2001 Ford F-250 Complaint Log

TURNED CORNER, HEARD A SUDDEN DRAGGING NOISE. CHECKED UNDER TRUCK. FUEL TANK STRAP HAD BROKEN AND FUEL TANK WAS DRAGGING. QUICKLY PULLED INTO DRIVEWAY. HAVING VEHICLE TOWED TO REPAIR SHOP. CALLED DEALER AND FOUND OUT THAT THERE WAS A RECALL ON THE SAME YEAR FORD TRUCK FOR F15 NOT F250. OBVIOUSLY APPEARS TO BE A PROBLEM IN OTHER MODELS.VERY LUCKY NO INJURIES, EXPLOSIONS, LEAKAGE, ETC...COULD HAVE BEEN BAD. FRUSTRATED. *TR

WAS DRIVING TRUCK ALL OF SUDDEN I HEARD A LOUD POP THEN LOUD SOUND COMING FROM UNDER THE HOOD. CALLED HUSBAND AND TOOK TRUCK BACK HOME (APPROXIMATELY 2 MILES). HUSBAND STARTED RESEARCHING PROBLEM AND FOUND ONLINE THAT SEVERAL PEOPLE HAVE HAD SPARK PLUGS EXPLODE AND HEARD SIMILAR SOUND, THIS CAUSED HIM TO REMOVE WIRES AND INSPECT SPARK PLUGS. ONE OF THE SPARK PLUG HAD POPPED OUT AND NOW THE THREADS CAN'T BE USED. I BELIEVE THIS IS A KNOWN PROBLEM AND FORD SHOULD BE RESPONSIBLE FOR THE DAMAGE. *TR

TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE STATED THAT A LARGE PUDDLE OF TRANSMISSION FLUID LEAKED FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT BOTH THE TRANSMISSION FRONT SEAL AND THE TORQUE CONVERTER WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.

WHILE I WAS DRIVING ALONG A HILLY, WINDING ROAD THE ENGINE OF MY 2001 F-250 DIESEL 4X4 TRUCK UNEXPECTEDLY SHUT OFF. I LOST STEERING AND BRAKING. THERE WERE NO LIGHTS ON THE DASH. THERE WAS NO PRIOR INDICATION OF ANY PROBLEM WITH THE ENGINE OR ELECTRICAL SYSTEM. I'VE HAD THE TRUCK FOR 12 YEARS AT THE TIME AND NEVER EXPERIENCED ANY PROBLEM LIKE THIS. I WAS VERY FORTUNATE TO HAVE BEEN ABLE TO GET THE TRUCK TO THE ROAD'S SHOULDER. AFTER THE TRUCK STOPPED I PUT THE SHIFT INTO PARK. THE KEY WAS STILL IN THE RUN POSITION. I SIMPLY TURNED IT TO THE START POSITION AND THE ENGINE STARTED RIGHT UP. I TOOK IT IMMEDIATELY TO THE LOCAL FORD DEALER WHO RAN DIAGNOSTICS ON THE TRUCK. THEY FOUND NO INDICATION OF A PROBLEM OTHER THAN ONE BATTERY'S VOLTAGE WAS SLIGHTLY LOW, BUT NOT OUT OF ACCEPTABLE RANGE. I REPLACED BOTH BATTERIES AS THEY WERE ALMOST 3 YEARS OLD. SO FAR, I'VE NOT EXPERIENCED THIS PROBLEM AGAIN. *JS

TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, THE VEHICLE STARTED TO EXHIBIT AN ABNORMAL STUTTERING NOISE AND THE CONTACT NOTICED THAT THE EXHAUST MANIFOLD WAS LEAKING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 72,000. *TR

DRIVER SEATBELT UNLATCHES UNEXPECTEDLY. THERE DOESN'T SEEM TO BE ANY PARTICULAR CAUSE FOR THE LATCHING FAILURE. *TR

WHILE SHOPPING MY F250 TRYED TO BURN DOWN IN PARKING LOT 2ND TIME AT A SCHOOL SOCCER GAME AND 4 THE THIRD TIME RIGHT IN FRONT OF MY HOUSE AND STILL AFTER THOUSANDS IN REPAIRS STILL SAME ISSUE FORD NEEDS TO MAN UP AN ADDRESS THIS SITUATION..... [XXXX] KEY NEVER IN TRUCK ALL THREE TIMES THIS HAS OCCURED REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE WAS RUNNING VERY ROUGH. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE SENDING UNIT HAD FAILED. THE DEALER ALSO STATED THAT THE FUEL TANK STRAPS HAD CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 252,000. THE VIN WAS UNAVAILABLE.

REAR SEAT BELT BUCKLE HAS BROKEN LATCHING MECHANISM WITHIN FEMALE BUCKLE. THIS ITEM IS NOT AVAILABLE FROM THE MANUFACTURER. SEAT BELT NOT AVAILABLE FROM THE MANUFACTURER ON A 14 YEAR OLD VEHICLE ? *TR

WHEN THE TRUCK IS STOPPED OR WHEN PARKING, THE POWER STEERING DISAPPEARS. WITH THE BRAKE APPLIED, THE STEERING WHEEL WON'T MOVE AT ALL. WITH THE BRAKE RELEASED, IT'S NEAR IMPOSSIBLE TO TURN THE STEERING WHEEL. I PURCHASED THIS TRUCK USED TWO YEARS AGO WITH JUST UNDER 11,000 MILES. IT IS LIKE NEW. THIS PROBLEM IS ANNOYING AT BEST AND COULD BE DANGEROUS IN AN EMERGENCY MANEUVER WITH HARD BRAKING. *TR

TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, HE ATTEMPTED TO ACTIVATE THE CRUISE CONTROL BUT IT WOULD NOT ENGAGE. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THE CONTACT THAT BRAKE FLUID WAS LEAKING FROM THE CRUISE CONTROL SWITCH AND THE SWITCH WOULD NEED TO BE REPLACED. THE DEALER ALSO STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 70,000. UPDATED 1/15/13 *CN UPDATED 1/25/13 *JS

TL* THE CONTACT OWNS A 2001 FORD F-250 EQUIPPED WITH MICKEY THOMPSON/BAJA ATZ TIRES, TIRE SIZES 35 * 12.50 R20. THE CONTACT STATED THAT WHILE TRAVELING 70 MPH, THE RIGHT FRONT PASSENGER TIRE BLEW OUT AND CAUSED THE CONTACT TO RUN OFF THE SIDE OF THE ROAD. THE CONTACT WAS NOT INJURED. THE CONTACT STATED THE BELT SEPARATED FROM THE TIRE. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER:06T024000(TIRES:TREAD/BELT) THE FAILURE AND CURRENT MILEAGE WAS 2360,000. UPDATED 11/19/12 *BF THE CONSUMER STATED THE DISCOUNT TIRE MANAGER REFUSED TO REPLACE THE TIRE OR GIVE A DOCUMENT STATING THERE WAS NO FAILURE WITH THE TIRE. THE MANAGER DID BALANCE THE TIRE BUT WOULD NOT PRINT A RECEIPT FOR THE CUSTOMER. ON 10/15/2012 THE CONSUMER FILED A REPORT WITH COOPER TIRE OVER THE PHONE AND WAS TOLD A PACKAGE WOULD BE SENT OUT. ON 10/30/2012 3 TIRES WERE BALANCED VIBRATING RECURRED. UPDATED 11/20/2012 *JS

TL* THE CONTACT OWNS 2001 FORD F-250. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IT CAUGHT FIRE AND THE FLAMES WERE COMING FROM UNDER THE HOOD. THE POLICE AND THE FIRE DEPARTMENT WERE NOTIFIED AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 59,075.

TL* THE CONTACT OWNED A 2001 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE WAS PARKED OUTSIDE OF HIS HOME WHEN HE HEARD A LOUD BANG. THE CONTACT INSPECTED THE VEHICLE AND NOTICED SMOKE AND FLAMES COMING FROM THE FRONT DRIVER'S SIDE WHEEL WELL AND UNDER THE HOOD. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE USING A WATER HOSE. THE FIRE DEPARTMENT WAS NOTIFIED AND A REPORT WAS FILED. THE FIRE INVESTIGATOR DETERMINED THAT THE FIRE BEGAN ON THE FRONT DRIVER'S SIDE, IN BETWEEN THE BRAKE BOOSTER AND BATTERY. THE VEHICLE WAS DESTROYED. THE OTHER RESIDENT OF THE HOME SUSTAINED SMOKE INHALATION AND WAS TREATED BY PARAMEDICS AT THE SCENE. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 09V399000 (VEHICLE SPEED CONTROL), WHICH THE VEHICLE WAS INCLUDED IN AND REPAIRED APPROXIMATELY THREE YEARS PRIOR. THERE WAS ANOTHER RECALL THAT MAY BE RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 06V286000 (VEHICLE SPEED CONTROL), BUT THE CONTACT WAS NOT AWARE IF THE VIN WAS INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

WE BOUGHT THE TRUCK ON 06/17/07 AND NEVER HAD ANY PROBLEM WITH IT. THE DAY BEFORE THE INCIDENT I DROVE THE TRUCK AND PARK IT AT 6PM, TAKE THE KEY OUT AND PUT IT UNDER THE MATE. THE NEXT DAY AT ABOUT 10:30AM OR 11 AM I SMILED SOME THING BURNING, I LOOKED OVER AND SAW A CLOUD OF SMOKE COMING FROM THE TRUCK, I TRIED TO BUT THE FIRE OUT WITH THE FIRE EXTINGUISHER, BUT NO LUCK. THE FIRE DONE SPREAD EVERY WHERE. CALLED 911 AND BY THE TIME THEY GOT THERE THE FIRE GOT THE TRUCK AND THE SIDE OF A HOUSE THAT WAS PARKED NEXT TO IT. *TR

WHILE DRIVING 55 MPH, HEARD A LOAD BANG AND THEN A STEADY POPPING SOUND. AFTER PULLING OFF ROAD TO CHECK PROBLEM OPEN THE HOOD TO SEE THE COIL EXPLODED AND ARCHING AGAINST FUEL RAIL, AND SPARK PLUG ON THE VALVE COVER. GOT THE TRUCK HOME STARTED RESEARCHING THIS ISSUE AND I SEE THIS IS A COMMON PROBLEM YET FORD SAYS IT ISN'T. MY BEST EDUCATED REPAIR SOLUTION IS CAL VAN 38900 FORD 5.4L SPARK PLUG PORT REPAIR KIT AT A COST OF 250 . IT TOOK A DAY AND A HALF TO DO A COMPLETE REPAIR. SEEMS TO BE WORKING BUT FORD HAS A PROBLEM AND SHOULD DO SOMETHING FOR THE OWNERS SHOULD IT HAPPEN. THEY CANT SAY THIS IS A TORQUE ISSUE THIS ARE THE FACTORY PLUGS AND COIL. SO IF THEY TORQUE THEM WRONG AT THE FACTORY. *TR

DRIVER SIDE SEAT BELT UNLATCHES AT RANDOM. I'VE SEEN COMPLAINTS ABOUT THIS ON THIS WEBSITE, SO I'M NOT THE ONLY ONE HAVING THIS PROBLEM. PROBLEM HAS BEEN GOING ON FOR A FEW YEARS AND I DON'T KNOW THE DATE OR MILEAGE WHEN IT STARTED HAPPENING. THE DEALER JUST TRIED TO SELL ME A NEW LATCH FOR AROUND A HUNDRED BUCKS. SEAT BELT LATCHES DON'T JUST WEAR OUT THAT EASY, MY '73 MUSTANG HAS LATCHES THAT STILL WORK. *TR

