2019 Toyota Tacoma Complaint Log

the left side inner and outer tie rods pulled apart at threads at jam nut. The threads approx 2 to three inches of threads were 100% rotted. The jam nut showed no sign of being loose. It did not UNTHREAD. No noise or any indication ever of an issue. It happened at 5:15 am. It was dark. I was at best going 1 mph in reverse. If this had happened at road speeds the outcome could have been fatal for someone. For sure a lot of damage. I did not take a picture my bad. I did ask for the parts back but am 99%sure the part I got was not mine.it had a weld on it likely to move vehicle. The inner tie rod Was cut and looking like new, not a part exposed to the elements for 65k miles. I visually compared to other side. I will dissect it when I go to my friends shop. I could be wrong but doubtful. Call if questions. I had an extended warranty so they covered under that or a warranty/campaign? I was a NIASE AND NOW called ASE certified mechanic specializing in front end repair so…I would not knowingly drive cars that have a safety issue that could kill me or anyone. Safety first.

The contact owns a 2019 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, there was an abnormal clattering sound coming from the engine, with a misfire coming from the engine. The check engine warning light was illuminated. The vehicle was restarted; however, the failure reoccurred. The vehicle was taken to several mechanics, where it was diagnosed and determined that the fuel injector in cylinder #3 had failed and needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 89,000.

While driving at Highway speeds fuel pump failed resulting in near miss collision on Interstate. Initial fuel pump was replaced with recall. This is second pump that failed. Vehicle towed to Bob Tyler Toyota in Pensacola Fl where fuel pump replaced by owner. Toyota refuses to pay for pump even though class action lawsuit resulted in Toyota being responsible for reimbursement. Vehicle has only 36000 miles.

On 10/9/25 said vehicle was brought to Central Florida Toyota (CFT) for the investigation of water intrusion into the rear passenger compartment. The cause of water intrusion was due to a defective duct (vent) assy (PN: 62930-04040. There are 2 vents located at the rear of the passenger cab.). The cost for the repair was estimated to be $15,153.39. This exorbitant fee includes the replacement of the entire carpeting system and the need to remove the vehicle bed to access the vents. Based on a musty smell CFT assumed that the carpet had been damaged by molds. Subsequently, CFT was requested to have the 2 vents replaced, only, and not the carpeting. In return, CFT stipulated that I must sign a health hazard waiver due the assumed (no evidence) moldy condition. Now, not only can 2 simple mechanical vents cause such an exorbitant fee to repair it has now evolved into a potential health safety issue. Yet, Toyota has failed to provide any caution/warning to the effect of water intrusion into the rear of the passenger area. No caution/warning in owner's manual that vehicle owner must periodically inspect the rear passenger for water, no warning tags/labels inside vehicle. On the other, my Toyota OEM floor mats have all sorts caution/warning plus installation instruction. It is recommended, as a minimum, Toyota must issue a recall to confirm the integrity of all vents in circulation. On my vehicle, the defective vent was due to bad seal which implies poor manufacturing. Secondly, the location of the vents is simply poor engineering. Even, if there's no damage to the carpeting the cost to replace the 2 vents would be $2,500 due to the need to vehicle bed removed.

Water leaked through the third brake light assembly into the cab roof, soaking the ceiling, seats, and carpet. This caused extensive mold growth and electrical corrosion near the control modules. The affected systems include the third brake light seal, cab roof, interior materials, and ECM (documentation attached). The truck remains at the dealer and is available for inspection upon request. The entire interior is contaminated with mold, creating a serious health hazard, and the vehicle cannot be safely driven or occupied. The leak also damaged electrical components, posing a risk of malfunction or short-circuit while operating the vehicle, and it is currently undrivable due to this damage. The problem was confirmed by Toyota of Clermont, which inspected the truck, documented the damage, and provided a written estimate exceeding $8,000 for repairs (copy attached). The vehicle was at the dealership while the manufacturer’s Limited Service Campaign 21TD03—issued to address this same defect—was still active, but the required inspection and seal repair were not performed. The failure of Toyota of Clermont to perform the mandated remedy under Campaign 21TD03 while the vehicle was in its possession resulted in a serious safety hazard. The entire interior of the cab—including the seats, ceiling, and carpet—is covered in mold, and the vehicle is undrivable due to water intrusion and electrical damage. There were no warning lamps or error messages before the failure, only a strong musty smell inside the cab shortly before the leak became visible. Toyota Motor North America was notified but declined responsibility. This case represents a potential noncompliance with federal defect-remedy obligations under the National Traffic and Motor Vehicle Safety Act (49 U.S.C. § 30120) and should be investigated as such.

