2005 Ford F-250 Steering Problems

While driving at 65 Mph, towing a fifth wheel camper, encountered a mildly rough section of highway when entire front end began to wobble and shake violently. Slowed the vehicle, maintaining control. When going back up to speed, the same shaking occured again. Also noted a less violent shaking at 45 mph. Took vehicle to have new tires rebalanced but did not change condition much. Inspected front end components. Currently replacing steering damper and shocks in hopes of correcting issue. All other components new or nearly new (3 years) with no issues. Vehicle and components can be inspected, and all replaced parts will be kept for inspection if required. Safety of my vehicle and others on busy highway could have been compromised had I not slowed and maintained control. The problem is being dealt with by me, as I do most maintenance on vehicle. The vehicle has not been seen or inspected by others except by tire mechanic who noted no obvious issues but did re-balance all tires. There was NO advance warning of a failure or compromise.

Wrench light comes on, but truck goes into limp loses power very dangerous don't know if it's going to cause me to be rear-ended, steering goes back and forth right to left can't hardly hold it in road

The back bed rails rot/rust very quickly and trying to buy new beds run 4500$ along with o2 sensors ir intake sensors go out of blue no reasoning let alone the power steering lines rusting very very quickly

towing a trailer, traveling at 70 mph, I hit a pothole and vehicle violently shook. The episode lasted for approx 30 seconds. It was very Difficult to maintain control and I almost ran off the road. It happened several times before I took it for repairs. The stabilizer bar was replaced, however the violent shaking has still continued.

In 2014, I got the “Ford death wobble” in the right front. VERY scary and dangerous. Trying to quickly slow down to stop it in traffic is almost as dangerous as the wobble itself. You have very little to no control with the steering when it happens. I had to repair the problem out of pocket because Ford won’t do anything about it. Now, two weeks ago, I had the same death wobble happen at 70 mph on the left front. So frightening. My passengers thought we had a blowout and we’re about to crash. I successfully slowed it down but this problem is a road hazard to me and everyone else on the road. So now, once again, it’s on me to shell out to fix a problem that should have been a recall a long time ago but Ford won’t step up and do the right thing. Please give us some relief here.

Front end suspension shimmy> My granddaughter and I were driving at 60mpa and hit a bump and could not control shaking of truck until pulling over to stop. This happened without warning. Had to drive back roads to get home.

Driving on the freeway at apps 65 miles per hour, the truck hit a numb in the road and started to shaking causing the truck to shake violently. I was able to get to the side of the road and slow down which eased the shaking. I started driving again and after reaching speeds this happened two more times, then I got off the freeway and drove backroads home under 40 miles per hour.

A SCARY AND SERIOUS WOBBLE AT 35 MPH. HAD TO CREEP HOME. ALMOST LOST CONTROL.

THE FORD 250 INITIATES A 'DEATH WOBBLE' OR INTENSE SHIMMY IN THE FRONT WHEELS AT SPEEDS GREATER THAN 50 MPH ANYTIME ANY SMALL BUMP IS ENCOUNTERED ON ROAD. THIS INSTANCE INITIATED 5 TIMES IN A 500 MILE HIGHWAY TRIP AT SUCH AN INTENSE RATE THAT THE VEHICLE LOST SIGNIFICANT STEERING CONTROL AND HAD TO BE IMMEDIATELY DECELERATED TO NEARLY 20 MPH FOR IT TO STOP. INITIAL SPEED WAS CLOSE TO 63 MPH. THE SHIMMY INITIATED WHEN A SMALL BUMP IS PASSED OVER AND ON THREE OF THESE INSTANCES IT INITIATED WITH THE CROSSING OF A EXPANSION GAP OR TRANSITION FROM THE HIGHWAY TO A BRIDGE OR BRIDGELIKE STRUCTURE. THE WOBBLE SHOOK TRUCK SO MUCH THAT DIRECTIONAL CONTROL WAS LOST. APPROACHING (TRAFFIC FROM THE REAR) HAD TO SWERVE OUT OF THEY WAY TO AVOID A REAR COLLISION. IF DECELERATION IS NOT IMMEDIATELY IMPOSED THE VEHICLE MAINTAINS THE SHIMMY AND DIRECTIONAL CONTROL IS SEVERELY COMPROMISED. IN TWO INSTANCES ON THIS TRIP I WAS ABLE TO NURSE THE WOBBLING VEHICLE OFF THE ROAD TO THE SHOULDER TO THEN BRAKE TILL CONTROL COULD BE RETRIEVED. HOWEVER, THERE ARE MANY INSTANCES WHEN ACCESS TO THE RIGHT SIDE IS IMPEDED SUCH AS WHEN PASSING IN LEFT LANE. THE SAME ISSUE HAS HAPPENED BEFORE ON A HIGHWAY TRIP TO ANOTHER STATE 6 MONTHS BEFORE.

