2023 Jeep Grand Cherokee Suspension Problems

I am reporting a systemic safety failure involving a 2023 Jeep Grand Cherokee sold as a "Certified Pre-Owned" (CPO) vehicle. Despite the mandatory 125-point CPO safety inspection, the vehicle was delivered with multiple safety-critical defects that should have prevented certification. Primary Safety Risks: Suspension/Stability: The vehicle exhibits vibration and instability at all speeds, resulting in a loss of steering stability and difficulty maintaining lane position at highway speed. Tire Integrity: The vehicle was sold with dry-rotted tires, indicating structural degradation that poses a high risk of catastrophic failure/blowout. Electrical/Powertrain: The Auto Start/Stop system is faulty. Additionally, the paddle shifters are non-functional, which interferes with manual gear selection and driver control over the powertrain. The selling dealership has refused to acknowledge these defects or bring the vehicle into compliance with manufacturer safety standards. Furthermore, Stellantis Corporate has failed to provide a safety compliance review. These mechanical and electrical defects existed at the time of sale and represent a failure of the CPO safety process.

The contact owns a 2023 Jeep Grand Cherokee. The contact stated that while driving approximately 40 MPH, the vehicle unexpectedly lowered and started pulling to the right. The vehicle was pulled over to the side of the road, and the contact exited to inspect the vehicle but found no failure. The vehicle was taken to the residence, and then to a dealer, where it was diagnosed and determined that the axle and passenger’s side rear tension link were bent and lodged into the knuckle, the passenger steering knuckle was fractured with a fractured bolt inside, and the passenger’s side rear tension link, CV axle, and steering knuckle needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately 8 weeks later on the driver's side. The contact stated that while driving approximately 20 MPH, there was an abnormal sound coming from the rear passenger’s side of the vehicle, and the vehicle started pulling to the left. The vehicle was pulled over to the side of the road and inspected, but the contact found no visible failure. The vehicle was taken to the dealer, where it was determined that the driver's side rear axle and driver's side rear tension link were bent and had lodged into the knuckle, the driver's side steering knuckle was fractured with a fractured bolt inside, and the driver's side rear tension link, CV axle, and steering knuckle needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 62,000.

I taken my vehicle to the dealership three times in less than one year, and my recall have not been fixed. An unexpected loss of propulsion can cause a vehicle crash without prior warning is what the recall is saying. this vehicle is not safe to drive, yet the dealership won't provide me another vehicle, nor buying it back. The recall number is 73C. My hybrid electrical system light comes on and my vehicle cuts off by itself when driving. vehicle can catch fire at any moment due to this recall not being fixed.

Upper passenger Suspension Coil spring isolator came unattached and caused coil spring to fall out.

Lower passenger coil spring isolator loose causing spring and upper isolator to fall out while driving Dealership stated recall was done 6/23 and was out of warranty for that recall. But everything in that suspension is OEM with the old part numbers not the ones in the recall..

While turning lnto my driveway, the passenger rear spring fell off and the car tilted to the passenger side

I was driving pulled in to driveway heard a loud bang and the back of the car dropped and hear scraping. The rear passenger coil spring had fallen out with the upper rubber isolator attached. Called jeep they said the recall had been done in 6 23 and was out of the 2 year repair warranty. I don't see how the recall was done when all the numbers on the coil spring , isolator were still original parts?

Driving in [XXX] in the HOV lanes on the evening of 22 June, the car traveled over an uneven section of the road. Heard a noise and felt the car go over a small bump. Car ride felt slightly different and continued on to home. Next day, looked at cat and the rear end was sitting uneven. Right rear lower than left rear. Looked under the rear of the car and saw the right rear coil spring was not there. The left rear spring is still in place. Prior to this, there was no problem with the ride or suspension of the car. There are no warning lights on the dash currently or prior to the spring falling off the car. I am not driving the car to to what I consider an unsafe condition. I am making an appointment at the dealer to get the problem resolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving at approximately 20 - 35 mph, the passenger side rear suspension coil spring fell off. When that happened, the vehicle sank on that side (rear, right side) and the coil spring and spring pad components projected outwards with force towards the road side. No dash lights were activated but, vehicle was exhibiting an unstable (bouncy) driving condition. The vehicle was towed to authorized service center for repairs and a claim was initiated with the manufacturer out of abundance of caution since the event has a resemblance to NHTSA Recall No. 23V-413 (JUN, 2023) and Safety Recall Notice 64A. Said Recall appears on the manufacturer's website as completed for this vehicle.

