There are 20 stored owner reports matching the brakes leading-label group for the 2006 Ford F-250 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 20 of 20 matching reports.
Open the full vehicle complaint log (all categories)BOUGHT TRUCK CASH HAD IT 3 WEEKS BRAKE LINES WE CORRODED NEVER LOOKED AT GOT TOLD GARAGE WON'T FIND TRANNY COOLER FITTING AND THE GAS STRAP BROKE OFF AND I HAVE ONLY HAD TRUCK 3 MONTHS NOW AND DEALERSHIP WON'T HELP AND GARAGE WON'T FIX TRUCK AND GOT TURNED AWAY FROM FORD DEALERSHIP..AND I HAVE A 6 MONTH UNLIMITED MILEAGE WARRANTY ON TRUCK..THE TRUCK WAS IN MOTION COMING FROM CHURCH WHEN BRAKE LINES BY ENGINE BLOCK SPRAYED ALL OVER ENGINE..WE WE DRIVING ON A STREET BEHIND OTHER CHURCH GOERS.. I NEEDED THIS TRUCK FOR HAULING AND SUCH AND HAD STRAP BREAKING AND MAY CAUSE FIRE IF TO DRIVE DOWN MAIN HIGHWAY AND IT FALL OUT..
TL* THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE BRAKES SEIZED AND OVERHEATED. THE VEHICLE WAS TAKEN TO A INDEPENDENT MECHANIC WHO STATED THAT THE CALIPER HOUSING AND BRAKE PADS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 125,000.
WHILE DRIVING I NOTICED THAT THE VEHICLE WAS SLUGGISH AND WHEN ENGAGING THE CLUTCH IN ORDER TO SHIFT THERE WAS A NOTICEABLE BRAKING FEELING EVEN THOUGH I WAS NOT TOUCHING THE BRAKE PEDAL. UPON REACHING HOME I SAW MY FRONT WHEELS/ROTORS/CALIPERS SMOKING AND THE HEAT FROM THE WHEELS COULD BE FELT ALMOST 3 FEET FROM THE VEHICLE. I TOOK MY PICK-UP TO THE DEALER AND WAS TOLD THAT MY FRONT CALIPERS HAD FROZEN AS WELL AS THE RIGHT REAR AND THE LEFT REAR WAS JUST AS BAD BUT HAD NOT FROZEN YET AND PROBABLY WOULD. THIS REPAIR REQUIRED FOUR (4) NEW CALIPERS, BRAKE PADS AND REQUIRED THE ROTORS TO BE RESURFACED. THE DEALER SAID THAT NO RECALL HAD BEEN MADE FOR THIS ITEM. *TR
THE BRAKE CALIPERS ON THE F-250 S.D. [RIGHT SIDE ONLY] LOCKED UP CAUSING IT TO PULL VERY HARD TO THE RIGHT. ON THE REAR I HAD TO REPLACE: ROTOR, CALIPER, AND PADS. ON THE FRONT, [RIGHT] JUST THE PADS. *TR
WHILE BACKING UP APPLYING BRAKING, HEARD POP THEN HAD BRAKE PEDAL PRESSURE FAILURE. VEHICLE STOPPED AFTER STRIKING EMBANKMENT. APPLYING BRAKE PEDAL AGAIN PRESSURE RETURNED WITH GRINDING AND ERRATIC WHEEL BRAKING. MECHANIC FOUND BROKEN CALIPER SUPPORT BRACKET DEFECTIVE CALIPER AND ROTOR DUE TO INTERFERENCE HAD THIS OCCURRED AT A GREATER SPEED OR OTHER LOCATION THE OUTCOME WOULD HAVE BEEN CATASTROPHIC. *TR
EMERGENCY BRAKES DO NOT HOLD. HAVE HAD THEM CHECKED FOR ADJUSTMENT SEVERAL TIMES. IS A MAJOR PROBLEM WITH A MANUAL TRANSMISSION AS IT HAS NO PARK PINS. ALTHOUGH MY INSURANCE COVERED IT, IT ACTUALLY ROLLED INTO ANOTHER BUILDING ON MY PROPERTY. I HAVE TO US A WOOD BLOCK AGAINST THE WHEEL TO STOP IT FROM ROLLING ON ALL BUT THE SLIGHTEST INCLINE. THERE HAVE BEEN SEVERAL OCCURRENCES WHEN THIS HAS HAPPENED.
