2004 Honda Odyssey Electrical System Problems

The contact owns a 2004 Honda Odyssey. The contact stated that while driving 60 MPH, the vehicle lost motive power without warning. The contact self-diagnosed the vehicle with an ignition switch failure. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 308,000.

AFTER THE SLIDING DOOR ON THE DRIVER SIDE STOPPED WORKING, WE WAS STILL ABLE TO SWITCH OFF THE SWITCH AND OPEN/CLOSE IT MANUALLY A FEW TIMES. THE FOLLOWING MORNING TRYING TO DO THE SAME THING IT ONLY OPENED HALFWAY AND THEN WOULDNT LATCH CLOSED AS I TRIED THE SECOND TIME TO GET IT TO LATCH CLOSED THE WHOLE DOOR JUST FELL OFF TRACK. LUCKILY IT HAPPENED SITTING IN MY MOMS DRIVEWAY. I WOULD HATE TO HAVE SEEN WHAT WOULD HAD HAPPENED HAD I BEEN DRIVING WHEN IT CAME OFF SINCE MY 4 YEAR OLDS SEAT IS RIGHT THERE.

MY HUSBAND WENT TO THE STORE, CAME BACK FOR MY 3 YEAR OLD AND I. TURNED THE CAR OFF AND CAME INSIDE FOR 10 MINS, WHEN WE CAME OUT TO LEAVE, THE ENTIRE CAR WAS FILLED WITH SMOKE AND FIRE. THE FIRE DEPARTMENT BELIEVES IT WAS THE SEAT MOTOR THAT MALFUNCTIONED.

CORROSION WITHIN THE FUEL PUMP WIRING CONNECTOR AND THE FUEL PUMP RETAINING NUT WAS CRACKED / BROKEN. CUSTOMER COMPLAINT WAS STALLING WHILE DRIVING, NO START CONDITION. TROUBLESHOOTING PROCEDURE INDICATED THE FUEL PUMP WIRING CONNECTOR WAS FAULTY THE INSPECTION REVEALED THAT THE CONNECTOR WAS CORRODED APPARENTLY FROM MOISTURE. THIS ISSUE IS CERTAINLY A SAFETY CONCERN CONSIDERING THE FAULTY CONNECTION CAN CAUSE LOSS OF ENGINE POWER -> LOSS OF POWER STEERING, AND THE FAULTY FUEL PUMP NUT CAN CAUSE GASOLINE FUMES TO ESCAPE CONTAINMENT WHICH MAY LEAD TO AN EXPLOSION / FIRE. IF THE CONNECTOR WAS JIGGLED THE FUEL PUMP WOULD INTERMITTENTLY OPERATE AND OR FAIL. THE LOCAL HONDA DEALER REFUSED TO RECOGNIZE THE SAFETY RECALL CAMPAIGN # 04V42000 OR THE HONDA SERVICE BULLETIN #04-049, AND REFUSED TO MITIGATE THE PROBLEM WITHOUT OFFERING THE OPTION TO REPAIR THE ISSUE OUTSIDE OF THE RECALL WHICH WOULD COST THE CUSTOMER $454.32 FOR THE FUEL PUMP REPAIR KIT IN ADDITION TO SERVICE FEES OF AT LEAST $374.00. THE VEHICLE WAS INITIALLY TOWED-IN AND PRESENTED FOR SERVICE ON JUNE OF 2018. THE HONDA DEALER IS PROVIDING WIRING HARNESS, RETAINING NUT AND GASKET AT A COST TO THE CUSTOMER.

HI THERE, I HAVE ISSUES WITH IGNITION CYLINDER LOCK SYSTEM AND LOOKS LIKE THERE WAS A RECALL FOR THE MODEL/YEAR OF HONDA ODYSSEY I CURRENTLY OWN. I WAS WONDERING IF THE RECALL MISSED OTHER BATCHES OF HONDA ODYSSEY VANS MANUFACTURED DURING THE SAME TIME. ELECTRICAL SYSTEM:IGNITION:SWITCH RECALL FOR 2004 HONDA ODYSSEY THANKS, RAJ

WHILE DRIVING MY 2004 HONDA ODYSSEY WOULD COMPLETLEY STAHL WITHOUT ANY WARNING, JUST SHUT OFF.. I GOT THE FUEL RELAY REPLACED AND IT STILL STAHLED NUMEROUS TIMES BUT STARTED BACK UP SOON AFTER.. ALMOST CAUSING NUMEROUS ACCIDENTS JUST STOPPING WHILE DRIVING.. NOW MY VAN HAS STAHLED AND THIS TIME IT WILL NOT RESTART. I HAVE LOOKED UP RECALLS AND FOUND ONE THAT MADE SENSE FOR A 2004 HONDA ODYSSEY FOR A FUEL PUMP WIRE THST HAS CORROSION CAUSING THE CAR TO STAHL. MY VANS VIN DOESNT FALL UNDER THIS RECALL....???