In February 2025, my jeep would flash a “Service Hybrid System” code that would last about 3-5 seconds and disappear. This happened about 4-5 times over the next few months, code would not stay up and vehicle seemed unaffected. On June 10, I was driving with son on a highway about 60 mph when my car completely shut off, no power to engine, no power steering- absolutely nothing. We experienced a very aggressive jerk when this happened and I limped the vehicle off to the shoulder- we live in a remote area and I had no cell service. I was able to restart my car and drove it in “e-save” mode home. The next day, I drove my car again and had my son and daughter in the vehicle and the same exact thing happened. I was driving about 55mph around a corner with a large semi coming at me in the oncoming lane and my vehicle shut off and lost power and power steering. I was terrified that I would veer into that truck and there was not a shoulder readily available. We had to yet again limp the vehicle a few yards around the corner to pull off and I did not have service. So I had to walk to call my husband to pick my children up. The car has been at the dealership since then and told there is a digital crash code showing with no eta on a fix. Stellantis has denied a buyback yet my car has 26,000 miles on it and is under warranty with no eta on fix. Vehicle is unsafe to drive and unfixable for 60 days now.

drive shaft is making a scary noise when accelerating an I read the info this is nothing to play with I would like to have this looked at again this will be my 3rd time

FCA Campaign 64A NHTSA 23V-413 / Date Completed: 09/26/2023 08/05/2024 - while driving at 30mph the rear coil spring shot down from the rear passenger side wheel nearly causing and a motor vehicle accident and injury. The recall was addressed back in September of 2023 yet failed the alleged fix from the dealership.

The contact owns a 2023 Jeep Grand Cherokee. While the contact’s daughter was driving approximately 60–65 MPH, the rear coil spring detached from the vehicle. The contact was unaware if there were any warning lights illuminated. The vehicle was previously taken to the local dealer, who repaired the vehicle under NHTSA Campaign Number: 23V413000 (Suspension). The vehicle was repaired; however, the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 40,000.

Forward Collision Warning not working not braking. When turning left or right I hear a loud scratching noise.l have had my 2023 Jeep Grand Cherokee at the dealership twice they can't find anything wrong, going back to the dealer tomorrow and try again........

So i’ve been dealing with a clunk sound & suspension ride issue, they have change 3 sway bars & links & back shocks etc.

Jeep tells me I need to leave my car for several days to repair the recall. However, they refuse to provide me with a loaner vehicle, and I need a vehicle to survive. I have work and family commitments. This is harming me as the consumer when the recalled item is the responsibility of Jeep.

The contact owned a 2023 Jeep Grand Cherokee. The contact stated that while driving at slow speeds in the driveway, there was an abnormal metallic sound coming from underneath the vehicle. After a visual inspection, the contact became aware that an unknown part had detached. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the rear coil spring. The contact was informed that the rear coil spring had detached. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V413000 (Suspension). The VIN was included; however, the vehicle was repaired by the dealer on December 6, 2023, 17 days before the failure occurred. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 9,000.

The contact owns a 2023 Jeep Grand Cherokee. The contact received notification of NHTSA Campaign Number: 23V413000 (Suspension) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The dealer has been putting us off for months on the safety recall for the coil spring issue. They keep telling us that the parts are unavailable. We are afraid to drive our brand new car. They will not give us an ETA on the repair.

The contact owns a 2023 Jeep Grand Cherokee. The contact received notification of NHTSA Campaign Number: 23V413000 (Suspension) however, the part to do the recall repair was not yet available. The local dealer was contacted and stated that parts were not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.