2007 Chevrolet Aveo Electrical System Problems

While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. The airbag warning light is also illuminated, indicating the safety restraint system may not function properly in a crash. These failures create a serious safety risk due to loss of exterior lighting, inability to shift, inability to turn the ignition off, and possible airbag malfunction. This failure is consistent with a known defect involving the Daytime Running Light (DRL) module overheating and causing electrical shorts, as documented in manufacturer recall and technical service bulletins for this vehicle. The problem has been reproduced multiple times and remains unresolved.

Out of no where it cought on fire

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHEN THE CONTACT PULLED IN THE DRIVEWAY AND ATTEMPTED TO TURN OFF THE VEHICLE, THE ELECTRICAL POWER SHUT OFF. AS A RESULT, THE CONTACT WAS UNABLE TO ROLL THE WINDOWS UP OR DOWN, UNLOCK THE DOOR WITH THE SWITCH, AND THE KEY WOULD NOT TURN TO THE OFF POSITION IN THE IGNITION. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE THE VEHICLE WAS PARKED OR WHILE DRIVING, A BURNING ELECTRICAL ODOR WAS DETECTED IN THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE ODOR COULD NOT BE DETERMINED. THE CONTACT WAS REFERRED TO AN ELECTRICAL SPECIALIST BY THE INDEPENDENT MECHANIC, BUT THE VEHICLE WAS NOT DIAGNOSED DUE TO THE DIAGNOSTIC FEES. THE CONTACT STATED THAT THE INDEPENDENT MECHANIC ADVISED HER TO DISCONNECT THE VEHICLE'S BATTERY. THE CONTACT RESEARCHED THE ISSUES ONLINE AND FOUND NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE, CONFIRMED THAT THE VIN WAS NOT INCLUDED IN THE RECALL, AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 10/25/17*LJ THE CONSUMER STATED THE VEHICLE WAS TRADED IN. *JS

BEEN SMELLING SOMETHING THAT SIMILAR TO PLASTIC BUT COULD NOT LOCATE ANYTHING BUT NOW I HAVE HAD MULTIPLE FUSES BLOWN FOR LOW BEAMS AND DRL. ULTIMATELY ALL DASHBOARD LIGHTS HAVE NOW GONE OUT ALONG WITH NO TAIL LIGHTS OR LOW BEAMS OR DRLS AT ALL AND NO HORN. DEALER IS SAYING THAT THE FUSE BLOCK IS GOING TO HAVE TO BE REPLACED BUT THE CAR ONLY HAS 83,000 AND NOTICED THAT THERE WAS A RECALL OUT THERE FOR THE DRL MODULE MELTING OR CATCHING ON FIRE BUT LOW AND BEHOLD MY CAR IS NOT ON THAT RECALL BUT LOOKS TO ME THAT IT SHOULD BE. IN ADDITION TO THE LIGHTS NOT WORKING CORRECTLY, THE GEAR SHIFTER WILL NOT COME OUT OF PARK AND THE KEY WILL NOT RELEASE FROM THE IGNITION SWITCH. I DID ALSO THINK IT ODD THAT MY KEY WOULD BE HOT TO TOUCH WHEN IT WOULD RELEASE ON PREVIOUS OCCASIONS LEADING UP TO THIS FAILURE. THE FIRST INSTANCE WHEN THE FAILURE INITIALLY STARTED WITH THE LIGHTS AND ALL THAT I COULD NOTICE WAS WHILE I WAS IN A PARKING LOT CRANKING THE CAR, BUT THE SECOND TIME AFTER CHANGING OUT THE FUSE, THE FUSE BLEW AGAIN AFTER I WAS DRIVING ON THE ROAD IN 5 O'CLOCK TRAFFIC.

I HAVE A 2007 CHEVY AVEO THAT I'VE HAD TO REPLACE THE DRIVERS SIDE > HEADLIGHT ON 5 TIMES IN THE 4 YRS I'VE HAD IT. ALSO, FOR THE PAST 2 YRS I > HAVEN'T HAD ANY RADIO LIGHTS. THERE'S A RECALL ON THE RUNNING LIGHT > MODULES FOR THIS YEAR, THE CARS CAN CATCH FIRE. RECALL NUMBER: 14V261000. THE MODULE ON MY CAR IS MELTED AND BLACK. I HAVE PICTURES OF THIS. I'VE CALLED CHEVY SEVERAL TIMES > BUT GET TOLD THERE'S NO RECALL ON MY CAR. DO I HAVE TO WAIT UNTIL THE CAR CATCHES FIRE TO DO BE ABLE TO DO SOMETHING ABOUT THIS?