VEHICLE WAS PARKED IN MY GARAGE AND AT 2:30 AM SMOKE ALARMS WENT OFF AND SMOKE WAS COMING OUT OF GARAGE AND MY HOUSE BURNED DOWN. FIRE INVESTIGATOR TOLD ME WAS FROM FAULTY CRUISE CONTROL SWITCH ON FORD F250. *TR

TL* THE CONTACT OWNS A 2001 FORD F250 SD. THE CONTACT STATED THE VEHICLE WAS PARKED WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE, ADVISING THAT THE FIRE WAS CAUSED BY AN ELECTRICAL MALFUNCTION. A FIRE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED OF THE FIRE WHO ADVISED THAT THEY WOULD NOTIFY HIM WITHIN 15 DAYS. THE FAILURE MILEAGE WAS 54,000.

MY THIRD UNIROYAL LIBERATOR TIRE HAS FAILED IN THE SAME MANNER AS THE TWO BEFORE. THIS IS MY THIRD COMPLAINT CONCERNING THESE DEFECTIVE TIRES. THESE TIRES ALL FAILED IN THE SAME EXACT MANNER (TREAD/TIRE SEPARATION) AND ALL WITHIN WEEKS OR MONTHS OF EACH OTHER. THE TREAD PULLED LOOSE FROM THE CARCASS,CAUSING A BUMP-IMBALANCE. I RECOGNIZED THE FAILURE AND WAS ABLE TO DRIVE HOME WHERE I CHANGED TO A SPARE. I LATER REPLACED THIS TIRE. THIS TIRE ONLY HAVE ABOUT 37,000 MILES. WALMART,WHERE I PURCHASED THE TIRES,REFUSES TO GIVE ANY TYPE OF WARRANTY OR TIRE CREDIT AND NO LONGER CARRY THIS TIRE. THIS TIRE HAD PLENTY OF TREAD AND WAS WELL WITHIN ITS LIFE SPAN. THIS LIBERATOR TIRE SHOULD BE RECALLED AND PULLED OFF THE MARKET BECAUSE OF ITS CONSISTENT FAILURE RATE. I HAVE SENT COMPLAINTS TO UNIROYAL WITH NO RESPONSE. PLEASE HAVE A RECALL BEFORE SOMEONE GETS KILLED OR INJURED. THESE THINGS ARE JUNK. *TR

ON SEPTEMBER 12, 2011, A KUMHO ROAD VENTURE AT TIRE, SIZE LT235/85R16, DOT K2ORYD4A3508 (MANUFACTURED AT KUMHO?S BINH DUONG PLANT IN VIETNAM IN THE 35TH WEEK OF 2008) SUFFERED A CATASTROPHIC TREAD SEPARATION, RESULTING IN SEVERE INJURIES TO THE FRONT SEAT PASSENGER OF THE FORD F-250 AND THE DEATH OF HER SON, WHO WAS 32 WEEKS OLD AND STILL IN UTERO. A LAWSUIT HAS BEEN FILED AGAINST KUMHO TIRE CO., INC. AND KUMHO TIRE U.S.A., INC. IN THE UNITED STATES DISTRICT COURT FOR THE DISTRICT OF KANSAS (CASE NO. 2:13-CV-02393-JTM-TJJ). DURING THE DISCOVERY STAGE OF THE CASE, THE PASSENGER RETAINED TROY COTTLES, A RENOWNED TIRE FAILURE EXPERT. AFTER INSPECTING THE SUBJECT TIRE, MR. COTTLES FOUND THE FOLLOWING DEFECTS IN THE SUBJECT TIRE: (1) INADEQUATE BONDING BETWEEN BELTS (TRAPPED AIR/STEAM BLISTER IMPRESSIONS); (2) PREMATURE OXIDATION OF THE BELT SKIMS; (3) BELTING DEFECTS (COINCIDENTAL BELT ENDINGS, IRREGULAR BELT WIRE SPACING, GAPPED BELT SPLICES, DOG-EARED SPLICES, SNAKING, AND SPREAD CABLES); (4) CORD SHADOWS ON THE INNERLINER; (5) LOW TOP BELT WIDTH TO TREAD WIDTH RATIO; AND (6) INADEQUATE APPLICATION OF NYLON CAP PLIES. AS PART OF HIS WORK ON THE CASE, MR. COTTLES TESTED TWO EXEMPLAR KUMHO ROAD VENTURE AT TIRES OF THE SAME SIZE AS THE SUBJECT TIRE THAT WERE ALSO MANUFACTURED AT KUMHO?S VIETNAM PLANT. BOTH OF THOSE TIRES FAILED IN SIDEWALL FAILURE MODE IN APPROXIMATELY 10,000 MILES OR LESS UNDER PROPER LOADS, INFLATIONS, AND SPEEDS THAT WERE MONITORED DAILY. SEE ATTACHED TEST REPORTS AND PHOTOGRAPHS. THIS INFORMATION IS BEING SUBMITTED BY THE ATTORNEYS FOR THE INJURED PASSENGER, AND WITH HER PERMISSION, IN HOPES THAT THIS TIRE (AND THOSE SIMILAR TO IT) WILL BE INVESTIGATED AND RECALLED TO ENSURE NO ONE ELSE IS NEEDLESSLY INJURED OR KILLED AS A RESULT OF THESE DANGEROUS AND DEFECTIVE TIRES....UPDATED 07/30/15 *BF UPDATED 10/23/2017*CN

