2012 Hyundai Sonata Complaint Log

The contact owns a 2012 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the driver’s side seat belt unexpectedly detached. Several attempts were needed to secure the seat belt while driving. The contact stated that while the vehicle was parked, the driver’s seat belt became inoperable and failed to latch properly. An independent mechanic was contacted. The vehicle was not diagnosed or repaired. The dealer was also contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 127,819.

The contact owns a 2012 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, there was an abnormal burning odor coming from the vehicle. While depressing the accelerator pedal, the vehicle hesitated and stalled. The contact stated that the rear driver’s side brake light was inoperative. The failure occurred on several occasions. No warning lights were illuminated. The contact researched and was made aware of an undisclosed recall; however, the VIN was not included in the recall. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 168,000.

The airbag warning light came on, so we took it in to see about a recall on the airbag control unit issue that required a wire filter kit as out lined in a recall in 2011-2013 Sonatas and Sonata Hybrids. In fact, upon reading the invoice filling out this form, I think that is exactly the issue, and Potamkin Hyundai is ignoring the recall. The invoice states that "AIRBAG MODULE NEED FIXING caused by the DTC for the driver airbag resistance is too high, and has liquid leaking out of it through the connector into the clock spring, and need to replace the air bag incongruent with clock spring to perform repair correctly" The technician explained to my son that driving the car in it's current state, the air bag could go off at any moment, possibly killing him. Their airbag could kill my child. The repair is quoted at $1588 and the solution was to turn off the airbag until a decision could be made if my son wanted to drive the car home, which he did, so not it is disabled. It is a Hyundai manufactured airbag, a safety feature installed into this vehicle that should not degrade over time. It is actually the reason my aunt bought the car for her child and why my son bought the car from her. The car has never been wrecked, the airbag had never been deployed or otherwise molested, has been dealer maintained, and had an extended warranty. I spoke to a Hyundai representative and am awaiting a call back, I do not think that he should be responsible for repair of a defective, degrading safety feature built and manufactured by Hyundai, installed a vehicle built and manufactured by Hyundai. I believe other people should be warned that their Sonata airbags might also have this dangerous issue and it should be immediately investigated. Attached is the invoice given to my son.

While I was driving my car wouldn’t go no higher than 60mph and kept dropping speed but I came to a stop and when I stopped the car was smoking. I heard knocking noise and rumbling noise on the passenger side. It wouldn’t start again

While driving, the vehicle experienced sudden engine malfunction. The car entered limp mode, lost power, and produced a loud knocking noise from the engine. The failure occurred without warning and created a safety risk because the vehicle could not accelerate properly in traffic. This increased the risk of being rear-ended or unable to move out of dangerous situations. The issue appears to involve the engine (possible internal failure). The vehicle is currently at an authorized dealership and is available for inspection upon request. The problem has been confirmed by the dealership during inspection. The vehicle has been under diagnosis for over three weeks. There were no prior major warning signs before the failure. At the time of the incident, the vehicle suddenly lost performance, entered limp mode, and began making abnormal engine noise. This issue is consistent with widely reported engine defects in similar vehicles. Despite this, the manufacturer has denied coverage and attributed the issue to maintenance, even though regular maintenance was performed. This is a serious safety concern due to sudden loss of power while driving.

I purchased a used 2012 Hyundai Sonata. Within about 2 weeks it broke down while I was in the far left lane of the freeway. The car suddenly stopped accelerating and made a very loud knocking noise. Thankfully I was able to put on my hazards and make it to the right shoulder without getting into an accident but as soon as I pulled over it shut off and the panel lights all came on. Evidently there was a recall on an engine rod and the previous owners advised they were not aware of it. Hyundai has declined the repair on the recalled engine several times and their reasons keep changing. First they said I was missing records (admittedly I was missing one record but then provided it to them), then they stated excessive neglect due to the condition of the valve train (I saw pics of the valve train and is in good condition), and now they state because the KSDS wasn't installed. From what I understand, being the second owner, if I can prove the upkeep of the vehicle the extended waranty should cover the repair. I even have the letter from the car mechanic stating the vehicle was maintained and in good condition. It seems a lot of good people are getting declined for repairs on these faulty engines. I have many more documents I could provide showing all of the services done and communications with the company. Due to the size limit I included these ones for your review. Thank you so much for any help you can provide.