THE DAYTIME RUNNING LIGHTS MODULE HAD A RECALL ON IT. I MADE AN APT AT THE LOCAL DEALER LAST WEEK AND MADE AN APPOINTMENT TODAY TO GET THE RECALL DONE. RECALL NUMBER IS 14236. THEY DID NOT FIX IT, SAID THEY DIDN'T HAVE THE PART EVEN THOUGH I CONTACTED THEM LAST WEEK AND GAVE THEM THE VIN AND THE RECALL NUMBER. I PICKED UP THE CAR WITH THE INTENT OF TAKING IT TO ANOTHER DEALER AND IT CAUGHT FIRE ON THE WAY HOME AND DESTROYED THE CAR.

APPROXIMATELY 3 MONTHS AGO MY DASH LIGHTS QUIT WORKING AND NOW MY PASSENGER REAR DRL QUIT ALSO. I SMELLED SOMETHING BURNING AT ABOUT THIS TIME ALSO. *TR

AIR BAG LIGHT COME ON AND WILL NOT GO OFF

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING AT 30 MPH, ALL THE INSTRUMENT PANEL LIGHTING FAILED TO ILLUMINATE. IN ADDITION, THE GAUGES DISPLAYED INCORRECT READINGS AND FAILED TO FUNCTION. THE KEY FAILED TO EJECT FROM THE IGNITION AND REMAINED IN THE ACCESSORY POSITION. THE GEAR LEVER FAILED TO SHIFT AND REMAINED IN THE PARK POSITION. THE VEHICLE WAS TOWED TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,000.

KEY GOT "STUCK IN IGNITION" AND WOULD NOT COME OUT. MY CAR IN NOT ON THE GM RECALL LIST SO DEALER WANTED TO CHARGE ME AN ARM AND TWO LEGS TO FIX. TOOK TO AN AUTO REPAIR SHOP. HOW DO CARS GET ADDED TO THE RECALL LIST? MINE SHOULD DEFINITELY BE ON THIS ONE FOR IGNITION PROBLEM TO THE TUNE OF $357. *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHEN THE CONTACT STARTED THE VEHICLE AND ACTIVATED THE HEADLIGHTS, ALL THE ELECTRICAL POWER FAILED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED A SHIFT INTERLOCK SOLENOID. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,587.

DASH LIGHTS QUIT WORKING AND COULD SMELL PLASTIC BURNING FROM UNDER THE DASH. ALSO THE TAIL LIGHT ON THE PASSENGER SIDE KEEPS BLOWING FUSES. *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET AEVO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PARTS NEEDED TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 04/06/15*LJ THE CONSUMER ALSO STATED THE VEHICLE STALLED. UPDATED 04/28/15*JB

I WAS DRIVING TO MY MOTHER'S HOUSE, THE CAR WAS NOT SHIFTING RIGHT AND THE ENGINE WAS WHINING, ALL OF A SUDDEN I SMELLED SMOKE AND SEEN FIRE UNDER THE HOOD. GM WOULD ONLY FIX THE HARNESS , THE VEHICLE WOULD START AGAIN BUT YOU COULD NOT DRIVE IT. NO POWER IN THE ENGINE. SO I HAD TO EAT $6400.00 DOLLARS I OWED AND TRADED IT WITH CARBONE AUTO IN YORKVILLE NEW YORK. THEY SOLD ME A CAR WITH THE ABS LIGHTS ON THE TRACTION LIGHTS ON, THE TIRE PRESSURE LIGHTS COME ON AND MY DOORS LOCK AND I HAVE TO CLIMB OVER TO THE OTHER SEAT TO GET OUT. THE SALESMAN KNEW THESE LIGHTS WERE ON BEFORE I SIGNED THE PAPERS AND MY CAR IS STILL NOT FIXED. THIS PAST WINTER I HAD NO HEAT AND GOT CAUGHT IN AN ICE STORM AND MY WINDOWS ICED RIGHT OVER I COULD NOT SEE AND HIT A POLE BY MY DRIVEWAY AND DENTED AND SCRATCH THE WHOLE RIGHT SIDE OF MY CAR. IT IS CARBONE AUTO THAT MADE IT SO MY AVEO CAUGHT FIRE. THEY WOULD NOT FIX IT, THE CAR WOULD NEVER SHIFT RIGHT THE MOTOR WOULD WHINE OUT AND THEY SAID OH THAT IS THE WAY A 1.6 LITER CAR RUNS. I HAD THE FIDELITY EXTRACT WARRANTY AND THEY WOULD NOT FIX THE AVEO I HAVE LOST 6400 DOLLARS ON THESE CARS AND IT IS THE DEALERS FAULT, WHAT DO I DO NOW MY 2008 IMPALA VIN IS [XXX] THE SALESMAN NAME IS [XXX] HE KNEW THESE LIGHTS WERE ON BEFORE I SIGNED THE PAPERS HE SAID IT WOULD BE FIXED. 8 MONTHS LATER STILL NOT FIXED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT BURNING FUMES EMITTED FROM THE ENGINE COMPARTMENT AND THE BATTERY WAS DRAINED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE BATTERY WAS REPLACED. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER FOR THE DIAGNOSTIC TESTING. THE CONTACT WAS MADE AWARE OF RECALL NHTSA CAMPAIGN ID NUMBER: 14V261000 (ELECTRICAL SYSTEM). HOWEVER, THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

