABOUT THIS TIME. I HAD BATTERY REPLACEMENT IN 2009 AND 2012. ON 11/02/2012 I ATTEMPTED TO START MY F250 ONLY TO DISCOVER ABOUT A PINT OF WATER IN THE FLOOR TRAY. I JUMP STARTED, CONTINUED THE TRIP ONLY TO DISCOVER THE HEATER FAN STILL OPERATING! AFTER FURTHER CHECKS, MY FORD DEALER PROVIDED A TSB 04-23-9 WHICH HAD NO WARNING OF THE POTENTIAL ELECTRONIC MALFUNCTIONS OR DAMAGES AND NOT MAILED TO ME. I HAD THE DEFECT CORRECTED BY A LOCAL SHOP AND FORD WAS MAILED MY COMPLAINT ON 11/28/2012 AND HAVE RECEIVED NO ANSWER. I HAVE HAD MORE THAN ENOUGH MAILING FOR SERVICE AND FORD SHOULD HAVE BEEN REQUIRED TO INFORM ME.

I HAVE A F250 FORD SUPER DUTY 7.3L DIESEL,YEAR 200 101,000 MILES.WHILE MY WIFE WAS TAKING THE KIDS TO SCHOOL A FIRE STARTED UNDER THE HOOD WITH THE CRUISE DEACTIVATION SWITCH.THIS IS IN A RECALL FOR F150 AND VANS BUT NOT MY F250 DIESEL.THIS FIRE WAS FLAMING UNDER THE HOOD WHEN MY WIFE PULLED INTO A GAS STATION.ACCORDING TO ZFORD THERE ARE NO RECALLS FOR THE F250 WITH THE SAME PART

WHILE CHANGING THE OIL, THE VEHICLE INADVERTENTLY CAUGHT ON FIRE. CONSUMER WAS ABLE TO STOP FIRE BY PULLING OUT WIRES WHERE FIRE WAS COMING FROM. *NM

CONSUMER COMPLAINED ABOUT THE ELECTRICAL SYSTEM. AT FIRST, VEHICLE LOST CRUISE CONTROL. THEN IT LOST THE BRAKE LIGHTS. WHEN TAKEN TO BE SERVICED, IT WAS DETERMINED THAT THE FAILURE WAS DUE TO A BLOWN OUT WIRING HARNESS CONNECTED TO THE CRUISE CONTROL.*AK