2024 Ford Maverick Brakes Problems

This is a supplemental filing to my existing NHTSA complaint #11715308. I am requesting that the Office of Defects Investigation open a formal Preliminary Evaluation into the 2024 Ford Maverick Hybrid braking system. Since my original complaint, the following has occurred: Ford Motor Company denied my claim on April 2, 2026 through a three-sentence letter from a paralegal at Erskine Law PC in Michigan. The denial addressed none of the evidence submitted including repair orders, fault codes from Ford's own OASIS system, a recorded call proving warranty claim suppression, and a notarized sworn statement. The vehicle now has 107,982 miles. The ABS defect remains unrepaired after four attempts and over 50 days out of service. Active fault codes C052E and U0418 were confirmed in Ford's OASIS system when the vehicle was returned unrepaired on January 28, 2026. Ford has already issued Recall 25V787000 for brake booster ECU overheating causing loss of brake power assist in Maverick vehicles, demonstrating prior corporate knowledge of braking defects in this model line. There are currently 149 brake-related complaints in the NHTSA database for the 2024 Ford Maverick with no open ODI investigation. On [XXX], the braking defect caused a collision (APD Crash Report [XXX], no driver error assigned). I have a notarized sworn statement linking the collision to the unrepaired defect. I have concurrent active complaints with the NM Department of Justice (XXX), BBB AUTO LINE (XXX), FTC (#XXX), CFPB (#XXX), and Ford's internal SpeakUp ethics program (#XXX). I am formally requesting ODI review of the 2024 Maverick Hybrid braking system given the volume of complaints, the existing recall on related models, and Ford's documented refusal to repair my vehicle despite confirmed fault codes in their own diagnostic system. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

6-18-25, driving at 20 mph in my neighborhood, applied brakes and pedal sank to the floor with no pressure. Pumped approximately six times with no pressure. On the last pump, I got severe juddering through the truck ( felt similar to an ABS activation) still no pedal pressure, but it did stop. Upon shutdown and restart, pedal was back to normal. Obvious safety issue as it would have caused a collision had I been on anything other than a quiet street. There were no warning lights on the dash and no fluid leaks. This is a new truck with 470 miles on it. Vehicle is currently at a Ford dealership. As of this writing no diagnosis.

New 2024 Ford Maverick. 12,000 miles. At around 10K miles, a factory recall regarding the firmware driving the brake light system was performed. This has 'broken' the factory installed trailer braking system that applies braking to an attached trailer with electric brakes. This is very dangerous, since failed trailer braking can cause a severe accident. The factory system shows alerts on the dash: when a trailer is electrically connected to the truck, the system responds with "Trailer connected". And now, that same message appears, but as soon as you apply brakes, either physically or by the factory system, an alert says, "Trailer disconnected". This never happened before the recall was performed. Also, If you connect the trailer and the system says "trailer connected", if you adjust the braking 'gain' in the cab of the truck, the system says "no trailer", and yet the other alert says "trailer connected". This is a computer firmware fault. This has been recorded by other owners online.