TL* THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE WOULD BEGAN SHAKING AS THE CONTACT ATTEMPTED A TURN. WHEN APPLYING THE BRAKES, THE SHAKING WOULD BECOME WORSE. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER OR A MECHANIC FOR DIAGNOSTIC TESTING. THE CONTACT DID NOT CONTACT THE MANUFACTURER. THE FAILURE MILEAGE WAS 63,000.
IN LATE 2011, WHILE DRIVING MY TRUCK DOWN HIGHWAY 90 EAST IN PASCAGOULA, MS, THE TRUCK BEGAN SLOW DOWN AND PULL DRAMATICALLY TO THE RIGHT AFTER APPLYING THE BRAKES. I MANAGED TO WRESTLE WITH THE STEERING WHEEL AND, IN COMBINATION WITH THE SLOWING SPEED, BROUGHT THE TRUCK SAFELY TO A STOP IN A WALMART PARKING LOT IN ABOUT 1 MILE. I INSPECTED THE TRUCK AND THE FRONT RIGHT ROTOR WAS SMOKING AND GLOWING RED HOT. APPARENTLY THE BRAKE CALIPER HAD SEIZED AFTER APPLICATION. I WENT INSIDE WALMART TO KILL TIME AND LET THE BRAKES COOL OFF, HOPING THAT WHEN COOLED, THE CALIPER WOULD RELEASE AND THE TRUCK WOULD BE DRIVABLE. AFTER APPROXIMATELY 1-1/2 HOURS, I RETURNED TO THE TRUCK AND NOTED THAT THE WHEEL WAS NOT SMOKING, BUT WAS STILL RADIATING HEAT. I BEGAN TO DRIVE THE TRUCK AND IT DROVE WITHOUT ANY NOTICEABLE ISSUES UNTIL I APPLIED THE BRAKES AGAIN TO STOP AT A TRAFFIC LIGHT. AFTER RELEASING THE BRAKE, THE TRUCK WAS NOW PULLING TO THE LEFT. EXPECTING A SIMILAR ISSUE, I DECIDED TO DRIVE DIRECTLY TO THE FORD DEALERSHIP IN PASCAGOULA. HOWEVER, UPON NEEDING TO APPLY THE BRAKES AGAIN, THEY DID NOT WORK AT ALL. I HAD TO USE THE PARKING BRAKE TO BRING THE TRUCK TO A STOP AS THE REGULAR BRAKES HAD COMPLETELY FAILED. I CONTINUED TO EXPERIENCE SIMILAR BRAKE ISSUES (PULLING AND HEATING FROM SEIZED CALIPERS) AND IN JUNE 2015 HAD A SIMILAR EXPERIENCE TO THE ONE IN 2011. LOOKING AT BLOGS AND COMPLAINT SITES, FORD'S SUPER DUTY SERIES OF TRUCKS, AS WELL AS F-150S, ARE KNOWN TO HAVE BRAKE ISSUES. THIS IS A SERIOUS PROBLEM THAT FORD NEEDS TO BE HELD ACCOUNTABLE TO FIX. PLEASE HELP. I'M TIRED OF SHELLING OUT $2,000+ WHEN ALL I SHOULD HAVE TO DO IS REPLACE THE BRAKE PADS DUE TO NORMAL WEAR AND TEAR. DUE TO THE SUDDEN AND SEVERE "PULL" AND SUBSEQUENT LOSS OF STOPPING ABILITY, THIS HAS THE POTENTIAL TO BE A VERY SERIOUS SAFETY PROBLEM.
TL*THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. WHILE HAVING THE BRAKES SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THE BACKING PLATES FOR THE REAR BRAKES WERE SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 40,000.
