2006 Ford F-250 Engine Problems

I REPLACED THE RADIATOR 3 TIMES AND CHANGE THE THERMOSTAT TO ,THE RADIATOR KEEPS POPPING, IT'S GETTING OLD,I ALSO CHANGED THE HEATER CORE AND IT POPPED . MAN WHAT IS GOING ON.IT HAPPENS WHEN I'M STATIONERY SITTING OVER NIGHT AT HOME.

HEADS WENT BAD NOW I HAVE TO REPLACE THE HEADS AND NEW HEAD STUDS BECAUSE THE OLD HEAD STUDS STRETCHED AND THE HEADS WARPED , ALSO HAD TO DO AN EGR DELETE . I WAS TOLD IT WAS BUILT PROOFING AND IT HAS TO BE DONE TO ALL 6.0 LTRS.

THE TRUCK WAS ON A MAJOR INTERSTATE (I-81 NEAR BLACKSBURG EXIT 118A,B,C) DRIVING UPHILL. WHILE TRYING TO MERGE INTO THE RIGHT LANE FROM THE MIDDLE LANE, WHILE LETTING OF THE ACCELERATOR THE ENGINE DIES. AT THIS POINT LOST ALL POWER INCLUDING BRAKES AND STEERING CONTROL. SINCE THERE WAS NO TRAFFIC IMMEDIATELY BEHIND THE TRUCK THEN WAS ABLE TO PULL OVER TO THE FIRST LANE AND GET OFF THE SHOULDER. THE TRUCK DIED AND FORTUNATELY DUE TO LOW TRAFFIC ABLE TO MANEUVER TO THE SHOULDER. AT THAT POINT, TRIED TO START THE TRUCK AND IT WOULD NOT START SO HAD TO REMAIN ON THE SIDE OF INTERSTATE UNTIL HELP COULD ARRIVE. STRANDED ON THE SIDE OF THE INTERSTATE. TRUCK WAS TOWED TO DEALERSHIP. FORD BLOGS INDICATE THERE IS A KNOWN PROBLEM THAT HAS GONE UNADDRESSED. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE DECELERATED AND THE SERVICE ENGINE SOON AND THE ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE OIL COOLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

TOWED ON SEPT/19/2014 KN MILEAGE DEALER SAID NO PROBLEM FOUND;. 2ND TOW 11/02/2014 MILEAGE 187190 EGR VALVE FAILED WILL NEED ENGINE REPLACED. DEALER WHERE BOUGHT DID NOT DISCLOSE. THE TRUCK HAD THE MOTOR REBUILD IN 2008. AND MANY CLASS ACTION SUITS HAVE BEEN FILED. ON 6.0L ENGINES. *TR

TL* THE CONTACT OWNS A 2006 FORD F250 DIESEL. THE CONTACT STATED THAT WHILE TRAVELING 65 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AS THE VEHICLE LOST POWER. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE HEAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE FAILURE MILEAGE WAS 128,000 AND THE CURRENT MILEAGE 128,691.

TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 3 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT IT FAILED TO RESPOND. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN STATED THAT THE OIL COOLER, THE EXHAUST BACK PRESSURE SENSOR, THE TURBO AND THE EGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 5 MPH, SMOKE EMITTED FROM THE EXHAUST PIPE. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS SHUT OFF AND TOWED TO THE DEALER. THE TECHNICIANS DETERMINED THAT THE EGR VALVE, EGR COOLER AND OIL COOLER HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 117,624.

WHILE PULLING A TRAVEL TRAILER, ENGINE BEGAN TO OVERHEAT. PULLED OVER AND NOTICE COOLANT RESERVOIR IS EMPTY. TOOK VEHICLE INTO A REPAIR SHOP, MOTOR COOLANT AND BOTH EGR COOLER FAILED. SERVICE SHOP REPORTED THAT FORD INFORMED THEM THAT THIS IS A COMMON ISSUE. THEY KEEP EXTRA EGR PARTS ON HAND FROM THE MASSIVE AMOUNT OF FAILURES REPORTED. *TR