WHEN DRIVING AT NORMAL SPEEDS IN A 2001 F-250 SD 5.4 LITER, SLOWED TO MAKE A STOP AND THEN PROCEEDED ON AND THERE WAS A LOUD POP AND THE TRUCK STARTED RUNNING ROUGH AND MAKING A LOT OF NOISE FROM UNDER THE HOOD. IT TURNED OUT THAT A SPARK PLUG HAD BLOWN OUT OF THE CYLINDER WALL CAUSING THE NOISE AND ROUGH RUNNING. THESE PLUGS HAD JUST BEE REPLACED ABOUT 1 YEAR AGO. THE TRUCK HAD TO BE TOWED TO A REPAIR SHOP ALMOST 100 MILES TO BE REPAIRED. FROM WHAT I UNDERSTAND FROM MY MECHANIC THIS IS AN ONGOING PROBLEM WITH THIS ENGINE. *TR

I CURRENTLY OWN A 2001 F250 7.3 DIESEL TRUCK. I ALONG WITH MANY OTHER PEOPLE IN THIS COUNTRY ARE SCARED TO DRIVE THEIR TRUCKS. I HAVE HAD SEVERAL INCIDENTS, BUT THE MOST RECENT WAS IN AUGUST 2011. I WAS DRIVING DOWN THE HIGHWAY AT 65 MPH ( THE SPEED DOESN'T MATTER FOR THE FAILURE). THE TRUCK IS VERY HARD TO KEEP CONTROL OF, IT SHAKES VIOLENTLY AND WALKS BACK AND FORTH. IT IS VERY DIFFICULT TO KEEP THE TRUCK IN ONE LANE. IT GOT SO BAD THAT I COULDN'T KEEP CONTROL OF IT AND BEGAN GOING FROM ONE SIDE TO THE OTHER TRYING TO GET CONTROL. OTHER VEHICLE'S ON THE ROAD GOT AWAY FROM MINE OR I WOULD HAVE HIT THEM. IT TOOK A WHILE TO GET CONTROL OF THE TRUCK. I DON'T KNOW HOW WE DIDN'T GO FLYING OFF THE HIGHWAY AND KILLED. THERE ARE ALOT OF PEOPLE WITH THIS SAME PROBLEM WITH THIS TRUCK. THERE IS SO MUCH "PLAY" IN THE STEERING THAT CAN'T BE CORRECTED. THE FORD DEALERSHIP SAYS THAT THERE IS NOTHING THEY CAN DO TO FIX IT. THIS VEHICLE IS DANGEROUS!!!! TO DRIVE AND SOMEONE IS GOING TO BE KILLED IF SOMETHING IS NOT DONE. APPARENTLY THIS IS NOT THE BEGINNING OF COMPLAINTS ABOUT THIS PROBLEM. I AM PRETTY SURE PEOPLE HAVE DIED AS A RESULT OF THIS FAILURE, BUT IT WENT UN NOTICED BECAUSE THEY WERE BLAMED FOR "OVERCORRECTING". THIS IS A SERIOUS ISSUE AND NEEDS TO BE ADDRESSED. THANK YOU FOR YOUR CONSIDERATION IN THIS PROBLEM. *TR

ON VACATION IN MAINE WITH MY 2001 FORD F250 SUPER DUTY I WAS DRIVING DOWN A VERY NARROW, HEAVILY WOODED TWO LANE ROAD AT ABOUT 20 MPH, SUDDENLY AND WITHOUT WARNING A LOUD BANG UNDER THE HOOD OCCURRED. DIFFICULT TO PULL OVER SAFELY AND INVESTIGATE. I HAD TO DRIVE SEVERAL HUNDRED FEET TO TRY TO GET ON A STRAIGHT AWAY FOR SAFETY. THERE WERE SEVERAL LOG TRUCKS THAT HAD TO PASS AS WELL AS OTHER TRAFFIC. I DISCOVERED THAT THE #6 SPARK PLUG HAD "BLOWN OUT" OF ITS HOLE AND DESTROYED THE THREADS, COIL PACK, AND SPARK PLUG. AFTER GETTING THE TRUCK TO A REPAIR FACILITY THE OWNER/MECHANIC INFORMED ME THAT THIS 5.4L TRITON ENGINE DOES THIS ALL THE TIME. HE INFORMED ME THAT HE REPAIRS TWO OR THREE OF THESE A WEEK, IN FACT THERE IS A "REPAIR KIT" AVAILABLE FROM MOST AUTO PART STORES. DOING SOME RESEARCH AFTER GETTING HOME I DISCOVERED THAT THIS IS A CHRONIC FORD PROBLEM THAT THEY REFUSE TO ADDRESS. I WILL BE SELLING THIS TRUCK BECAUSE IT IS A HUGE SAFETY ISSUE FOR ME. I DON'T NEED TO BE STRANDED ON BACK COUNTRY ROADS OR INTERSTATES WITH ANY OF THE OTHER 7 SPARK PLUGS READY TO LAUNCH FROM MY ENGINE WITHOUT WARNING OR CAUSE. *TR

TL* THE CONTACT OWNS A 2001 FORD F250. THE CONTACT STATED WHILE DRIVING 5 MPH THE ENGINE CAUGHT ON FIRE. THERE WERE FLAMES COMING FROM UNDER THE VEHICLE. AFTER STOPPING ON THE SIDE OF THE ROAD, THE ENTIRE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED AND PUT THE FIRE OUT. A REPORT WAS AVAILABLE IF NEEDED. THE ORIGIN OF THE FIRE WAS UNKNOWN. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE DEALER WHO WILL INSPECT THE VEHICLE. THE MANUFACTURER WAS CONTACTED WHO STATED THEY WILL SEND A REPRESENTATIVE OUT WITHIN THE NEXT TWENTY DAYS TO INSPECT THE VEHICLE. THE FAILURE MILEAGE WAS 220,000. UPDATED 09/27/11 *BF UPDATED 10/05/11

THE TRUCK WAS PARKED INSIDE A METAL BUILDING WHEN THE FIRE OCCURRED AROUND 1:41 A.M. WHILE BUSINESS WAS CLOSED. FIRE ORIGINATED FROM A FAILURE IN THE BRAKE SWITCH MOUNTED ON THE MASTER CYLINDER RESULTING IN THE VEHICLE BEING DESTROYED AND DAMAGE TO THE BUILDING AND CONTENTS.