The rear cabin pressure vent leaks water into the cabin creating an unsafe vehicle to drive during rainy days. I took the vehicle to Sarasota Toyota and was told that my claim to get it fixed thru the Toyota warranty was denied because it is considered trim. I contacted the warranty company and Toyota about this issue but was told the same.NOT COVERED. I am also concerned that the water intrusion can affect the safety and health hazard of more drivers with this problem if not addressed by Toyota as soon as possible.

While having routine maintenance performed on 8/5/2025, I was advised that the steering rack must be replaced at an approximate cost of $2,200. I was told this should be done as soon as possible because it poses a safety issue. The vehicle only has 29,000 miles and has not been driven off road or in extreme conditions. I researched the issue and it seems that a number of complaints have been filed for the same concern, specifically because this is happening at such low mileage. If Toyota does not come up with a resolution and recall for faulty equipment, will I be doing this repair again in another 29,000 miles?

Rear leaf springs are flat and curving in opposite direction causing vehicle to bottom out with only 100 pounds in the truck bed. This is a potential safety issue as control problems to keep vehicle going straight.

My check engine light came on when I was traveling in Oregon. I didn't notice any major changes in my vehicle's performance. Drove it all the way back to Colorado without issues. It went off and came back on several times. I replaced the cabin air filter, engine air filter and put fuel injector cleaner in the vehicle. Finally I took it in to the Toyota dealership to get an oil change and then the check engine light came back on. I paid for them to do a diagnostic test and they stated they were almost certain it was the 2nd fuel injector running rich. Brought it back a week later for the repair. Fyi...I was still getting 20 mpg in fuel and I wasn't noticing anything major in performance. They replaced the fuel injector and then the check engine light came back on with a different code. They are now running "another" more expensive diagnostic test and I still don't have my truck. They are saying it could be the 2nd cylinder or the engine and claiming it has 150,000 miles so I should expect these issues (and conveniently my warranty has run out).

Truck has 33,XXX miles. Was driving and the fuel gauge needle dropped to E. Dash screen stated 225 miles till empty please refuel. I tried turning it on and off, no change. Filled the gas tank numerous times, no change. Needle remains on E with warning message to please refuel. Mechanic checked and there are no codes or CELs.

I’m filing this complaint regarding a known issue with the A/C evaporator core on my Toyota Tacoma (3rd generation). The evaporator core has prematurely failed, leading to a complete loss of air conditioning and, more importantly, reduced defrosting and defogging capabilities that directly affect visibility and driver safety. This issue is widespread and well-documented among Tacoma owners, and Toyota has issued TSB T-SB-0145-20, acknowledging that corrosion in the evaporator core leads to refrigerant leakage. Despite the known defect, Toyota has not issued a recall and is charging owners thousands of dollars to repair a part that is failing far earlier than expected. In my case, the system began blowing only warm air, and the defroster can no longer clear moisture from the windshield, which is a serious safety issue in humid or cold conditions. This should be treated as a systemic defect, not regular wear and tear. Toyota needs to be held accountable for this manufacturing flaw, which affects safety-critical components like the defroster and visibility systems.

Engine Block

The contact owns a 2019 Toyota Tacoma. The contact stated that the rear cabin pressure vent seals had deteriorated, causing rainwater to leak into the rear cabin of the vehicle. The contact stated that there was a mildew odor inside the cabin of the vehicle. The contact was concerned that mold had developed inside the vehicle due to the water inside the vehicle. The vehicle was taken to the local dealer, who indicated that the rear pressure seals were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 80,000.