My 2012 Hyundai Sonata recently had an engine replacement completed under a Hyundai recall. Immediately after the recall repair, the vehicle began shaking while driving, produced a burning smell, and the air conditioning stopped working, none of which occurred prior to the recall repair. These symptoms started immediately after the engine replacement, indicating a possible improper or unsafe installation. I believe the vehicle is unsafe to drive due to the burning smell and shaking. I contacted Hyundai Customer Service and was told the issue must be resolved with the dealership. However, the dealership has refused timely inspection, has dismissed my safety concerns, and has declined to provide a rental or loaner vehicle, leaving me without safe transportation. This is a post-recall safety issue, and I am concerned about the risk of fire or mechanical failure due to the burning smell and vehicle instability. I am requesting this issue be formally investigated.

Odometer Fraud. The contact purchased a 2012 Hyundai Sonata. It was discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. The contact stated that the mileage on the title was discovered to be 98,000. At the time of purchase, the vehicle mileage was 99,000; however, a Carfax Report indicated that the mileage was 237,532.

The warning light for the airbags is on on my dashboard with no airbags ever been deployed.

Unknown, my ESP KEEPS Coming trying to see if it’s recall

Noticed there’s a crack on the passenger side dashboard of the car that’s about 12 inches long. From what I read this could cause issues with any possible airbag deployment.

The vehicle dashboard is severely cracked. It doesn’t appear to be from wear and tear.

No incident to report. Vehicle not regularly driven in about 5 years, other than to keep battery charged. But charge not hold. Have to charge battery again the next day. This is to reporting a crack in the passenger side dashboard where airbag is located.

My engine seized on the highway on my way home from work. The service department has been horrid. They lied about who the manager is. They lied about the reason behind not wanting to honor the recall. They are rude - threatened to tow my car today after I waited 6 days to hear back from them about the issue with my car and determination. Was extremely rude. Stated that they were not honoring the recall because there was obvious signs of my engine being tampered with or certain parts on my engine, but could not provide a name of the part or a serial or model number so that this could be verified. I need this addressed immediately.

My 2012 Hyundai Sonata cut off and stopped working! The vehicle locked up in the middle of a main street and would not start back up causing a very unsafe situation. There were no check engine lights on or anything at the time of the incident I immediately had the vehicle towed and inspected it has been determined that the engine is failing! Upon research I found out that these engines have had recalls in the past. Carfax shows that the vehicle has been taken in for routine maintenance and oil changes when needed. I am looking to see if the engine replacement could be covered for this vehicle.

The contact owned a 2012 Hyundai Sonata. The contact stated that while driving to her residence at unknown speeds, the vehicle suddenly caught fire while making a U-turn. The brakes and emergency brake were inoperable. The seatbelt was inoperable. The driver jumped out of the window. A pedestrian attempted to alert her of the fire. The vehicle exploded after exiting the vehicle. The contact sustained an injury to her leg, but no medical attention was provided. The fire department extinguished the fire. A police report was filed. There was no report of a crash or airbag deployment. The vehicle was towed to a tow lot. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 136,000. The vehicle was auctioned off by the towing company.

Driving came to a stop ,light turned green made a U-turn to go to the gas station heard a pop noise smoke came from inside the car tried stopping it but the brake pedal sunk into the ground pressed my emergency brake it was seized wouldn’t go down (never had that issue my brakes always work ) I smelled brake fluid and seen the abs light on the dash then the power started to go out and my girlfriend almost got trapped in the car

Based on what I experienced, the fire appears to have resulted from an internal mechanical or electrical failure that occurred without warning while the vehicle was in motion. No prior issues or dashboard alerts were present at the time, and there was no external impact or damage that could explain the fire.

