2014 Ford Focus Fuel System Problems

The contact owns a 2014 Ford Focus. The contact stated that after refueling, the vehicle shook abnormally and stalled. The vehicle was restarted and driven to the residence. The contact referenced NHTSA Campaign Number: 18V735000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was taken to a dealer; however, the vehicle was not repaired, and the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 145,000.

The contact owns a 2014 Ford Focus. Upon investigation, the contact found notifications of NHTSA Campaign Numbers: 18V735000 (FUEL SYSTEM, GASOLINE) and 20V331000 (LATCHES/LOCKS/LINKAGES) associated with the VIN. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The vehicle was shifted into neutral(N) and coasted to the side of the road. The check engine warning light illuminated. The contact waited for one to two hours before restarting the vehicle. The accelerator pedal was depressed at the same time while starting the vehicle. The vehicle was taken to the dealer; however, the contact was informed that the vehicle was serviced under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) in 2019. The vehicle was not inspected, diagnosed, or repaired. The contact was the second owner of the vehicle and was unsure if the previous owner had repaired the vehicle under the recall. The contact searched on the NHTSA.gov website, and the website indicated that the recall was incomplete. The contact stated that the failure had become worse. The manufacturer was not made aware of the issue. The failure mileage was approximately 190,000.

I am filing a safety complaint regarding my 2014 Ford Focus due to recurring error codes P0456 (Very Small Leak Detected), P1450 (Unable to Bleed Up Fuel Tank Vacuum), and P2190 (System Too Rich at Idle). These issues relate to the Evaporative Emission Control System (EVAP) and fuel tank system, which have caused symptoms such as intermittent Check Engine Light warnings, fuel odor, and difficulty refueling. These problems were confirmed by an independent service center during diagnostic testing, but the dealership refused to perform a goodwill fix, citing that my vehicle is not currently included in related recalls. This is particularly concerning because a large number of 2014 Ford Focus vehicles—approximately 1.5 million—have been recalled for similar issues with the EVAP and fuel systems, which pose risks such as fuel vapor leaks and stalling due to fuel system pressure irregularities. Although my VIN is not listed under the recall, the identical symptoms strongly suggest my vehicle should be included. I have not had the vehicle inspected by Ford or other representatives, but I urge NHTSA to investigate further as this is a significant safety concern that endangers me and others on the road.

-Canister Purge Valve malfunctioning. Vehicle is available for inspection upon request. -This is a potential safety risk, makes and models within the same year are showing recall. When checking the specific VIN, does not appear to be covered under current recall. -Failure Code P1450 -No -Check Engine Light

Purge value. Code p1450. It tries die on me. Everytime I get gas my car has hard time starting. While driving last few days car tries die or make a surge forward. I'm still having trouble with this transmission ever since I bought it. I been back 3 times for them to adjust something.it has died on me while driving.

The contact owns a 2014 Ford Focus. The contact stated that after refueling the vehicle, the vehicle sputtered and stalled. The vehicle was able to restart. Additionally, the contact stated that while driving at an undisclosed speed, the vehicle was running roughly. The check engine warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 19V515000(Fuel System, Gasoline), and the contact replaced the purge valve; however the failure recurred. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the local dealer and to the NHTSA hotline for assistance. The failure mileage was approximately 116,000.

The contact owns a 2014 Ford Focus. The contact stated that after refueling the vehicle, the vehicle failed to restart. The contact stated that the failure was intermittent. The contact stated that while driving at various speeds, the vehicle stalled while the RPM was elevated. The contact pulled over to the side of the road on one occasion, and the vehicle was pushed to the side of the road on the other occasions. The vehicle was restarted after an extended time. An unknown warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the canister purge valve and the TCM had failed and needed to be replaced. The dealer informed the contact that the canister purge valve replacement was covered under Ford Campaign Number: 24N07, and a repair fee would be charged for the TCM replacement. The vehicle was not repaired. The contact related the TCM failure to NHTSA Campaign Number: 13V523000 (Power Train); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000.

My card was recalled several years ago for a Purge Valve Canister. It was repaired but would still cut out sometimes. It is doing it again now, as a matter of fact when you pull up to a light or sudden stop it will stall the engine. Also when you fill up with gas, it does not want to start. I know that when it was fixed, the problem was a band aid fix. There is something in the vehicle causing this Purge Valve canister to malfunction. I think it should be covered under the SAME RECALL and it should be paid for by FORD.