WHILE DRIVING MY 2001 FORD F250 5.4 L V8 ENGINE POWERED TRUCK THE SECOND (2ND) SPARK PLUG ON THE PASSENGER SIDE OF THE ENGINE BLEW OUT (WAS EJECTED) FROM THE HEAD. THIS WAS AN ORIGINAL SPARK PLUG ON THE 2001 F250 TRUCK WITH 75300 ORIGINAL MILES ON IT. *KB

JULY 7, 2011, MY 2001 FORD F250 DIESEL, CAUGHT ON FIRE WHILE MY TRUCK WAS IN DRIVEWAY. I WAS ABLE TO PUT FIRE OUT BUT MY TRUCK WAS RENDERED INOPERABLE. FORD HAS CLAIMED SEVERAL THINGS THAT CAUSED THE FIRE INCLUDING A BACKFIRE (WHICH DIESELS DO NOT DO) AND THE MECHANICS I HAVE HAD TO LOOK AT IT, INCLUDING THE LOCAL FORD DEALER'S MECHANIC, CAME TO THE SAME CONCLUSION, IT WAS THE CRUISE CONTROL. FORD REFUSES TO FIX MY VEHICLE, AND I HAVE BEEN WITHOUT TRANSPORTATION SINCE THEN. I DO NOT HAVE THE ALMOST $3,000.00 THAT IT WILL COST TO FIX MY TRUCK. *TR

WE HAVE A 2001 FORD F250 SD, 5.4 LITER TRITON V8. THERE WAS AN AWFUL TICKING NOISE FOR A FEW WEEKS AND ON MONDAY, JULY 4TH, WHILE RESTARTING THE TRUCK IT MADE A HUGE POP NOISE FOLLOWED BY A VERY LOUD TICK THAT SOUNDED LIKE AN EXHAUST LEAK. IT WAS SO LOUD THAT MY 2 YEAR OLD SON WAS SCARED. AFTER CONTACTING FORD AND MANY AUTO SHOPS WE LEARNED THIS WILL COST US OVER 500 DOLLARS AND THAT THEY HAVE SERVICED OVER 10 VEHICLES IN THE LAST MONTH WITH THE SAME PROBLEM!! WHAT? AND AFTER RESEARCH HAVE NOTICED THAT THERE HAVE BEEN COMPLAINTS DATING BACK TO 2006 AND NO RECOURSE BY OWNERS! WHAT? THIS SAFETY ISSUE NEEDS TO BE FIXED! IT IS SO DANGEROUS. WE ARE REPAIRING OUR VEHICLE USING THE MECHANIC THAT FORD RECOMMENDED, HE WILL BE CHANGING THE COIL AND ADDING PINS TO IT TO ENSURE THAT IT WON'T HAPPEN AGAIN FOR THAT PLUG, BUT THE OTHERS...KEEPING OUR FINGERS CROSSED THAT NOTHING ELSE HAPPENS BEFORE FORD GETS THEIR STUFF TOGETHER AND FIXES THIS!! *TR

WE HAVE A 2001 FORD F250 SD, 5.4 LITER TRITON V8. THERE WAS AN AWFUL TICKING NOISE FOR A FEW WEEKS AND ON MONDAY, JULY 4TH, WHILE RESTARTING THE TRUCK IT MADE A HUGE POP NOISE FOLLOWED BY A VERY LOUD TICK THAT SOUNDED LIKE AN EXHAUST LEAK. IT WAS SO LOUD THAT MY 2 YEAR OLD SON WAS SCARED. AFTER LOOKING UNDER THE HOOD, I SAW THE SPARK PLUG HAD BEEN DISLODGED FROM THE HEAD, THE THREADS WERE STRIPPED AND I CANNOT REPAIR IT MYSELF!! THEN AFTER CONTACTING FORD AND MANY AUTO SHOPS WE LEARNED THIS WILL COST US OVER 500 DOLLARS AND THAT THEY HAVE SERVICED OVER 10 VEHICLES IN THE LAST MONTH WITH THE SAME PROBLEM!! WHAT? AND AFTER RESEARCH HAVE NOTICED THAT THERE HAVE BEEN COMPLAINTS DATING BACK TO 2006 AND NO RECOURSE BY OWNERS! WHAT? THIS SAFETY ISSUE NEEDS TO BE FIXED! IT IS SO DANGEROUS. WE ARE REPAIRING OUR VEHICLE USING THE MECHANIC THAT FORD RECOMMENDED, HE WILL BE CHANGING THE COIL AND ADDING PINS TO IT TO ENSURE THAT IT WON'T HAPPEN AGAIN FOR THAT PLUG, BUT THE OTHERS...KEEPING OUR FINGERS CROSSED THAT NOTHING ELSE HAPPENS BEFORE FORD GETS THEIR STUFF TOGETHER AND FIXES THIS!! *TR