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHEN TRYING TO DECELERATE HE SMELLED A STRONG ODOR. WHEN HE INSPECTED THE VEHICLE, THE CALIPERS ON THE BRAKE LINE HAD DISINTEGRATED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 108,400. UPDATED 04/12/11*LJ THE CONSUMER STATED WHEN HE PULLED THE BRAKE APART, HE NOTICED ONE OF THE TWO CALIPER PISTONS HAD DISINTEGRATED. UPDATED 04/13/11
TL* THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE REAR BRAKES WOULD MALFUNCTION WHEN DRIVING IN REVERSE. THE CONTACT STATED THAT THE BRAKE LINE COLLAPSED CAUSING THE CALIPERS TO CLOSE IN ON THE BRAKE PADS. THIS CAUSED THE CALIPER SEAL TO BURST AND BRAKE FLUID BEGAN LEAKING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE THE ENTIRE REAR BRAKING SYSTEM WAS REPLACED. THE MANUFACTURER ADVISED THE CONTACT THAT REPAIRS WOULD BE AT THE CONTACTS EXPENSE AND THEY WOULD NOT ASSIST. THE CONTACT STATED IF THE VEHICLE WAS TRAVELING AT A HIGHER RATE OF SPEED, A CRASH COULD HAVE POTENTIALLY OCCURRED. THE FAILURE MILEAGE WAS 51,500.
DROVE HOME FROM THE STORE ABOUT 10 MILES RIGHT REAR BRAKE CALIPER FAILED AND SEIZED. WHEN WE GOT HOME SMOKE WAS POURING OUT FROM UNDER THE TRUCK, WHEN WE DISCOVERED IT. BURNED THE PAINT OFF THE BRAKE DUST SHIELD. FORD DEALER SAID IT WAS A DEFECTIVE CALIPER BUT I HAVE TO PAY $750.00? THAT'S NOT RIGHT. AND THEY TELL ME IT HAS HAPPENED TO OTHER FORD TRUCKS? *TR
2006 FORD-250 SD. S10 APPROPRIATE HANDLING-LETTER FROM REGARDING FORD PROBLEMS *TGW THE CONSUMER STATED THE RIGHT REAR CALIPER SEIZED WHICH CAUSED HEAVY SMOKE. THE DEALER INFORMED THE CONSUMER THE CALIPERS WERE DEFECTIVE. THE CONSUMER STATED THE BRAKES STILL HAVE NOT BEEN REPAIRED TO HIS SATISFACTION. THERE WAS A MUSHY FEEL WHEN THE BRAKE PEDAL WAS APPLIED. *JB
I OWN A FORD SUPER DUTY F 250 2006 WAS BOUGHT 03-18-10 .APROX 2 1/2 MONTHS THE TRUCK VIOLENTLY SHAKES AND LOSES CONTROL WHEN HITTING THE SMALLEST BUMP IF EXCEEDING 45 KLM OUR HIGHER. IF YOU APPLY YOUR BRAKES WHILE THIS HAPPENS THE BACK END WILL 360 THIS IS A DEATH TRAP. THIS HAS HAPPENED ABOUT 15 TIMES BUT IT COULD OF BEEN MORE I ONLY DRIVE VERY SLOW AND IN THE SLOW LANE SO IF IT HAPPENS I CAN PULL OVER. I HAVE HAD EVERYTHING REPAIRED ON THIS TRUCK I REPLACED ALL THE HEAVY DUTY SHOCKS THE TIE RODS THE STEERING DAMPER THE ALIGNMENT THE PRESSURE IN MY TIRES AND EVEN THE BRAKES, AT FIRST I THOUGHT THE GARAGE JUST WANTED MY MONEY BUT ONCE SEARCHING ON THE INTERNET I FOUND MANY OTHERS WITH THE EXACT SAME PROBLEMS NO ONE HAS FOUND A SOLUTION TO THE PROBLEMS AND MY OWN MECHANIC SAYS HE HAS EXHAUSTED ALL AVENUES WITH THIS TRUCK. MY BIGGEST FEAR IS SOMEONE WILL HAVE TO DIE TO MAKE FORD UNDERSTAND THERE IS A DEFECT WITH THIS TRUCK AND I DON'T WANT IT TO BE ME. I HAVE NOT DRIVEN THIS TRUCK IN THE WINTER AS OF YET AND CAN TELL YOU WITH EXPERIENCE IF THE TRUCK SHAKES VIOLENTLY AND I HAVE A HAD A TOUGH TIME CONTROLLING IT IN THE SUMMER IMAGINE THE WINTER. SOMEONE NEEDS TO TAKE THIS SERIOUS. JUST TELL ME HOW TO FIX IT AT LEAST I CAN MAKE IT SAFE. *TR
TL*THE CONTACT OWNS A 2006 FORD F-250 EXTENDED CAB. WHILE CHANGING THE BRAKES, THE CALIPER PISTON THE DRIVER SIDE CRUMBLED, THE FRONT PASSENGER SIDE CALIPER PISTON WAS LOCKED. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALERSHIP WHERE HE WAS INFORMED THAT THE CALIPER WAS LOCKED, FROZEN OR BUSTED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 60,000.