I am reporting a pattern of systemic failures on a 2012 Hyundai Sonata Hybrid with approximately 131,000 miles. This is my second NHTSA complaint regarding this vehicle and manufacturer. Primary Safety Concern — Engine Wiring Harness: During a recent engine replacement at an authorized Hyundai dealership, technicians identified damage to the engine wiring harness and documented in writing that the owner “might have issues with drive ability.” The dealership declined to repair it under the same goodwill program used to replace the engine and returned the vehicle with this known defect unresolved. The harness directly controls engine operation, hybrid system communication, and overall vehicle control. On a hybrid vehicle, a compromised harness presents a serious and ongoing safety risk. This component is available for inspection upon request. Engine Failure: The hybrid system warning light appeared prior to failure. The vehicle was towed to an authorized dealership where diagnostic code P1326 confirmed engine failure. The manufacturer acknowledged this and replaced the engine under goodwill. Additional System Failures: A pre-scan diagnostic revealed simultaneous fault codes across six systems — engine, transmission, ABS, active hydraulic booster, battery management, and motor control unit — including codes U0293 and U1004 indicating lost communication with the hybrid powertrain control module across multiple systems simultaneously. Independent Safety Advisory: A separate independent repair facility documented in writing that the vehicle presented a severe wheel hub bearing noise and formally advised of an extremely dangerous driving condition. Prior NHTSA Complaint: My first complaint to NHTSA involved this same vehicle when the manufacturer refused to provide a loaner during an extended recall-related repair hold, requiring formal escalation before they complied. The wiring harness defect remains unrepaired. The vehicle is driven daily out of necessity.

This is the 2nd Hyundai I've owned, same year make and model. The first one was totaled due to the air bag deployment. The accident did not warrant the air bag deploying. I should have reported it at the time. I didn't realize that I could and now it's too late. The claim has already been submitted. Now, we have the same exact car and a crack has appeared on the passenger dash. My concern is the airbag. The crack just appeared from nowhere. I do not feel that we should have to pay for a replacement dash. Is this something that can be repaired by Hyundai, as it poses a risk to my 18 year old student driver. My number is [XXX] , [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

came off the highway to a stop sign went turn and the engine just seized and would not start no matter what I did. had to have it towed to my house. safety risk was just off the road so i did not get hit. police stop and told me to get a tow truck. and no warning signs at all

The part of hand break assembly that’s inside the disk break (the drum assembly) fell off when the dealer ( [XXX] Hyundai, Schaumburg, IL) tried to adjusted. I went to the dealer because the hand break stop to function. I suspect very bad design of the whole assembly disk and drum break. Also the dealer stated that all assembly was rusted. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2012 Hyundai Sonata originally had its engine replaced under Hyundai’s recall (NHTSA Recall #17V226000) due to the Theta II GDI engine defect. The replacement engine was installed by the dealership as part of the recall. However, the replacement engine has now failed after only ~50,000 miles, exhibiting the same issues (engine knocking, stalling, and eventual failure). This occurred despite proper maintenance and care. The dealership contacted Hyundai, and I also contacted Hyundai Consumer Affairs directly. Both refused to replace or assist with the failed replacement engine. It is unacceptable that a recall replacement engine would fail so soon and that Hyundai will not stand behind the part they used to correct a safety defect. The issue remains a serious safety concern, especially since engine failure can lead to fire. I request that NHTSA investigate the durability and safety of replacement engines and Hyundai’s refusal to support affected owners when these replacement engines fail prematurely. I have case number with Hyundai 41436693

Vehicle loses power while driving making it unsafe to drive, it can cause an accident in certain conditions like when passing another vehicle or crossing a street. There is a recall for this issue.