2005 FORD F250 WITH APPROXIMATELY 19,100 MILES. ORIGINAL FACTORY TIRES, SUSPENSION- NO MODIFICATIONS. TIRE PRESSURE SET TO FACTORY DOOR LABEL SPECS. ON MONDAY, 8-19-2019 WHILE ON I-95, TRAVEL SPEED AT ABOUT 60 M.P.H., I DROVE OVER A BRIDGE EXPANSION JOINT & THE ENTIRE TRUCK STARTED SHAKING VIOLENTLY. STEERING WHEEL WAS VIBRATING/SHAKING MAKING IT DIFFICULT FOR ME TO MAINTAIN CONTROL OF THE TRUCK IN MY ESTABLISHED LANE AND NEARLY TOOK OUT SEVERAL CARS IN THE ADJACENT LANES NEARLY CAUSING MULTI-VEHICLE COLLISION. WENT ON THE INTERNET & FOUND THOUSANDS OF SIMILAR COMPLAINTS REGARDING THIS SAME ISSUE I JUST EXPERIENCED. LATER FOUND OUT IT IS CALLED HARMONIC RESONANCE A.K.A. THE DEATH WOBBLE. THIS DANGEROUS SITUATION AFFECTS NOT ONLY THE DRIVER AND THE PASSENGERS IN THE DEFECTIVE VEHICLE, BUT TO OTHER UNSUSPECTING MOTORIST'S AND THEIR PASSENGERS WHOM SHARE THE SAME ROADWAYS.

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 70 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT STATED THAT THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. ADDITIONALLY, THE VEHICLE STALLED WITHOUT ANY WARNING INDICATORS ILLUMINATING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BATTERY, ALTERNATOR, AND FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 162,000.

MY TRUCK VIOLENTLY SHAKE AT ANY TIME BETWEEN 30 AN 70 MPH I HAVE TO SLOW DOWN TO MAKE IT STOP WHICH COULD CAUSE A ACCIDENT IT HAPPENS IN THE CITY AN HIGHWAY

AT ANYWHERE BETWEEN 45MPH, AND 70 THE TRUCK WILL WOBBLE AND SHAKE OUT OF CONTROL TO THE POINT WHERE YOU CAN ALMOST LOOSE CONTROL. TRUCK CAN BARELY BE DRIVEN AND IS VERY UNSAFE

ON MY 2005 FORD DIESEL F250,AFTER 126000 MILES, STEERING BECAME VERY LOOSE. HAD ENTIRE FRONT END REPLACED INCLUDING GEAR BOX. REBUILDER PURCHASED MOTOCRAFT REBUILT STEERING BOXES FROM FORD. FOUR OF THESE REBUILT BOXES WERE TRIED ON THE TRUCK. NONE WERE ANY GOOD. BUILDER SAID THAT THIS WAS A COMMON PROBLEM WITH FORD GEAR BOXES. THEY INDICATED THAT THE GEAR BOX REBUILDERS ONLY REPLACED THE BEARINGS, NOT THE WORN-OUT GEARS WITHIN THE BOX. THE FORTH GEARBOX INSTALLED WAS EVEN WORSE, IT WAS DANGEROUS. WHEN DRIVING ON THE FREEWAY THE TRUCK WOULD VEER WITHOUT WARNING INTO ANOTHER LANE AND WOULD BE VERY DIFFICULT TO CORRECT. THE TRUCK IS BACK IN THE SHOP AGAIN. THIS TIME TO BUY AN AFTER MARKET (NON FORD) GEAR BOX. THIS VEHICLE'S FRONT END PROBLEM HAS SO FAR COST ME OVER $4000. IN REPAIRS, BUT , WHAT IS WORSE THESE GEAR BOX REPLACEMENTS COULD CAUSE AN ACCIDENT.