FRONT BRAKES SEIZED UP WHEN DRIVING DOWN ROAD JUST AS WARRANTY WAS TO EXPIRE. CONTACTED DEALER AFTER THIS HAD HAPPENED 4-5 TIMES. DEALER REPLACED FRONT CALIPERS BUT WAS OUT OF WARRANTY. 4 MONTHS LATER HAD TO REPLACE BOTH REAR CALIPERS FOR SEIZURE PROBLEM. FORD DEALER WOULD NOT PROVIDE ANY COMPENSATION. NOW 2 MONTHS LATER, CHECK BRAKE LIGHT IS ON. *TR
BRAKE LINE FAILURE. *TR
TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING BETWEEN 40-45 MPH IN RAINY CONDITIONS, THE CONTACT'S VEHICLE STRUCK AN OPPOSING VEHICLE ON THE DRIVER'S SIDE. THE FRONTAL AIR BAGS FAILED TO DEPLOY, BUT THE CONTACT WAS UNINJURED. THE POLICE WAS CALLED TO THE SCENE AND FILED A REPORT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND REPAIRED. ON APRIL 10, 2009, THE MASTER CYLINDER FAILED AND THE CONTACT CRASHED INTO TWO OTHER VEHICLES. THE AIR BAGS FAILED TO DEPLOY AGAIN. THE DRIVER WAS UNINJURED, BUT HIS VEHICLE SUSTAINED SEVERE BODY DAMAGE. THE VEHICLE WAS TOWED TO A COLLISION CENTER AFTER BEING TOWED TO HIS RESIDENCE. HOWEVER, THE OTHER TWO VEHICLES WERE COMPLETELY DESTROYED THE OCCUPANTS WERE INJURED. THE VEHICLE IS IN THE PROCESS OF BEING INSPECTED AND REPAIRED. THE CAUSE OF THE AIR BAG FAILURES HAS NOT BEEN DETERMINED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 36,000 AND CURRENT MILEAGE WAS 46,000. UPDATED 05/18/09. *LJ UPDATED 05/20/09.*JB
TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE FIRST BRAKES ENGAGED INDEPENDENTLY. THE BRAKE DISENGAGED AS THE ABS WARNING LIGHT ILLUMINATED. ON A SEPARATE OCCASION, THE REAR PASSENGER BRAKE ENGAGED INDEPENDENTLY AND EMITTED SMOKE. THE BRAKE UNLOCKED AFTER THE SYSTEM COOLED DOWN BUT THE ROTORS SHOWED SIGNS OF OVERHEATING. IN ADDITION, THE FRONT PASSENGER BRAKE OVERHEATED AND CAUSED THE PASSENGER SIDE TIRE TO BLOW. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FAILURE WAS LOCATED AT THE FRONT PASSENGER SIDE CALIPER. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 45,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 75,000. THE VIN WAS NOT AVAILABLE.
THE RIGHT REAR BRAKE DRAGS OCCASIONALLY....AND MANY OTHER FORD TRUCK OWNERS ARE HAVING THE SAME PROBLEM.... *TR
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Sep 3, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.