The contact owns a 2012 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 18V934000 (Engine, Fuel System, Gasoline). The contact stated that while driving 20 MPH, the vehicle stalled. There was an abnormal knocking sound coming from the vehicle. While driving at an undisclosed speed, the vehicle stalled after five minutes. The engine and the ABS warning lights were illuminated. The vehicle was towed to the residence. The contact called the local dealer and was informed that the maintenance records were needed. The contact was using an independent mechanic for maintenance and did not have the records. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 100,000.

My car has a problem whith the break lamps, the sockets that hold the bulbs are melting and they have deformed making it hard to replace the fused bulbs. Also the brake light stay on even after the engine is off draining the Battery and causing a short circuit.

This is the first time I have an engine failure. I drove my car 3 min before merging into the route 1 highway. In approximately 800 feet, my car went haywire, all lights in the dashboard went ON, the steering wheel got stiff, and the car speed dropped off, I almost got rear-ended. I made an effort to pull over to the break lane. The car shut off and I could not get it to start. I opened the hood, a light smoke was coming out of the engine. I left it open to make sure it doesn't get worse. After 10 min, a State trooper stopped by to check on my safety, I informed him that I called the insurance to report the incident and request a tow truck. After the tow truck dropped off my car in front of my house, I called a mechanic to check it, he informed me that the engine is seized.

Airbags failed to deploy. I was involved in a hit and run accident. Vehicle has not been inspected. I had a recall done on it with paperwork confirming it was fixed. I have 4 herniated discs in my back and neck.

With no warning my car left me sit on the side of the road and when started the engine made an awful knocking noise. Hyundai denied to replace the engine despite there being at least 2 engine recalls. When I asked why they said it was due to no maintenance records so I provided them with maintenance records like they requested and then they deny it again and say they aren’t replacing the engine because the problem with my engine had nothing to do with the 2 engine recalls my vehicle IS affected by.

My 2012 Hyundai Sonata (VIN: [XXX] ) experienced complete engine failure at 241,433 miles on August 7, 2025. The failure aligns with known safety defect symptoms described under NHTSA Recall Campaign 15V568000 and 17V226000, which cite premature bearing wear due to metal debris during engine manufacturing. My vehicle had previously received the knock sensor update under Campaign T3G and failed the BCT (bearing clearance test), confirming bearing damage. Despite this, Hyundai denied my engine replacement claim, stating the issue was related to a fuel pipe and not a rod bearing issue—this is contrary to their own recall documentation and dealer diagnosis. Hyundai continues to deny engine replacement, in violation of their federal recall obligations under 49 U.S.C. §30120. Their refusal endangers public safety by ignoring engine failures that can lead to stalling and crashes. I request NHTSA intervention to compel Hyundai Motor America to comply with federal law and perform the necessary recall repairs on my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine seized due to extremely low oil despite more than regular oil changes.

I started the car, put it into gear and then the breaks wouldn’t work. The car dash said something like check breaks hybrid system failure do not drive. There is not recall on my car but the Hyundai service department doesn’t know how to fix it. This is the second time it’s happened. I’m scared to drive it. Please investigate!

I drive a 2012 Hyundai Sonata Limited. After a recent fill-up, I began experiencing delayed acceleration, engine hesitation, and what appears to be misfiring—especially at low throttle. Most notably, the brake lights stay illuminated even when the car is turned off, which drains the battery and poses a major safety hazard. I scanned the vehicle with an OBD-II scanner and received code P0504, which points to a brake light switch malfunction. I also noticed that pressing the start button with my foot off the brake still starts the engine instead of going into accessory mode—confirming abnormal brake signal behavior. I replaced the brake light switch, which temporarily fixed the issue, but the symptoms returned within a day. After researching, I found there was a recall (NHTSA 15V759000) for a nearly identical issue involving the brake light switch and stopper pad. However, my VIN is not listed, even though I am experiencing the same safety-critical symptoms. This issue poses a significant safety risk on the road, and I believe my vehicle should be included in the affected population of the recall or issued a Technical Service Bulletin extension.