I WAS PULLING A 3 HORSE TRAILER HOME FROM AN EVENT LOCATED IN JACKSON, MS . WHEN WE REACHED MCCOMB, MS THE TRUCK DIED. WE WERE RUNNING ABOUT 50 MPH WHEN THAT HAPPENED, POWER STEERING WAS GONE AND TRUCK HAD TO ROLL TO A STOP. I PUT THE EMERGENCY FLASHERS ON, WAITED A MINUTE AND ATTEMPTED TO RESTART THE TRUCK. IT CRANKED AND I WAS ABLE TO LIMP HOME. THERE WERE NO WARNING INDICATORS. THE TRUCK IS STILL IN THE SHOP AND THE MECHANICS ARE CHANGING PARTS BUT CANNOT SEEM TO CORRECT THE PROBLEM. IN FRUSTRATION, I DID A LOT OF RESEARCH ON THE INTERNET AND IT APPEARS THAT THIS NOT AN UNCOMMON PROBLEM FOR 03-07 POWERSTROKE DIESELS. I FEEL THIS IS A SAFETY HAZARD, A DEFECT IN THE ENGINEERING AND THAT FORD SHOULD CORRECT THE PROBLEM. THE PUBLIC NEEDS TO BE INFORMED. PLEASE INVESTIGATE THIS ISSUE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT AFTER CHECKING THE COOLANT RESERVOIR, HE NOTICED THAT THERE WAS A COOLANT LEAK. THE VEHICLE WAS INSPECTED AT A PRIVATE REPAIR SHOP, WHO DETERMINED THAT THE HEAD GASKETS WERE DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 75,000. THE CURRENT MILEAGE WAS 84,000.

2006 FORD F-250. CONSUMER STATES PROBLEM WITH EGR COOLER/EGR VALVE *TGW THE CONSUMER STATED THE PURPOSE OF THE EGR COOLER WAS TO COOL THE EXHAUST. AFTER MAKING SOME INQUIRIES, IT WAS BROUGHT TO HER ATTENTION THAT IT WAS A VERY COMMON PROBLEM. THE CONSUMER WAS INFORMED SINCE THE EGR VALVE WAS NOT MANUFACTURED PROPERLY, IT WAS GETTING PLUGGED UP WITH WET CARBON. THE CONSUMER WAS INFORMED IT WOULD COST $3,000 TO FIX THE PROBLEM. *JB

EGR AND OIL COOLER FAILURE...CAUSED ENGINE FAILURE AND HYDROLOCK SITUATION. THE ENGINE STOPPED THE TRUCK RIGHT IN THE MIDDLE OF AN INTERSECTION ALMOST CAUSING AN ACCIDENT. TOTAL COST OF REPAIRS TO MY VEHICLE $2542.42. SURE WOULD BE NICE FOR FORD TO HAVE A HAND IN THE REPAIRS DUE TO THEIR FAULTY ENGINE DESIGN. I HAVE READ 100'S OF REPORTS ONLINE ABOUT THIS AND FORD STILL WILL NOT FIX OR HELP PAY FOR THEIR ENGINE. FORD REFUSED TO HELP WITH REPAIR COST. I ONLY HAVE 98000K MILES. PLEASE LAUNCH AN INVESTIGATION INTO THESE COMPLAINTS. I BELIEVE YOU WILL FIND ENOUGH EVIDENCE TO WARRANT AN INVESTIGATION. I AM SURE THAT THE LOBBYIST AT FORD ARE DOING THEIR JOB TO KEEP THIS FROM BECOMING A RECALL SITUATION. IT IS HURTING NO ONE BUT THE OWNERS OF THIS 6.0L DIESEL ENGINE!!! WE NEED YOUR HELP! *TR

UPON ACCELERATION, FROM STOP AT A RED LIGHT, VEHICLE HESITATED (STALLED) TO ACCELERATE. UPON ACCELERATION, AFTER SEVERAL SECONDS, THICK CLOUD OF BLACK SMOKE APPEARED FROM EXHAUST PIPE, AND WHITE SMOKE DISCHARGED FROM ENGINE OIL (FILL) TUBE. VEHICLE CONTINUED WITH DESCRIBED PROBLEM(S) FOR THE REST OF THE TRIP, WHICH WAS APPROXIMATELY TEN (10) MINUTES, AND HAS CONTINUED WITH DESCRIBED PERFORMANCE PROBLEMS FOR MANY DAYS SINCE. THIS PROBLEM AROSE AFTER SPENDING OVER $2000 TO HAVE SIMILAR ENGINE PROBLEMS FIXED, AT FORD AUTHORIZED DEALERSHIP. UPON CONTACTING FORD MOTOR COMPANY, DIRECTLY (FOR FINANCIAL ASSISTANCE ON FIXING THE PROBLEM FOR THE SECOND TIME), I WAS INFORMED THAT THERE WOULD BE NO SUCH ASSISTANCE GRANTED. PERIOD. *JS