I HAD ANOTHER UNIROYAL LIBERATOR TIRE (265/75/16 E-RATED, LIGHT TRUCK TIRE) FAILURE. BOTH TIRES FAILED WITHIN ONE THOUSAND MILES OF EACH OTHER AND IN THE SAME EXACT WAY. I FILED A COMPLAINT WITH NHTSA ON THE FIRST TIRE APPROX. 2-MONTHS AGO. BOTH TIRES AT ABOUT 35 TO 36,000 MILES, WHILE DRIVING AT SPEEDS APPROACHING 65 MPH FORMED A BALLOON ON TOP OF THE TREAD CAUSING AN IMBALANCE. AFTER CHANGING THE TIRE, IT EXPLODED IN THE BED OF MY TRUCK. IT WAS OBVIOUS TO ME THAT A TREAD SEPARATION HAD OCCURRED. ONE COULD SEE THE SMOOTH AREAS WHERE THE TREAD HAD SEPARATED FROM THE BELT CARCASS VERSUS THE AREA WHERE THE TREAD PULLED AWAY WHEN IT EXPLODED. THESE UNIROYAL LIBERATORS SHOULD BE RECALLED BECAUSE OF HOW QUICKLY THIS FAILURE OCCURS. BOTH TIRES HAD PLENTY OF TREAD AND WERE RUN WITHIN THE PROPER PRESSURE RANGES (70 TO 80 PSI). I HAVE SENT UNIROYAL EMAIL COMPLAINTS CONCERNING THESE TIRES. I HAVE ONE REMAINING ON MY TRUCK THAT WILL BE REPLACED BECAUSE I KNOW IT WILL ALSO FAIL ANY MOMENT. PLEASE DO WHAT YOU CAN TO GET THESE TIRES OFF THE MARKET. THE TIRES DATE OF MANUFACTURE WAS 14TH WEEK OF 2007. *TR

SPARK PLUG EJECTED FROM THE MOTOR WHILE DRIVING. BLEW OUT THE COIL AND STRIPPED THE THREADS. 5.4 LITER TRITON ENGINE WITH 122,000 MILES. *TR

I OWN A 2001 FORD F250 SUPER DUTY 4X4 TRUCK. AFTER PURCHASING TRUCK USED, I REPLACED ALL STEERING COMPONENTS WITH O.E EQUIPMENT SPECIFICATIONS AT CERTIFIED REPAIR FACILITIES. ALL FACILITIES CERTIFIED ALL STEERING PARTS IN ORIGINAL SPECIFICATION FORM. DESPITE ALL THIS, THE TRUCK WOULD SHAKE VIOLENTLY UPON HITTING ANY KIND OF ROUGH ROADS OR POTHOLES. AFTER READING OTHER COMPLAINTS, I REALIZED THIS IS DEFECT WITH THE TRUCK EVEN GOING TO 2007 MODEL YEAR. THIS TRUCK IS DANGEROUS!! DANGEROUS!! DANGEROUS!!!!!!!!. NEEDS TO BE RECALLED AND FAIR MARKET VALUE GIVEN TO THE BUYERS. SOMEONE WILL GET KILLED. A DRIVER SHOULD NOT HAVE TO FEAR DRIVING A TRUCK ON ANY ROAD EXCEPT A PERFECTLY SMOOTH ONE WHICH DOES NOT EXIST. I ALMOST DIED DRIVING THIS TRUCK CROSSING THE WALT WHITMAN BRIDGE FROM NJ TO PA. I AM NOT ALONE. NHTSA HAS COMPLAINTS AGAINST THE F250 SD 4X4 GOING INTO 2007 MODEL YEAR. GIVE FAIR MARKET VALUE AND RECALL THE TRUCKS. OWNERS CAN GET THE CREDIT TOWARD PURCHASE OF NEW OR USED FORD TRUCKS MODELS THAT DO NOT SUFFER FROM THIS DEFECT. FORD WILL NOT LOSE IF THEY ACKNOWLEDGE THEIR MISTAKE WHILE NO ONE DIED OR SERIOUSLY INJURED YET!!!!. *TR

CONCERNING TREAD SEPARATION ON UNIROYAL LIBERATOR A/T LT 265/75R16 TIRE PURCHASED FROM WALMART ON 092007,APPROX. 36,000 MILES ON TIRE. USED ON 2001 FORD F-250,DIESEL, REAR WHEEL DRIVE. THE TIRE HAS DOT MARKING AS FOLLOWS: DOT BFW8 C62U 0807, E RANGE RATED. ON MARCH 23 2011 WHILE DRIVING AT 65 MPH I FELT BAD VIBRATION AND WHEN SAFE, PULLED OFF ROADWAY TO FIND THE RIGHT REAR TIRE TO HAVE A BULGE ON TREAD AND SIDE WALL DISTORTION. I HAVE HAD THIS SAME FAILURE FROM COOPER TIRES WHICH CAUSED LOSS OF CONTROL AND DESTRUCTION TO QUARTER PANEL. I CHANGED THE TIRE AND LATER (03302011) CONTACTED UNIROYAL WHO OPENED A FILE BASED ON MY PHONE NUMBER([XXX]). UNIROYAL CLAIMS NO RECALL NOR DO THEY ACKNOWLEDGE ANY SIMILAR COMPLAINTS ON THIS TIRE. I HAVE 3 OF THESE TIRES AND HAVE SAFETY CONCERNS ON THE 2-REMAINING TIRES IN USE. AT TIMES I PULL AN RV OR A BOAT AND MUST HAVE AN ASSURANCE THAT THESE TIRES WILL BE SAFE TO USE. *TR INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

AT VARIOUS TIMES, THE DRIVER'S SIDE SEAT BELT BUCKLE WILL RELEASE CAUSING THE BELT TO BECOME LOOSE. IT HAPPENS AT ALL SPEEDS AND USUALLY WILL HAPPEN MULTIPLE TIMES DURING A TRIP OR NOT AT ALL. I HAVE NEVER HAD IT HAPPEN ON THE PASSENGER'S SIDE SEAT BELT. *TR