On [XXX] while driving approximately 1.5 hours away from home, a warning message appeared on my dashboard stating: “Hybrid System Warning. Stop and Do Not Drive.” I immediately pulled over and contacted my insurance company, who arranged for the vehicle to be towed to the nearest authorized Hyundai dealership (Thomas Hyundai in Cumberland). The warning clearly indicated that it was not safe to continue driving. Later, I found out that the issue reported (recall 198) have presented cases ending with fire of the engine. It is critical to mention that in January 2025, I attended the official manufacturer recall for this vehicle, which was supposed to ensure safety and reliability. Despite this, the vehicle failed and left me stranded in an unsafe area. Since then, I have been without my vehicle for over three weeks. I contacted Hyundai customer care and opened a case. I was repeatedly told a case manager would call me within three business days, but I never received any follow-up until I insisted. I was eventually assigned a case manager named Snowy, and also remained in contact with the dealership. On several occasions, both Snowy and the dealership assured me that the vehicle would be ready by Thursday, July 10 and that It was not until then that I could start to request a reimbursement for my rental expenses. I repeatedly asked for confirmation because I am renting a car at my own expense in order to go to work and manage my life. However, on Thursday, July 10, I called again and was told the vehicle would instead be ready by Tuesday, July 15. Then, on Friday, July 11, I received an email stating that the engine had just arrived, and that the dealership was only now able to begin repairs. After that, and only once the car is finished, Hyundai will “review” the case and determine whether I qualify for reimbursement. This is unacceptable. I have been without a vehicle for over three weeks, forced to rent a car entirely at my own expense. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving on the highway with my two minor children, my vehicle suddenly shut off without warning. I lost power in the middle of traffic, which was extremely dangerous — we were nearly rear-ended and had to coast to the shoulder. The check engine light had been on for some time prior to the incident, but there were no other warning messages. After being towed, the car would not start again, even after attempting to jump-start it. A mechanic inspected it and believes the engine is seized. I later discovered that my 2012 Sonata is equipped with the Theta II engine, which is known for sudden failure due to oil starvation or bearing wear. Although there are no current recalls on my VIN, the symptoms are consistent with the known Theta II engine defect. This situation put me and my children at serious risk, and I believe this failure needs to be addressed as a safety issue.

Hybrid system malfunction Do not Drive warning light comes on while driving and stalls out the car

The contact owns a 2012 Hyundai Sonata. The contact stated that while attempting to start the vehicle, the vehicle briefly hesitated before starting. After starting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the engine. The contact was advised to take the vehicle to the dealer for assistance. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 137,000.

On [XXX] at approximately [XXX], my [XXX] Daughter was using my car to go to work. When she called us and informed my husband that the car did not start. At that point he asked to video call him so that he can visually see what was going on. She was directed to turn on the car again at and that point, the car started then smoke was noticed from coming out of the hood. My daughter managed to open the hood where flames emerged from the center of the engine. She then ran in the house to get a fire extinguisher and managed to put it out and it reignited. She then made a second attempt with another fire extinguisher where it briefly subsided and then grew larger. At that point the fire dept arrived and successfully extinguished the fire and deemed the car totaled after the Fire Marshall carefully inspected the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Hyundai Sonata. The contact stated while driving 35 MPH, the vehicle was leaking engine oil. There were no warning lights illuminated. The contact towed the vehicle to an independent mechanic who diagnosed the vehicle with engine failure. Due to the oil leak, the vehicle was left with no oil in the engine, causing the engine to seize. The dealer was made aware of the failure; however, the contact was informed the vehicle only had a 60-day warranty. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 105,761.

Unknown Cought fire under the hood was engulfed within minutes

Painting chipping on front top car... Seatbelt don't fasten all the time...Lights are dim.

Engine suddenly shut off middle of the road while driving and will not restart. No warning lights came on prior to the engine failure. My family safety was put at risk since engine shut off middle of the road and I had to push it to the corner lane. Just imagine if I was on the middle lane on a highway when this happened. Alternator, battery was checked by a mechanic...no issue.