I HAVE A 2006 FORD F250 6.0 IT HAS BEEN TOWED 8 TIMES, I VE HAD TURBO,INJECTOR,ELECTRICAL,WHEEL,TRANS PROBLEMS SINCE DAY ONE OF PURCHASE. THERES OVER 16 PAGES OF MECHANICAL PROBLEMS THAT HAS BEEN PERFORMED AND COUNTING. I KNOW I AM NOT THE ONLY ONE THATS HAVING THESE PROBLEMS AND I CAN'T GET MUCH ASSISTANCE FROM FORD. IT GOING TO TAKE SOMEONE LIKE THIS AGENCY TO HELP US. THIS IS ALOT WHEN YOU PAY $51000.00 PLUS ADDITION REPAIRS FOR A VEHICLE WITH A EXTENTED WARR. *TT

TL* THE CONTACT OWNS A OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED DIFFICULTY ACCELERATING AT ALL SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT ALL OF THE SPARK PLUGS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 128,000.

WHILE TRAVELING ON VACATION WITH A TRAVEL TRAILER IN TOW, THE TEMPERATURE GAUGE ON OUR 2006 FORD-F-250 (WITH A 5.4 LITER ENGINE) INDICATED THE ENGINE WAS OVERHEATING. AFTER STOPPING SEVERAL TIMES ON THE BERM OF AN INTERSTATE, THERE WAS NO INDICATION THAT THE ENGINE WAS HOT. SINCE WE WERE TRAVELING ON A HOLIDAY, THE TRUCK WAS FIRST TAKEN TO A PEP BOYS LOCATION WHERE THEIR EVALUATION SHOWED THERE WAS NO SIGN OF OVERHEATING. WE WERE ADVISED OF A SERVICE BULLETIN ISSUED ON THIS VEHICLE STATING THAT IT MIGHT EXHIBIT FALSE OVERHEATING. SO, WE CONTINUED OUR TRIP. TRUCK CONTINUED TO DISPLAY FALSE READINGS AND THE ENGINE STARTED TO DERATE. AT THIS TIME, WE HAD TO HAVE THE TRUCK TOWED TO A FORD DEALERSHIP, WHERE THEY INSTALLED AN UPDATED COOLANT CROSSOVER TUBE AND THERMOSTAT HOUSING TO CORRECT THE PROBLEM OF FALSE OVERHEATING. THIS WORK WAS DONE (PARTS & LABOR) AT A COST TO US OF $645.67 AFTER AAA DISCOUNT. THE COST TO US WAS A SURPRISE, AS THE DEALERSHIP WAS AWARE OF THE PROBLEM AND KNEW EXACTLY WHAT WAS NEEDED TO BE DONE TO RECTIFY IT. WE WERE TOLD THAT THIS KNOWN PROBLEM WAS A SERVICE BULLETIN NOT A RECALL BECAUSE IT IS NOT CONSIDERED A SAFETY ISSUE. HOWEVER, IT WAS VERY MUCH A SAFETY ISSUE FOR US AS WE WERE COMPELLED TO STOP SEVERAL TIMES ON THE SIDE OF A BUSY INTERSTATE BEFORE HAVING TO REQUEST THAT THE PICKUP AND TRAVEL TRAILER BE TOWED TO A SAFE LOCATION.

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE NOTICED THAT THE VEHICLE WAS OVERHEATING. AFTER PULLING OVER HE NOTICED THAT THERE WAS SMOKE COMING FROM THE ENGINE AND THAT THERE WAS NO COOLANT IN THE RESERVOIR. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE WOULD HAVE TO BE DIAGNOSED AT A DEALER BEFORE GOING ANY FURTHER. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 89,000.

TL* THE CONTACT OWNS A 2006 FORD F250. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THE HIGH PRESSURE OIL WOULD NEED REPLACING. THE VEHICLE WAS REPAIRED HOWEVER THE FAILURE CONTINUED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS EMITTING SMOKE FROM THE TAIL PIPE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT EGR COOLER, ENGINE COOLER, FUEL INJECTOR AND TURBO NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WAS 63,500.