The contact's fiancé owns a 2014 Ford Focus. The contact stated that while his fiancé was driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the vehicle hesitated to start and failed to start right away after a jumpstart. The contact was later able to start the vehicle. The RPM also fluctuated while the vehicle was idling. The vehicle was taken to an independent mechanic, who reset the check engine warning light; however, the failure recurred. The vehicle was taken back to the independent mechanic, who retrieved DTC Code: P1450 and determined that the canister purge valve (CPV) and fuel vapor system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The contact related the failure to NHTSA Campaign Numbers: 18V735000 (Fuel System, Gasoline) and 19V515000 (Fuel System, Gasoline); however, the VIN was not included in the recalls. The failure mileage was approximately 98,500.

Gas tank was filled and experienced erratic fuel gauge indication during drive. Parked vehicle and next day there was gasoline coming out of the bottom of the car. Towed and mechanic said the gas tank shows deformation, issue where the tube into tank/assembly is defective.

I purchased a new 2014 Ford Focus Electric (FFE) in 2014. I have learned since then that every FFE develops a high voltage battery, the battery that powers the electric motor, coolant leak at no more than 80,000 miles, rendering the car inoperable. Ford will not repair the leak and will only sell a replacement battery. Ford has not issued a recall and is allowing the cooling system for a battery made from a highly combustible material to fail. The cooling system failure also requires the driver to get off the road immediately with the "Stop safely now" message and leaves the driver stranded with a useless car. The following are links about the FFE battery coolant leak. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2014 Ford Focus. The contact stated while driving 60 MPH, the vehicle started sputtering and then stalled. The contact pulled over to the side of the road and restarted the vehicle; however, the failure reoccurred a short while later. The contact stated that gasoline was added to the fuel tank allowing the vehicle to be driven to the residence. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the canister purge valve, fuel tank ,and fuel pump module needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,074.

The contact owns a 2014 Ford Focus. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle stalled. The vehicle was taken to an independent mechanic where it was diagnosed with evap purge valve failure. The contact was informed that the evap purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that the NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) had expired. The contact stated that there was two parts to the recall repair being completed and only one part was completed. The failure mileage was approximately 112,665.

Check engine light came on due to the code P0442. It was caused by a faulty purge valve, which my car was already recalled due to this. To my knowledge the valve was replaced. The check engine light is on again, same code. The purge valve was replaced again, but the engine light did not turn off. Upon further inspection, the fuel tank is deformed. The purge valve defect can cause the fuel tank to be vacuumed in on itself, and there happens to be another recall on this issue. My car is not part of this recall. Not only is the check engine light on for the deformed fuel tank, but my MPG number does not match up with the amount of mileage I actually have left. There needs to be another recall with the cars that were not in the original group recalled.

12-18 ford focus equipped with 2.0 GDI or 2.0 GTDI equipped with purge valve, failing causing gas tank deformation

The contact owns a 2014 Ford Focus. The contact stated that after refueling the vehicle, the vehicle routinely failed to start, but would restart after 15-20 minutes. The contact stated that the failure had been a recurring failure. The check engine warning light was illuminated. The vehicle was taken to a local Pep Boys, where it was diagnosed and determined that the Evaporative Emission Control (EVAP) System had failed. An unknown dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 19V515000 (Fuel System, Gasoline). The failure mileage was approximately 160,000.

My Ford Focus died on me at a stop sign, when trying to start it sounded it seemed like it ran out of gas, put gas in and it leaked out onto the ground. I had it towed to the Sewell Ford in Fayetteville AR 72703. They replaced the R Tube Asv-Fuel Vapour Separa, Fuel Cannister-fuel vapour store, E Tank Esy-Fuel, Ax Sender and Pump Asy and AA Gasket. They said this happened because of pressure in the gas tank. They looked up the recall, that this is associated with and a Ford location in Frisco said it didn't need to be fixed. Obviously it did. I paid 3,173.88 for the repair work. I called Ford Corp number and they stated same as the other Ford location is we closed out without being repaired. Is there anything i can do?

The contact owns a 2014 Ford Focus. The contact stated that on numerous occasions while the accelerator pedal was depressed, the engine hesitated to respond then the vehicle stalled. The contact was able to restart the vehicle. The contact stated that while accelerating the vehicle inadvertently decelerated. The transmission fault warning light and an unknown warning light were illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the clutch needed to be replaced. Other unknown failures were found. The contact was made aware of the NHTSA Campaign Number: 18V350000 (Fuel System, Gasoline) however, the parts to do the repair was unavailable. The manufacturer was notified of the failure and the contact was provided a case number and advised to call the NHTSA Hotline. The failure mileage was approximately 85,000.

The contact owns a 2014 Ford Focus. The contact received notification of NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The dealer was notified of the recall and confirmed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2014 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle stalled without warning. The vehicle was taken to the local dealer but was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The manufacturer was not contacted. The approximate failure mileage was 140,000.