The engine in my 2019 Toyota Tacoma TRD Off Road suffered internal damage that appears linked to Toyota’s low-pressure fuel pump recall (issued 10/28/2020, repaired 581 days later on 6/10/2022). While out on personal lease, the truck was driven over 16,000 miles with the defective pump, which can cause lean running conditions and elevated combustion temperatures. The result was metallic contamination and a damaged wrist pin in cylinder #6, requiring full engine replacement. All failed components remain available for inspection upon request. The fuel pump defect and resulting internal engine damage continues to place my safety and others’ at risk by creating potential for loss of power, engine stall, or total failure while driving. The problem was confirmed by two separate Toyota dealerships, both of which diagnosed the need for engine replacement. The vehicle has been inspected by multiple Toyota service centers and the Toyota Brand Engagement Center, which opened and later denied my case. No warning lights or messages appeared prior to the ticking noise that first appeared around 62,000 miles. In fact, no warning lights have ever illuminated on the dash. Despite clear evidence that the recall-related defect likely caused the damage, Toyota has refused to provide any assistance or coverage toward repairing or replacing the failed engine, leaving me with a $21,000 repair for a vehicle that was otherwise maintained and operated responsibly.

I have the exact same issues as the big recall done with the Toyotas for the brake master cylinder. My Tacoma is leaking brake fluid from the inside of the cabin! I contacted Toyota showed the pictures and evidence, I have the exact same issue as all the other trucks with the recall, Toyota refused to help me fix my truck, even tho everything is exactly the same. They argued that because the date my truck was assembled is why they wouldn’t help. They cannot track which parts are used for which dates! It’s not fair, they know this is a huge problem which is why they had a large recall for the Tacomas. My truck barely had 55k miles on it, I shouldn’t be having brake master cylinder issues at this mileage, it’s a 2019, it’s way too new for these problems! This should be covered under the recall. It’s a faulty seal from the inside of the brake master cylinder. Toyota refuses to help or fix it. This is a severe safety issue and concern, I could have crashed or killed myself. My warranty just expired in December. This master cylinder is only made by Toyota and it’s a $1600 part. This should all be covered by Toyota under the recall for safety! This is now going to cost me around $2,000 to fix out of my pocket, all for my own safety. My truck sat for 2-3 weeks waiting for Toyota all for them to deny helping me.

BRAKE FLUID IS LEAKING IN CAB OF VEHICLE BY PEDAL C/A ~|~CONFIRMED BRAKE FLUID LEAK SEEPING FROM BRAKE MASTER, LEAKING FROM ACTUATOR TO BRAKE PEADAL AND DRIPS OF FLUID FOUND ON FLOOR OF VEHICLE.

The contact owned a 2019 Toyota Tacoma. The contact stated while driving at 60MPH; that he was cut off while on a turnpike and to avoid a collision the contact turned into and went over a guard rail, crashing into an embankment. The side curtain air bags deployed however, the front driver-side air bag did not deploy. The vehicle was deemed a total loss. A police report was filed however was not available. The contact did not seek medical attention however felt sore within the next few days. Personal items for his vision were destroyed during the accident. The local dealer was not contacted. The vehicle was towed to a storage facility where it was later towed to another storage facility. The manufacturer was made aware of the failure and was claim was filed. The failure mileage was approximately 47,000. The VIN was not available.

The transmission cooling line in my 2019 Toyota Tacoma was never installed by an authorized repair shop following an accident. This critical component failure led to the transmission failing just 1.5 hours after I retrieved the vehicle from the shop. My safety was compromised, as the failure occurred while driving at highway speeds, without any warning lights or messages indicating an issue. The failure has been confirmed by the dealership (MotorWorld Toyota) currently inspecting my vehicle. The shop responsible for the initial repairs has taken liability for missing the installation of the transmission cooling line. My insurance company (GEICO) has been involved but is delaying total loss consideration. No warning lamps or messages appeared before or after the transmission failure, which is highly suspicious. This negligence has caused severe damage to a vital component of my vehicle, and I question the overall integrity of the repairs.

Two of my three 2019 Tacoma’s drivers side door hinges broke clean off the door frame.

the differential skid plate was manufactured in a way that one of the brackets make contact with the fuel tank of the truck. It rubs and compromises the integrity of the tank. Possibly leading to a puncture and leak. I brought it to the attention of the manufacturer, and they have stated that they received several complaints from customers and redesigned the skid plate to prevent this. However they refused to replace mine and others, they also have taken NO steps to notify owners of this safety hazard.