WHILE DRIVING HOME FROM WORK, JUST LEAVING TOWN I HIT 50 MPH AND THE TRUCK STARTS TO WOBBLE FROM SIDE TO SIDE AND VIBRATE TILL I SLOW DOWN TO UNDER 40 MPH. I GOT THE NOTICE FROM FORD TELLING ME IT ALL HAD TO DO WITH TIRE PRESSURE. I INFLATED THE TIRES TO THE REQUIRED PRESSURE AND IT ONLY MADE THINGS WORSE. I HAVE CONTACTED THEM THE FIRST TIME THIS HAPPENED ONLY FOR THEM TO TELL ME THERE IS NOTHING WRONG. CLEARLY THERE IS A PROBLEM. I HAVE SPENT SO MUCH MONEY REPLACING PARTS IN THE FRONT END OF THIS TRUCK. TIRES ARE NOW JUNK ON THE FRONT END. THE ONLY THING I COULD DO IS UNDER INFLATE THE FRONT TIRES TO GAIN BETTER CONTROL AND DRIVE SLOWER. STILL WOBBLES JUST NOT AS BAD. THIS IS AN ON GOING PROBLEM I HAVE EVERYDAY.

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY VIBRATED AND PULLED TO THE LEFT. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE BRAKE CALIPERS WERE HOT TO THE TOUCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 109,000.

I WAS HEADING DOWN MY STREET IN MY NEIGHBORHOOD AND JUST BEFORE THE STREET BENDS TO THE LEFT MY TRUCK STALLED AND I LOST MY POWER BRAKES AND POWER STEERING. DOING THE BEST I COULD I TURNED THE WHEEL JUST ENOUGH TO AVOID THE CAR PARKED ON THE SIDE OF THE STREET THEN I PROCEEDED TO RUN THROUGH MY NEIGHBOR'S WROUGHT IRON GATE AND PLASTER COMING TO REST ON THE HILL IN HIS FRONT YARD. AFTER ASSESSING THE DAMAGE, I TRIED TO START MY TRUCK TO SEE IF I COULD MOVE IT. IT STARTED AND I MOVED IT TO MY DRIVEWAY. AFTER THE REPAIRS WERE DONE AT THE BODY SHOP I THEN TOOK IT TO MY MECHANIC WHERE HE DISCOVERED A FAULTY WIRE IN THE WIRE HARNESS CAUSING THE ENGINE TO STALL WITHOUT ANY NOTICE OR SIGNS OF TROUBLE. LATER I LEARNED FROM MY INSURANCE COMPANY THAT THERE WAS A RECALL FOR THE 2004-2005 MODELS FOR THE WIRE HARNESS SPECIFICALLY, THAT I NEVER RECEIVED ANY INFORMATION ON. *TR

STOPPED AT A STOP SIGN, ACCELERATED TO MAKE LEFT TURN,HIT EITHER A BUMP OR PATCH OF SAND WHEN STEERING TOOK TO LEFT THEN RIGHT AND COULD NOT GET BACK. HIT A GUARDRAIL AND LANDED IN DITCH. MY TRUCK IS TOTALED BUT LUCKILY I WAS NOT SEVERELY INJURED. *TR

I WAS DRIVING DOWN A MAIN ST, GOING ABOUT 35 MPH...WHEN I HIT A BUMP THE TRUCK WOULD SHAKE VIOLENTLY AND THE STEERING WHEEL WAS ALSO SHAKING VIOLENTLY , I HAD IT DIAGNOSED AS THE DRAG LINK BALL JOINT AND AN UPPER BALL JOINT BOTH ON THE PASSENGER SIDE FRONT...I GOT A LETTER IN THE MAIL FROM FORD JUST YESTERDAY ABOUT THE SHIMMY/SHAKING ISSUE, THE LETTER STATES THAT IT IS DUE TO TIRE PRESSURE IN WHICH I BELIEVE TO BE VERY WRONG!! *TR

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 55 TO 60 MPH, A POT HOLE WAS HIT AND CAUSED THE VEHICLE TO SHIMMY AND SHAKE OUT OF CONTROL. THE BRAKE WAS ENGAGED WHILE AT HIGHWAY SPEEDS TO BRING THE VEHICLE UNDER CONTROL. THE DEALER ADVISED THAT THE TIE RODS FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 97,000.