There are 110 stored owner reports matching the engine leading-label group for the 2000 Ford F-250 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 50 of 110 matching reports. This is a limited sample of up to 50 reports, ordered by incident date when available, not the complete group. The list controls page through the loaded reports only.
Open the full vehicle complaint log (all categories)WENT TO START ENGINE IN THE TRUCK AFTER SETTING OVER NIGHT UNDER MY CARPORT AND SPARK PLUG BLEW OUT OF THE HEAD . THIS TRUCK HAS A 5.4 LITER V8
SPARK PLUG BLEW WHILE DRIVING ON A CITY STREET, GOING 30 MILES PER HOUR. *TR
I HAVE HAD THREE DIFFERENT OCCASIONS WHERE THE SPARK PLUG HAS BLOWN OUT WHILE I WAS DRIVING TO AND FROM WORK AND TWO OF THE THREE TIMES I ALMOST HIT ANOTHER VEHICLE.WE FIXED THEM WITH NEW PARTS FROM AUTO STORE BUT WAS REMINDED THAT THE REPAIR IS ONLY TEMPORARY.TWO OR THE THREE TIMES I WAS ON A HIGHWAY IN BUSY TRAFFIC AND THE OTHER TIME I WAS ON A RURAL ROAD.
TL* THE CONTACT OWNS A 2000 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 55 MPH, A LOUD NOISE WAS HEARD UNDER THE HOOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SPARK PLUG THREAD IN THE ENGINE HEAD FAILED AND CAUSED THE SPARK PLUG TO SEPARATE FROM THE ENGINE. THE CONTACT INDICATED THAT THE FAILURE OCCURRED ON THREE SEPARATE OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.
BLUE A SPARK PLUG OUT OF HEAD, BROKE COIL IN PROCESS WHILE DRIVING DOWN HIGHWAY AT ABOUT 45MPH.
TL* THE CONTACT OWNS A 2000 FORD F-250. WHILE DRIVING 40 MPH, THE CONTACT NOTICED AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SPARK PLUGS BLEW OUT AND THE ENGINE CYLINDER HEAD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 163,000.
SPARK PLUG BLEW OUT OF MOTOR I AM THE ORIGINAL OWNER OF MY TRUCK. I HAVE ALWAYS HAD THE FORD DEALERSHIP PERFORM THE TUNE-UPS BECAUSE I AM AWARE OF THE ONGOING PROBLEMS WITH THE FORD 5.4 ENGINE AND SPARK PLUGS. I HAD MY DAUGHTER IN THE TRUCK WITH ME AT THE TIME OF THE SPARK PLUG COMING OUT AND CATCHING ON FIRE. THIS IS COMPLETELY UN-ACCEPTABLE, FORD MOTOR COMPANY OBVIOUSLY KNOWS ABOUT THE PROBLEM. BUT NOTHING HAS BEEN DONE TO CORRECT THE PROBLEM. I AM EXTREMELY UPSET ABOUT THE DANGEROUS SITUATION THIS PUT ME AND MY FAMILY IN. THERE IS NOTHING FORD COULD EVER DO TO HELP "MAKE THINGS RIGHT" IF SOMETHING WERE TO HAPPEN TO MY FAMILY. I SURE HOPE THAT FORD CAN BE RESPONSIBLE ENOUGH TO CORRECT THIS PROBLEM BEFORE SOMEONE GETS HURT. *TR
THIS IS MY THIRD PROBLEM WITH THE SAME TRUCK. THE SPARK PLUGS HAVE BEEN BLOWN OUT OF THE HEAD. EVERY TIME THAT I HAVE HAD THIS PROBLEM HAPPEN I HAD TAKEN IT TO A SHOP AND THEY HAVE FIXED IT. THIS HAS HAPPENED TO THREE DIFF. PLUGS, NOT THE SAME ONE. THIS LAST TIME THAT THIS HAPPENED THE SHOP TOLD ME THAT THE PLUG STRIPPED IT OUT SO BAD THAT IT CANT BE FIXED AND THAT I NEED A NEW HEAD OR ENGINE. I HAVE BEEN READING ALOT ABOUT THIS AND NOTHING IS HAPPEN, SO I THOUGHT THAT I WOULD REPORT IT AS WELL. *TR
I HAVE A 2000 FORD F-250 WITH A V-10 ENGINE. I HAVE HAD 5 OF MY 10 SPARK PLUGS BLOW OUT IN THE LAST YEAR. 4 OF THEM REQUIRED A HELO-COIL REPLACEMENT AT A COST OF ABOUT $1,600.00 TOTAL. THE SPARK PLUGS BLOW OUT WITHOUT WARNING RIPPING THE THREADS OUT OF THE HEADS, RENDERING THE TRUCK USELESS. IN THAT LAST INCIDENT I WAS TOWING A CAMPER WHEN IT BLEW LEAVING ME IN AN EXTREMELY HAZARDOUS AND DANGEROUS POSITION. I CAN NOT EMPHASIZE HOW DANGEROUS THIS PROBLEM IS. FORD TELLS ME I NOW NEED NEW HEADS AT A COST OF ABOUT $5,000.00. FORDS STATES THEY ARE NOT RESPONSIBLE AND WILL NOT DO ANYTHING ABOUT THIS, EVEN THOUGH THEIR HAVE BEEN THOUSANDS OF COMPLAINTS FOR THIS ISSUE. THEY TELL ME THAT IT IS UP TO THE NHTSA TO MAKE A RECALL. AND UNTIL THEY DO NOTHING WILL HAPPEN. THIS IS UNBELIEVABLE..... THIS IS NOT A BLOWN MUFFLER OR A BLOWN WINDSHIELD WIPER. THIS IS A SERIOUS PROBLEM THAT HAS BEEN GOING ON FOR YEARS YET NOTHING IS BEING DONE. WILL THE NHTSA STAND TALL HERE AND ORDER A RECALL OR PUSH IT OFF? *TR