Brakes pedal inside car was dripping brake fluid and there was a loss of power when breaking. The vehicle was taken to a Toyota dealership and they diagnosed the problem as a failure of the brake master cylinder (part # 47050-04180). There was no warning lamp or messages of the problem prior to brakes having loss of power when breaking and fluid dripping from brake pedal inside of vehicle.

Brake fluid leaking into the cab floor of 2019 Toyota Tacoma. VIN not listed on NHTSA list. Toyota refuses to believe this is the same issue as recall, as per Yemi at 10:48AM on Sept 18, 2024 Toyota Corporate call 1-800-331-4331. Brake master cylinder diagnosed by independent, non-bias mechanic as: "Diagnosed brake fluid seeping through dust seal inside cabin running down shaft connecting the pedal to assembly, fluid is of consistency of the brake fluid required by system, fluid level is low at this time, if pedal is pumped 5 times and held down there is visible drip from the rod to pedal connection, needs master Cyl. assembly and exhibits same issues and description of fault as set forth in the recall notice. Customer advised to seek manufacturer assistance." Previous examination by local Toyota dealer was fluid leaking from steering column.

Steering rack was found to be leaking fluid onto the rubber boot during the 52,000 mile oil change and general maintenance by the Toyota dealership. This leak requires the complete steering rack to be replaced for approximately $2,100.

Approximately 100 feet from the vehicle, I rear end of the car in front of me. when I hit the brake pedal it didn’t seem like it stopped the vehicle I ran into another car and totaled the Toyota Tacoma. Conditions for dry and cloudy and road construction nearby.

Experienced a check engine light and took the 2019 Toyota Tacoma to the Toyota dealer where they ran diagnostic check revealing the # 1 cylinder had little to no compression due to damaged valves. Mileage at the time of failure was 59966 miles.

Leaking of brake fluid from brake master cylinder into driver footwell.

The contact owns a 2019 Toyota Tacoma. The contact stated that after starting the vehicle, the vehicle was idling abnormally rough. After shifting into driving and releasing the brake pedal with his foot off the accelerator pedal, the vehicle briefly independently accelerated. Upon reaching an undisclosed speed, the vehicle returned to normal functionality, but the failure became a regular occurrence. The contact stated that the failure first occurred after the dealer had replaced the high-pressure fuel pump. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was unknown.

Break Master Cylinder leaking.

I sat in my Tacoma with my son we heard a loud noise and the sunroof spontaneously shattered. Looks like it burst outwards. and there was glass on the windshield. Could have been really dangerous if the sunshade wasn't closed and even more dangerous if we were driving the vehicle at the time.

Brake fluid leaking into driver-side floorboard. Due to leak in brake master cylinder seal. Recalls have been issued for same year and model, but my truck is not included. I assume mine has a different manufacturing date. Yet my truck has the same problem as those with the recall.

I currently own a 2019 Tacoma with around 70,000 miles on it. I keep up with all the Toyota recommended maintenance services to make sure my vehicle is well taken care of. So, while driving the vehicle on the interstate it drastically slowed down on its own and I could not get the gas pedal to engage almost causing a rear end collision. This also happened on two other occasions at lower speeds. My display stated I was having issues with ABS, Collision, and that I was pressing the gas pedal and break at the same time. My vehicle has been at the dealership for 4 days now with no resolve or any answers to why the vehicle is slowing down on its own. I feel the vehicle is a health/safety issue and I will not drive it until the issue is resolved. The computer was also flashed by Toyota a year earlier as I was experiencing a lag in engine engagement and high rpm's when the vehicle shifted from first to second gear. Something the tech noted he experienced driving it. It's also an issue I've had since purchasing the vehicle. I had to bring the vehicle back a month later as it started doing the same thing but was told they could not find any issues. I have found many other forums and spoke with other Tacoma owners who have had similar issues. I feel Toyota is definitely aware of the issues but not addressing them! I hope to get some answers soon!