THE SRS LIGHT COMES ON INDISCRIMINATELY. CONCERNED ABOUT THE AIR BAG AND SAFETY RELATING TO IT. IT COULD HAPPEN DRIVING OR WHILE ITS STATIONARY. SECONDLY THE YELLOW CHECK ENGINE LIGHT IS CONSTANTLY ON. FUEL SYSTEM LEAK ACCORDING TO A TECH. HE SAID IT WASN'T WORTH FIXING. THIRDLY, THE DOOR LIGHTS AND REAR COURTESY BRAKE LIGHT COMES ON OCCASIONALLY, BUT THEN GOES OFF.

TL* THE CONTACT OWNS A 2004 HONDA ODYSSEY. THE CONTACT STATED THAT THE SRS WARNING INDICATOR ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V344000, 15V320000, 15V045000 (AIR BAGS) AND 12V573000 (ELECTRICAL SYSTEM). THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 148,000. PARTS DISTRIBUTION DISCONNECT. UPDATED 11/01/16*LJ UPDATED 11/02/16/*JB

THE KEY CAN BE REMOVED FROM THE IGNITION WITHOUT BEING IN PARK.

TL* THE CONTACT OWNS A 2004 HONDA ODYSSEY. THE CONTACT STATED THAT THE IGNITION KEY REMAINED IN THE IGNITION SWITCH, PREVENTING THE VEHICLE FROM STARTING. THE CONTACT MENTIONED THAT THE VEHICLE WAS REPAIRED UNDER A MANUFACTURER'S RECALL RELATED TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 240,000.

TL* THE CONTACT OWNS A 2004 HONDA ODYSSEY. THE CONTACT STATED THAT THE IGNITION KEY WAS DIFFICULT TO ENTER AND REMOVE FROM THE IGNITION SWITCH. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY SERVICED APPROXIMATELY A YEAR AGO UNDER NHTSA CAMPAIGN NUMBER: 12V257000 (ELECTRICAL SYSTEM). THE CONTACT MENTIONED THAT THE FAILURE WAS NOT EXPERIENCED PRIOR TO THE RECALL REPAIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 97,000.

TL*THE CONTACT OWNS A 2004 HONDA ODYSSEY. THE CONTACT STATED THAT THE IGNITION KEY FAILED TO GO INTO THE ON POSITION WITHOUT WARNING. AS A RESULT, THE VEHICLE FAILED TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

MY WIFE WAS DRIVING IN THE HIGHWAY ALL OF THE SUDDEN THE PASSENGER DOOR START, IT TO BEEP TO MY WIFES SURPRISE THE POWER DOOR NEVER LATCHED, SHE HAD TO PULL OVER AND BUMP THE DOOR TO MAKE IT LATCH. WHEN SHE CAME HOME I CHECKED THE DOOR AND CLEARLY SEE THE DOOR APPEAR AS CLOSED BUT IT DOES NOT SHUT AND IF YOU DON'T BUMP THE DOOR IT DOES NOT LATCH AT ALL. EVIDENTLY THIS HAS BEEN GOING ON FOR A WHILE BUT SHE NEVER HAD IT TO ADJURE BEFORE VERY, VERY DANGEROUS AND IT SHOULD BE ADDRESSED. WE HAD IT LOOKED AT ONCE AND THEY SAID IT IS FIXED BUT HERE WE GO AGAIN.

TL* THE CONTACT OWNS A 2004 HONDA ODYSSEY. WHILE DRIVING AT ANY SPEED AND MAKING A RIGHT TURN, THE HORN INDEPENDENTLY ACTIVATED. IN ADDITION, THE WINDOW ON THE PASSENGER SIDE FAILED TO OPEN. THE CONTACT MENTIONED THAT THE FAILURES OCCURRED AFTER THE VEHICLE WAS SERVICED UNDER THE MANUFACTURER FRONTAL AIR BAG RECALL. THE CONTACT ALSO MENTIONED THAT AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2004 HONDA ODYSSEY. WHILE DRIVING UPHILL AT APPROXIMATELY 45 MPH, THE VEHICLE MADE A BEEPING NOISE AND THE ENTIRE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE FELT AS IF IT WERE LOSING POWER. WHILE DRIVING DOWNHILL, THE CONTACT DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE FAILED TO STOP. THE PARKING BRAKE HAD TO BE ENGAGED IN ORDER TO STOP THE VEHICLE. THE VEHICLE STALLED ONCE IT STOPPED. AFTER FORTY MINUTES, THE VEHICLE RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,950.

