There are 13 stored owner reports matching the electrical system leading-label group for the 2007 Suzuki XL7 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 13 of 13 matching reports.
Open the full vehicle complaint log (all categories)I PURCHASED MY XL7 LUXURY NEW IN 2007 WITH ONLY 368+ MILES. BEFORE I HAD DRIVEN THE VEHICLE FOR 3 MONTHS, THE STABILITY CONTROL AND TRACTION CONTROL LIGHTS CAME ON AND I WAS FORCED TO TAKE THE VEHICLE FOR SERVICE. BEFORE MY VEHICLE WARRANTY EXPIRED, I HAD TO REPLACE THE GAS CAPS NUMEROUS TIMES RESULTING IN THE REPLACEMENT OF MY CATALYTIC CONVERTER. NOW BEFORE MY VEHICLE REACHED 100,000 MILES, I AM FORCED TO REPLACE THE ELECTRICAL HARNESS (OR COMPLETE COMPUTER OUTPUT). PUGMIRE LINCOLN MERCURY IS THE ONLY DEALERSHIP IN MY AREA THAT PROVIDES REPAIRS FOR MY VEHICLE. AFTER THE HARNESS REPAIR, THE CHECK ENGINE LIGHT IS BACK ON, AND THE CODES (IN LESS THAN 3 MONTHS) REVEAL THAT CODES: [P2099, P0157, P2272 AND P2099] RESULTING THAT THERE IS AN OIL LEAK, AN O2 SENSOR PROBLEM AND ANOTHER CATALYTIC FUEL PROBLEM AGAIN. IT IS TIME FOR MY 100,000 MILE CHECK-UP, BUT I CANNOT GET PAST THE ORIGINAL PROBLEMS. THESE CONDITIONS CONTINUE AND I LOVE MY VEHICLE. I WAS USING MY VEHICLE FOR TO AND FROM WORK OF LESS THAN 11 MILES DAILY. I HAVE DRIVEN AS FAR WEST AS SAN ANTONIO, TX AND NORTH TO BALTIMORE MD AND SOUTH TO JACKSONVILLE FL. MY ABS LIGHT CONTINUES TO COME ON AND MY OIL LIGHT FLASHES TO INSTRUCT ME TO CUT OFF THE MOTOR AND TIGHTEN MY GAS CAP WHILE IN MOTION.
TL* THE CONTACT OWNS A 2007 SUZUKI XL7. WHILE DRIVING APPROXIMATELY 25 MPH, THE TEMPERATURE GAUGE ABNORMALLY INCREASED AND THE ENGINE OVERHEATED. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED SMOKE (NO FLAMES) UNDER THE HOOD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT CLUSTER WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
WHEN PUT GAS IN DOESN'T START HAS TO HOLD GAS PEDAL DOWN.. DRIVING ON HI WAY GOING 70MPH ON INTERSTATE 69. HAD TO COME TO ABRUPT STOP TRUCK SHUT OFF AND WOULD NOT START FOR FEW MINUTES IN MIDDLE OF HIGHWAY . THIS HAS HAPPENED TWICE SO FAR.AND SOMETIMES WHEN SPEEDING UP IT SMELLS LIKE SOMETHING IS BURNING.THERES OTHER STUFF BUT NOT TOO MAJOR AS THESE ARE. *TR