I AM AN OWNER OF A 2001 F-250 SUPER DUTY, I HAVE HAD THE PROBLEM WITH SPARK PLUG EJECTION FROM THE HEADS OF MY MOTOR. THE FIRST TIME THIS HAPPENED WAS WITH THE OEM PLUGS STILL IN THE MOTOR, THE SECOND TIME I HAD THE BLOW OUT REPAIRED ALREADY AND ALL PLUGS WERE REPLACED BUT YET AGAIN A LITTLE OVER A YEAR LATER THE PLUG IN ANOTHER HOLE BLEW OUT. THIS TIME I HAD ALL HOLES PATCHED WITH A STAINLESS STEEL INSERT. BOTH TIMES I HAD TO PAY WELL OVER $50.00 FOR TOWING AND THE LAST REPAIR BILL WAS IN EXCESS OF $800.00. I AM A FULL TIME STUDENT AND SINGLE FATHER I DO NOT HAVE THE RESOURCES TO PAY FOR CONSTANT REPAIRS BECAUSE OF AN ENGINEERING PROBLEM WITH OEM EQUIPMENT, FROM WHAT I HAVE SEEN ON THE INTERNET AND TOLD BY MY MECHANICS THIS IS HAPPENING TO ALMOST EVERY VEHICLE WITH THESE TYPES OF MOTORS. THANK YOU FOR YOUR TIME AND EFFORT IN LOOKING INTO THIS MATTER. *TR

TL* THE CONTACT OWNS A 2001 FORD F-250 SD DIESEL. THE CONTACT STATED THAT THE VEHICLE WAS PARKED AND IDLE WHEN IT ATTEMPTED TO START INDEPENDENTLY. THE KEYS WERE NOT IN THE IGNITION AT THE TIME OF FAILURE. THE CONTACT DISCONNECTED AND RECHARGED THE BATTERY. ONCE THE BATTERY WAS REINSTALLED IN THE VEHICLE, THE VEHICLE FAILED TO START. HE THEN CONTACTED SEVERAL LOCAL MECHANICS ABOUT THE FAILURE BUT NO ONE COULD PROVIDE AN EXPLANATION OF THE FAILURE. SEVERAL AUTHORIZED DEALERS WERE ALSO CONTACTED BUT AGAIN THEY TOO, COULD NOT PROVIDE AN EXPLANATION FOR THE FAILURE. THE FAILURE DID NOT RECUR AND THE MANUFACTURER WAS NOT CONTACTED TO REPORT THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 113,000.

I HEARD A NOISE LIKE A LOOSE ROCKER ARM AND TOOK IT TO A MECHANIC AND WAS TOLD NOT TO WORRY. THEN AT THE BANK THE NOISE CHANGED AND QUIT "TICKING" AND BY THE TIME I PULLED OUT OF THE LINE I HEARD A LOUD "POP" AND THEN A CONTINUAL POPPING NOISE, AFTER I GOT PULLED OVER I CHECKED UNDER THE HOOD AND THE SPARK PLUG CLOSEST TO THE DRIVERS SEAT WAS OUT. WITH FUEL COMING OUT AND A SPARK PLUG FIRING ON THE MOTOR, I AM AMAZED IT DID NOT CATCH FIRE. *TR

VIOLENT SHAKE IN STEERING UPON ENCOUNTERING LESS THAN SMOOTH ROAD. *TR

DRIVING MY TRUCK ON HIGHWAY. THE SPARE TIRE CABLE BROKE THE TIRE WENT UNDER A TRAILER AND BENT TWO RIMS AND THE AXLE. I BOUGHT THE TRUCK NEW HAS 60,900 MILES THE SPARE HAS NEVER BEEN OF THE TRUCK. *TR

I OWN A 2001 FORD F 250 SUPER DUTY WITH A 6.8 LITER V10 THIS IS THE SECOND TIME NOW THAT IT HAS BLOWN OUT A SPARKPLUG WHILE DRIVING DOWN THE ROAD AT A HIGH SPEED THEY WERE NOT THE SAME PLUG AND THEY ARE ORIGINAL MOTORCRAFT PLUGS . BOTH TIMES YOU SMELL ALOT OF GAS THAT COULD CAUSE A FIRE. *TR

BRAKE LINE TO THE REAR BRAKES RUPTURED DUE TO EXTREME CORROSION INSIDE THE FRAME THIS FAILURE RESULTED IN THE LOSS OF BRAKING/STOPPING POWER WITHOUT ANY WARNING. THE LINE WAS REPLACED. *TR

FAULTY CYLINDER HEAD ON A 6.8L V-10 2001 F-250. HEAD BLEW AND IT STARTED TO SOUND LIKE A RIDING LAWN MOWER. I AM A 3RD GENERATION FORD OWNER, IF FORD WANTS TO BE FORD TOUGH THEN THEY NEED TO FIX FORD DEFECT NO NEED FOR A TRUCK THAT HASN'T PULLED A HEAVY LOAD TO HAVE SUCH A FUBAR ENGINE DEFECT. MAKES ME WANT TO SWITCH TO FOREIGN TRUCK>. *TR