TL* THE CONTACT OWNS A 2004 HONDA ODYSSEY. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 12V573000 (ELECTRICAL SYSTEM) IN JANUARY OF 2014. AFTER TAKING THE VEHICLE TO THE DEALER THE CONTACT WAS INFORMED THAT BECAUSE THE VEHICLE WAS MODIFIED DUE TO A HANDICAP THE MANUFACTURER WAS NOT WILLING TO PAY TO HAVE THE MODIFIED HAND CONTROLS DISCONNECT AND RECONNECTED IN ORDER TO INSTALL THE REMEDY. THE CONTACT NOTIFIED THE MANUFACTURER OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 08/19/14*LJ UPDATED 8/30/2017*CN

TL* THE CONTACT OWNS A 2004 HONDA ODYSSEY. THE CONTACT STATED THAT THE IGNITION WAS FRACTURED AND THE KEY BECAME STUCK IN THE IGNITION. THE KEY WAS REMOVED FROM THE IGNITION SWITCH BUT IT WAS DIFFICULT TO INSERT IT BACK. THE CONTACT STATED THAT THE VEHICLE HAD BEEN PREVIOUSLY REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER: 12V573000 (ELECTRICAL SYSTEM). THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2004 HONDA ODYSSEY. THE CONTACT STATED NHTSA CAMPAIGN NUMBER: 13V412000 (AIR BAGS) AND NHTSA CAMPAIGN NUMBER: 12V573000 (ELECTRICAL SYSTEM) HAD SURPASSED REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DELAY. THERE ARE NO FAILURES AT THIS TIME. UPDATED 06/10/14 MA THE CONSUMER STATED IT HAS BEEN 18 MONTHS, AND THE PART IS STILL NOT AVAILABLE. UPDATED 07/24/14

THE KEY WOULD FREQUENTLY FALL OUT OF THE LOCK, OR GET STUCK IN THE LOCK. A RECALL WAS ISSUED FOR THE INTERLOCK LEVER IN THE IGNITION SWITCH. WE WERE UNABLE TO IMMEDIATELY BRING OUR VEHICLE TO THE DEALER FOR THE RECALL REPAIR BECAUSE IT WAS OUR SOLE SOURCE OF TRANSPORTATION. WHILE I WAS AWAY IN CALIFORNIA ATTENDING MY AUNT'S MEMORIAL, THE KEY TO THE VEHICLE FAILED TO FUNCTION WHETHER IN PARK OR OTHERWISE. THE TOW TRUCK DRIVER BROKE THE KEY OFF IN THE LOCK TRYING TO GET THE VEHICLE INTO NEUTRAL, BECAUSE THE SWITCH WOULD NOT PROPERLY RELEASE THE KEY. THE VEHICLE WAS BROUGHT TO THE DEALER TO APPLY THE RECALL REPAIR TO THE INTERLOCK LEVER *AND ANY OTHER NECESSARY PART OF THE IGNITION SWITCH* PER THE RECALL NOTICE. AFTER REPLACING THE IGNITION SWITCH, THE DEALER AND HONDA CORPORATE DECIDED THAT THIS WAS NOT A RECALL ISSUE AND REFUSED TO ACCEPT RESPONSIBILITY FOR ANY PART OF THE REPAIR COST, EVEN THOUGH THE NOTICE CLEARLY STATES THAT REPAIRS TO THE INTERLOCK LEVER AND *ANY NECESSARY PART OF THE IGNITION SWITCH* SHOULD BE COVERED AT NO COST. [XXX] IN THE CASE MANAGEMENT DIVISION OF AMERICAN HONDA CORPORATE (HE REFUSED TO GIVE ME HIS LAST NAME, BUT INDICATED THAT HE WAS THE ONLY [XXX] IN THAT DIVISION) AND [XXX] AT THE LOCAL DEALERSHIP, CROWN HONDA OF GREENSBORO, BOTH REFUSED TO ACKNOWLEDGE ANY RESPONSIBILITY FOR THIS REPAIR AND FORCED US TO PAY FULL PRICE FOR THE REPAIR IN ORDER TO RELEASE MY VAN. THE RECALL NOTICE CLEARLY STATES THAT NOT ONLY THE FAULTY INTERLOCK LEVER BUT ANY NECESSARY PART OF THE IGNITION SWITCH WOULD BE REPLACED AT NO COST. IT DOESN'T MATTER WHETHER THERE WERE OTHER ISSUES WITH THE IGNITION SWITCH. IT WAS STILL SPECIFICALLY STATED IN THE RECALL NOTICE THAT THIS WOULD BE COVERED AT NO COST. APPARENTLY, HONDA DOES NOT FEEL THAT IT HAS TO HONOR THE RECALL NOTICE IF THERE ARE ANY OTHER MINOR MECHANICAL ISSUES EXISTING IN THE IGNITION ASSEMBLY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS COMING OUT OF APARTMENT PARKING LOT AND SUDDENLY CAR STOPPED. I HAVE TO TOWED CAR TO HERB CHAMBER OF HONDA IN WESTBOROUGH, MA. TECHNICIAN TOLD ME THAT IT IS A COMPUTER FAILURE. I AM NOT SURE WHY COMPUTER FAIL AS BEFORE THIS INCIDENT MY USED NOT TO START AFTER PARKING. TO START I HAD TO INSERT KEY AND MOVE GEAR FROM PARKING TO D1 AND MOVE IT BACK TO P AND IT STARTED ALL THE TIME. I NOT SURE THIS IS A COMPUTER ISSUE. THEY ARE CHARGING ME $1500.00 FOR THIS. COULD YOU PLEASE HELP TO RESOLVE THIS. SINCE I BOUGHT THIS CAR I AM HAVING ISSUES, MY CAR PAINT IS PEELING OFF TOO, WITHOUT CORROSION OR SCRATCH. *TR