THERE ARE MULTIPLE ISSUES WITH MY 2007 XL-7. MOST RECENTLY IT'S BEEN THE SMELL OF BURNING WIRES COMING FROM EITHER THE STEERING COLUMN OR UNDER THE DASHBOARD WHICH I WILL NEED TO GET INSPECTED ASAP. I READ ONE OTHER COMPLAINT POSTED ON 2/29/12 STATING THE SAME PROBLEM OF SMELLING BURNING WIRES WHICH ENDED IN THE VEHICLE BEING ENGULFED IN FLAMES AND THE FAMILY RUNNING FOR THEIR LIVES. I'VE ALREADY HAD A SO CALLED TUNE-UP FROM THE LOCAL DEALER ABOUT 1 1/2 YEARS AGO, BUT I NOW HAVE ISSUES STARTING THE VEHICLE WHEN I GET GAS. I HAVE TO PUMP THE GAS PEDAL MULTIPLE TIMES IN ORDER TO START THE SUV AND THEN IT'S A ROUGH IDLE UNTIL I START DRIVING. I GET THE OIL CHANGE REGULARLY, BUT WAS TOLD ON THE LAST OIL CHANGE THAT I NEEDED A NEW OIL PAN GASKET BECAUSE OIL WAS LEAKING FROM THE PAN. I ALSO HAD MY BRAKES CHECKED 2 YEARS AGO AND WAS TOLD BY THE MECHANIC THAT I HAVE UNEVEN BRAKE PADS DUE TO THE FRONT BRAKE CALIPERS ENGAGING INCORRECTLY OR ON ONE SIDE OF THE ROTORS. IN ORDER TO REPLACE THE CALIPERS, GET NEW BRAKE PADS AND TURN THE ROTORS ON THE FRONT, IT WOULD COST ME $400+ PER THE MECHANIC WHICH I FELT WAS RIDICULOUS. I'VE NEVER HEARD OF FAULTY BRAKE CALIPERS ON A VEHICLE BELOW 5 YEARS OF AGE AS I BOUGHT MY XL-7 NEW IN 2007 AND THE BRAKE INSPECTION WAS BETWEEN 2009 AND 2010. MY WINDSHIELD WIPERS FAILED ONE YEAR TO THE POINT WHERE I NOW HAVE A SCRATCH ON MY WINDSHIELD. I LIKE THE STYLE OF THE XL-7 AND ITS HORSE POWER AND IT' HAS NOT FAILED ME ON LONG ROAD TRIPS, BUT THE RECENT ISSUE AND PAST ISSUES ARE VERY TROUBLESOME. I'M VERY CLOSE TO PAYING MY SUV OFF AND NO LONGER HAVE THE WARRANTY SO I HAVE SOME DECISIONS TO MAKE ON WHETHER I SHOULD INVEST THE MONEY OR GET RID OF IT. A RECALL ON THE ELECTRICAL SYSTEM SHOULD BE IMPLEMENTED WHEN CONSIDERING ALL THE PAST COMPLAINTS. BY THE WAY, THE DEALER I PURCHASED MY XL-7 FROM NO LONGER EXISTS. *TR
THERE ARE MULTIPLE ISSUES WITH MY 2007 XL-7. MOST RECENTLY IT'S BEEN THE SMELL OF BURNING WIRES COMING FROM EITHER THE STEERING COLUMN OR UNDER THE DASHBOARD WHICH I WILL NEED TO GET INSPECTED ASAP. I READ ONE OTHER COMPLAINT POSTED ON 2/29/12 STATING THE SAME PROBLEM OF SMELLING BURNING WIRES WHICH ENDED IN THE VEHICLE BEING ENGULFED IN FLAMES AND THE FAMILY RUNNING FOR THEIR LIVES. I'VE ALREADY HAD A SO CALLED TUNE-UP FROM THE LOCAL DEALER ABOUT 1 1/2 YEARS AGO, BUT I NOW HAVE ISSUES STARTING THE VEHICLE WHEN I GET GAS. I HAVE TO PUMP THE GAS PEDAL MULTIPLE TIMES IN ORDER TO START THE SUV AND THEN IT'S A ROUGH IDLE UNTIL I START DRIVING. I GET THE OIL CHANGE REGULARLY, BUT