About 70,000 miles, bearings on the idler pulley and tensioner on serpentine belt failed. These have been replaced. About 75,000 miles, the rack and pinion began leaking from one end. I'm watching power steering fluid levels and expect to replace the rack and pinion soon. Note: I'm being told the design of this vehicle requires that the engine be partially pulled to replace the rack and pinion.

The contact owns a 2019 Toyota Tacoma. The contact stated that while driving at various speeds, the vehicle suddenly stalled. The contact stated that the failure had occurred on several occasions. The cause of the failure was not yet determined. The local dealer was contacted. The manufacture was not contacted. The failure mileage was approximately 120,000.

Paint is starting to come off in different areas of the truck, left front fender and right front area of the bed. Toyota dealer inspected the truck and checked for recalls which Toyota has on earlier white vehicles but stated this vehicle was not in the year or vin range of affected vehicles. I have checked online and multiple owners of white Toyota Tacomas are having the same issue and appears to be trucks built at their Mexico plant.

When driving the vehicle to work - the brakes failed and the emergency brake had to be used to bring the vehicle to a complete stop. The vehicle had to be towed to a Toyota dealership where it was diagnosed that the master brake cylinder needs to be replaced.

This 2019 truck feels like it just doesn’t want to go. It struggles to go up ANY hill no matter how small. The engine jumps feels like it’s got a heart beat while riding. The gas mileage is horrendous and awful the 2015 was all around a better truck I read somewhere that Toyota recalled a bunch of 2019 trucks for a gas line rip was causing fires and whatever else. I thought for sure it had to be my trucks issue bc that would absolutely explain why it’s running so weird and ragged. The poor thing … I’m very worried about it.

This describes false alarms by the vehicle electronics. About once every four to six months, the center display on the dash says, "BRAKE," and a Sonalert-type steady beep comes out of the dash. This happens with cruise control on. In two cases, there was no vehicle in front of me on the road. I could not see any source of radio signal or radar interference (EMI) in the area or nearby. In one case, there were no vehicles nearby, no weather or other radars nearby, only a television translator station about two miles away. The brakes may have been applied in some cases but generally are not. Weather has been sunny and clear in every case when this occurs. So far as I can tell, these are random false alarms with no apparent EMI cause. They seem to be getting less frequent. I get frequent and reproducible lane departure warnings with certain "fog line" configurations used in my state or with random tire skid marks.

A severe crack formed around the full circumference of tire near where the sidewall joins to the tread. The tire started leaking air and the severe crack was found while mounting the spare tire. The crack was present on the inside of the tire and therefore not visible until the wheel was removed. This crack was on its way to a catastrophic failure of the tire. The crack was found at 23500 miles on a tire with claimed treadlife of 60,000. This was the tire sold with my new 2019 Tacoma: Goodyear Wrangler AT Adventure with Kevlar 265/70R16. The Toyota dealership said to take the problem to GY but GY has no recall on this tire and I do not want any new GY tire if offered a replacement.

Toyota has a campaign to address white paint flaking/chipping on numerous vehicles, with the exception of Tacomas. My truck is a 2019 with 34k miles and the paint is chipping and flaking off. This is a known problem with this paint, so I am not sure why they don't address it with Tacomas. I would like Toyota to take care of this for me. It is not fair for me to pay out of pocket to address a defect in their paint.

The engine part “Coolant bypass joint” failed, started leaking coolant at 44k miles, because it was made of inferior plastic material, unlike the same part used in the same 3.5L V6 engines in the Lexus vehicles, which are made of aluminum. This is a widespread failure since 2016 model years, and Toyota refused change the design or manufacturing material of the part, or to repair it under warranty. The part number for this failed part is 16356-31051.