UNABLE TO MOVE GEAR FROM PARK TO DRIVE OVER SEVEN TIMES MECHANIC INFORMED FAILURE IN GEAR BOX ALSO INFORMED THAT THIS IS A MANUFACTURRING DEFECT. *TR

MY DAUGHTER WAS DRIVING THIS VEHICLE WHEN THE ENGINE DIED AT HIGHWAY SPEED. SHE LOST ALL POWER ASSIST SYSTEMS INCLUDING POWER STEERING AND BRAKES. SHE PLACED THE CAR IN NEUTRAL, AT SPEED, RESTARTED THE VEHICLE AND CONTINUED TO TRAVEL WITHOUT INCIDENT. *TR

ABOUT A WEEK AGO I STARTED SMELLING SOMETHING BURNING. THOUGHT I WAS MISTAKEN. TRIED TO CRANK THE CAR TODAY AND THE BATTERY WAS DEAD. HAD A RELATIVE JUMP IT AND FOUND THE DAYTIME RUNNING LIGHTS STAY ON EVEN WHEN THE CAR IS OFF. IN RESEARCHING WHAT THE PROBLEM COULD BE I FOUND THAT A RECALL HAS BEEN ISSUED REGARDING THE DAYTIME RUNNING LIGHTS MODULE BUT I HAVE NOT RECEIVED A NOTICE YET. I ONLY HAVE THIS ONE VEHICLE AND I CANNOT GET ANYONE TO CALL ME ABOUT GETTING THIS PROBLEM FIXED. YOU WOULD THINK THAT WITH ALL THE BAD PUBLICITY GM IS GETTING AT THIS TIME THEY WOULD WANT TO ASSIST QUICKLY. NOPE. I AM ALSO DEALING WITH MY DAUGHTERS CAR WHICH IS AN HHR THAT HAS HAD THE IGNITION SWITCH RECALLED AND I WAS ADVISED TODAY THAT IT COULD TAKE 8 WEEKS FOR THE PART TO COME IN. REALLY? I AM VERY CONCERNED BECAUSE MY 3 YEAR OLD GRANDSON RIDES IN BOTH THESE CARS. I AM FILING THIS HOPING SOMEONE CONTACTS ME. NEXT STEP IS KEN AMARO. *TR

THE AIRBAG WARNING LIGHT CAME ON. FIRST DIAGNOSTIC BY THE GM DEALERSHIP POINTED TO A 12V POWER LOSS. THEN AFTER ~2 MONTHS THE AIRBAG LIGHT CAME ON AGAIN. AN INDEPENDENT CAR REPAIR SHOP TESTED FOR 2 HOURS PER TROUBLE CODE AND FOUND THE ROOT CAUSE WAS THE TIME CLOCK IN THE DASHBOARD. LIGHT STAYED OFF WHEN CLOCK WAS REPLACED (REPEATED TWICE WITH ORIGINAL TIME CLOCK). LIGHT IS OFF SINCE 1 WEEK AFTER MULTIPLE CAR TRIPS. WHY DOES THE TIME CLOCK CAUSES THE AIRBAG WARNING LIGHT TO COME ON AND POTENTIALLY DISABLE THE AIRBAG SYSTEM.