WAS TOLD ON THE LAST OIL CHANGE THE I NEEDED A NEW OIL PAN GASKET BECAUSE OIL WAS LEAKING FROM THE PAN. I ALSO HAD MY BRAKES CHECKED 2 YEARS AGO AND WAS TOLD BY THE MECHANIC THAT I HAVE UNEVEN BRAKE PADS DUE TO THE FRONT BRAKE CALIPERS ENGAGING INCORRECTLY OR ON ONE SIDE OF THE ROTORS. IN ORDER TO REPLACE THE CALIPERS, GET NEW BRAKE PADS AND TURN THE ROTORS ON THE FRONT, IT WOULD COST ME $400+ PER THE MECHANIC WHICH I FELT WAS RIDICULOUS. I'VE NEVER HEARD OF FAULTY BRAKE CALIPERS ON A VEHICLE UNDER 5 YEARS OF AGE AS I BOUGHT MY XL-7 NEW IN 2007 AND THE BRAKE INSPECTION WAS BETWEEN 2009 - 2010. MY WINDSHIELD WIPERS FAILED ONE YEAR TO THE POINT WHERE I NOW HAVE A SCRATCH ON MY WINDSHIELD. I LIKE THE STYLE OF THE XL-7 AND IT'S HORSE POWER AND IT'S NOT FAILED ME ON LONG ROAD TRIPS, BUT THE RECENT ISSUE AND PAST ISSUES ARE VERY TROUBLESOME. I'M VERY CLOSE TO PAYING MY SUV OFF AND NO LONGER HAVE THE WARRANTY SO I HAVE SOME DECISIONS TO MAKE ON WHETHER I SHOULD INVEST THE MONEY OR GET RID OF IT. A RECALL ON THE ELECTRICAL SYSTEM SHOULD BE IMPLEMENTED WHEN CONSIDERING ALL THE PAST COMPLAINTS. BY THE WAY, THE DEALER I PURCHASED MY XL-7 FROM NO LONGER EXIST. *TR
TL* THE CONTACT OWNS A 2007 SUZUKI XL7. THE CONTACT STATED ALL OF THE GAUGES ON THE INSTRUMENT PANEL FAILED TO FUNCTION. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND STATED THERE WERE NO RECALLS AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 53,000.
THE ENGINE OVERHEATED DUE TO WIRING SHORTING OUT ON TWO FAN MOTORS. NO FUSE WAS TRIPPED OR LIGHT CAME ON. BOTH MOTORS SHORTED CAUSING THE CONNECTORS IN THE WIRING HARNESS TO MELT. MELTING WAS DISCOVERED BY LOCAL DEALER. THE WIRING IS BEING REMOVED. I HAVE PICTURES AND I HAVE DOCUMENTED THE PROBLEM. THE PARTS BEING KEPT DUE TO SERIOUSNESS OF THE DEFECT. *TR
MY CAR SPEEDOMETER IS NOT WORKING IT STARTED ALL OF A SUDDEN READING 120 MILES AN HOUR WHEN I WAS DRIVING 30 MILES PER HOUR ALSO MY SPEEDOMETER READS 120 MILES PER HOUR WHEN CAR IS STOPPED. *TR
TL* THE CONTACT OWNS A 2007 SUZUKI XL7. THE CONTACT STATED THAT IF THERE WAS A POWER FAILURE WHILE IN THE VEHICLE, HE NOTICED THAT ONE WOULD BE UNABLE TO EXIT THE VEHICLE. THE UNLOCK/LOCK BUTTON WAS ELECTRONICALLY CONTROLLED. HE HAD TO HAVE SOMEONE GET A SECOND KEY TO UNLOCK THE DOORS SO HE COULD GET OUT OF THE VEHICLE. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 18,000.