I was at a stop light and when the light turn green I started driving forward and the ABS/ Brake lights on instrument cluster came on with repeated blinking. I slowed off the gas to apply the brakes. Brake pedal went to the floor with no brakes or slowing down at all. Luckily no one was in front of me and I had to pull the emergency brake. It was the only brakes I had at all. Once vehicle was towed to the nearest Toyota Dealer I had them diagnose the problem. Right rear wheel had leaked out fluid due to the rear brake cylinder failing. Upon repair of all brake pads, rotors, brake shoes, brake drums, both rear brake cylinders the problem was still an issue. Costly amounts of money already being spent to find out another failure with the Brake Master Cylinder/ Module. That part alone is also very expensive. Research has shown that the 2018 and 2019 Toyota Tacoma’s did have history of faulty brakes in turn possibly causing an accident. For my case on the road I was lucky. I can’t understand a loyal customer of years with Toyota that the company refuses any sort of aid and assistance in the matter. Why did the recalls end? Especially if this affected not just the 2018 model but the 2019 model like my Tacoma as well. For such low miles and no abuse this vehicle has faced other failures not only with the brakes alone. Vehicle is still with the Dealer at this time. Requesting some assistance in the matter please. Thank you!

The power steering fluid, when cold , is below the “low” line. Upon looking at the steering boots I noticed that both have fluid on them indicating a leak. I have searched Toyota Tacoma forums online and the 2019 Tacoma seems to be the only one with this problem. If the power steering all of a sudden stops working due to fluid leaking I put myself and all of those around me in and outside of my truck at risk of injury or death especially at highway speeds. Thank you very much for looking into this.

Hello, my name is Andrew I have a 2019 Tacoma TRD Sport 4WD. I have roughly 78,000 miles on my truck as it is still fairly new and has never been in a wreck. I have so rattling noises coming from my front end, and I have taken it to Toyota and other shops to figure out if something was loose, and the response is my steering is about to go out, at first, I am like what its still a new truck never seen the dirt and never has pulled a camper or trailer in its life. So my question is why is my Steering Rack, and or the Rack and Pinion going out so early on a truck that is treated like a child? I haven't had insurance involved because I am hoping this is a defect and it can be fixed or resolved as it is a part that should be replaced in its safety. I just had a recall on my 3rd brake, that doesn't concern me as much as this. Knocking, and grinding when turning going forward, and in reverse. I at first thought it was my lower control arms, and they are saying steering and the truck is not even 3 years old. Please help me and others get this issue resolved as the part is going out sooner than i would think a new truck steering component should.

Passenger Side Back Seat Seatbelt ripped under normal wear and tear.

Coming back home at 15:00 on 12 /22/22 it was light snow day on two lane county road my wife was following back for are mother in laws , West snoqualmie valley road carnation Washington , speed 30 miles per hours I was coming into a turn that cautions 35 miles or less and the. My dash comes up a yellow triangle with a exclamation and my brake pedal disappears out from under my feet and the brakes lock up and slide of the side of the road into the grass , put the truck into park then I try to put engage the brake pedal up towards me with my foot and the motor stalls /cuts out , I push the start button system comes back on and out into four wheel drive to get out of the grass/ cow field and the check engine stays yellow . I take it Toyota and they tell me everything is fine and it was just a traction issue with the program of the truck

Occasionally, my Tacoma jerk at lower speeds of 20 to 5 mph. Also, random I hear a click sound on brake.

During a repair for a tire pressure warning light the service technician noticed that my steering rack was leaking and needed to be replaced. My vehicle has 34,651 miles on it. Repair cost $1700.

Timing cover gasket failed. I notice leak at 70k but the gasket may have failed earlier. I believe this to be a manufacture defect as this is a common issue.

My 2019 Toyota Tacoma (Super White) is experiencing paint chipping and delamination across multiple body panels. Toyota has acknowledged this defect in limited repair programs, but my vehicle is affected beyond the covered areas. Paint loss exposes underlying primer/metal and may lead to corrosion over time. This appears widespread among similar model-year Tacomas.

Fuel system - vehicle surged (high RPMS) while gearshift lever was in the Drive position after release of pressure on the accelerator as I was parking the vehicle surged and smashed into a cement post, the vehicle traveled approximately 10 to 15 feet. The vehicle is currently at the dealership where an independent contractor, who is contracted by Toyota, will be doing a visual and diagnostic analysis. I expect the vehicle to be returned to me on 1/19/2023. The vehicle and components have not been inspected by any other individual at this time. There were no warning lights on prior to the surge. Unknown if any warning light came during the incident which I believe was two (2) seconds until impact with the post.