BLOWN OUT SPARK PLUG WITH ORIGINAL EQUIPMENT. *TR
SPARK PLUG BLOW-OUT ON #4 CYL, POTENTIAL FIRE HAZARD. *TR
I WAS DRIVING MY 2000 FORD F-250 SUPER DUTY PICK UP TRUCK AT 35 MPH, WHEN I HEARD A LOUD BANG, I PULLED OVER RIGHT AWAY , WHEN I POPPED THE HOOD, I SEEN THE COIL WITH THE SPARK PLUG ON THE OTHER END ! IT HAD BLOWN RIGHT OUT OF THE ENGINE ! I HAVE READ A LOT OF BLOGS OUT THEIR AND I WAS VERY LUCKY, BECAUSE SOME PEOPLE HAVE HAD THIS HAPPEN AND THE PLUG BLEW OUT WITH SUCH FORCE IT HIT THE FUEL INJECTORS AND CAUSE AN ENGINE FIRE ! I DO NOT HAVE THE AMOUNT OF MONEY THAT FORD IS CHARGING TO FIX THIS ISSUES THAT THEY HAVE KNOWN FOR YEARS THAT I HAVE BEEN READING ! THEIR HAS BEEN PEOPLE THAT ARE RETAPPING WHERE THE PLUGS ARE GOING INTO ONLY TO HAVE THIS HAPPEN TO ANOTHER SPARK PLUG ! SOMEONE IS GOING TO GET KILLED HERE AND FORD NEEDS TO STEP UP TO THIS PROBLEM THESE 5.4 LITER TRITON MOTORS ARE HAVING ! I AM IN THE MILITARY AND JUST CAME HOME FROM IRAQ AND REALLY DONT HAVE TO MONEY TO GET IT FIXED THE RIGHT WAY ! HOPE YOU CAN HELP ? *TR
THIS IS THE THIRD TIME THE SAME SPARK PLUG HAS BLOWN OUT!!! *TR
THE SAME PLUG BLEW OUT AGAIN. *TR
I BOUGHT A NEW ENGINE ABOUT 5 YEARS AGO AND THE SPARK PLUG BLEW OUT. GOT IT "FIXED" FOR $200. *TR
I WAS TRAVELING ON I-90 IN ERIE,PA AND A SPARK PLUG BLEW OUT OF THE MOTOR. I LOST ALL POWER AND WAS NEARLY HIT FROM BEHIND. THE TRUCK IS A FORD F-250 WITH A TRITAN 5.4 L MOTOR. *TR
MY YEAR 2000 FORD F-250 TRUCK BURST INTO FLAMES IN MY DRIVEWAY TODAY AN HOUR AND A HALF AFTER I PARKED IT. IT'S A TOTAL LOSS. *TR
TL* THE CONTACT OWNS A 2000 FORD F-250 SD. THE CONTACT WAS DRIVING 40 MPH WHEN THE SPARK PLUGS DISCONNECTED FROM THE ENGINE. THE VEHICLE WAS INSPECTED BY THE DEALER WHO DRILLED INTO THE ENGINE AND REPLACED THE SPARK PLUGS BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THERE WERE NO FURTHER REPAIRS. THE FAILURE MILEAGE WAS 103,000 AND THE CURRENT MILEAGE WAS 103,050. THE VIN WAS UNAVAILABLE.
THE SPARK PLUGS ON MY TRUCK HAVE BLOWN OUT OF THE HEAD GASKET WHILE DRIVING ON THE HIGHWAY. I HAVE SPENT OVER $1300 REPAIRING/REPLACING THE SPARK PLUG AND THREADS ON THE HEADS. I HAVE BEEN READING ON THE INTERNET WHERE OTHER FORD OWNERS ARE HAVING THE SAME PROBLEM AND IT APPEARS THAT NOTHING IS BEING DONE TO CORRECT THE PROBLEM. THIS HAS HAPPENED TWICE TO ME SINCE I HAVE OWNED THE TRUCK. THE FIRST TIME WAS IN FEBRUARY 2011, SECOND TIME WAS APRIL 2015.
BLEW #2 PLUG OUT OF CYLINDER HEAD ON A FORD F 250 V10 TRITON ENGINE AT 36K MILES AND THEN RECENTLY AT 85 K MILES. PROBLEM LIES IN THE MANUFACTURING/DESIGN BY FORD. SPARK PLUGS HAVE FEW THREADS TO HOLD THEM IN THE CYLINDERS. ALSO ALUMINUM HEADS WON'T HOLD THE PLUGS. THOUSANDS ARE HAVING THIS SAME PROBLEM WITH THEIR FORDS. WHY NO RECALL????? I HAVE TO REPLACE THE HEAD TOTALING NEARLY $ 4000.00 TO FIX THIS! TALKED TO 3 OTHER FORD TRUCK OWNERS LOCALLY, AND THEY ALL HAVE HAD PLUGS BLOW OUT OF THEIR FORD TRUCKS TOO! WHAT GIVES????? THIS IS SAD AS THIS HAS BEEN HAPPENING FOR SEVERAL YEARS NOW AND FORD STILL FEELS LIKE THEY ARE NOT RESPONSIBLE!!! *TR
Showing 1-20 of 50 loaded complaints
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Sep 3, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.