WHILE DRIVING HOME FROM WORK TODAY DURING A RAIN STORM IN RUSH HOUR (I'M TRAVELING AT 10MPH TOP), MY ENGINE SUDDENLY LOST POWER AND SOUNDED AS IF IT HAD LOST THE MUFFLER, EXCEPT THE SOUND WAS COMING FROM THE ENGINE COMPARTMENT. BECAUSE OF THE RAIN, IT WASN'T AS LOUD AS THE LAST TIME IT HAPPENED THREE YEARS AGO, BUT I KNEW WHAT HAD HAPPENED THANKS TO MY PRIOR EXPERIENCE. I PULLED OVER IMMEDIATELY AND EXITED THE HIGHWAY. ONCE THE RAIN STOPPED, I WAS SURE WHAT HAD HAPPENED. THERE IS NO REASON FOR THIS OCCURRING AT ALL, BUT TO HAVE IT HAPPEN TWICE! THERE IS SERIOUSLY SOMETHING WRONG WITH THE DESIGN IN FORD'S ENGINES (MINE IS A 5.4 V8, F-250.) I SEE ALL THE REPORTS OF THE SAME PROBLEM ON THE INTERNET AND IT MENTIONS THE FACT THAT THERE IS THE POSSIBILITY OF ENGINE COMPARTMENT FIRES. WHEN IT HAPPENED TO ME THE FIRST TIME, I WAS TOLD BY THE DEALERSHIP I SHOULD BE ABLE TO DRIVE IT IN FOR SERVICE, SO I DID. AND I DID SO AGAIN TODAY, TAKING THE BACKROADS. ONLY LATER THIS EVENING, WHILE RESEARCHING THE PROBLEM, DID I DISCOVER THE DANGER. PLEASE APPLY PRESSURE TO FORD TO CORRECT THIS PROBLEM BEFORE SOMEONE IS SERIOUSLY INJURED. AND SINCE THIS IS A COSTLY REPAIR THAT I FEEL IS CAUSED BY POOR DESIGN, IT SHOULD NOT BE PLACED ON THE BURDEN OF FORD CUSTOMERS WHO PAY THOUSANDS OF DOLLARS FOR THEIR VEHICLES IN THE FIRST PLACE. *TR

TL*THE CONTACT OWNS A 2001 FORD F-250 SD. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THERE WAS A SIGNIFICANT AMOUNT OF OIL LEAKING FROM MULTIPLE LOCATIONS IN THE OIL PAN . THE DEALER WAS CONTACTED AND STATED THAT THE OIL PAN WAS COVERED WITH RUST AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT THE OWNERS EXPENSE. THE FAILURE MILEAGE WAS 157000 AND THE CURRENT MILEAGE WAS 157752.

I WAS IN MY FORD F250 V10 TRITON SITTING IDLE AT A RED LIGHT WHEN I HEARD A LOUD POP UNDER MY HOOD WHICH WAS FOLLOWED BY A STEAM ENGINE SOUND WHEN I ACCELERATED. HAD IT TOWED TO A MECHANIC AND FOUND THAT MY FACTORY SPARK PLUG HAD BLOWN OUT OF THE HEAD. THE MECHANIC TOLD ME THIS HAPPENS OFTEN WITH FORD TRITON MOTORS. THE MECHANIC USED A HELICOIL TYPE TOOLING TO RETAP THE HOLD AND FIT A COLLAR IN IT THAT WOULD ACCEPT A NEW SPARK PLUG. THE COST WAS ABOUT $300 BUT THE FACT THAT THIS HAPPENS SO OFTEN FOR THIS PARTICULAR MANUFACTURER SEEMS TO ME THAT THEY SHOULD BARE THE COST FOR EACH OCCURRENCE. *TR

I'VE HAD TWO OF THE TIRES GOING 65-70 MPH BASICALLY GO FLAT AND TEAR INTO PIECES AFTER ONLY A FEW SECONDS. BOTH TIMES THERE IS HARDLY NO IDENTIFYING PARTS OF THE TIRE LEFT ON THE RIM. THE LAST TIME I WAS HAULING A 20' TRAILER WHEN IT WENT FLAT AND TORE TO SHREDS. THE FIRST TIME I WAS DRIVING WITH NO TRAILER AND I HEARD IT GO FLAT THEN THE TIRE JUST TORE TO SHREDS ALSO. THESE TIRE ARE ONLY A YEAR OLD. IT DID BEND THE REAR QUARTER PANEL. A EMPLOYEE WAS BEHIND ME AND SAID BASICALLY THE WHOLE TIRE CAME OFF THE RIM AND WENT ACROSS THE MEDIAN OF THE INTERSTATE. *TR

TL* THE CONTACT OWNS A 2001 FORD F250 SUPER DUTY. THE CONTACT STATED DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE WOULD NOT ACCELERATE AS HE CONTINUED TO DEPRESS THE ACCELERATOR PEDAL. HE SHIFTED THE VEHICLE INTO NEUTRAL AND BACK INTO DRIVE TO GET THE VEHICLE TO ACCELERATE. THE FAILURE CONTINUED TO PERSIST INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THE ACCELERATOR PEDAL AND THE ACCELERATOR PEDAL SENSORS WOULD NEED TO BE REPLACED. THE VEHICLE WAS IN THE PROCESS OF HAVING THE ACCELERATOR PEDAL AND SENSORS REPLACED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 70,000.

I HAVE A 2001 FORD F250 WITH A 6.8L V10. IT HAS 149,489 MILES ON IT. I AM NO SHADE TREE MECHANIC, I HAVE REBUILT ENGINES, TRANSMISSIONS AND TROUBLE SHOOT CPU?S . I WAS DRIVING DOWN THE ROAD AND CAME TO A TRAFFIC LIGHT THEN MADE A RIGHT HAND TURN. AS SOON AS I MADE THE TURN THE #4 SPARK PLUG BLEW OUT. MY FATHER HAS A 2002 F250 WITH THE 6.8L V10 AND HIS BLEW OUT THE #1 AND ABOUT 300 MILES LATER IT BLEW OUT THE #5 PLUG. IT CAUGHT ON FIRE WHEN IT BLEW OUT THE #5. THIS IS NOT RIGHT!! THERE HAVE BEEN TO MANY COMPLAINTS ABOUT THESE TRUCKS WITH THE SAME PROBLEM. THE CAUSE IS NOT DUE TO INCORRECT TORQUE ON THE PLUG. BUT DUE TO A COMBINATION OF TWO THINGS, 1. THE AMOUNT OF THREADS THAT HOLD THE PLUG IN PLACE.2 THE AMOUNT OF COMPRESSION THAT THE ENGINE PRODUCES. *TR

2001 FORD F-250 SUPER DUTY PICKUP CAUGHT ON FIRE DUE TO FAULTY WIRING. *TR