The contact owns a 2012 Hyundai Sonata. The contact stated while driving 70 MPH, the check brake and "Hybrid System Warning Safely Stop - Do Not Drive" messages were displayed on the instrument panel, and the vehicle went into LIMP Mode. The vehicle was towed to the residence, and the contact replaced the hydraulic pressure units and hydraulic unit assemblies (HECU/ABS modules). The contact stated that after the repairs, the failure returned approximately 30,000 miles later. The dealer was notified of the failure, and the contact was provided with an estimate for the repair. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 130,000.

When driving. Slow down to turn or to use round about car goes into EV. When i go to accelerate the gas motor will not re engage and the hybrid alarm system will go off. I lose all power to go any where. I have to pull over shut my car off give it a min then restart so the motor will come back on so i can drive again. I have to do this mulitple time in a 20 mile drive.

Car went complete stall after a warning light came off “Hybrid System Warning - Check Brakes” I am completely braked, but when I slowly releasing the brake pedal, there’s was a loud grinding noice and the wheels wouldn’t go forward at all, so I have to step on the brake again . I got stuck IN THE MIDDLE of the road and couldn’t park on the right curb since the car randomly got stalled completely. It took almost 40mins for the warning issue to go away and the car went back to normal. However, IT’S COMPLETELY A SAFETY ISSUE for the car to randomly stall in the middle of driving! I could be driving to fast traffic on a freeway or wide street where accidents can occur since I couldn’t even drive it a bit to park on the curb. On top of this - I occasionally get “hybrid system warning” whenever I am in the middle of driving and I always have to pull over and wait at least half an hour for it to go away, it’s been happening for few years now, and tonight was the most dangerous one so far!!! Please make Hyundai do a recall on the hybrid battery diagnose or replacement

I took the car to the dealer because the codes was reading engine assembly issues. I took it to the dealer and they stated it was the knock sensor and they got it approved to replace it now they saying it's the engine and it was denied. I just got the engine from the dealership in 2020

In October of 2023, I was driving my 2012 Hyundai Sonata Hybrid to the laundry mat about a quarter of a mile from my home. I stopped at a stop light and all of a sudden, a warning sound burst from my dasher board. The message stated, "Hybrid Warning-DO NOT DRIVE: CHECK BRAKES". The brakes completely stopped working, the pedal was to the floor and the accelerator was stalling. After managing to get the vehicle back to my home, naturally I went to the Dealership (Langdale Hyundai of Valdosta) and informed them of the issue. They informed me there was no issue, charged me for a diagnostic and sent me on my way. Once I provided proof of my car stopping mid-drive, they began to check wiring and such. What they told me the issue was is a Hydraulic Power Unit. I had it replaced, still the same issue "CHECK BRAKES". I only have 116k miles on this car, bought it with 72K in 2021, so I haven't driven it much. It spent 8 months in Hyundai Dealership in Holiday, FL for a brand-new Hybrid Battery in 2022. I have been looking online for anyone that knows more about this issue so I can get it resolved. It turns out there are thousands of people who are just like me. I believe this is indeed a recall issue. I believe this is an issue is an emergency issue, brakes giving out while driving is an issue that needs to be addressed. This has been happening for years, and Hyundai has not done one thing on it. It's happening with newer vehicles as well as older. Langdale Hyundai of Valdosta was not much of a help at all, to be honest, I don't trust their workers at all. I believe they do nothing and charge customers for the max that they can.

I bought car octv230th little after month as driving engine failure occurred had towed to dealership and they sent to authorized hyndai dealership for the extended warranty campaign. That garage acknowledged problems with the cars engine stating rod bearing clearance and the engine had to be replaced then charged me denied the extended warranty they initially said would classify for. I couldn't keep up with traffic and was very busy almost cause a crash.

Car engine light is flashing

I was driving I seen smoke then full flames on my windshield and I tried to stop and put my car in park to get out but my brakes stopped working and I couldn’t get the gear in park so I opened the driver door and had to jump out of the car .I had an engine replacement a year before for it being recalled and police and firefighters were on scene after incident