Ford · F-550 · 2018
10
Recalls
8
Complaints
-
Not Rated
The 2018 Ford F-550 has 10 recalls and 8 owner-reported complaints on file with NHTSA. Most reported issue: structure (2 reports).
Source: NHTSA Public Records · Updated May 4, 2026
The 2018 Ford F-550 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is structure with 2 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
Farber Specialty Vehicles (Farber) is recalling certain 2018 Ford F-550 vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which can cause the camera image to be reversed.
Remedy Status
Farber will notify owners, and dealers will add a harness relay capacitor module, free of charge. The recall began May 9, 2019. Owners may contact Farber customer service at 1-800-331-3188 or ASA customer service at 1-800-384-4400.
VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
Remedy Status
VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.
LGE Coachworks, Inc. (LGE Coachworks) is recalling certain 2018-2019 Ford E-450, F-550, and Freightliner M2-based vehicles equipped with ASA Electronics Voyager back-up camera displays. The displays may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
Remedy Status
ASA will notify LGE Coachworks owners, and dealers will replace the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA customer service at 1-800-384-4400 or LGE Coachworks at 1-800-209-3985.
Unruh Fire, Inc. (Unruh Fire) is recalling certain 2017-2018 Ford F-550-based fire trucks equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
Remedy Status
Unruh Fire has notified owners and will replace the brake lights, free of charge. The recall began in May 20, 2019. Owners may contact Unruh Fire customer service at 1-800-856-7080.
Taylor Made Ambulances is recalling certain 2017-2018 Ford E-350, F-450, E-450, F-550, and GMC G3500-based ambulances equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
Remedy Status
Taylor Made will notify owners and Whelen will replace the brake lights, free of charge. The recall began June 5, 2019. Owners may contact Taylor Made Ambulances customer service at 1-800-468-1310.
Weis Fire & Safety is recalling one 2018 Emergency vehicle built on a Ford F-550 4x4 Crew Cab chassis and equipped with Whelen brake lights recalled under 18E-063. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
Remedy Status
Weis Fire & Safety has already notified the owner, and replaced the brake lights, free of charge. The recall began October 1, 2018. Owners may contact Weis Fire & Safety customer service at 1-785-825-9526.
Fire Equipment Sales & Service (FES) is recalling one Super C Brush emergency vehicle and one Tanker emergency vehicle equipped with Whelen brake lights recalled under 18E-063. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
Remedy Status
FES has already notified owners, and replaced the brake lights, free of charge. Owners may contact FES customer service at 1-803-494-6000 or Whelen customer service at 1-860-718-2331.
Blanchat Mfg., Inc. (Blanchat) is recalling one 2018 B-27 Minuteman vehicle built on a Ford F-550 chassis and equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
Remedy Status
Blanchat has notified the owner, and will replace the brake lights, free of charge. The recall began on March 27, 2019. Owners may contact Blanchat customer service at 1-620-896-7145.
Excellance, Inc. (Excellance) is recalling certain 2018 Ambulances and Emergency Vehicles built on Ford E-350, E-450, F-650, F-550 4x4, Chevrolet G4500, G4500 Diesel, C3500, G3500, Freightliner M2, International 4300, and Dodge 4500 chassis and equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Remedy Status
Excellance has notified owners, instructing them to contact Whelen to have the brake lights replaced, free of charge. The recall began on March 21, 2019. Owners may contact Whelen customer service at 1-860-718-2331 or Execellance at 1-256-772-9321.
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Remedy Status
Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
The contact owns a 2018 Ford F-550. The contact stated while driving approximately 10 MPH, the subframe suddenly fractured in half. The contact stated that the fracture occurred near the rear cabin of the vehicle. The vehicle was later towed from the scene. The cause of the failu...
Preview excerpt
The contact owns a 2018 Ford F-550. The contact stated while the vehicle was parked, the contact stated that the frame was cracked between the bed and the cab. There were no warning lights illuminated. The vehicle was taken to a dealer where it was confirmed that the vehicle was ...
Preview excerpt
The contact owns a 2018 Ford F-550. The contact stated while driving 65 MPH, the contact observed a humming sound coming from the rear-end of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the ring and pinion needed to be replaced. The v...
Preview excerpt
TL* THE CONTACT OWNS A 2018 FORD F-550. THE CONTACT STATED WHILE DRIVING 45 MPH, THE VEHCILE STARTED TO SHAKE VIOLENTLY FROM FRONT END OF VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO HEARTLAND FORD (5979 WEST, US HWY 136, COVINGTON, IN 47...
Preview excerpt
The contact's company owns a 2018 Ford F-550. The contact stated while an employee was driving at 55 MPH, the service vehicle soon warning light illuminated intermittently. The contact took the vehicle to the local dealer, where it was diagnosed with needing the turbocharger to b...
Preview excerpt
FRONT END VIOLENTLY SHAKES ON VEHICLE ABOVE 45MPH CITY AND HIGHWAY DRIVING. BEEN TO DEALER 2X FOR ISSUE WITH NO RESOLVE
THE AIR BAG COVERING HAS FAILED ALONG THE SEAMS.*DT*JB *DT *TR
TL* THE CONTACT OWNS A 2018 FORD F-550. THE CONTACT STATED THAT WHEN DRIVING THEIR VEHICLE, THE VEHICLE WOULD VEER LEFT OR RIGHT ON IT'S OWN WITHOUT WARNING. THE VEHICLE'S STEERING WOULD NOT BE ABLE TO STRAIGHTEN ITSELF. THE CONTACT TOOK THE VEHICLE TO THE DEALER (DORSCH FORD LIN...
Preview excerpt
Showing 8 recent complaints from 8 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2018 Ford models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2018 Ford F-550 has 10 recalls recorded by NHTSA.
NHTSA has received 8 owner-reported complaints for the 2018 Ford F-550.
NHTSA has not published a safety rating for the 2018 Ford F-550.
The most commonly reported complaint categories for the 2018 Ford F-550 are structure (2 reports), air bags (1 reports), power train (1 reports).
Yes. NHTSA has 10 recalls on record for the 2018 Ford F-550. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.