I AM THE ORIGINAL OWNER OF A 2007 SUZUKI XL7. DUE TO DISABILITIES IN THE FAMILY I PUT SEVERAL MILES ON THIS VEHICLE. FROM THE BEGINNING I HAVE SEVERAL ISSUES W/THIS VEHICLE. BECAUSE OF SUZUKI'S LACK OF CONCERN/INTEREST I HAVE DECIDED TO MAKE FORMAL COMPLAINTS ABOUT THE "SAFETY" ISSUES TODAY. IF I WAS TO LIST ALL PROBLEMS WITH THIS VEHICLE I WOULD BE HERE ALL DAY. OUT OF 4 PASSENGER WINDOWS WE CURRENTLY HAVE ONLY 2 FUNCTIONING. WHEN DIAGNOSED I WAS TOLD THAT ONE WINDOW WAS THE MOTOR AND THE OTHER WAS ELECTRICAL. AFTER PAYING $76.00 TO THE DEALERSHIP TO IDENTIFY THE ELECTRICAL PROBLEM THEY TOLD ME THAT THEY WOULD NEED AT LEAST AN ADDITIONAL HOUR (ADDITIONAL $76.00) TO FIND THE WIRING PROBLEM. I DECLINED. I HAVE MADE SEVERAL CALLS TO SUZUKI, ABOUT THEIR PRODUCT, TO WHICH THEY HAVE REPLIED I HAVE TOO MANY MILES ON MY CAR AND THEY WILL DO NOTHING FOR ME. ALSO, THE LATCHES THAT FOLD THE MIDDLE SEATS DOWN OFTEN STICK. AT ANY GIVEN TIME YOU CAN GO TO PULL ONE UP SO AS TO FOLD THE MIDDLE SEATS AND THEY WILL NOT BUDGE! WE HAVE ALREADY HAD THIS ISSUE ADDRESSED WAY BACK IN THE BEGINNING OF OWNING THE VEHICLE. WHEN WE BROUGHT IT BACK IN TO HAVE THE MULTIPLE ISSUES ADDRESSED (SOMETHING SUZUKI SUGGESTED WE DO TO SEE IF WE COULD HELP) WE WERE TOLD THAT "THEY WOULD NEED TO BE TAKEN APART TO SEE WHAT THE PROBLEM WAS". FOR A COST, OF COURSE. WE DO NOT LET OUR DAUGHTERS RIDE IN THE THIRD ROW SEATING FOR FEAR THAT IF SOMETHING HAPPENED THEY COULD NOT GET OUT!! SUZUKI'S REP (WHO I WAS TOLD WAS ON VACATION AND DIDN'T KNOW WHEN HE COULD CONSIDER OUR ISSUES) QUICKLY EMAILED BACK TO THE DEALER "TOO MANY MILES, NOT GOING TO HELP". I CANNOT EVEN BEGIN TO AFFORD THE MULTIPLE PROBLEMS W/THIS CAR AND THE VALUE HAS DECREASED SO THAT TRADING IT IN IS JUST NOT AN OPTION. MY CONCERN IS THAT I DRIVE MY CHILDREN IN THIS CAR DAILY AND EVERYTIME I HOPE AND PRAY NOTHING MAJOR HAPPENS. MY CHILDREN NOW CALL THE CAR THE "LEMON" OR THE "BEATER". AS THEY TOO ARE WELL AWARE OF ALL THE PROBLEMS W/THE VEHICLE. *TR
EVERY TIME I GET A CAR WASH, MY CAR HORN STOPS WORKING ON MY 2007 SUZUKI XL7. HAVE REPLACED MULTIPLE TIMES. SUZUKI TOLD ME NOT TO WASH MY CAR AND MY HORN WILL WORK FINE(???). THIS IS A MAJOR SAFETY ISSUE IN BOTH LOCKING MY CAR AND WITH ONCOMING TRAFFIC TO AVOID ANY COLLISIONS. *TR
POSSIBLE BAD SOFTWARE ISSUE. FAULTY (GONE BAD) 'VOLTAGE REGULATOR CHIP" THAT CONTROLS VOLTAGE AND ALTERNATOR. WHEN IT MALFUNCTIONS IT CAUSES ENTIRE SYSTEM AND MOTOR TO SHUT DOWN. IF YOU ARE DRIVING IT LOCKS UP TRANSMISSION AND YOU CAN NOT CONTROL CAR. BEEN GOING ON FOR MONTHS. DEALERSHIP JUST JERKING ME AROUND FOR MONTHS. *TR
TL* THE CONTACT OWNS A 2007 SUZUKI XL7. THE CONTACT STARTED THE IGNITION AND ALL OF THE DOORS AUTOMATICALLY LOCKED AND COULD NOT BE UNLOCKED. AFTER THREE ATTEMPTS, THE DOORS WERE EVENTUALLY UNLOCKED BY A PERSON ON THE EXTERIOR OF THE VEHICLE USING THE KEY FOB. THE VEHICLE WAS NOT DIAGNOSED FOR THE MALFUNCTION. THE CONTACT HAD NOT NOTIFIED THE MANUFACTURER OF THE ONE TIME OCCURRENCE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000. UPDATED 12/20/11*LJ UPDATED 01/19/12
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.